Peugeot 407 C Dag 2006.5 Owner's Manual

1010
106
CHANGING A FUSE
The fuse boxes are placed in the lower part of the fascia (driver’s side), in the engine compartment (left-hand side) and in the left boot trim.
Fascia fuses
To access the fuses, open the cover of the storage compartment on the driver’s side. Tilt the fuse box down-wards.Replacing a fuse
Before replacing a fuse, the cause of the incident must be found and recti-fied. The fuse numbers are indicated on the fuse box.
Always replace a faulty fuse with a fuse of the same rating (same colour).
Use the special pliers located on the support next to the fuse box, this sup-port also contains the replacement fuses.
Fuse N°RatingFunctions
G29-Not used.
G305 AHeated rear screen.
G315 ATyre under-inflation detection, CD changer.
G32-Not used.
G335 APower steering electropump unit, dual-function brake switch.
G345 ADual-function brake switch, automatic gearbox relay.
G355 ASteering wheel angle sensor and ESP gyrometer sensor.
G3625 AHi-Fi amplifier.
G3715 AAutomatic gearbox.
G3820 AHeated seats.
G3930 APassenger seat memory unit.
G4030 ADriver’s seat memory unit.

1010
107
Fuse N°RatingFunctions
F1-Not used.
F230 ALocking and deadlocking.
F35 AAir bags and pre-tensioners control unit.
F410 AAutomatic gearbox switch, diagnostic socket, electrochromatic mirror.
F530 ADriver and passenger electric windows.
F630 ASunroof.
F75 AGlove box light, map reading lights, courtesy lights, courtesy mirrors.
F820 AMultifunction display, audio equipment, top-of-column, trailer fuse box (accessory), alarm, alarm siren.
F930 AFront lighter, 12 V rear socket, glove box light, map reading lights, courtesy lights, courtesy mirrors.
F1015 ATyre under-inflation detection, CD changer.
F1115 ADiagnostic socket, ignition switch.
F1215 ATrailer fuse box (accessory), parking assistance control unit supply, p assenger seatmemory unit, rain and brightness sensor.
F135 AWindscreen wipers relay control, engine fuse box.
F1415 ADriver’s seat memory unit, instrument panel, air bags and pre-tensioners control unit, air conditioning control panel, steering wheel adjustment switch, hands-free kit.
F1530 ALocking and deadlocking.
F16-PARC shunt.

1010
110
CHANGING A WINDSCREEN
WIPER BLADE
Placing the wiper blades in the maintenance position
 Less than one minute after switch-ing off the ignition, press the wind-screen wiper stalk down once to position the blades at the top of the windscreen (maintenance position).
Replacing a blade
 Lift the arm, then unclip the blade and remove it.
 Fit the new blade and fold down the arm.
To reposition the blades, switch on the ignition and operate the windscreen wiper stalk.
ECONOMY MODE FUNCTION
After the engine has stopped, certain functions (windscreen wiper, electric windows, sunroof, electric seats, au-dio equipment, telephone, interior boot light, video, etc) can only be used for a combined duration of approximately thirty minutes, to prevent discharging of the battery.
Once the thirty minutes are over, a switching to economy mode message appears on the multi-function display and the active functions areput on standby.
These functions are reactivated au-tomatically next time the vehicle is driven.
In order to resume the use of these functions immediately, the engine must be started and left to run for a few minutes.
The time available to you will then be approximately double the duration for which the engine is left running. How-ever, this period will always be be-tween five and thirty minutes.
LOAD REDUCTION FUNCTION
When driving, certain functions (air conditioning, heated rear screen, heating system for passenger com-partment of diesel vehicles, etc.) may be switched off temporarily, depending on the level of battery charge.
Reactivation of these functions is automatic, once the battery charge is sufficient.
Note: at the risk of discharging the battery, the functions that have been switched off may be reactivated manually.
Note: if the telephone is being used when economy mode starts, it will still be possible to finish the call.
A flat battery prevents the en-gine from starting.

1010
111
To charge the battery using a battery charger:
- Disconnect the battery,- Follow the instructions for use given by the battery charger manufacturer,- Reconnect starting with the negative (-) terminal,- Check that the terminals and con-nectors are clean. If they are covered with sulphate (white or greenish deposit), disconnect them and clean them.
- Operate the starter, let the engine run.- Wait for the engine to return to idle, then disconnect the cables.
BATTERY (LOCATED IN THE
ENGINE COMPARTMENT)
To start the vehicle from another battery:
 open the bonnet,
 use the two additional positive (+) and negative (-) terminals located under the bonnet,
 open the red cover of the positive (+) terminal,
 connect the red cable between the positive (+) terminal and the positive (+) terminal of the slave battery,
 connect the green or black cable between the negative (-) terminal and the negative (-) terminal of the slave battery,
 operate the starter, let the engine run,
 wait for the engine to return to idle, then disconnect the cables,
 close the red cover of the positive (+) terminal,
 refit the left side cover,
 close the bonnet.
To start the vehicle from another battery:
- Connect the red cable to the positive (+) terminals of the two batteries,- Connect one end of the green or black cable to the negative (-) termi-nal of the slave battery,- Connect the other end of the green or black cable to an earth point on the broken down vehicle as far as possible from the battery.
It is advisable to disconnect the battery if the vehicle is not to be used for a period of more the battery if the vehicle is not the battery if the vehicle is not
than one month.
BATTERY (LOCATED IN THE
BOOT)*
The battery is in the left boot trim.
* Vehicles fitted with the 2.7 litre HDI 24V engine.
To charge the battery using a battery charger (boot open):
 fold down the panel to gain access to the battery,
 disconnect the battery,
 follow the instructions for use given by the battery charger manufacturer,
 reconnect starting with the nega-tive (-) terminal,
 raise the panel and close it.

1010
112
Before disconnecting the bat-tery, you must wait for 2 minutes after switching off the ignition.
Never disconnect a terminal when the engine is running.
Never charge a battery without first disconnecting the terminals.
Open the windows and close the sun-roof before disconnecting the battery. If they do not operate normally following reconnection of the battery, they must be reinitialised (see sections "Reini-tialisation of the electric windows" and "Sunroof").
After every reconnection of the bat-tery, switch on the ignition and wait 1 minute before starting to allow the electronic systems to be initialised. However, if slight difficulties are ex-perienced after this, please contact a PEUGEOT dealer.
On the 2.7 litre 24V HDI engine, if there is no battery in the boot, do not connect a slave battery to the positive (+) and negative (-) termi-nals under the bonnet as a short circuit may occur.
TOWING YOUR VEHICLE
Without lifting(4 wheels on the ground)
You must always use a towbar.
The removable towing eye is inside the spare wheel.
From the rear:
Unclip the cover, pulling the upper rib towards you,
 Screw in the towing eye as far as it will go.
Special featuresof the automatic gearbox
Lifting (2 wheels only on the ground)
It is preferable to raise the vehicle with a professional lifting device.
The batteries contain harmful substances such as sulphu-ric acid and lead. They must be disposed of in accordance with regulations and must never be discarded with household waste.
Take used batteries to an approved collection point.
When towing with the engine switched off, there is no brak-ing or steering assistance.
From the front:
Unclip the left part of the cover,
 Screw in the towing eye as far as it will go.
Towing a vehicle with an auto-matic gearbox in reverse gear is prohibited (absence of lubri-cation).
When being towed with all four wheels on the ground, it is imperative that the following rules are obeyed:
- selector lever in position N,- the vehicle must be towed at a speed of less than 30 mph (50 km/h) over a maximum distance of 30 miles (50 km),- do not add oil to the gearbox.

1010
112
Before disconnecting the bat-tery, you must wait for 2 minutes after switching off the ignition.
Never disconnect a terminal when the engine is running.
Never charge a battery without first disconnecting the terminals.
Open the windows and close the sun-roof before disconnecting the battery. If they do not operate normally following reconnection of the battery, they must be reinitialised (see sections "Reini-tialisation of the electric windows" and "Sunroof").
After every reconnection of the bat-tery, switch on the ignition and wait 1 minute before starting to allow the electronic systems to be initialised. However, if slight difficulties are ex-perienced after this, please contact a PEUGEOT dealer.
On the 2.7 litre 24V HDI engine, if there is no battery in the boot, do not connect a slave battery to the positive (+) and negative (-) termi-nals under the bonnet as a short circuit may occur.
TOWING YOUR VEHICLE
Without lifting(4 wheels on the ground)
You must always use a towbar.
The removable towing eye is inside the spare wheel.
From the rear:
Unclip the cover, pulling the upper rib towards you,
 Screw in the towing eye as far as it will go.
Special featuresof the automatic gearbox
Lifting (2 wheels only on the ground)
It is preferable to raise the vehicle with a professional lifting device.
The batteries contain harmful substances such as sulphu-ric acid and lead. They must be disposed of in accordance with regulations and must never be discarded with household waste.
Take used batteries to an approved collection point.
When towing with the engine switched off, there is no brak-ing or steering assistance.
From the front:
Unclip the left part of the cover,
 Screw in the towing eye as far as it will go.
Towing a vehicle with an auto-matic gearbox in reverse gear is prohibited (absence of lubri-cation).
When being towed with all four wheels on the ground, it is imperative that the following rules are obeyed:
- selector lever in position N,- the vehicle must be towed at a speed of less than 30 mph (50 km/h) over a maximum distance of 30 miles (50 km),- do not add oil to the gearbox.

1010
113
In all cases, pay attention to the cool-ant temperature.Brakes: towing increases the braking distance. Drive at a moderate speed, change down early and brake gradu-ally.
Side wind: sensitivity to side wind is increased. Drive smoothly and at a moderate speed.
TOWING A TRAILER,
CARAVAN, BOAT, ETC...
We recommend the use of original PEUGEOT towbars which have been tested and approved from the design stage of your vehicle and that the tow-bar is fitted by a PEUGEOT dealer.
Driving advice
Distribution of loads: distribute the load in the trailer so that the heavi-est loads are as close as possible to the axle and the nose weight is close to the maximum authorised without, however, exceeding it.
Cooling: towing a trailer on a slope in-creases the coolant temperature.
As the fan is electrically controlled, its cooling capacity is not dependent on the engine speed.
Note: in certain cases of par-ticularly arduous use (towing the maximum load in high temperatures), the engine au-tomatically limits its power and selects the appropriate automatic gearbox gear in manual mode. In this case, cutting off the air conditioning allows the engine power to be recovered, and therefore the towing capacity to be in-creased.
If the coolant temperature warning light comes on, stop the vehicle and switch off the engine as soon as possible.
Tyres: check the tyre pressures of the towing vehicle (label on the central door pillar on the driver’s side) and of the trailer towed, observing the recom-mended pressure.

1010
114
ACCESSORIES FOR YOUR 407
COUPÉ
A wide range of accessories recom-mended by PEUGEOT and original parts are offered by the Network.
They all benefit from PEUGEOT’s rec-ommendation.
These accessories and parts, having been tested and approved for reliabil-ity and safety, are all adapted to your PEUGEOT vehicle.
The product range offered by PEUGEOT Accessories is structured around 5 categories: PROTECTION - TOURING - IN-CAR TECHNOLOGY - STYLING - UNIVERSAL.
Anti-theft alarm, engraved windows, wheel anti-theft devices, first aid kit, warning triangle, high visibility safety jacket, snow chains, ...
"Protection":
Mats, boot tray.
For leisure pursuits: child seats and booster cushions, audio/telephone console, cool box, bicycle carrier on towbar.
Trailer towbar which must be fitted by the PEUGEOT Network.
"Touring":
Telephone, hands-free kits, satellite navigation, CD changer, multimedia.
"In-Car Technology":
Alloy wheels, wheel trims, spoiler, seat covers compat-ible with side air bags, twin exhaust tailpipe, leather steering wheel.
"Styling":
Windscreen wash fluid, inte-rior and exterior cleaning and maintenance products.
"Universal":
The fitting of electrical equipment or accessories which are not rec-ommended by PEUGEOT may result in a failure of your vehicle’s electronic system.
Please note this specific warning. You are advised to contact a representa-tive of the Marque to be shown the range of recommended equipment and accessories.
The NINETEEN alloy wheels which are available as accessories require the fitting of tyres of specific dimen-sions(235/40ZR19 96 Y), with a maxi-mum section of 236 mm. Contact a PEUGEOT dealer.
Depending on the country in which the vehicle is sold, it is compulsory to have a high visi-bility safety jacket, warning triangle and spare bulbs available in the vehicle.
Note
To prevent the mat from becoming caught under the pedals:
- ensure that the mat is positioned and secured correctly,- never fit one mat on top of another.

11
115
ENGINES AND GEARBOXES
Model codes: 6J...
PETROL
3FYHXFVHXFVJ
ENGINES2.2 litre 16V3 litre V6 24V
Cubic capacity (cm3)2 2312 946
Bore x stroke (mm)86 x 9687 x 82.6
EU standard maximum power(kW)/(bhp)120/163155/211
Maximum power engine speed (rpm)5 8766 000
EU standard maximum torque (Nm)220290
Maximum torque engine speed (rpm)4 1263 750
FuelUnleadedUnleaded
Catalytic converterYesYes
GearboxManual
(6-speed)
Manual
(6-speed)
Automatic
(6-speed)
Oil capacity (in litres)
Engine (with cartridge replacement)*4.755.255.25
* Draining by gravity with oil filler cap open.

11
117
ENGINES AND GEARBOXES
Model codes: 6J...
DIESEL
UHZJ
ENGINES2.7 litre HDI 24V
Cubic capacity (cm3)2 720
Bore x stroke (mm)81 x 88
EU standard maximum power
(kW)/(bhp)150/204
Maximum power engine speed (rpm)4 000
EU standard maximum torque (Nm)440
Maximum torque engine speed (rpm)1 900
FuelDiesel
Catalytic converterYes
Particle emission filter (PEF)Yes
GearboxAutomatic(6-speed)
Oil capacity (in litres)
Engine (with cartridge replacement)*5.80
* Draining by gravity with oil filler cap open.