Peugeot Boxer Dag 2005 Owner's Manual

74
01-01-2005
75
01-01-2005* According to destination.
In the
"OFF" position, the passenger
air bag will not be triggered in the
event of an impact.
As soon as you remove the rear-fac-
ing child seat from the front passen-
ger seat, turn the air bag switch to
the "ON" position, to arm the air bag
and thus ensure the safety of your
passenger in an impact.
If the passenger air bag is
armed (passenger air bag
switch in the "ON" position),
the indicator light comes on
for six seconds when the ig-
nition is switched on.
If the passenger air bag is disarmed
(passenger air bag switch in the
"OFF" position), the indicator light
remains on.
In all cases, if the light lashes, con-
tact your PEUGEOT dealer. If this indicator light comes on,
contact a PEUGEOT dealer to
have the system checked.
SIDE AIR BAGS*
The side air bags are incorporated
into the front seat backs on the door
side.
They are deployed independently of
each other, on whichever side the
collision occurs.
Operating check
This is conirmed by the light on the
instrument panel.Operating check
This is conirmed by an indicator light
on the instrument panel.
YOUR BOXER IN DETAIL

76
01-01-2005
For the front and side* air
bags to be fully effective,
observe the following
safety rules:
• Wear a correctly adjusted seat belt.
• Sit in a normal upright position.
• Do not leave anything between the occupants and the air bags (child,
animal, object...).
This could hamper the operation of the air bags or injure the occu-
pants.
• All work on the air bag systems is strictly prohibited unless it is car-
ried out by qualiied personnel of
the PEUGEOT network.
• After an accident or if the vehicle has been stolen or broken into,
have the air bag systems checked. Front air bags
• Do not drive holding the steering
wheel by its spokes or resting your
hands on the centre part of the
wheel.
• Passengers must not place their feet on the fascia.
• Smoke as little as possible; deploy- ment of the air bags can cause
burns or the risk of injury from a
cigarette or pipe.
• Never remove or pierce the steer- ing wheel or hit it violently. Side air bags*
• Only put approved covers on the
front seats. Contact your PEUGEOT
dealer.
• Do not ix or glue anything to the front seat backs. This could cause
injury to the chest or arms when the
side air bag inlates.
• Do not sit with the upper part of the body any nearer to the door than
necessary.
* According to country.
YOUR BOXER IN DETAIL

74
01-01-2005
75
01-01-2005* According to destination.
In the
"OFF" position, the passenger
air bag will not be triggered in the
event of an impact.
As soon as you remove the rear-fac-
ing child seat from the front passen-
ger seat, turn the air bag switch to
the "ON" position, to arm the air bag
and thus ensure the safety of your
passenger in an impact.
If the passenger air bag is
armed (passenger air bag
switch in the "ON" position),
the indicator light comes on
for six seconds when the ig-
nition is switched on.
If the passenger air bag is disarmed
(passenger air bag switch in the
"OFF" position), the indicator light
remains on.
In all cases, if the light lashes, con-
tact your PEUGEOT dealer. If this indicator light comes on,
contact a PEUGEOT dealer to
have the system checked.
SIDE AIR BAGS*
The side air bags are incorporated
into the front seat backs on the door
side.
They are deployed independently of
each other, on whichever side the
collision occurs.
Operating check
This is conirmed by the light on the
instrument panel.Operating check
This is conirmed by an indicator light
on the instrument panel.
YOUR BOXER IN DETAIL

76
01-01-2005
For the front and side* air
bags to be fully effective,
observe the following
safety rules:
• Wear a correctly adjusted seat belt.
• Sit in a normal upright position.
• Do not leave anything between the occupants and the air bags (child,
animal, object...).
This could hamper the operation of the air bags or injure the occu-
pants.
• All work on the air bag systems is strictly prohibited unless it is car-
ried out by qualiied personnel of
the PEUGEOT network.
• After an accident or if the vehicle has been stolen or broken into,
have the air bag systems checked. Front air bags
• Do not drive holding the steering
wheel by its spokes or resting your
hands on the centre part of the
wheel.
• Passengers must not place their feet on the fascia.
• Smoke as little as possible; deploy- ment of the air bags can cause
burns or the risk of injury from a
cigarette or pipe.
• Never remove or pierce the steer- ing wheel or hit it violently. Side air bags*
• Only put approved covers on the
front seats. Contact your PEUGEOT
dealer.
• Do not ix or glue anything to the front seat backs. This could cause
injury to the chest or arms when the
side air bag inlates.
• Do not sit with the upper part of the body any nearer to the door than
necessary.
* According to country.
YOUR BOXER IN DETAIL

77
01-01-2005
1 - Power steering reservoir.
2 - Battery.
3 - Coolant reservoir.
4 - Brake luid reservoir.
5 - Air ilter.
6 - Windscreen and headlamp
wash reservoir. 7 -
Fuse box.
8 - Engine oil iller cap.
9 - Dipstick.
2 LITRE PETROL INJECTION ENGINE
PRACTICAL INFORMATION

78
01-01-2005
79
01-01-2005
1 - Power steering reservoir.
2 - Battery.
3 - Coolant reservoir.
4 - Brake luid reservoir.
5 - Air ilter.
6 - Windscreen and headlamp
wash reservoir. 7 -
Fuse box.
8 - Dipstick.
9 - Engine oil iller cap.
2.0/2.2 LITRE TURBO DIESEL HDI ENGINE
PRACTICAL INFORMATION

78
01-01-2005
79
01-01-2005
1 - Power steering reservoir.
2 - Battery.
3 - Coolant reservoir.
4 - Brake luid reservoir.
5 - Air ilter.
6 - Windscreen and headlamp
wash reservoir. 7 -
Fuse box.
8 - Dipstick.
9 - Engine oil iller cap.
2.8 LITRE TURBO DIESEL HDI/TED ENGINE
PRACTICAL INFORMATION

80
01-01-2005
81
01-01-2005
CHECKING THE LEVELS
Oil level
F Check the level regularly and top
up between changes. The maxi-
mum consumption is 0.5 l per
600 miles (1 000 km).
Check the level with the vehicle level, engine cold, using the oil
level gauge on the instrument
panel or the dipstick.
There are two marks on
the dipstick:
A = maximum
Never ill past this mark.
B = minimum
To maintain the reliability
of engines and emission
control systems, the use
of additives in engine oil
is prohibited.
Oil change
According to the information given in
the servicing booklet.
Note: avoid used oil coming into pro-
longed contact with the skin.
Viscosity selection
In all cases, the oil selected must
meet the manufacturer's require-
ments.
Used oil
Do not dispose of used oil, brake
luid or coolant into drains or into the
ground.
Dipstick
* According to country.
Brake fluid change:
- must be carried out according to the manufacturer's servicing schedule.
- use luids recommended by the manu- facturer, which fulil DOT4 standards.
Note: brake luid is harmful to health
and very corrosive. Avoid all contact
with the skin.
Cooling systemUse the luid recommended by the
manufacturer.
When the engine is warm, the tem-
perature of the coolant is controlled
by the engine fan. As this fan can op-
erate with the ignition key removed
and because the cooling system is
pressurised, wait for at least one
hour after the engine has stopped
before carrying out any work.
Slacken the cap by two turns to re-
lease the pressure to prevent any
risk of scalding. When the pressure
has dropped, remove the cap and
top up the level.
Power steering reservoir
F Open the reservoir, with the en-
gine at ambient temperature. The
level should always be above the
MIN. mark and close to the MAX.
mark.
Windscreen and headlamp*
wash level
For best quality cleaning and for
your safety, we would advise that
you use products recommended by
PEUGEOT.
PRACTICAL INFORMATION

80
01-01-2005
81
01-01-2005
CHECKS
Battery
At the start of winter, have your bat-
tery checked by a PEUGEOT dealer.
Oil filter
Change the ilter regularly, in accord-
ance with the servicing schedule.Only use products recom-
mended by PEUGEOT.
To ensure best performance
from components as impor-
tant as the power steering and the
braking system, PEUGEOT selects
and offers quite speciic products.
To prevent damage to the electrical
units, avoid washing the engine.
Fuel supply cut-off
In a serious collision, a system pre-
vents fuel from reaching the engine.
To re-establish the fuel supply, press
the switch on the angle of the front
left-hand suspension assembly, under
the bonnet.
Air filter and passenger
compartment filter
Have the ilter elements replaced
regularly. If you drive in dusty
conditions, change them twice as
often.
Brake pads
Brake pad wear depends on the style
of driving, in particular for vehicles
which are used in town, over short
distances.
It may be necessary to check the
thickness of the pads, even between
services.
Handbrake
Where the handbrake travel is too
great or there is a reduction in the
performance of the system, the
handbrake should be adjusted, even
between services.
Have the system checked by a
PEUGEOT dealer.
Manual gearbox
This does not require an oil change.
Check the level in accordance with the
manufacturer's servicing schedule.
To check the main levels and cer-
tain components, in accordance
with the manufacturer's servicing
schedule, refer to the pages of
the servicing booklet which corre-
spond to your vehicle's engine.
PRACTICAL INFORMATION

82
01-01-2005
83
01-01-2005
Access to the spare wheel
The spare wheel is located in a carrier
underneath the vehicle at the rear.
The two carrier support bolts are
located near the outer edge of the
rear loor.
F Unclip the covers on the bolts.
F Slacken these two bolts using a
ratchet spanner 2 and the socket 3.
F Lift the carrier to release the
retaining hook using the wheel-
brace 4. Tools
The following tools are in a holder
under the front passenger seat:
1 -
Jack.
2 - Ratchet spanner.
3 - Spare wheel carrier access
socket.
4 - Wheelbrace.
5 - Screwdriver (for removal of the
grille when changing bulbs).
CHANGING A WHEEL
Parking the vehicle
F Whenever possible, park the vehicle
on level, stable and non-slippery
ground.
F Apply the handbrake, switch off the
ignition and engage irst or reverse
gear (position P for the automatic
gearbox).
PRACTICAL INFORMATION