Peugeot 407 C 2005.5 Owner's Manual

Practical information114 -
04-11-2005
115Practical information-
04-11-2005
To charge the battery using a
battery charger:
- Disconnect the battery,
- Follow the instructions for use given by the battery charger manu-
facturer,
- Reconnect starting with the nega- tive (-) terminal,
- Check that the terminals and con- nectors are clean. If they are cov-
ered with sulphate (white or greenish
deposit), disconnect them and clean
them. - Operate the starter, let the engine
run.
- Wait for the engine to return to idle, then disconnect the cables.
BATTERY (LOCATED IN THE
ENGINE COMPARTMENT)
To start the vehicle from another
battery:
F open the bonnet,
F use the two additional positive (+)
and negative (-) terminals located
under the bonnet,
F open the red cover of the positive
(+) terminal,
F connect the red cable between the
positive (+) terminal and the positive
(+) terminal of the slave battery,
F connect the green or black cable
between the negative (-) terminal
and the negative (-) terminal of
the slave battery,
F operate the starter, let the engine
run,
F wait for the engine to return to
idle, then disconnect the cables,
F close the red cover of the positive
(+) terminal,
F reit the left side cover,
F close the bonnet.
To start the vehicle from another
battery:
- Connect the red cable to the positive
(+) terminals of the two batteries,
- Connect one end of the green or black cable to the negative (-) ter-
minal of the slave battery,
- Connect the other end of the green or black cable to an earth point on
the broken down vehicle as far as
possible from the battery,
It is advisable to disconnect the bat-
tery if the vehicle is not to be used for
a period of more than one month.
BATTERY (LOCATED IN THE
BOOT)*
The battery is in the left boot trim.
To charge the battery using a
battery charger (boot open): F fold down the panel to gain ac-
cess to the battery,
F disconnect the battery,
F follow the instructions for use
given by the battery charger manu-
facturer,
F reconnect starting with the nega-
tive (-) terminal,
F raise the panel and close it.
* Vehicles itted with the 2.7 litre HDI
24V engine.

Practical information116 -
04-11-2005
117Practical information-
04-11-2005
Before disconnecting the
battery, you must wait for
2 minutes after switching off
the ignition.
Never disconnect a terminal when
the engine is running.
Never charge a battery without irst
disconnecting the terminals.
Open the windows and close the
sunroof before disconnecting the
battery. If they do not operate nor-
mally following reconnection of the
battery, they must be reinitialised
(see sections "Reinitialisation of the
electric windows" and "Sunroof").
After every reconnection of the bat-
tery, switch on the ignition and wait
1 minute before starting to allow the
electronic systems to be initialised.
However, if slight dificulties are ex-
perienced after this, please contact a
PEUGEOT dealer.
Do not connect a slave battery
to the positive (+) and negative
(-) terminals, located under the
bonnet, if there is no battery in the
boot as a short circuit may occur
(Diesel engine).
TOWING YOUR VEHICLE
Without lifting (4 wheels on
the ground)
You must always use a towbar.
The removable towing eye is inside
the spare wheel.
From the rear:
F Unclip the cover, pulling the upper
rib towards you,
F Screw in the towing eye as far as
it will go. Special features of the automatic
gearbox
Lifting (2 wheels only on the
ground)
It is preferable to raise the vehicle
with a professional lifting device.
The batteries contain harm-
ful substances such as sul-
phuric acid and lead. They
must be disposed of in ac-
cordance with regulations and must
never be discarded with household
waste.
Take used batteries to an approved
collection point. When towing with the engine
switched off, there is no brak-
ing or steering assistance.
From the front:
F
Unclip the left part of the cover,
F Screw in the towing eye as far as
it will go. Towing a vehicle with an
automatic gearbox in reverse
gear is
prohibited (absence
of lubrication).
When being towed with all four
wheels on the ground, it is imperative
that the following rules are obeyed:
- selector lever in position N,
-
the vehicle must be towed at a speed
of less than 30 mph (50 km/h) over a
maximum distance of 30 miles (50 km),
- do not add oil to the gearbox.

Practical information116 -
04-11-2005
117Practical information-
04-11-2005
Before disconnecting the
battery, you must wait for
2 minutes after switching off
the ignition.
Never disconnect a terminal when
the engine is running.
Never charge a battery without irst
disconnecting the terminals.
Open the windows and close the
sunroof before disconnecting the
battery. If they do not operate nor-
mally following reconnection of the
battery, they must be reinitialised
(see sections "Reinitialisation of the
electric windows" and "Sunroof").
After every reconnection of the bat-
tery, switch on the ignition and wait
1 minute before starting to allow the
electronic systems to be initialised.
However, if slight dificulties are ex-
perienced after this, please contact a
PEUGEOT dealer.
Do not connect a slave battery
to the positive (+) and negative
(-) terminals, located under the
bonnet, if there is no battery in the
boot as a short circuit may occur
(Diesel engine).
TOWING YOUR VEHICLE
Without lifting (4 wheels on
the ground)
You must always use a towbar.
The removable towing eye is inside
the spare wheel.
From the rear:
F Unclip the cover, pulling the upper
rib towards you,
F Screw in the towing eye as far as
it will go. Special features of the automatic
gearbox
Lifting (2 wheels only on the
ground)
It is preferable to raise the vehicle
with a professional lifting device.
The batteries contain harm-
ful substances such as sul-
phuric acid and lead. They
must be disposed of in ac-
cordance with regulations and must
never be discarded with household
waste.
Take used batteries to an approved
collection point. When towing with the engine
switched off, there is no brak-
ing or steering assistance.
From the front:
F
Unclip the left part of the cover,
F Screw in the towing eye as far as
it will go. Towing a vehicle with an
automatic gearbox in reverse
gear is
prohibited (absence
of lubrication).
When being towed with all four
wheels on the ground, it is imperative
that the following rules are obeyed:
- selector lever in position N,
-
the vehicle must be towed at a speed
of less than 30 mph (50 km/h) over a
maximum distance of 30 miles (50 km),
- do not add oil to the gearbox.

Practical information116 -
04-11-2005
117Practical information-
04-11-2005
In all cases, pay attention to the cool-
ant temperature.Brakes:
towing increases the brak-
ing distance. Drive at a moderate
speed, change down early and brake
gradually.
Side wind: sensitivity to side wind is
increased. Drive smoothly and at a
moderate speed.TOWING A TRAILER,
CARAVAN, BOAT, ETC...
Only use original PEUGEOT tow-
bars which have been tested and
approved from the design stage of
your vehicle.
The towbar must be itted by a
PEUGEOT dealer.
Driving advice
Distribution of loads: distribute the
load in the trailer so that the heavi-
est loads are as close as possible to
the axle and the nose weight is close
to the maximum authorised without,
however, exceeding it.
Cooling: towing a trailer on a slope
increases the coolant temperature.
As the fan is electrically controlled,
its cooling capacity is not dependent
on the engine speed. Note:
in certain cases of par-
ticularly arduous use (towing
the maximum load in high
temperatures on a steep
slope), the engine automatically
limits its power and selects the ap-
propriate automatic gearbox gear in
manual mode. In this case, cutting off
the air conditioning allows the engine
power to be recovered, and therefore
the towing capacity to be increased.
If the coolant temperature
warning light comes on, stop
the vehicle and switch off the
engine as soon as possible.
Tyres: check the tyre pressures of
the towing vehicle (label on the cen-
tral door pillar on the driver's side)
and of the trailer towed, observing
the recommended pressure.

Practical information118 -
04-11-2005
ACCESSORIES FOR YOUR
407 COUPÉ
A wide range of accessories recom-
mended by PEUGEOT and original
parts are offered by the Network.
They all beneit from PEUGEOT's
recommendation.
These accessories and parts, having
been tested and approved for reli-
ability and safety, are all adapted to
your PEUGEOT vehicle.
The product range offered by
PEUGEOT Accessories is structured
around 5 categories: PROTECTION -
TOURING - IN-CAR TECHNOLOGY -
STYLING - UNIVERSAL.Anti-theft alarm, engraved
windows, wheel anti-theft
devices, irst aid kit, warn-
ing triangle, high visibility
safety jacket, snow chains,
...
"Protection":
Mats, boot tray.
For leisure pursuits: child
seats and booster cush-
ions, audio/telephone con-
sole, cool box.
Trailer towbar which must be itted by
the PEUGEOT Network.
"Touring":
Telephone, hands-free kits,
satellite navigation, CD
changer, multimedia.
"In-Car Technology": Alloy wheels, wheel trims,
spoiler, seat covers com-
patible with side air bags,
stainless steel sill protec-
tors.
"Styling":
Windscreen wash luid, in-
terior and exterior cleaning
and maintenance products.
"Universal":
The itting of electrical equip-
ment or accessories which
are not recommended by
PEUGEOT may result in a
failure of your vehicle's electronic
system.
Please note this speciic warning.
You are advised to contact a repre-
sentative of the Marque to be shown
the range of recommended equip-
ment and accessories.
The alloy wheels which are available
as accessories require the itting of
tyres of speciic dimensions. Contact
a PEUGEOT dealer.

119Technical data-
04-11-2005
ENGINES AND GEARBOXES
Model codes: 6J...PETROL
3FZH XFVH XFVJ
ENGINES 2.2 litre 16V 3 litre V6 24V
Cubic capacity (cm
3) 2 231 2 946
Bore x stroke (mm) 86 x 96 87 x 82.6
EU standard maximum power
(kW)/DIN (bhp) 120/167 155/212
Maximum power engine speed (rpm) 5 876 6 000
EU standard maximum torque (Nm) 220 290
Maximum torque engine speed (rpm) 4 126 3 750
Fuel Unleaded Unleaded
Catalytic converter YesYes
Gearbox Manual
(6-speed) Manual
(6-speed) Automatic
(6-speed)
Oil capacity (in litres)
Engine (with cartridge replacement)* - 5.25 5.25
* Draining by gravity with oil iller cap open.

Technical data120 -
04-11-2005
121Technical data-
04-11-2005
ENGINES AND GEARBOXES
Model codes: 6J...DIESEL
UHZJ
ENGINES 2.7 litre HDI 24V
Cubic capacity (cm
3) 2 720
Bore x stroke (mm) 81 x 88
EU standard maximum power (kW)/
DIN (bhp) 150/204
Maximum power engine speed (rpm) 4 000
EU standard maximum torque (Nm) 440
Maximum torque engine speed (rpm) 1 900
Fuel Diesel
Catalytic converter Yes
Particle emission ilter (PEF) Yes
Gearbox Automatic
(6-speed)
Oil capacity (in litres)
Engine (with cartridge replacement)* 5.55
* Draining by gravity with oil iller cap open.

Technical data120 -
04-11-2005
121Technical data-
04-11-2005
In accordance with directive 80/1268/CEE
Engines Gearboxes Model
codes Urban
driving mpg
(litres/100 km) Inter-urban
driving mpg
(litres/100 km) Mixed driving
mpg
(litres/100 km) Emission of
CO 2 by mass
(g/km) mixed
2.2 litre 16V Manual 6J3FZH 23.2 (12.2) 42.8 (6.6) 32.4 (8.7) 206
3 litre V6 24V Manual 6JXFVH 18.8 (15.0) 38.7 (7.3) 27.6 (10.2) 242
3 litre V6 24V Automatic 6JXFVJ 18.8 (15.0) 38.7 (7.3) 27.6 (10.2) 242
CONSUMPTION
The consumption igures shown here correspond to the values communicat ed at the time of printing. These consumption
values were established in accordance with Directive 80/1268/CEE. They may vary depending on the style of driving, trafic
conditions, weather conditions, the load in the vehicle, t he maintenance of the vehicle and the use of the accessories.
Engines 2.2 litre 16V 3 litre V6 3 litre V6
Gearbox Manual Manual Automatic
Model codes: 6J3FZH 6JXFVH 6JXFVJ
• Kerb weight* 1 660 1 738 1 763
• Gross vehicle weight (GVW) 1 940 2 020 2 060
• Gross train weight (GTW)** 3 140 3 320 3 360
• Unbraked trailer weight 750 750 750
• Braked trailer weight (a) 1 200 (1) 1 300 (1) 1 300 (1)
• Recommended nose weight 56 60 61
WEIGHTS AND TOWED LOADS (IN KG)
* The kerb weight is equal to the unladen vehicle + driver (75
kg) + fuel tank illed to 95 % capacity.
** The speed of a towing vehicle is limited to 60 mph (100 km/h).
(a) The braked trailer value corresponds to the towing capacity of the vehicle on a 12 % incline.
The braked trailer weight may be increased by (1) 250 kg, on cond ition that the load in the vehicle is reduced so that the GTW
is not exceeded.
High exterior temperatures may result in a reduction in the perfo rmance of the vehicle in order to protect the engine; when the
exterior temperature is higher than 37 °C, limit the weight towed to 600 kg, without load transfer.

Technical data122 -
04-11-2005
123Technical data-
04-11-2005
In accordance with directive 80/1268/CEE
Engines Gearboxes Model
codes
Urban driving
mpg (l/100 km)Inter-urban
driving mpg (l/100 km)Mixed driving
mpg (l/100 km)Emission
of CO2 by mass
(g/km) mixed
2.7 litre HDI 24V Automatic 6JUHZJ 23.7 (11.9) 43.5 (6.5) 33.2 (8.5) 226
CONSUMPTION
The consumption igures shown here correspond to the values communicat ed at the time of printing. These consumption
values were established in accordance with Directive 80/1268/CEE. They may vary depending on the style of driving, trafic
conditions, weather conditions, the load in the vehicle, t he maintenance of the vehicle and the use of the accessories.
Diesel engines 2.7 litre HDI 24V
Gearbox Automatic
Model codes: 6JUHZJ
• Kerb weight* 1 850
• Gross vehicle weight (GVW) 2 130
• Gross train weight (GTW)** 3 430
• Unbraked trailer 750
• Braked trailer (a) 1 300 (1)
• Recommended nose weight 60
WEIGHTS AND TOWED LOADS (IN KG)
* The kerb weight is equal to the unladen vehicle + driver (75 kg) + fuel tank illed to 95 % capacity.
** The speed of a towing vehicle is limited to 60 mph (100 km/h).
(a) The braked trailer value corresponds to the towing capacity o f the vehicle on a 12 % incline.
The braked trailer weight may be increased by (1) 250 kg, on cond ition that the load in the vehicle is reduced so that the GTW
is not exceeded.
High exterior temperatures may result in a reduction in the perfo rmance of the vehicle in order to protect the engine; when the
exterior temperature is higher than 37 °C, limit the weight towed to 600 kg, without load transfer.

Technical data122 -
04-11-2005
123Technical data-
04-11-2005
DIMENSIONS (in mm)WARNING
The 407 Coupé has reduced ground clearance.
Drive carefully over kerbs, speed humps, access ramps, fords and dirt tracks.