Peugeot Expert VU Dag 2007 Owner's Manual

125
6
In all cases, pay attention to the coolant
temperature.
Good Practice
In certain cases of particularly arduous
use (towing the maximum load up a steep
slope in high temperatures), the engine
automatically limits its power. In this
case, the automatic cutting off of the air
conditioning allows the engine power to be
recovered.If the coolant temperature warning
light comes on, stop the vehicle
and switch off the engine as soon
as possible. Tyres: check the tyre pressures of the
towing vehicle (see the "Identification
features" section of chapter 9) and of
the trailer, observing the recommended
pressure.
Brakes:
towing increases the braking distance. Drive
at a moderate speed, change down early
and brake gradually.
Side wind:
sensitivity to side wind is increased. Drive
smoothly and at a moderate speed.
ABS:
the system only controls the vehicle, not
the trailer.
Rear parking assistance:
the assistance does not function while
the vehicle is towing. Towbar
We recommend the use of original
PEUGEOT towbars and harnesses, which
have been tested for endurance from
the design stage of your vehicle.
Towing equipment must be fitted in
accordance with the manufacturer ’s
instructions, with particular attention to
the towing capacities of your vehicle,
the load towed, the nose weight and the
electrical connection. As this fitting should
be carried out by a professional, we
recommend that you entrust the fitting of
this equipment to a PEUGEOT dealer.
In accordance with the general instructions
a reminder of which has been given above,
we draw your attention to the risk linked with
fitting a towbar or electrical accessory not
recommended by PEUGEOT.
Fitting such equipment could result in
the failure of your vehicle’s electronic
system. Please contact a PEUGEOT dealer
for information before fitting this type of
equipment.
See the "Levels" section of chapter 7.
Towing a trailer
ACCESSORIES

126OTHER ACCESSORIES
These accessories and parts, having been
tested and approved for reliability and
safety, are all adapted to your Expert.
A wide range recommended by PEUGEOT
and original parts are offered by PEUGEOT
"Accessories", in a catalogue and on line at
PEUGEOT dealerships.
Range of professional equipment
Pièces et Services technical information
publishes an Expert accessories catalogue
offering various equipment and fittings, such
as:
Roof bars for short, medium and long
wheelbase (load retainers for all models).
Sill plate, loading roller, sill.
Towbar, towbar harness: trailer towbar which
must be fitted by the PEUGEOT network.
Roof bars for the various heights, roof bars,
ladder.
Separation partitions and grilles, smooth,
non-slip wooden protective floor.
Protective grilles, multimedia.
"Accessories"
Another range is also available from
PEUGEOT Accessories, structured around
5 groups:"Protection":
anti-theft alarm,
window engraving, first aid kit, high
visibility safety jacket, rear parking
assistance, warning triangle, ...
"Touring": front seat covers
compatible with air bags, bench,
rubber mats, carpet mats.
To prevent the mat from becoming
caught under the pedals:
- ensure that the mat is positioned correctly,
- never fit one mat on top of another.
Snow chains.
"In-car technology": audio
equipment, hands-free kit, speakers,
CD changer, navigation, ...
Regardless of the audio and
telematic equipment offered on the
market, the technical constraints linked with
the fitting of equipment of these families of
products mean that the special features of
the equipment and its compatibility with the
capacities of the your vehicle’s standard
equipment must be taken into account.
Please contact a PEUGEOT dealer for
information before fitting such equipment.
"Styling": front mud flaps, rear mud
flaps, ...
The fitting of electrical equipment
or accessories which are not
recommended by Automobiles PEUGEOT
may result in the failure of your vehicle’s
electronic system. Please note this specific
warning. You are advised to contact a
representative of the Marque to be shown
the range of recommended equipment and
accessories.
Depending on the country in which the
vehicle is sold or operated, it is compulsory
to have a high visibility safety jacket,
warning triangle and replacement bulbs
available in the vehicle.
"Universal": screenwash,
interior and exterior cleaning and
maintenance products, replacement
bulbs, ...
For further information, refer to the site
http://public.infotec.peugeot.com.
ROOF BARS
To install the transverse roof bars, use
the fixings provided for this purpose.
Maximum load: 170 kilogrammes.
Equipment

127
7
OPENING THE BONNET
From inside:
- lift the cover located at the left foot of the
driver ’s seat.
- pull the control upwards. To close
Lower the bonnet and release it at the
end of its travel. Check that the bonnet is
properly locked.
"Bonnet open" warning
This warning is linked to the
alarm option only.
With the engine running or the
vehicle moving, a warning light
and a diagram on the display,
accompanied by an audible
signal, warn you that the bonnet
is not properly closed.
From outside:
lift the catch and raise the
bonnet.
Bonnet strut
Secure the strut in one of the two notches,
according to the height required, to hold the
bonnet open.
Before closing the bonnet, replace the strut
in its housing. Opening the bonnet
CHECKS

4
3
7
1
2
5
6
8
9
11
10b
10a
128
DIESEL ENGINES 4 - Brake and clutch fluid reservoir.
5 - Air filter.
6 - Dipstick.
7 - Engine oil filler cap. 8 -
Power steering reservoir.
9 - Removable towing eye.
10 - Repriming pump
( a : 1.6 litre HDi; b: 2 litre HDi).
11 - Engine oil filling funnel (2 litre HDi).
UNDER THE BONNET
1
- Windscreen/headlamp wash reservoir.
2 - Fuse box.
3 - Coolant reservoir.
Under the bonnet

4
3
7
1
2
5
8
9
6
129
7
PETROL ENGINE 4 - Brake and clutch fluid reservoir.
5 - Air filter.
6 - Dipstick. 7 -
Engine oil filler cap.
8 - Power steering reservoir.
9 - Removable towing eye.
1
- Windscreen/headlamp wash reservoir.
2 - Fuse box.
3 - Coolant reservoir. Under the bonnet
CHECKS

A
B
130
Levels
LEVELS
These regular maintenance operations
will keep your vehicle in good running
order. Consult the instructions at PEUGEOT
dealerships, on the Infotec site or in the
servicing booklet enclosed in the handbook
pack.
If you have to remove/refit the engine
style cover, handle it with care to avoid
damaging the fixing clips.
Oil level
Check the level regularly and top up between
changes. The maximum consumption is 0.5 litre
per 600 miles (1 000 km).
Check the level with the vehicle level,
engine cold, using the dipstick.
Dipstick
There are two marks on the
dipstick:
A = maximum
If you fill past this mark,
contact a PEUGEOT dealer.
B = minimum
Never allow the level to fall
below this mark.
To maintain the reliability
of engines and emission control systems, the use of additives in
engine oil is prohibited.
Oil change
It is imperative that this is carried out at the
intervals specified and the viscosity grade of
the oil selected must fulfil the requirements
in accordance with the manufacturer’s
servicing schedule. Consult the instructions at
PEUGEOT dealerships or on the Infotec site.
Remove the dipstick before filling.
For the 2 litre HDi engine, use the funnel
supplied when filling via the sump opening.
Check the level after filling (never exceed
the max mark).
Screw the cap back onto the sump before
closing the bonnet.
Viscosity selection
In all cases, the oil selected must meet the
manufacturer ’s requirements.
Changing the brake fluid
The brake fluid must be changed at
the intervals stated, according to the
manufacturer ’s servicing schedule.
Use fluids recommended by the
manufacturer, which fulfil DOT4 standards.
The level must be between the MIN and
MAX marks on the reservoir.
If fluid has to be added frequently, this
indicates a failure which must be checked by
a PEUGEOT dealer as soon as possible.
Warning lights
Checking by means of the warning lights on
the instrument panel is described in chapter 2,
refer to the "Instruments and controls" section.

131
7
Levels
Cooling system
Only use the fluid recommended by the
manufacturer.
Otherwise, you risk seriously damaging your
engine.
When the engine is warm, the temperature
of the coolant is controlled by the engine
fan. As this fan can operate with the ignition
key removed and because the cooling
system is pressurised, wait for at least one
hour after the engine has stopped before
carrying out any work.
Slacken the cap by 1/4 of a turn to release
the pressure to prevent any risk of scalding.
When the pressure has dropped, remove the
cap and top up the level with coolant.
If fluid has to be added frequently, this
indicates a failure which must be checked by
a PEUGEOT dealer as soon as possible. Topping up
The level must be between the MIN and
MAX marks on the expansion bottle. If
more than 1 litre of fluid is required to top
up the level, have the system checked by a
PEUGEOT dealer.
Power steering fluid level
The vehicle must be parked on level ground
with the engine cold. Unscrew the cap
integrated with the gauge and check the
level which must be between the MIN and
MAX marks.
Windscreen wash and headlamp
wash level
For best quality cleaning and for your safety,
we would advise that you use products of
the PEUGEOT Universal range.
Capacity of the screenwash reservoir:
approximately 4.5 litres.
If your vehicle is fitted with headlamp
washers, the capacity of the reservoir is
7.5 litres. Diesel additive level (Diesel
with particle emission filter)
The minimum level of this additive
is indicated by lighting of the
service warning light, accompanied by
an audible signal and a message on the
display.
Topping up
It is imperative that this additive is topped up
by a PEUGEOT dealer without delay.
Used oil
Avoid prolonged contact of used oil with the
skin.
Brake fluid is harmful to health and very
corrosive.
Do not dispose of used oil, brake fluid or
coolant into drains or into the ground but
into the containers dedicated to this use at
PEUGEOT dealerships.
CHECKS

132
Checks
CHECKS
Battery
At the start of winter, have your battery
checked by a PEUGEOT dealer.
Brake pads
Brake pad wear depends on the style of
driving, in particular for vehicles which are
used in town, over short distances.
It may be necessary to check the thickness
of the pads, even between services.
Unless there is a leak on the circuit, a drop
in the brake fluid level indicates that the
brake pads are worn.
Brake disc/drum wear status
For any information relating to checking
the brake disc/drum wear status, contact a
PEUGEOT dealer. Handbrake
Where the handbrake travel is too great
or there is a reduction in the performance
of the system, the handbrake should be
adjusted, even between services.
Have the system checked by a PEUGEOT
dealer.
Oil filter
Change the filter regularly, in accordance
with the servicing schedule.
Air filter and passenger
compartment filter
If the passenger compartment filter becomes
clogged, this may reduce the performance
of the air conditioning system and generate
unpleasant odours.
Refer to the servicing booklet to find out the
replacement interval for these components.
Depending on the environment (dusty
atmosphere...) and the use of the vehicle
(urban driving...), change them twice as
often if necessary, refer to the "Under the
bonnet" section of chapter 7.
Particle emission filter (Diesel)
It is imperative that particle emission filter
maintenance is carried out by a PEUGEOT
dealer.On acceleration after the vehicle has been
running for a prolonged period at very low
speed or at idle, you may, in exceptional
circumstances, notice the emission of water
vapour at the exhaust.
This water vapour does not have any
adverse effect on vehicle handling or the
environment.

133
7
Manual gearbox
Have the level checked in accordance with
the manufacturer ’s servicing schedule.
To check the main levels and certain
components, in accordance with the
manufacturer ’s servicing schedule, refer
to the pages of the servicing booklet which
correspond to your vehicle’s engine.
Only use products recommended by
PEUGEOT or products of equivalent
quality and characteristics.
In order to optimise the operation of units as
important as the braking circuit, PEUGEOT
selects and offers specific products.
In order to avoid damaging the electrical
units, high pressure washing of the engine
compartment is strictly prohibited.
Checks
Bleeding the water contained in
the diesel filter If this warning light comes on,
bleed the filter. Otherwise bleed
regularly each time the engine is
drained.
To evacuate the water, unscrew the bleed
screw located on the filter.
Operate until all of the water in the
transparent pipe has been drained out
then tighten the bleed screw.
HDi engines use advanced technology.
All work requires a special qualification
which is guaranteed by a PEUGEOT dealer.
1.6 litre HDi 2 litre HDi
CHECKS

135
7
FILLING WITH FUEL
Low fuel level
When the needle is at the start of
the red zone, the minimum fuel
tank level is reached when this
warning light comes on.
At this moment, you have approximately
8 litres of fuel remaining. Fill up without
delay to avoid running out of fuel.
FUEL CIRCUIT DISARMED
In a serious collision, a mechanism
automatically prevents fuel from reaching
the engine.
The flashing of this warning light
is accompanied by a message on
the display.
Check that there is no odour or leakage of
fuel outside the vehicle and re-establish the
fuel supply:
- switch off the ignition (STOP position).
- remove the key.
- put the key back in the ignition.
- switch on the ignition and start.
The fuel tank must be filled
with the engine
off .
When filling with fuel, do not open the
left-hand side door, if fitted on your
vehicle, as there is a risk of damage to the
fuel filler flap.
- Open the fuel filler flap.
- Insert the key, then turn it a quarter turn.
- Remove the cap and hook it onto the clip located on the inside of the flap.
A label affixed to the inside of the flap
reminds you of the type of fuel to be used.
When filling the fuel tank, do not continue
after the 3rd cut-off of the nozzle. This could
cause malfunctions.
The capacity of the fuel tank is
approximately 80 litres.
- After filling the fuel tank, lock the cap and close the flap. Fuel
DIESEL REPRIMING PUMP
If you should run out of fuel, it is necessary
to re-prime the circuit:
- fill the fuel tank with at least five litres of
diesel,
- squeeze and release the manual re-priming pump, under the bonnet under the protective
cover, until fuel appears in the transparent
pipe,
- operate the starter until the engine starts.
CHECKS