Peugeot Partner VU 2001 Owner's Manual

A
3
102VI-5CHANGING A WHEEL
Access to the spare wheel.
The spare wheel is in a carrier under the rear floor. The retaining bolt Aof the spare wheel carrier is inside the vehicle
close to the rear door closing device.Lift up the load space floor covering.Unscrew the nut using the end of the wheelbrace 3.
Raise the carrier to release the retaining hook, then lower the carrier.
Take care that the weight of the wheel does not trap your fingers or press on your feet. Advice Refit the repaired wheel as soon as possible.

Never reach under the vehicle when it is raisedonly by the jack.
103
VI-5CHANGING A WHEEL
Removal
1 -Park the vehicle, if possible on a flat and levelsurface. Apply the handbrake, engage first or reverse gear,
immobilise the vehicle by placing the chock from the spare wheel against the diagonally opposite wheel.
2 - Position the jack at one of the four points marked by arrows (on the sills). These are provided on the subframe, close to the wheels. Extend the jack using the wheelbrace.
3 - Loosen the four wheel bolts using the wheelbrace.
4 - Extend the jack further until the wheel is a few centimetres above the ground.
5 - Unscrew the wheel bolts, remove the wheel embellisher and remove the wheel.

Refitting
1 - Fit the wheel onto the hub, making sure that it is correctly positioned.
2 - Screw in one of the wheel bolts without fully tightening it. Clip the wheel embellisher onto the bolt, then tightenthe three other bolts.
3 - Lower the jack and remove it.4 - Fully tighten the wheel bolts using the wheelbrace.5 - Refit the repaired wheel as soon as possible6 - Reset the tyre pressure of the repaired wheel (see ÒTYRESÓ) and have the balance checked. Replacing the spare wheel in the carrier Place the chock back in the wheel.
Slide the spare wheel back into its carrier.Lift the carrier and position the hook so that it is aligned with the tightening nut.Retighten the nut from inside the vehicle.Store the wheelbrace, and then the jack. Note The wheel bolts are specific to each wheel type. When a wheel is changed, check with an approved dealer that the
bolts are suitable for the new wheel (See ÒUSING THE SPARE WHEELÓ).
104 VI-5CHANGING A WHEEL

To maintain steering, do not remove the ignition key.
105TOWING AND LIFTING THE VEHICLE
Towing with wheels on the ground
Towing eyes are at the front and rear of the vehicle.
Towing at slow speed for a short distance is permissible in emergencies
(depending on road traffic regulations).Use a bar with hooks attached to the towing eyes indicated above.
Being towed with the front or rear wheels lifted Use a special rigid towing bar with belt attachments. Fit the belt attachments to the front
crossmember.
Take the necessary precautions to protect the bumpers and the front orrear of the vehicle.
Tow at slow speed.
WARNING
When the engine is not running there is no power assistance for the steering and braking systems.
VI-6

Towbar The installation of a towbar should be carried out by an approved dealer who will know the towing capacity of your
vehicle and have the necessary information on the fitting of such a safety related item. The dealer will also be aware
of any modifications to the vehicleÕs cooling system needed to cater for any arduous towing conditions.
Towing (boat, caravan, etc.)
¥ Before setting off :- check the tyre pressures of both the vehicle and the towed load and check the signalling lamps on the towed load.
- practise manoeuvring, especially reversing.
- regularly grease the towball hitch, remove it when not required.
¥ Spread the load inside the caravan and keep within the weight limits.
¥ Always drive at a moderate speed, Change down to a lower gear in good time before going uphill and downhill. Be aware of the effect of side winds.
¥ Towing increases fuel consumption.
¥ Braking distances are increased. Use the brakes gently and progressively. Avoid harsh braking.
¥ When parking on a slope: as well as following the instructions for operation of the handbrake, make sure that the towbar is properly locked and use wheel chocks if necessary.
106VI-7SAFETY ADVICE
Keep within the towing limits of your vehicle.
In the case of a towing vehicle exceeding its maximum rear axle weight or Gross Vehicle Weight, its speed limit is 60 mph (100 Km/h).
Towing weights: see ÒGENERALÓ.

112
Engine type1.1i (TU1JP) 1.4i (TU3JP) 1.9D (DW8B) 2.0HDI (DW10TD)
Payload (kg) 475 600 600 800 600 800 600 800
Fuel tank capacity
55 litres 60 litres
Recommended fuel See ÒFILLING WITH FUELÓ
Oil capacity (without air conditioning) 3,5 litres 4,75 litres 4,50 litres
Oil capacity (with air conditioning) Ñ 4,50 litres 4,25 litres
Screen wash reservoir capacity 3,5 or 7,5 litres
Turning circle between walls
(in metres) 11,55 or 11,75 ** 11,75 **
French fiscal rating 6 6 7 8
Theoretical maximum speed (mph) 134 140 148 148 140 142 161
Battery 12 V See ÒBATTERYÓ
Sparking plugsContact your dealer
Weights (kg)
Unladen 1050 1070 10701110/11651165 1185
Gross vehicle weight 1525 1670 1670 18701710/17651965 1785 1985
Max. on front axle 800 930 930 930 930 955
Max. on rear axle 840 950 950 1060 970 1080 970 1080
Gross train weight (GTW) 2200 25502810/28552900 2885 3085
Gross trailer weight with brakes *** 750 900 1100
Gross trailer weight without brakes 525 535 535 555/580 580 630
Trailer nose weight 70
Max. roof rack load 100
VII-1
GENERAL*
* According to model or country.
** With power steering.
*** Towing weights valid for France.In each country, it is essential not to exceed the maximum tow- ing loads and speeds permitted by local legislation. For informa-tion on the towing capacity of your vehicle and its maximum
authorised train weight, contact your dealer.

F
E
G
I
H
B
DAC
J
A 2.69
B4
.1 1
C 0.82
D 0.60
E 1.44
F 1.42
G 1.72
H 1.81
I 1.96
J 0.57
Table of dimensions (in metres)
113
VII-2
DIMENSIONS *
* According to specification.

K 1.14
L 1.32
M 1.19
N 1.19
O 0.57P 1.70
O
N
M
K
L
P
114
Table of dimensions (in metres) VII-2
DIMENSIONS *
* According to specification.

S
LP
W
R
M
V
T
U
R 0.89
S 0.24
T 0.38
U 0.42
V 1.53
W 1.67
Floor and multi-purpose seat Half-height
115
VII-2DIMENSIONS *
Table of dimensions
in metres
* According to model.

1 2 345
Chassis number plate: In the engine compartment on the right hand inner wing 1: Vehicle Identification Number (VIN).
2 : Gross vehicle weight *.
3 : Gross train weight *.
4 : Maximum weight on front axle *.
5 : Maximum weight on rear axle *.
Colour code On the right hand wheel arch.
116
VII-3IDENTIFICATION *
* According to country