PEUGEOT 407 DAG 2004 Owner's Guide

30 -
11-10-2004
31
-
11-10-2004
STOP warning light
If this is the only warning light which
is on, it indicates a power steering
fault.
It comes on linked with the engine oil
pressure, coolant temperature, brak-
ing system or punctured tyre warning
lights.
Stop immediately.
Contact a PEUGEOT dealer.
WARNING LIGHTS
SPECIFIC TO THE
4-DIAL INSTRUMENT
PANEL
Engine oil pressure
warning light
This indicates that the engine oil
pressure is too low.
It is linked with the STOP warning
light
Stop immediately if it is displayed
while the engine is running.
In the case of a lack of oil in the lubri-
cation circuit, top up the oil.
Contact a PEUGEOT dealer as soon
as possible. Coolant temperature
warning light
This indicates that the engine tem-
perature is high.
It is linked with the STOP warning light.
Stop immediately.
Wait for the engine to cool
down before topping up the
level, if necessary.
Battery charge warning
light
This indicates a charging circuit fault
(battery terminals, alternator belt).
Contact a PEUGEOT dealer.
Punctured tyre warning
light
This indicates that one or more punc-
tured tyres have been detected.
A message on the multifunction display
indicates the wheel(s) concerned.
It is linked with the STOP warning
light.
Stop immediately.
Change the damaged wheel.
Have it repaired by a PEUGEOT
dealer.
Instruments and controls
Coolant temperature indicator
When the needle is in zone A, the
temperature is correct.
When the needle is in zone B, the
temperature is too high.
If the coolant temperature warning
light comes on (linked with the STOP
warning light), stop immediately.
Wait for the engine to cool down
before topping up the level, if neces-
sary.
As the cooling circuit is pressurised,
in order to prevent any risk of scald-
ing, unscrew the cap by two turns to
allow the pressure to drop.
When the pressure has dropped, re-
move the cap and top up the level, if
necessary.
Contact a PEUGEOT dealer. Automatic CHECK
With the key in the ignition on posi-
tion, all of the warning lights of the
functions tested are displayed. They
are switched off after a few seconds.

30 -
11-10-2004
31
-
11-10-2004
Electronic stability control
system (ESP) warning
light
If this is displayed continuously, it in-
dicates deactivation or a malfunction
of the ESP.
In this case, contact a PEUGEOT
dealer.
If the warning light lashes, this indi-
cates that the ESP is in operation.
Water in diesel ilter
warning light
This indicates the presence of water
in the diesel ilter.
There is a risk of damage to the in-
jection system.
Contact a PEUGEOT dealer as soon
as possible. Air bags warning light
This indicates an air bag fault.
Contact a PEUGEOT dealer. Service warning light
This is displayed for the following
warnings:
- tyre under-inlation ,
- engine diagnostics ,
- blown bulb ,
- low wash-wipe luid level ,
- particle emission ilter
saturation (Diesel engine),
- engine oil level ,
- speed control system (cruise
control/speed limiter),
- automatic switching on of the
lights system,
- obstacle proximity detection
system,
- engine immobiliser system,
- remote control battery lat ,
Instruments and controls
- low coolant level ,
- one or more doors open at a
vehicle speed above 6 mph
(10 kmh),
- an automatic headlamp beam
adjustment system fault,
- brake pad wear,
- a tyre under-inlation detection
system fault,
- low diesel additive reservoir
level (Diesel engine).

32 -
11-10-2004
33
-
11-10-2004
Tyre under-inlation
warning light
This indicates that the tyre pressure
is too low.
A message on the multifunction
display indicates the wheel(s) con-
cerned.
Refer to the information label afixed
to the central pillar of the driver's
door. For your safety, check the tyre
pressures as soon as possible.
Electronic stability control
system (ESP) warning lights
Activation warning light
Operation warning light
Deactivation warning light
Malfunction warning light
Instruments and controls
Power steering warning
light
This indicates a power steering fault.
It is linked with the STOP warning
light.
Contact a PEUGEOT dealer.
Handbrake warning light
This indicates that the handbrake
is applied or has not been released
correctly.
It is linked with the braking system
warning light. Low wash-wipe and
headlamp wash luid level
warning light
When the wipers are switched on,
this indicates that the luid level is
too low.
Fill the wash-wipe and headlamp
wash luid reservoir. Engine oil level warning
light
This indicates a critical engine oil
level (too low or too high).
Stop immediately .
Contact a PEUGEOT dealer as soon
as possible.
WARNING LIGHTS
SPECIFIC TO THE 5-DIAL
INSTRUMENT PANEL
These warning lights are displayed
on the instrument panel display.
STOP warning light
Low coolant level warning
light
This warning light indicates an insuf-
icient cooling circuit level.
Stop immediately.
Contact a PEUGEOT dealer.
Warning: the cooling circuit is pres-
surised, wait for the engine to cool
down before topping up the level.
When topping up, and in order to
prevent any risk of scalding, unscrew
the cap by two turns to allow the
pressure to drop.
When the pressure has dropped, re-
move the cap and top up the level.
This comes on linked with the power
steering or punctured tyre warning
lights.
Stop immediately.
Contact a PEUGEOT dealer.

32 -
11-10-2004
33
-
11-10-2004
Punctured tyre warning
light
This indicates that one or more punc-
tured tyres have been detected.
A message on the multifunction
display identiies the wheel(s) con-
cerned.
It is linked with the STOP warning
light.
Stop immediately.
Change the damaged wheel.
Have it repaired by a PEUGEOT
dealer.
Tyre under-inlation
detection system warning
light
This indicates the absence or mal-
function of one or more tyre pressure
sensors or a system fault.
Contact a PEUGEOT dealer.
Electronic engine
immobiliser warning light
This indicates an electronic engine
immobiliser system malfunction.
Contact a PEUGEOT dealer. Front brake pads wear
warning light
This indicates that the brake pads
are worn.
For your safety, have them replaced
by a PEUGEOT dealer.
Fuel tank cap warning light
(according to version)
With the engine running, this indi-
cates that the fuel tank cap is incor-
rectly secured or absent.
It comes on in orange if the vehicle
speed is below 6 mph (10 km/h).
If the vehicle speed is above 6 mph
(10 km/h), it comes on in red.
Door/boot open warning
light
With the engine running, this indi-
cates that an access has not been
closed correctly. An illustration on the
multifunction display identiies the
access(es) concerned.
It comes on in orange if the vehicle
speed is below 6 mph (10 km/h).
If the vehicle speed is above 6 mph
(10 km/h), it comes on in red. Air bags warning light
This indicates an air bag fault.
Contact a PEUGEOT dealer. Bulb blown warning
light
(halogen lights)
When the lights are switched on, this
indicates that one or more bulbs are
faulty (excluding the side repeaters
and the 3rd brake light).
Have the faulty bulb replaced by a
PEUGEOT dealer.
Automatic headlamp
beam adjustment system
warning light
This indicates that the automatic
headlamp height adjuster is faulty.
Contact a PEUGEOT dealer.
Automatic switching on of
the lights system warning
light
This indicates an automatic switch-
ing on of the lights system fault.
Manual control is still possible.
Contact a PEUGEOT dealer.
Instruments and controls

34 -
11-10-2004
35
-
11-10-2004
Electronically controlled
suspension indicator
lights
This comes on when the SPORT
function is activated.
Automatic switching on of
the lights indicator light
This comes on when the AUTO func-
tion is activated. Automatic switching on
of the lights deactivation
indicator light
This comes on when the AUTO func-
tion is deactivated.
Automatic wipers indicator
light
This comes on when the AUTO func-
tion is activated. Automatic wipers
deactivation indicator light
This comes on when the AUTO func-
tion is deactivated.
Instruments and controls
Automatic gearbox fault
warning light
This indicates an automatic gearbox
fault.
The gearbox will operate in down-
grade mode, locked in 3rd gear.
Never force the selector lever.
Contact a PEUGEOT dealer.
Electronically controlled
suspension fault warning
light
This indicates an electronically con-
trolled suspension malfunction.
Select automatic operation and con-
tact a PEUGEOT dealer as soon as
possible.
Obstacle proximity
detection system warning
light
In reverse gear, this indicates an
obstacle proximity detection system
fault.
Contact a PEUGEOT dealer. Speed control system
warning light
This indicates a cruise control/speed
limiter fault.
Contact a PEUGEOT dealer. This comes on when the
SPORT function is deacti-
vated.
Particle emission ilter
saturation warning light
(Diesel engine)
With the engine running, this indi-
cates that the particle emission ilter
is starting to become saturated (ex-
ceptionally prolonged urban driving
type conditions: low speed, long
trafic jams...) or a low diesel additive
reservoir level.
In order to regenerate the ilter, you
are advised to drive, as soon as pos-
sible when the trafic conditions per-
mit, at a speed of 40 mph (60 km/h)
or above for at least ive minutes (un-
til the warning light is switched off).
If the warning light remains on, con-
tact a PEUGEOT dealer.
Following prolonged use of the vehi-
cle at very low speeds or at idle, you
may, exceptionally, notice an emis-
sion of water vapour at the exhaust
during acceleration. This does not
affect the performance of the vehicle
or the environment.
Service warning light
This is displayed for the following
warnings:
- remote control battery lat ,
- injection or ignition system fault.

34 -
11-10-2004
35
-
11-10-2004
This indicates an automatic
gearbox program fault.
Automatic gearbox lever
postion indicator lights
This indicates an automatic
gearbox malfunction.
4 or 6 speed automatic gearbox
"Manual" indicator lights
"Park" indicator
lights
"Reverse"
indicator lights
"Neutral" indicator
lights
"Drive" indicator
lights
The letter S or the symbol T asso-
ciated with the gate lever position
indicator lights, corresponds to the
Sport or Snow program selected
intentionally. These correspond to the manual
control of the gearbox, four or six
speed.
When the engine speed is too low
or too high in relation to the gear
engaged, the gear selected lashes
for a few seconds, then the actual
gear is displayed, the auto-adaptive
program having taken control
temporarily.
Instruments and controls
Engine oil temperature
indicator
When the ignition is switched on or
while the vehicle is moving, this indi-
cates the engine oil temperature.
When the needle is in zone
C, the
temperature is correct.
When the needle is in zone D, the
temperature is too high.
Reduce your speed to lower the tem-
perature.

34 -
11-10-2004
35
-
11-10-2004
This indicates an automatic
gearbox program fault.
Automatic gearbox lever
postion indicator lights
This indicates an automatic
gearbox malfunction.
4 or 6 speed automatic gearbox
"Manual" indicator lights
"Park" indicator
lights
"Reverse"
indicator lights
"Neutral" indicator
lights
"Drive" indicator
lights
The letter S or the symbol T asso-
ciated with the gate lever position
indicator lights, corresponds to the
Sport or Snow program selected
intentionally. These correspond to the manual
control of the gearbox, four or six
speed.
When the engine speed is too low
or too high in relation to the gear
engaged, the gear selected lashes
for a few seconds, then the actual
gear is displayed, the auto-adaptive
program having taken control
temporarily.
Instruments and controls
Engine oil temperature
indicator
When the ignition is switched on or
while the vehicle is moving, this indi-
cates the engine oil temperature.
When the needle is in zone
C, the
temperature is correct.
When the needle is in zone D, the
temperature is too high.
Reduce your speed to lower the tem-
perature.

30 -
11-10-2004
31
-
11-10-2004
STOP warning light
If this is the only warning light which
is on, it indicates a power steering
fault.
It comes on linked with the engine oil
pressure, coolant temperature, brak-
ing system or punctured tyre warning
lights.
Stop immediately.
Contact a PEUGEOT dealer.
WARNING LIGHTS
SPECIFIC TO THE
4-DIAL INSTRUMENT
PANEL
Engine oil pressure
warning light
This indicates that the engine oil
pressure is too low.
It is linked with the STOP warning
light
Stop immediately if it is displayed
while the engine is running.
In the case of a lack of oil in the lubri-
cation circuit, top up the oil.
Contact a PEUGEOT dealer as soon
as possible. Coolant temperature
warning light
This indicates that the engine tem-
perature is high.
It is linked with the STOP warning light.
Stop immediately.
Wait for the engine to cool
down before topping up the
level, if necessary.
Battery charge warning
light
This indicates a charging circuit fault
(battery terminals, alternator belt).
Contact a PEUGEOT dealer.
Punctured tyre warning
light
This indicates that one or more punc-
tured tyres have been detected.
A message on the multifunction display
indicates the wheel(s) concerned.
It is linked with the STOP warning
light.
Stop immediately.
Change the damaged wheel.
Have it repaired by a PEUGEOT
dealer.
Instruments and controls
Coolant temperature indicator
When the needle is in zone A, the
temperature is correct.
When the needle is in zone B, the
temperature is too high.
If the coolant temperature warning
light comes on (linked with the STOP
warning light), stop immediately.
Wait for the engine to cool down
before topping up the level, if neces-
sary.
As the cooling circuit is pressurised,
in order to prevent any risk of scald-
ing, unscrew the cap by two turns to
allow the pressure to drop.
When the pressure has dropped, re-
move the cap and top up the level, if
necessary.
Contact a PEUGEOT dealer. Automatic CHECK
With the key in the ignition on posi-
tion, all of the warning lights of the
functions tested are displayed. They
are switched off after a few seconds.

34 -
11-10-2004
35
-
11-10-2004
This indicates an automatic
gearbox program fault.
Automatic gearbox lever
postion indicator lights
This indicates an automatic
gearbox malfunction.
4 or 6 speed automatic gearbox
"Manual" indicator lights
"Park" indicator
lights
"Reverse"
indicator lights
"Neutral" indicator
lights
"Drive" indicator
lights
The letter S or the symbol T asso-
ciated with the gate lever position
indicator lights, corresponds to the
Sport or Snow program selected
intentionally. These correspond to the manual
control of the gearbox, four or six
speed.
When the engine speed is too low
or too high in relation to the gear
engaged, the gear selected lashes
for a few seconds, then the actual
gear is displayed, the auto-adaptive
program having taken control
temporarily.
Instruments and controls
Engine oil temperature
indicator
When the ignition is switched on or
while the vehicle is moving, this indi-
cates the engine oil temperature.
When the needle is in zone
C, the
temperature is correct.
When the needle is in zone D, the
temperature is too high.
Reduce your speed to lower the tem-
perature.

36 -
11-10-2004
37
-
11-10-2004
SERVICE INDICATOR
This is a visual reminder of when the
next service is due. This service is to
be carried out according to the man-
ufacturer's servicing schedule.
Operation
As soon as the ignition is switched
on and for 5 seconds, the spanner
symbolising ''service operation'' is lit.
The trip recorder display shows the
distance remaining (in round igures)
before the next service.
Example: when switching on the
ignition and for 5 seconds, the
display shows that 900 miles/km
remain before the next service is
due. Service indicator zero re-set
Your PEUGEOT dealer carries out
this operation after each service.
However, if you carry out the service
yourself, the re-set procedure is as
follows:
F
Switch off the ignition,
F Press and hold the trip recorder
re-set button,
F Switch on the ignition.
The display begins a countdown.
When the display shows "= 0", re-
lease the button; the service symbol
disappears.
Important: after this operation, if you
wish to disconnect the battery, lock
the vehicle and wait for at least ive
minutes, otherwise the zero re-set
will not be registered.
Once an engine oil level indication
has been displayed, the display indi-
cates the total and trip distances.
If the service is overdue, each
time the ignition is switched on and
for 5 seconds,
the distance and the
service spanner lash.
Example: when the ignition is
switched on and for 5 seconds, the
display indicates that the service
is overdue by 300 miles/km. The
service should be carried out very
shortly.
Once the servicing and oil level infor-
mation has been displayed, the total
distance recorder resumes normal
operation and the symbol remains
lit.
The point at which a service is due is
calculated using two parameters:
- the total distance travelled,
- the time elapsed since the last service.
The distance remaining may be
weighted by the time factor, depend-
ing on the user's driving habits.
Instruments and controls