PEUGEOT 607 2005.5 Owners Manual

110 -Practical information
01-06-2005
111
-
Practical information
01-06-2005
Fuse N° Rating
Functions
F1 15 A Front wash-wipe pump and wash-wipe luid level sensor.
F2 30 A Locking and deadlocking earth.
F3 5 A Air bags.
F4 10 A Clutch switch, brake dual-function switch, diagnostic connector,
ESP sensor, air bags and
pre-tensioners unit, air conditioning BCP3 relay, electrochromatic mirror.
F5 30 A Front electric windows and sunroof supply.
F6 30 A Rear electric windows supply.
F7 5 A Glove box switch, courtesy lights, map reading lights, courtesy mirror .
F8 20 A Multifunction display supply, steering wheel control, alarm sire n, trailer fusebox supply.
F9 30 A Front and rear lighters.
F10 15 A Additive reservoir control unit supply.
F11 15 A Automatic gearbox control unit, automatic gearbox p ositions selection switch, ignition switch.
F12 15 A Trailer fusebox supply, hands-free kit, seats relay, seat memory uni
t, rain and brightness
sensor.
F13 5 A Engine fusebox supply, headlamp adjustment supply.
F14 15 A Parking assistance control unit supply, headlamp adjustment switch
, instrument panel, air
conditioning, air bags and pre-tensioners unit.
F15 30 A Locking and deadlocking supply.
F17 40 A Heated rear screen and heated mirrors.

114 -Practical information
01-06-2005
115
-Practical information
01-06-2005
CHANGING A WINDSCREEN
WIPER BLADE
Placing the wiper blades in the
maintenance position
F
Less than one minute after switch-
ing off the ignition, press the wind-
screen wiper stalk down once to
position the blades at the top of the
windscreen (maintenance position).
Replacing a blade
F Lift the arm, then unclip the blade
and remove it.
F Fit the new blade and fold down
the arm.
To reposition the blades, switch on the
ignition and operate the windscreen
wiper stalk.
ECONOMY MODE FUNCTION
After the engine has stopped, certain
functions (windscreen wiper, electric
windows, sunroof, electric seats, au-
dio equipment, telephone, etc) can
only be used for a combined duration
of approximately thirty minutes, to
prevent discharging the battery.
Once the thirty minutes are over, a
switching to economy mode mes-
sage appears on the multi-function
display and the active functions are
put on standby.
These functions are reactivated au-
tomatically next time the vehicle is
driven.
In order to resume the use of these
functions immediately, the engine
must be started and left to run for a
few minutes.
The time available to you will then
be double the duration for which the
engine is left running. However, this
period will always be between ive
and thirty minutes.
Note: if the telephone is being used
when economy mode starts, it will
still be possible to inish the call.
A lat battery prevents the
engine from starting.
LOAD REDUCTION
FUNCTION
When driving, certain functions (air
conditioning, heated rear screen,
heating system for passenger com-
partment of diesel vehicles, etc.) may
be switched off temporarily, depend-
ing on the level of battery charge.
Reactivation of these functions is
automatic, once the battery charge
is suficient.
Note: at the risk of discharging the
battery, the functions that have been
switched off may be reactivated
manually.

114 -Practical information
01-06-2005
115
-Practical information
01-06-2005
BATTERY
The battery is in the left boot trim. Never disconnect a ter-
minal when the engine is
running.
Never charge a battery with-
out irst disconnecting the
terminals.
Close the windows and sunroof fully
before disconnecting the battery.
Use cables of suitable cross-sec-
tion; for further information, contact a
PEUGEOT dealer.
After every re-connection of the bat-
tery, switch on the ignition and wait
for 1 minute before starting, to alllow
the electronic systems to be initial-
ised. However, if slight dificulties
are experienced after this, please
contact a PEUGEOT dealer.
To charge the battery using a
battery charger:
F pull the handle downwards and
fold back the panel to gain access
to the battery,
F disconnect the green terminal (-)
of the battery,
follow the instructions for use given
by the battery charger manufacturer,
F check that the terminals and
connectors are clean. If they are
covered with sulphate (whitish
or greenish deposit), disconnect
them and clean them,
F reconnect the green terminal (-) of
the battery,
F reit the panel and close it. To start the vehicle from another
battery:
F
open the bonnet,
F remove the left side cover,
F use the two additional terminals (+)
and (-) located under the bonnet,
F open the red cover of the (+) terminal,
F connect the red cable between
the (+) terminal and the positive (+)
terminal of the slave battery,
F connect the green or black cable be-
tween the (-) terminal and the nega-
tive (-) terminal of the slave battery,
F start the engine and let it run,
F wait for the engine to return to idle
then disconnect the cables,
F close the red cover of the (+) ter-
minal,
F reit the left side cover,
F close the bonnet. If electrical work is carried out,
disconnect the battery.
It is advisable to disconnect the
battery if the vehicle is not to be
used for a period of more than
one month.
When charging or replacement
of the battery is necessary, do
not close the boot as, since it is
only opened electrically, it would
then be necessary to use the
emergency control (see corre-
sponding section).
Do not connect a slave battery to
the (+) and (-) terminals located
under the bonnet if there is no
battery in the boot (risk of short
circuit).

116 -Practical information
01-06-2005
117
-Practical information
01-06-2005
TOWING YOUR VEHICLE
Without lifting (4 wheels on
the road)
You should always use a towbar.
The towing eye is inside the spare
wheel. From the rear:
F
Carefully unclip the top of the
cover using a small screwdriver,
F Screw in the towing eye until it
locks.
Lifting (2 wheels only on the
road)
It is preferable to raise the vehicle us-
ing professional lifting equipment.
Never use the radiator crossmem-
ber.
From the front:
F
Carefully unclip the bottom of the
cover, using a small screwdriver.
F Screw in the towing eye until it
locks. When towing with the en-
gine switched off, there is
no braking or steering as-
sistance.
Special features of the
automatic gearbox
Towing a vehicle with an automatic
gearbox in reverse gear is
prohibi-
ted (absence of lubrication).
When being towed with all four
wheels on the ground, it is imperative
that the following rules are obeyed:
- selector lever in position N,
- the vehicle must be towed at a speed of less than 30 mph (50 km/h) over
a maximum distance of 30 miles
(50 km),
- do not add oil to the gearbox.

116 -Practical information
01-06-2005
117
-Practical information
01-06-2005
TOWING A TRAILER,
CARAVAN, BOAT, ETC...
We recommend the use of original
PEUGEOT towbars which have been
tested and approved from the design
stage of your vehicle and that you
entrust the itting of the towbar to a
PEUGEOT dealer. Note:
in certain cases of particularly
arduous use (towing the maximum
load in high temperatures on a steep
slope), the engine automatically
limits its power and selects the ap-
propriate automatic gearbox gear in
manual mode. In this case, cutting off
the air conditioning allows the engine
power to be recovered, and therefore
the towing capacity to be increased.
If the coolant temperature warning
light comes on, stop the vehicle and
switch off the engine as soon as pos-
sible.
Tyres: check the tyre pressures of
the towing vehicle (label on the cen-
tral door pillar on the driver's side)
and of the trailer towed, observing
the recommended pressure.
Brakes: towing increases the brak-
ing distance. Drive at a moderate
speed, change down early and brake
gradually.
Side wind: sensitivity to side wind is
increased. Drive smoothly and at a
moderate speed. Automatic adjustment
For vehicles with Xenon bulbs, this
system automatically corrects the
height of the beam, whatever the
load of the vehicle. The driver is then
assured of having optimum lighting
and not causing a nuisance to other
road users.
Driving advice
Distribution of loads:
distribute the
load in the trailer so that the heavi-
est loads are as close as possible to
the axle and the nose weight is close
to the maximum authorised without,
however, exceeding it.
Cooling: towing a trailer on a slope
increases the coolant temperature.
As the fan is electrically controlled,
its cooling capacity is not dependent
on the engine speed.
In the case of vehicles itted with an
HDI engine, it is advisable, following
intensive use (towing on a motorway,
prolonged driving, ...), to leave the
engine running at idle for approxi-
mately 20 seconds before switching
off the ignition. This limits any in-
crease in the temperature of the en-
gine after it has been switched off.
In all cases, pay attention to the cool-
ant temperature.
Lighting
Manual adjustment
Adjust your headlamps so as not to
dazzle other road users. Check the
electrical signalling of the trailer.

118 -Practical information
01-06-2005
ACCESSORIES FOR YOUR
607
A wide range of accessories recom-
mended by PEUGEOT and original
parts are offered by the Network.
They all beneit from PEUGEOT's
recommendation.
These accessories and parts, having
been tested and approved for reli-
ability and safety, are all adapted to
your PEUGEOT vehicle.
The product range offered by PEUGEOT
Accessories is structured around 5 cat-
egories: PROTECTION - TOURING -
IN-CAR TECHNOLOGY - STYLING
UNIVERSAL.
The itting of electrical
equipment or accessories
which are not recom-
mended by PEUGEOT may
result in a failure of your ve-
hicle's electronic system.
Please note this speciic warning.
You are advised to contact a repre-
sentative of the Marque to be shown
the range of recommended equip-
ment and accessories.
"Protection":
parking assistance, anti-
theft alarm, stolen vehicle
tracking system*, engraved
windows, locking wheel
nuts, irst aid kit, warn-
ing triangle, high visibility
safety jacket, snow chains. "Touring":
covers compati-
ble with side air bags, mats,
boot tray, luggage retaining
net, sill protectors.
For leisure pursuits: roof
bars, transportation acces-
sories (bicycle carrier, ski
carrier), roof box, child seats and
booster cushions, rear screen blind,
audio/telephone console, cool box.
Trailer towbar which must be itted by
the PEUGEOT Network.
"In-Car Technology": tele-
phone, hands-free kits, sat-
ellite navigation systems,
CD changer, DVD player,
video screen.
"Styling": alloy wheels,
wheel trims, spoiler, leather
gear lever knob, styling
strips, door spoilers, sport
exhaust. "Universal":
windscreen
wash luid, interior and ex-
terior cleaning and mainte-
nance products.
Wheels which are itted with 235/
45 R 18 tyres cannot be itted with
snow chains. For further informa-
tion, contact a PEUGEOT dealer. Note
To prevent the mat from becoming
caught under the pedals:
- ensure that the mat is positioned
and secured correctly,
- never it one mat on top of another. Compatible portable equipment
For the Audio RD4, the itting of an
auxiliary socket is offered speciically
by the Network.
The audio cable for connection to the
auxiliary socket is also offered by the
Network.
Following connection of the cable
and selection of the AUX mode, by
means of the source button, your
portable equipment is ready for use.
Set the portable equipment to half
volume to avoid overloading the au-
dio equipment sound. Then use the
audio equipment volume button.
* According to country.

119
-
Technical data
01-06-2005
MODELS:
Model codes 9U... PETROL DIESEL
3FYH XFV6 - XFVJ
XFVJ/D - XFVU/D RHLH RHRH
ENGINES 2.2 litre 16V 3 litre 24V V6 Injection 2 litre 16V Turbo
Diesel HDI
Capacity (cm 3
) 2 230 2 946 1 997
Bore x stroke (mm) 86 x 96 87 x 82.6 85 x 88
Number of valves 16 24 16
Max. power: EU standard (KW) 120 155 93 100
Max. power at engine speed (rpm) 5 875 6 000 4 000
Max. torque: EU standard (Nm) 220 290 320
Max. torque at engine speed (rpm) 4 150 3 750 2 000
Fuel Unleaded Unleaded Diesel
Catalytic converter Yes Yes Yes
Particle emission ilter (PEF) No No Yes
Electronic injection Yes Yes Yes
GEARBOX Manual
(6-speed) Automatic
(6-speed) Manual
(6-speed)
CAPACITIES (in litres)
Engines (with ilter replacement) - (1) 4.75 (1)/5.25 (2) 5.25 (1)
ENGINES AND GEARBOXES
(1) Draining by gravity - (2) Draining by suction

120 -Technical data
01-06-2005
121
-Technical data
01-06-2005
Fuel consumption values correct at time of printing. These consump
tion values were established in accordance with EC Di-
rective 80/1268 (as amended). They may vary depending on the style of driving, trafic conditions, weather conditions, the
load in the vehicle, the maintenance of the vehicle and t he use of the accessories.
As per EC Directive 80/1268 (as amended) in MPG (litres/100
km)
Engine Gearbox Model
codes 9U... Urban driving
(liter/100 km) Extra-urban
driving
(liter/100 km) Mixed driving
(liter/100 km) Emission
by mass of CO
2 (g/km)
2.2 litre 16V Manual
3FYH21.7 (13.0) 40.4 (7.0) 30.7 (9.2) 219
3 litre 24V V6
injection AutomaticXFV6 - XFVJ
XFVJ/D -XFVU/D 19.0 (14.9) 37.6 (7.5) 27.2 (10.2) 242
2 litre 16V
turbo diesel HDI ManualRHLH
RHRH 8.1 (34.9) 5.0 (56.5) 6.1 (46.3) 162
CONSUMPTION

120 -Technical data
01-06-2005
121
-
Technical data
01-06-2005
WEIGHTS AND TOWING LOADS (in kg)
Engines PETROL DIESEL
2.2 litre 16V 3 litre 24V
V6 injection 2 litre 16V HDI
Gearboxes Manual Automatic Manual
Model codes: 9U... 3FYH XFV6 - XFVJ
XFVJ/D - XFVU/D RHLH RHRH
• Kerb weight 1 535 1 644 1 590
• Payload 493 500 493
• Gross vehicle weight (GVW) 2 028 2 144 2 083
• Gross train weight (GTW)
on 12 % gradient 3 628 3 644 3 583
on 8 % gradient 3 828 3 944 3 883
• Braked trailer (within GTW limit)
on 12 % gradient 1 600 1 500 1 500
on 10 % gradient 1 600 1 500 1 500
on 8 % gradient 1 800 1 800 1 800
• Braked trailer* (with load transfer within GTW limit) 1 850 1 800 1 760
• Unbraked trailer 750 750 750
• Recommended nose weight 74 72 72
*
The weight of the braked trailer may be increased, within th e GTW limit, by the same amount by which the GVW of the tow ing
vehicle is reduced; warning, towing with a lightly loaded towing vehicle may have an adverse effect on its road holding.
The GTW values and the towing loads indicated are valid f or a maximum altitude of 1 000 metres; the towing load menti oned
must be reduced by 10 % for every 1 000 additional metres.
The speed of a towing vehicle is limited to 60 mph (100 km/h )**.
High exterior temperatures may result in lowering of the performan ce of the vehicle in order to protect the engine; when the
exterior temperature is above 45 °C, limit the towed load.
** according to the legislation in force in the country.

122 -Technical data
01-06-2005
123
-Technical data
01-06-2005
THE IDENTIFICATION
FEATURES OF YOUR 607
A. Manufacturer's plate.
B. Serial number on the
bodywork.
C. Serial number on the fascia. D. Tyres.
Label
D on the central door pillar on
the driver's side indicates:
- the dimensions of the rims and tyres,
- the makes of tyre recommended by the manufacturer, - the tyre pressures
(checking of
the tyre pressure must be car-
ried out when the tyres are cold,
at least once a month) ,
- the paint colour reference.