oil filter Peugeot 508 2016 Owner's Manual

10
508_en_Chap00b_vue-ensemble_ed01-2016
Maintenance - technical data
Identification markings 2 73
Dimensions 271-272
Running out of fuel (Diesel)

2

28
Checking levels
2

18-220
-

oil
-

b

rake fluid
-

p

ower steering fluid
-


coolant
-
s

creenwash/headlamp wash fluid
-

f

uel additive (Diesel)
AdBlue
® additive 3 5-38, 223-226
Checking components 2 21-222
-

1

2 V battery
-

a

ir filter
-
p

assenger compartment filter
-

o

il filter
-

p

article filter (Diesel)
-


gearbox
-

b

rake pads / discs
-
par

king brake
-

e

lectric parking brake
Changing bulbs
2

42-248
-

front
-

rear 12V battery

2
53 -256
Removing/refitting the 12V battery

257-260
Load reduction, economy mode
26
1
en

gine compartment fuses
2
49, 252
Opening the bonnet
2
14
un

der the bonnet, petrol
2
15
un

der the bonnet, Diesel
2
16 -217
Petrol engines

2
64
Diesel engines
26

6-267Petrol weights

2
65
Diesel weights
26

8-269
Over view

12
508_en_Chap00c_eco-conduite_ed01-2016
Limit the causes of excess consumption
Spread loads throughout the vehicle; place the heaviest items in the
bottom of the boot, as close as possible to the rear seats.
Limit the loads carried in the vehicle and reduce wind resistance (roof
bars, roof rack, bicycle carrier, trailer...). u
s
e a roof box in preference.
Remove roof bars and roof racks after use.
At the end of winter, remove snow tyres and refit your summer tyres.
Observe the recommendations on
maintenance
Check the tyre pressures regularly, when cold, referring to the label in
the door aperture, driver's side.
Carry out this check in particular:
-

b
efore a long journey,
-

a
t each change of season,
-

a
fter a long period out of use.
Don't forget the spare wheel and the tyres on any trailer or caravan.
Have your vehicle serviced regularly (engine oil, oil filter, air filter,
passenger compartment filter...) and observe the schedule of
operations recommended in the manufacturer's service schedule.
With a BlueHDi Diesel engine, if the SCR system is faulty your vehicle
becomes polluting; go to a P
e

uge
Ot
dealer or a qualified workshop
without delay to have the emissions of nitrous oxides brought back to
the legal level.
When refuelling, do not continue after the third cut-off of the nozzle to
avoid any over flow.
At the wheel of your new vehicle, it is only after the first 1 800 miles
(3
000 kilometres) that you will see the fuel consumption settle down to
a consistent average.
eco-driving

20
508 _en_Chap01_instrument-bord_ed01-2016
Serviceon temporarily. A minor fault has occurred for which
there is no specific warning lamp. Identify the fault by means of the associated
message, such as:
-

l
ow engine oil level,
-

l
ow screenwash/headlamp wash fluid level,
-

d
ischarged remote control battery,
-

l
ow tyre pressures,
-

s
aturation of the particle filter (FAP) on Diesel
vehicles.
For more information on checking the particle filter,
refer to the corresponding section.
For any other faults, contact a P
e

uge
Ot
dealer or a
qualified workshop.
fixed. A major fault has occurred for which
there is no specific warning lamp. Identify the fault by reading the message and contact
a P
e

uge
Ot
dealer or a qualified workshop.
fixed, associated with
flashing and then
fixed display of the
service spanner.
the

servicing interval has been
exceeded. Only on BlueHDi Diesel versions.
Your vehicle must be serviced as soon as possible.
Warning / indicator lamp
StateCause Action / Observations
Instruments

220
508_en_Chap07_info-pratiques_ed01-2016
Coolant level
the coolant level should be close
to the "MA X" mark but should never
exceed it.
In addition, as the cooling system is pressurised,
wait at least one hour after switching off the engine
before carrying out any work.
to a

void any risk of scalding, unscrew the cap by
two turns to allow the pressure to drop. When the
pressure has dropped, remove the cap and top up
the level.
Changing the coolant
the coolant does not have to be replaced at routine services.
Fluid specification
the coolant must conform to the
manufacturer's recommendations.
Fluid specification
For optimum cleaning and to avoid freezing,
this fluid must not be topped up with or
replaced with plain water.
Screenwash and headlamp
wash fluid
In the case of vehicles fitted with
headlamp washers, the low fluid level
is indicated by an audible signal and
a message in the instrument panel
screen.
Avoid prolonged contact of used oil or
fluids with the skin.
Most of these fluids are harmful to
health or indeed very corrosive.
Do not discard used oil or fluids into
sewers or onto the ground.
ta

ke used oil to a P
e
uge
Ot
dealer or
a qualified workshop (France) or to an
authorised waste disposal site.
Used products
A low additive level is indicated by illumination
of this warning lamp, accompanied by an
audible warning and a message in the
instrument panel screen.
Diesel additive level (Diesel
engine with particle filter)
When the engine is warm, the temperature of
the coolant is regulated by the fan.
to

p up the reservoir when you next stop
the


vehicle.
In wintry conditions, the use of an
ethyl alcohol or methanol base fluid is
recommended.
The cooling fan may star t after
switching off the engine: take care
with articles and clothing that might
be caught by the fan blades.
To p p i n g u p
this additive must be topped up by a
Pe
ugeOt dealer or a qualified workshop
without delay.
Practical information

221
508_en_Chap07_info-pratiques_ed01-2016
Checks
12 V battery
the battery does not require any
maintenance.
However, check regularly that the
terminals are correctly tightened (versions
without quick release terminals) and that
the connections are clean.Refer to the manufacturer's
service schedule for details of the
replacement intervals for these
components.
Air filter and passenger compartment filter
Replace the oil filter each time the
engine oil is changed.
Refer to the manufacturer's
service schedule for details of
the replacement interval for this
component.
Oil filter
Versions equipped with Stop & Start are
fitted with a 12 V lead-acid battery of specific
technology and specification.
Its replacement should be carried out only by a
P
e
uge
Ot
dealer or a qualified workshop.
Particle filter (Diesel)
the start of saturation of the particle
filter is indicated by the temporary
As soon as the traffic conditions permit,
regenerate the filter by driving at a speed
of at least 40 mph (60 km/h) until the
warning lamp goes off.
If the warning lamp stays on, this
indicates a low additive level.
For more information on checking levels,
refer to the corresponding section.
On a new vehicle, the first particle
filter regeneration operations may be
accompanied by a "burning" smell,
which is per fectly normal.
Following prolonged operation of the
vehicle at very low speed or at idle,
you may, in exceptional circumstances,
notice the emission of water vapour at
the exhaust on acceleration.
t
h
is does
not affect the behaviour of the vehicle
or the environment.
un

less otherwise indicated, check these components in accordance with the manufacturer's service schedule and according to your engine.
Other wise, have them checked by a P
e

uge
Ot

dealer or a qualified workshop.
When carrying out any operation on the 12 V
battery, refer to the corresponding section for
details of the precautions to be taken before
starting work. Depending on the environment (e.g. dusty
atmosphere) and the use of the vehicle
(e.g.

city driving), replace them twice as often
if necessary .
A clogged passenger compartment filter may
have an adverse effect on the per formance
of the air conditioning system and generate
undesirable odours. illumination of this warning lamp accompanied
by a message in the multifunction screen.
7
Practical information

264
508_en_Chap09_caracteristiques-techniques_ed01-2016
Petrol engine1.6 litre THP 15 0 / 15 61.6 litre THP 165 S&S
Gearbox Automatic
(6-speed) Manual
(6-speed)
eAt6

automatic
(6-speed)
Model code


8D...: 508 saloon


8E...: 508 SW 8D5FNA - 8
e5

FNA
8 D5 F VA - 8
e5

F VA8 D 5 F Z A* * 8D5GZM/S
8E5GZM/S 8 D5G Z T/S
8E5GZT/S
Cubic capacity (cc) 1 5981 6 01* * 1 598
Bore x stroke (mm) 77 x 85.877 x 85.8
Max power:
eu standard (kW)* 11 0
115 115 * *
121
Max power engine speed (rpm) 6 0006 000
Max torque:
eu standard (Nm) 240240
Max torque engine speed (rpm) 1 4003 000** 1 400
Fuel
u

nleaded
u
nleaded
Catalytic converter yesyes
Oil capacities (in litres)
eng

ine (with filter replacement) 4.254.25
Petrol engines and gearboxes
* the maximum power corresponds to the value type approved on a test bed, under conditions defined by eu ropean legislation
(Directive 1999/99/eC ).
** For Iran only.
technical data

266
508_en_Chap09_caracteristiques-techniques_ed01-2016
Diesel engine1.6 litre BlueHDi 120 S&S2.0 litre HDi 140
Gearbox Manual
(6-speed)
eAt6

automatic
(6-speed) Manual
(6-speed)
Model code


8D...: 508 saloon


8E...: 508 SW 8DBHZM/S
8
eB

HXM/S8DBHZT/S - 8DBHXT/S
8EBHZT/S - 8EBHXT/S 8DRHR8
8DRHF8
Cubic capacity (cc) 1 5601 560 1 997
Bore x stroke (mm) 75 x 88.375 x 88.3 85 x 88
Max power:
eu standard (kW)* 8888103
Max power engine speed (rpm) 3 5003 5004 000
Max torque:
eu standard (Nm) 300300 320
Max torque engine speed (rpm) 1 7501 7502 000
Fuel DieselDieselDiesel
Catalytic converter yesyesyes
Particle filter yesyesyes
Oil capacity (in litres)
eng

ine (with filter replacement) 3.253.25 5.25
Diesel engines and gearboxes
* the maximum power corresponds to the value type approved on a test bed, under conditions defined by eu ropean legislation
(Directive 1999/99/eC ).
technical data

267
508_en_Chap09_caracteristiques-techniques_ed01-2016
Diesel engine2.0 litre HDi 136 / 1632.0 litre BlueHDI 136** /
15 0 S&S2.0 litre BlueHDi 180 S&S
Gearbox Manual
(6-speed)
eAt6

automatic
(6-speed) Manual
(6-speed)
eAt6

automatic
(6-speed)
Model code



8

D... : 508 Berline



8

E... : 508 SW


8U... :
508 Non-hybrid RXH
8DRHHA
8DRHDA 8DRHH88DAHXM/S
8eAH XM/S8DAHWt/
S
8eA HWt /S
8
uA

HW
t
/S
Cubic capacity (cc) 1 9971 9971 9971 997
Bore x stroke (mm) 85 x 8885 x 8885 x 8885 x 88
Max power:
eu
standard (kW)* 12010 0
120 10 0**
11 0 132
Max. power engine speed (rpm) 3 7503 7504 000 3 750
Max torque:
eu
standard (Nm) 340340 370400
Max torque engine speed (rpm) 2 0002 0002 0002 000
Fuel DieselDieselDieselDiesel
Catalytic converter yesyesyesyes
Particle filter yesyesyesyes
Oil capacities (in litres)
eng

ine (with filter replacement) 556 .1 5 .1
Diesel engines and gearboxes
* the maximum power corresponds to the value type approved on a test bed, under conditions defined by eu ropean legislation
(Directive 1999/99/eC ).
** For Belgium only.
9
technical data

276
508_en_Chap10b_JBL_ed01-2016
JBL eQuIPMeNt
the Hi-Fi system is a 5.1 system developed by
PeugeOt in conjunction with JBL.
4 two-way speaker kits, separated by an active
filter, are fitted at front and rear.
th

ese are based on a fabric dome tweeter
delivering stable and balanced treble
reproduction and a 50W RMS neodymium
magnet inverted motor medium-woofer
possessing a very high output of bass
frequencies.
th

e central acoustic path in the dashboard
improves reproduction of the musical
scene, putting the listener in a situation that
realistically reproduces the original musical
recording.
th

e bass unit located in the boot carries a
150W triple-coil true subwoofer in an optimised
space, giving depth and impact to the bass
ranges.
th

is set of speakers is controlled by a 10 -way
500W RMS 2 ohm amplifier, using advanced
surround sound and sound distribution
handling, so as to deliver optimum performance
both for the driver and for the passengers in the
vehicle.
Audio and telematics

354
508_en_Chap11_index-alpha_ed01-2016
gauge, fuel.............................................. 13, 20 0ge
arbox,
automatic
........ 1

1, 16, 176, 180, 183, 222, 253
ge

arbox, manual

......11, 16, 174, 180, 183, 222
gea

r lever, automatic gearbox
..................... 17

6
ge

ar lever, manual gearbox

.........................174
ge

ar shift indicator

....................................... 175
gl

ove box ...................................................... 101
gr

ound clearance

......................................... 272
gu

ide-me-home

.................................... 121, 124Identification, vehicle
....................................
2
73
Immobiliser, electronic

................
52, 61, 69, 167
Indicator, coolant temperature
........................ 3
0
Indicator, engine oil level ................................
31
Indicator lamps ................................................
14
Indicators, direction ......................................120
Inflating tyres


..........................................11, 2 7 3
Inflating tyres and accessories (using the kit)
..............................

................234
Input, auxiliary
.............................. 1

08, 292, 346
Instrument panel
...............................

..............13
Instruments and controls

..................................7
I

ntelligent t
ra
ction Control
............................13

4
ISOFIX


...................................................152-15 6
Hazard warning lamps


..........................
132, 2 27
Headlamp adjustment

...................................
126
Headlamps, automatic illumination

......
118 , 12 1
Headlamps, dipped beam

.............
117, 242, 244
Headlamps, halogen

.............................
242, 244
Headlamps, main beam
................ 1
17, 242, 244
Headlamp wash

............................................
128
Head restraints, front ................................
75, 78
Head restraints, rear .....................................
109
Head-up display

............................
18 4, 188, 19 0
Heating

.........................................
83, 86, 88, 91
Heating, programmable (Webasto)
................ 97
H
ill start assist
...............................................
18
3
Horn ............................................................... 132
Filling the fuel tank

............................... 20

0, 202
Filter, air
...............

......................................... 221
Filter, oil


......................................................... 221
Filter, particle


........................................ 220, 221
G
I
E
H
F
Driving positions (storing) ...............................77
Dynamic stability control (DSC) ........ 1
8, 22, 133Filter, passenger compartment
.....................221
Fitting a wheel ............................... ................240
Fitting roof bars


.............................................212
Fittings, boot
......................................... 11

2 , 113
Fittings, front


...................................................99
Fittings, rear
...............................

...................111
Flap, fuel filler

...............................
.................200
Flashing indicators


................................120, 125
Foglamps, front


.............................119, 123, 242
Foglamps, rear


..............................119, 245, 246
Folding the rear seats


...................................109
Folding/unfolding the door mirrors


.................80
Frequency (radio)


..........................................288
Fuel ................................................................ 202
Fuel consumption
............................................ 11
F

usebox, dashboard

.....................................250
Fusebox, engine compartment


.....................252
Fuses


.............................................................249
e

BA

............................................................... 13 3
ec

o-driving (advice)

........................................ 11
el

ectronic brake force distribution
(
eB

FD)

........................................................ 13 3
em

ergency call
..................................... 1

3 2 , 2 74
em

ergency switching off
............................... 16

6
em

ergency warning lamps
................... 13

2, 2 27
em

issions control system, SCR .............25, 223
en

ergy economy mode

.................................261
en

gine compartment

.............................215 -217
en

gine,
Diesel


............16, 202, 216, 217, 228, 266, 268
en

gine, petrol

....................... 202, 215, 264, 265
en

vironment
......................... 1

1, 54, 63, 96, 179,
186, 220, 226, 253
Alphabetical index