Peugeot Boxer 2004 Owners Manual

16-02-200416-02-2004
4849YOUR BOXER IN DETAIL
Never leave one or more
children alone and unsu-
pervised in a vehicle.
Never leave a child or
an animal in a vehicle which is
exposed to the sun and has the
windows closed.
To protect your young children
from the sun, it blinds on the rear
windows.
Groups 1, 2 and 3: from 9 to 36 kg
L7 - "Kiddy Life": installed in the rear
using a three-point seat belt.
The height and width at the shoul-
ders and the length of the seat cush-
ion must be adjusted according to
the age and build of your child. Recommendations
For optimum installation of a forwards
facing child seat, check that the back
of the child seat is resting against the
back of the vehicle's seat correctly
and that the head restraint does not
cause any discomfort.
If it is necessary to remove the
head restraint, as in the case of the
"RECARO Start", "KLIPPAN Optima"
and "KIDDY Life" child seats (over
6 years of age), ensure that the
head restraint is securely stored or
attached so that it cannot act as
a projectile in the event of sharp
braking.
L6- "Klippan Optima": installed in the
rear using a three-point seat belt.
From the age of 6 years (approxi-
mately 22 kg), the booster is used
on its own.
Disarm the passenger air bag
when installing a "rearwards
facing" child seat on the front
passenger seat. Otherwise, the
child would risk being seriously
injured or killed were the air bag
to inlate.For the safety of young children (from
9 to 18 kg), PEUGEOT recommends
use of the restraining cushion.
Never leave the keys within reach
of children inside the vehicle.
Observe strictly the
recommendations for assembling
and securing the child seat
as shown in the child seat
instructions.
To prevent the doors from opening
accidentally, use the child lock*.
Also, do not open the rear windows
more than a third*.* According to model.

16-02-200416-02-2004
5051YOUR BOXER IN DETAIL
INSTALLATION OF CHILD SEATS SECURED USING THE SEAT BELT
In accordance with the European regulation (Directive 2000/3), this table indicates the options for the installation of child
seats secured using the seat belt and universally approved.
Installation of child seats secured using the seat belt in relation to the weight of the child and the seat in the
vehicle.
(*) The rules for transporting children in the front passenger se at are speciic to each country. Consult the current
legislation in your country.
Group 0+ Group 1 Group 2 Group 3
from birth to 1 year or weighing up to 13 kg from 1 to 3 years
or weighing 9 to 18 kg from 3 to 6 years or
weighing
15 to 25 kg from 6 to 10 years
or weighing 22 to 36 kg
Seats suited to the installation of a child seat secured usin g the seat belt and universally approved U “rear facing” and
“forward facing”.
Front passenger seat (*)
U U U U
Rear side seats
Rear centre seats

16-02-200416-02-2004
5051YOUR BOXER IN DETAIL
SEAT BELTS
To adjust the height of the front
seat belts
F To lower the attachment point,
press the upper control and slide
it downwards.
F To raise the attachment point,
slide the control upwards.
To lock the seat belts
F Pull the strap, then insert the
buckle into the stalk.
Pre-tensioning front seat belts
Safety in the event of a frontal
impact has been improved by
the introduction of pre-tensioning
front seat belts. Depending on the
seriousness of the impact, the pre-
tensioning system instantly tightens
the seat belt irmly against the body
of the occupant.
The pre-tensioning seat belts are
armed when the ignition is on.
Rear seat belts
Minibus: the rear seats are all itted
with three-point inertia reel seat
belts.
Combi: the rear side seats are itted
with three-point inertia reel seat
belts. The centre seats are itted with
lap seat belts
To be effective, a seat
belt must be tightened
as close to the body as
possible.
Depending on the nature and the
seriousness of the impact, the
pre-tensioners may be triggered
before and independently of the
air bags.
In all cases of an air bag being
triggered, the air bag warning light
on the instrument panel comes
on.
After an impact, have the system
checked by a PEUGEOT dealer.

16-02-200416-02-2004
5253YOUR BOXER IN DETAIL
THE KEYS
The keys allow you to switch on the
ignition and operate the passenger
air bag disarming switch as well as to
independently operate the locks on
the front doors, the fuel iller cap and
the glove box.
Unfolding the key
Button 1 unfolds the key from the
remote control casing.
To re-fold the key, press button 1 and
fold the key into the remote control
casing.
Central locking
From the driver’s door, the keys
allow you to lock and unlock the front
doors, the side door (Minibus) and
the rear doors.
If one of the front doors is open, the
central locking does not work.
The remote control performs the
same functions at a distance.
The remote control
Locking
Press button A to lock the vehicle.
Unlocking
Press button B to unlock the vehicle.

16-02-200416-02-2004
5253YOUR BOXER IN DETAIL
Electronic engine immobiliser
This locks the engine control system
as soon as the ignition has been
switched off and therefore prevents
starting of the vehicle by anyone who
does not have the key.
The ignition key has an electronic
chip which has a special code.
When the ignition is switched on, the
code must be recognised for starting
to be possible.
If the system does not function
correctly, the electronic immobiliser
key indicator light, situated on the
instrument panel, lashes rapidly
when the ignition is switched on (2nd
notch).In this case your vehicle will
not start.
Contact a PEUGEOT dealer as soon
as possible.
If the electronic immobiliser
key indicator light comes on
continuously after switching on
the ignition (2nd notch), check the
identiication of your key. It may also
indicate an operating anomaly.
Contact a PEUGEOT dealer as soon
as possible.
Confidential card
The conidential card is necessary for
any work carried out by a PEUGEOT
dealer on the system.
It contains:
- a ive digit identiication code 1
necessary for the emergency
starting procedure,
- a code 2 for reproduction of your
keys by a PEUGEOT dealer.
These codes are hidden by a ilm,
which should be removed only if
necessary.
Keep your card in a safe place,
never inside the vehicle.
Key in ignition
A buzzer sounds on opening the
driver's door, if the key has been left
in the ignition.
Changing the battery of the
remote control
If the indicator light on the key lights
only once, or does not light at all
when the button is pressed, change
the battery.
To do this, unclip the casing using
a coin at the ring (CR2032/3 volt
battery).
If the remote control does not work
after the battery has been changed,
reinitialise the remote control.
Programming the remote
control
F Switch off the ignition.
F Switch the ignition on again.
F Immediately press button A.
F Switch off the ignition and remove
the remote control key from the
ignition lock. The remote control
is now working again.

16-02-200416-02-2004
5455YOUR BOXER IN DETAIL
Make a careful note of the
number on each key. The
key number is coded on
the label attached to the
key. If the key is lost, your
PEUGEOT dealer can rapidly
supply you with new keys.
The high-frequency remote
control is a sensitive system; do
not operate it while it is in your
pocket as there is a possibility that
it may unlock your vehicle without
your knowledge.
The remote control cannot operate
if the key is in the ignition, even if
the ignition is switched off, except
for reprogramming.
As a safety measure (when there
are children on board), remove
the ignition key when leaving the
vehicle, even for a short time.
Do not handle the buttons of your
remote control when out of range
of your vehicle. You run the risk of
stopping it from working. It would then be necessary to
reprogramme the remote control.
When buying a second-hand car:
- Ensure that you are given the
conidential card;
- have the key codes memorised by a PEUGEOT dealer, to
ensure that the keys in your
possession are the only ones
that can start your vehicle.
Do not make any modiications to
the electronic engine immobiliser
system.

16-02-200416-02-2004
5253YOUR BOXER IN DETAIL
Electronic engine immobiliser
This locks the engine control system
as soon as the ignition has been
switched off and therefore prevents
starting of the vehicle by anyone who
does not have the key.
The ignition key has an electronic
chip which has a special code.
When the ignition is switched on, the
code must be recognised for starting
to be possible.
If the system does not function
correctly, the electronic immobiliser
key indicator light, situated on the
instrument panel, lashes rapidly
when the ignition is switched on (2nd
notch).In this case your vehicle will
not start.
Contact a PEUGEOT dealer as soon
as possible.
If the electronic immobiliser
key indicator light comes on
continuously after switching on
the ignition (2nd notch), check the
identiication of your key. It may also
indicate an operating anomaly.
Contact a PEUGEOT dealer as soon
as possible.
Confidential card
The conidential card is necessary for
any work carried out by a PEUGEOT
dealer on the system.
It contains:
- a ive digit identiication code 1
necessary for the emergency
starting procedure,
- a code 2 for reproduction of your
keys by a PEUGEOT dealer.
These codes are hidden by a ilm,
which should be removed only if
necessary.
Keep your card in a safe place,
never inside the vehicle.
Key in ignition
A buzzer sounds on opening the
driver's door, if the key has been left
in the ignition.
Changing the battery of the
remote control
If the indicator light on the key lights
only once, or does not light at all
when the button is pressed, change
the battery.
To do this, unclip the casing using
a coin at the ring (CR2032/3 volt
battery).
If the remote control does not work
after the battery has been changed,
reinitialise the remote control.
Programming the remote
control
F Switch off the ignition.
F Switch the ignition on again.
F Immediately press button A.
F Switch off the ignition and remove
the remote control key from the
ignition lock. The remote control
is now working again.

16-02-200416-02-2004
5455YOUR BOXER IN DETAIL
Make a careful note of the
number on each key. The
key number is coded on
the label attached to the
key. If the key is lost, your
PEUGEOT dealer can rapidly
supply you with new keys.
The high-frequency remote
control is a sensitive system; do
not operate it while it is in your
pocket as there is a possibility that
it may unlock your vehicle without
your knowledge.
The remote control cannot operate
if the key is in the ignition, even if
the ignition is switched off, except
for reprogramming.
As a safety measure (when there
are children on board), remove
the ignition key when leaving the
vehicle, even for a short time.
Do not handle the buttons of your
remote control when out of range
of your vehicle. You run the risk of
stopping it from working. It would then be necessary to
reprogramme the remote control.
When buying a second-hand car:
- Ensure that you are given the
conidential card;
- have the key codes memorised by a PEUGEOT dealer, to
ensure that the keys in your
possession are the only ones
that can start your vehicle.
Do not make any modiications to
the electronic engine immobiliser
system.

16-02-200416-02-2004
5455
sounds and the direction indicator
lights lash for thirty seconds.
After triggering, the alarm remains
set.
Warning: if the alarm has been
triggered ten times in succession,
on the eleventh time it becomes
inactive.
Note : if the red warning light, located
on the fascia, lashes rapidly, the
alarm has been triggered while you
were away from your vehicle. To stop
it lashing, insert the remote control
key and switch on the ignition.
Disarming
Unlock the vehicle with the remote
control key (the red indicator light,
located on the fascia, goes out).
To set the alarm with exterior
protection only
If, while you are away from the
vehicle, you wish to leave a window
partially open or a pet inside the
vehicle, you should choose exterior
protection only.
F Switch off the ignition placing the
key in the STOP position.
F Place the key in the ON position.
F Switch off the ignition placing the
key in the STOP position.
F Remove the key.
The interior protection is disarmed
when the red indicator light located
on the fascia comes on for two
seconds.
YOUR BOXER IN DETAIL
THE ALARM
This provides two types of
protection:
- exterior protection:
it sounds if a
door, the tailgate or the bonnet is
opened.
- interior protection: it sounds if the volume inside the passenger
compartment changes (breaking
of a window or a movement inside
the vehicle).
Setting the alarm
F Switch off the ignition and get out
of the vehicle.
F Set the alarm within ive minutes
of getting out of the vehicle, by
locking using the remote control
(the red indicator light, located on
the fascia, visible from outside,
lashes once per second).
Note : if you wish to lock your vehicle
without setting the alarm, use the
door lock.
When the alarm is triggered, the siren F
Get out of the vehicle.
F Within the next ive minutes, set
the alarm by locking using the
remote control (the red indicator
light, located on the fascia,
lashes once a second).
Note : when the alarm is set but the
remote control does not operate:
F Unlock the doors with the key
and open the door. The alarm is
triggered.
F Switch on the ignition in the
next ten seconds. The alarm is
disarmed.
Incorrect operation
When the ignition is switched on,
if the red indicator light, located
on the fascia, comes on for ten
seconds, there is a fault in the siren
connection.
Contact a PEUGEOT dealer to have
the system checked.
Do not make any modiications to
the alarm system, this could cause
faults.

16-02-200416-02-2004
5657
REAR DOORS
Opening the doors from
outside
To open, pull the rear right door
handle towards you and open the
rear left door by pulling the lever on
the inside.
Locking / Unlocking from the
inside
Front door
To lock, lower button A.
The closing control of one of the front
doors permits complete locking of
the vehicle.
To unlock and open, lift button A and
pull the handle towards you.
The opening control of one of
the front doors permits complete
unlocking of the vehicle.
Sliding side door
The side door opening/closing control
only controls the door concerned.
Side door child lock
This prevents opening of the side
door from the inside.
F Turn the control a quarter turn
using the ignition key.
Note: the sliding side door can be
secured in the fully open position.
To release it, pull the handle towards
you and slide the door.
YOUR BOXER IN DETAIL
FRONT DOORS AND SLIDING
SIDE DOOR
Opening the doors from
outside (front and side doors)
Opening the doors from
inside (front doors)
The front door opening controls
permit complete unlocking of the
vehicle.