Peugeot 307 Dag 2005 Owner's Manual

Checks110 -
01-06-2005
111Checks-
01-06-2005
OPENING THE BONNET
From inside: push the handle on the
left-hand side under the fascia.
Bonnet strut
Secure the strut to hold the bonnet
open.
Before closing the bonnet, replace
the strut in its housing.
To close
Lower the bonnet and release it at
the end of its travel.
Check that the bonnet is properly
locked.
RUNNING OUT OF FUEL
(DIESEL)
If you should run out of fuel, it is
necessary to re-prime the circuit.
The repriming pump, the degas
screw and the transparent pipe are
located under the bonnet (see cor-
responding drawing):
1.6 litre HDI 16V engine
- ill the fuel tank with at least ive litres of diesel,
- unclip the style cover to access the repriming pump,
- squeeze and release the manual repriming pump until fuel appears
in the transparent pipe with the
green connector,
- operate the starter until the engine starts.
2 litre HDI 16V engine
- ill the fuel tank with at least ive litres of diesel,
- unclip the style cover to access the repriming pump,
- unscrew the degas screw,
- squeeze and release the manual repriming pump until diesel is seen
escaping via the degas screw,
- retighten the degas screw,
- operate the starter until the engine starts.
From outside:
lift the catch and raise
the bonnet.

Checks110 -
01-06-2005
111Checks-
01-06-2005
1. Power steering reservoir.
2. Windscreen and headlamp*
wash reservoir.
3. Coolant reservoir.
4. Brake luid reservoir.
5. Battery.
6. Fuse box.
7. Air ilter.
8. Dipstick.
9. Engine oil reservoir.
1.4 LITRE 16V PETROL ENGINE
* According to country.

Checks112 -
01-06-2005
113Checks-
01-06-2005
1. Power steering reservoir.
2. Windscreen/headlamp* wash
reservoir.
3. Coolant reservoir.
4. Brake luid reservoir.
5. Battery.
6. Fuse box.
7. Air ilter.
8. Dipstick.
9. Engine oil reservoir.
1.6 LITRE 16V PETROL ENGINE
* According to country.

Checks112 -
01-06-2005
113Checks-
01-06-2005
1. Power steering reservoir.
2. Windscreen/headlamp* wash
reservoir.
3. Coolant reservoir.
4. Brake luid reservoir.
5. Battery.
6. Fuse box.
7. Air ilter.
8. Dipstick.
9. Engine oil reservoir.
2 LITRE 16V PETROL ENGINE
* According to country.

Checks114 -
01-06-2005
115Checks-
01-06-2005
1. Power steering reservoir.
2. Windscreen/headlamp* wash
reservoir.
3. Coolant reservoir.
4. Brake luid reservoir.
5. Battery
6. Fuse box.
7. Air ilter.
8. Dipstick.
9. Engine oil reservoir.
2 LITRE 16V (180 bhp) PETROL ENGINE
* According to country.

Checks114 -
01-06-2005
115Checks-
01-06-2005
1. Power steering reservoir.
2. Windscreen/headlamp* wash
reservoir.
3. Coolant reservoir.
4. Brake luid reservoir.
5. Battery.
6. Fuse box.
7. Dipstick.
8. Engine oil reservoir.
9. Priming pump.
1.6 LITRE 16V TURBO DIESEL HDI ENGINE (90 bhp/110 bhp)
* According to country.

Checks116 -
01-06-2005
117Checks-
01-06-2005
1. Power steering reservoir.
2. Windscreen/headlamp* wash
reservoir.
3. Coolant reservoir.
4. Brake luid reservoir.
5. Battery.
6. Fuse box.
7. Air ilter.
8. Engine oil reservoir.
9. Dipstick.
10. Priming pump.
11. Degas screw.
2 LITRE 16V TURBO DIESEL HDI ENGINE (136 bhp)
* According to country.

Checks116 -
01-06-2005
117Checks-
01-06-2005
CHECKING THE LEVELS
There are two marks on
the dipstick:
A = maximum
Never ill past this mark.
B = minimum
Oil change
According to the information given in
the servicing booklet.
Viscosity selection
In all cases, the oil selected must
meet the manufacturer's require-
ments.
Power steering reservoir
Remove the style trim* (see § "Chang-
ing a bulb - Front lights").
Open the reservoir, with the engine at
ambient temperature. The level should
always be above the MIN. mark and
close to the MAX. mark.
Dipstick Cooling system
Use the luid recommended by the
manufacturer.
When the engine is warm, the temper-
ature of the coolant is controlled by the
engine fan. This fan can operate with
the ignition off.
In the case of vehicles itted with
a particle emission ilter, the fan
can operate after the vehicle has
stopped, even when the engine is
cold.
In addition, as the cooling system
is pressurised, wait for at least one
hour after the engine has stopped
before carrying out any work.
Slacken the cap by two turns to re-
lease the pressure to prevent any
risk of scalding. When the pressure
has dropped, remove the cap and
top up the level.
Note:
the coolant does not need to
be changed. Windscreen and headlamp**
wash level
For best quality cleaning and for
your safety, we would advise that
you use products recommended by
PEUGEOT.
Diesel additive level
If the service warning light comes on,
accompanied by a message and an
audible signal, this indicates a low
diesel additive level.
This additive must be topped up.
Contact a PEUGEOT dealer as soon
as possible.
Brake luid level
Replacement must be carried out ac-
cording to the manufacturer's servicing
schedule.
Use luids recommended by the man-
ufacturer, which fulil DOT4 standards.
* According to engine.
** According to country.
Oil level
Check the level regularly and top up
between changes. The maximum
consumption is 0.5 l per 600 miles
(1 000 km).
Check the level with the vehicle
level, engine cold, using the oil level
gauge on the instrument panel or the
dipstick.
To maintain the reliability
of engines and emission
control systems, the use
of additives in engine oil is
prohibited.

Checks118 -
01-06-2005
Used products
Avoid all prolonged contact of the
used oil with the skin.
Brake luid is harmful to health and
very corrosive.
CHECKS
Battery
At the start of winter, have your bat-
tery checked by a PEUGEOT dealer.
Oil ilter
Change the ilter regularly, in accord-
ance with the servicing schedule.
Air ilter and passenger
compartment ilter
Have the ilter elements replaced reg-
ularly. If you drive in dusty condi-
tions, change them twice as often. Note:
following prolonged operation
of the vehicle at very low speed or at
idle, you may, in exceptional cases,
notice discharges of water vapour
at the exhaust on acceleration. This
has no effect on the behaviour of the
vehicle or on the environment.
Brake pads
Brake pad wear depends on the style
of driving, in particular for vehicles
which are used in town, over short
distances .
It may be necessary to check the
thickness of the pads, even between
services.
Handbrake
Where the handbrake travel is too
great or there is a reduction in the
performance of the system, the
handbrake should be adjusted, even
between services.
Have the system checked by a
PEUGEOT dealer. To check the main levels and
certain components, in accord-
ance with the manufacturer's
servicing schedule, refer to the
pages of the servicing booklet
which correspond to your vehi-
cle's engine.
Only use products recom-
mended by PEUGEOT
or products of equivalent
quality and characteristics.
To ensure best perform-
ance from components as important
as the power steering and the brak-
ing system, PEUGEOT selects and
offers quite speciic products.
To prevent damage to the electrical
units, high pressure washing of the
engine compartment is strictly pro-
hibited .
Manual gearbox
This does not require an oil change.
Have the level checked in accord-
ance with the manufacturer's servic-
ing schedule.
Particle emission ilter
(Diesel)
It is imperative that the particle
emission ilter is maintained in ac-
cordance with the manufacturer's
servicing schedule, by a PEUGEOT
dealer. Do not dispose of used oil,
brake luid or coolant into
drains or onto the ground.
Empty the used oil into the
containers provided for this
purpose in the PEUGEOT network.

Checks118 -
01-06-2005
Used products
Avoid all prolonged contact of the
used oil with the skin.
Brake luid is harmful to health and
very corrosive.
CHECKS
Battery
At the start of winter, have your bat-
tery checked by a PEUGEOT dealer.
Oil ilter
Change the ilter regularly, in accord-
ance with the servicing schedule.
Air ilter and passenger
compartment ilter
Have the ilter elements replaced reg-
ularly. If you drive in dusty condi-
tions, change them twice as often. Note:
following prolonged operation
of the vehicle at very low speed or at
idle, you may, in exceptional cases,
notice discharges of water vapour
at the exhaust on acceleration. This
has no effect on the behaviour of the
vehicle or on the environment.
Brake pads
Brake pad wear depends on the style
of driving, in particular for vehicles
which are used in town, over short
distances .
It may be necessary to check the
thickness of the pads, even between
services.
Handbrake
Where the handbrake travel is too
great or there is a reduction in the
performance of the system, the
handbrake should be adjusted, even
between services.
Have the system checked by a
PEUGEOT dealer. To check the main levels and
certain components, in accord-
ance with the manufacturer's
servicing schedule, refer to the
pages of the servicing booklet
which correspond to your vehi-
cle's engine.
Only use products recom-
mended by PEUGEOT
or products of equivalent
quality and characteristics.
To ensure best perform-
ance from components as important
as the power steering and the brak-
ing system, PEUGEOT selects and
offers quite speciic products.
To prevent damage to the electrical
units, high pressure washing of the
engine compartment is strictly pro-
hibited .
Manual gearbox
This does not require an oil change.
Have the level checked in accord-
ance with the manufacturer's servic-
ing schedule.
Particle emission ilter
(Diesel)
It is imperative that the particle
emission ilter is maintained in ac-
cordance with the manufacturer's
servicing schedule, by a PEUGEOT
dealer. Do not dispose of used oil,
brake luid or coolant into
drains or onto the ground.
Empty the used oil into the
containers provided for this
purpose in the PEUGEOT network.