steering PONTIAC SOLSTICE 2007 Service Manual

Maintenance Schedule................................ 334
Introduction............................................... 334
Maintenance Requirements........................ 334
Your Vehicle and the Environment............ 334
How This Section is Organized................. 334
Part A: Scheduled Maintenance Services..... 336
Using the Maintenance Schedule............... 336
Scheduled Maintenance............................. 337
Part B: Owner Checks and Services......... 346
At Each Fuel Fill....................................... 346
At Least Once a Month............................. 346
At Least Twice a Year.............................. 347
At Least Once a Year............................... 348Part C: Periodic Maintenance Inspections.... 351
Steering and Suspension Inspection.......... 351
Exhaust System Inspection........................ 351
Fuel System Inspection............................. 351
Engine Cooling System Inspection............. 352
Throttle System Inspection........................ 352
Brake System Inspection........................... 352
Part D: Recommended Fluids and
Lubricants.............................................. 353
Normal Maintenance Replacement Parts ... 355
Engine Drive Belt Routing......................... 356
Part E: Maintenance Record...................... 357
Section 6 Maintenance Schedule
333

The vehicle should start only when the clutch
pedal is pushed down all the way to the
oor. If the vehicle starts when the clutch pedal
is not pushed all the way down, contact your
GM Goodwrench
®dealer for service.
Automatic Transmission Shift Lock
Control System Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the vehicle
moves, you or others could be injured.
1. Before you start, be sure you have enough
room around the vehicle. It should be parked
on a level surface.
2. Firmly apply the parking brake. SeeParking
Brake on page 86.
Be ready to apply the regular brake
immediately if the vehicle begins to move.3. With the engine off, turn the ignition to RUN,
but do not start the engine. Without applying
the regular brake, try to move the shift
lever out of PARK (P) with normal effort. If the
shift lever moves out of PARK (P), contact
your GM Goodwrench
®dealer for service.
Ignition Transmission Lock Check
While parked, and with the parking brake set, try
to turn the ignition to LOCK in each shift lever
position.
With an automatic transmission, the ignition
should turn to LOCK only when the shift
lever is in PARK (P). The ignition key should
come out only in LOCK.
With a manual transmission, the ignition key
should come out only in LOCK.
Turn the steering wheel to the left and to the right.
It should only lock when turned to the right.
Contact your GM Goodwrench
®dealer if service
is required.
349

Part C: Periodic Maintenance
Inspections
Listed in this part are inspections and services
which should be performed at least twice a
year (for instance, each spring and fall).You
should let your dealer’s service department
do these jobs. Make sure any necessary repairs
are completed at once.
Proper procedures to perform these services may
be found in a service manual. SeeService
Publications Ordering Information on page 380.
Steering and Suspension Inspection
Inspect the front and rear suspension and
steering system for damaged, loose or missing
parts, signs of wear or lack of lubrication. Inspect
the power steering lines and hoses for proper
hook-up, binding, leaks, cracks, chang, etc.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the
body near the exhaust system. Look for broken,
damaged, missing or out-of-position parts as
well as open seams, holes, loose connections
or other conditions which could cause a heat
build-up in the oor pan or could let exhaust fumes
into the vehicle. SeeEngine Exhaust on page 91.
Fuel System Inspection
Inspect the complete fuel system for damage
or leaks.
351

Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name,
part number, or specication may be obtained
from your dealer.
Usage Fluid/Lubricant
Engine Oil
(2.4L L4
engine)Engine oil which meets
GM Standard GM6094M and
displays the American Petroleum
Institute Certied for Gasoline
Engines starburst symbol.
GM Goodwrench
®oil meets
all the requirements for your vehicle.
To determine the proper viscosity
for your vehicle’s engine, see
Engine Oil on page 247.
Usage Fluid/Lubricant
Engine Oil
(2.0L L4
engine)The engine requires a special engine
oil meeting GM Standard GM4718M.
Oils meeting this standard may
be identied with the American
Petroleum Institute (API) Certied for
Gasoline Engines starburst symbol.
However, not all synthetic API oils
with the starburst symbol will meet
this GM standard. You should
look for and use only an oil that
meets GM Standard GM4718M.
GM Goodwrench
®oil meets all
the requirements for your vehicle.
For the proper viscosity, see
Engine Oil on page 247.
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant
on page 257.
Hydraulic Brake
SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Hydraulic Clutch
SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Power Steering
SystemGM Power Steering Fluid
(GM Part No. U.S. 89021184,
in Canada 89021186).
353

In Canada, please call us at 1-800-263-3777
(English) or 1-800-263-7854 (French). Or, write:
General Motors of Canada Limited
Customer Communication Centre, CA1-163-005
1908 Colonel Sam Drive
Oshawa, Ontario L1H 8P7
Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle
suspension, brakes, electrical, steering, body, etc.
Transmission, Transaxle, Transfer
Case Unit Repair Manual
This manual provides information on unit repair
service procedures, adjustments, and
specications for GM transmissions, transaxles,
and transfer cases.
Service Bulletins
Service Bulletins give technical service information
needed to knowledgeably service General
Motors cars and trucks. Each bulletin contains
instructions to assist in the diagnosis and service
of your vehicle.
In Canada, the service bulletin reference number
can be obtained by contacting your General
Motors dealer or by calling 1-800-GM-DRIVE
(1-800-463-7483). This reference number is
needed to order the service bulletin from
Helm, Inc.
RETAIL SELL PRICE: $6.00 US + Processing Fee
380

Audio System(s).......................................... 157
Audio Steering Wheel Controls................. 185
Care of Your CD Player........................... 187
Care of Your CDs.................................... 187
Fixed Mast Antenna................................. 187
Radio with CD................................161, 166
Setting the Time..............................158, 159
Theft-Deterrent Feature............................ 185
Understanding Radio Reception............... 186
XM™ Satellite Radio Antenna System...... 187
Automatic Door Lock..................................... 67
Automatic Door Unlock.................................. 67
Automatic Transmission
Fluid........................................................ 256
Operation................................................... 82
B
Battery........................................................ 273
Run-Down Protection............................... 121
Before Leaving on a Long Trip.................... 216
Brake
Anti-Lock Brake System (ABS)................. 195
Emergencies............................................ 197
Parking...................................................... 86
System Inspection.................................... 352
System Warning Light.............................. 134Brakes........................................................ 270
Braking....................................................... 194
Braking in Emergencies............................... 197
Break-In, New Vehicle................................... 76
Bulb Replacement....................................... 280
Back-Up Lamps....................................... 282
Front Turn Signal, Parking and
Fog Lamps........................................... 281
Halogen Bulbs......................................... 280
Headlamps............................................... 280
License Plate Lamps................................ 282
Replacement Bulbs.................................. 283
Taillamps, Turn Signal, and Stoplamps..... 281
Buying New Tires........................................ 296
C
California Fuel............................................. 238
California Proposition 65 Warning................ 236
Canadian Owners........................................... 3
Capacities and Specications...................... 332
Carbon Monoxide.................. 68, 91,220, 231
Care of
Safety Belts............................................. 317
Your CD Player........................................ 187
Your CDs ................................................. 187
CD, MP3 ..................................................... 176
384

Electronic Stability Control Indicator Light...... 136
Engine
Air Cleaner/Filter...................................... 254
Battery..................................................... 273
Check and Service Engine Soon Light..... 138
Coolant.................................................... 257
Coolant Temperature Warning Light.......... 137
Cooling System Inspection....................... 352
Drive Belt Routing.................................... 356
Engine Compartment Overview................ 244
Exhaust..................................................... 91
Oil ........................................................... 247
Oil Life System........................................ 252
Overheating............................................. 260
Reduced Power Light............................... 143
Starting...................................................... 80
Entry/Exit Lighting....................................... 120
Event Data Recorders (EDR)...................... 373
Extender, Safety Belt..................................... 26
F
Filter
Engine Air Cleaner................................... 254
Finish Damage............................................ 322
Fixed Mast Antenna.................................... 187Flashers, Hazard Warning........................... 110
Flash-to-Pass.............................................. 113
Flat Tire...................................................... 302
Fluid
Automatic Transmission............................ 256
Manual Transmission................................ 256
Power Steering........................................ 268
Windshield Washer.................................. 269
Fog Lamps.................................................. 120
Fuel............................................................ 237
Additives.................................................. 238
California Fuel.......................................... 238
Filling a Portable Fuel Container.............. 242
Filling Your Tank...................................... 240
Fuels in Foreign Countries....................... 239
Gage....................................................... 144
Gasoline Octane...................................... 237
Gasoline Specications............................ 237
Low Warning Light................................... 145
System Inspection.................................... 351
Fuses
Floor Console Fuse Block........................ 327
Fuses and Circuit Breakers...................... 326
Underhood Fuse Block............................. 329
387

G
Gage
Fuel......................................................... 144
Speedometer........................................... 129
Tachometer.............................................. 129
Gasoline
Octane..................................................... 237
Specications........................................... 237
Glove Box..................................................... 98
GM Mobility Reimbursement Program.......... 367
H
Hazard Warning Flashers............................ 110
Headlamp Wiring......................................... 326
Headlamps.........................................118, 280
Bulb Replacement.................................... 280
Daytime Running Lamps.......................... 119
Flash-to-Pass........................................... 113
Front Turn Signal, Parking and
Fog Lamps........................................... 281
Halogen Bulbs......................................... 280
High/Low Beam Changer......................... 112
On Reminder........................................... 119
Heater......................................................... 122Highbeam On Light..................................... 143
Highway Hypnosis....................................... 217
Hill and Mountain Roads............................. 218
Hood
Checking Things Under............................ 242
Release................................................... 243
Horn............................................................ 110
How to Use This Manual................................ 4
How to Wear Safety Belts Properly............... 18
Hydraulic Clutch.......................................... 256
I
Ignition Positions........................................... 77
Infants and Young Children, Restraints.......... 30
Ination - Tire Pressure............................... 292
Inator Kit, Tire........................................... 303
Inspection
Brake System.......................................... 352
Engine Cooling System............................ 352
Exhaust System....................................... 351
Fuel System............................................ 351
Part C - Periodic Maintenance.................. 351
Steering and Suspension ......................... 351
Throttle System........................................ 352
388

Loading Your Vehicle................................... 226
Locks
Automatic Door Lock................................. 67
Automatic Door Unlock.............................. 67
Delayed Locking........................................ 66
Manual Door.............................................. 65
Power Door............................................... 66
Loss of Control........................................... 208
Low Coolant Warning Light.......................... 138
Low Fuel Warning Light............................... 145
M
Maintenance Schedule
At Each Fuel Fill...................................... 346
At Least Once a Month............................ 346
At Least Once a Year.............................. 348
At Least Twice a Year.............................. 347
Brake System Inspection.......................... 352
Engine Cooling System Inspection........... 352
Exhaust System Inspection...................... 351
Fuel System Inspection............................ 351
How This Section is Organized................ 334
Introduction.............................................. 334
Maintenance Requirements...................... 334Maintenance Schedule (cont.)
Normal Maintenance Replacement Parts.... 355
Part A - Scheduled Maintenance
Services............................................... 336
Part B - Owner Checks and Services....... 346
Part C - Periodic Maintenance
Inspections........................................... 351
Part D - Recommended Fluids and
Lubricants............................................. 353
Part E - Maintenance Record.................... 357
Scheduled Maintenance........................... 337
Steering and Suspension Inspection......... 351
Throttle System Inspection....................... 352
Using....................................................... 336
Your Vehicle and the Environment............ 334
Malfunction Indicator Light........................... 138
Manual Seats.................................................. 8
Manual Transmission
Fluid........................................................ 256
Operation................................................... 85
Manual Windows........................................... 71
Message
DIC Warnings and Messages................... 148
Mirror Reading Lamps................................. 120
390

Passenger Position, Safety Belts................... 26
Passenger Sensing System........................... 50
Passing....................................................... 206
PASS-Key
®III+............................................. 74
PASS-Key®III+ Operation............................. 74
Power
Accessory Outlet(s).................................. 121
Door Locks................................................ 66
Electrical System..................................... 326
Lift Seat..................................................... 12
Reduced Engine Light.............................. 143
Retained Accessory (RAP)......................... 80
Steering Fluid.......................................... 268
Windows.................................................... 71
Pretensioners, Safety Belt............................. 26
Q
Questions and Answers About
Safety Belts............................................... 17
R
Radios........................................................ 157
Care of Your CD Player........................... 187
Care of Your CDs.................................... 187
Radio with CD................................161, 166
Setting the Time..............................158, 159
Theft-Deterrent......................................... 185
Understanding Reception ......................... 186
Rear Axle.................................................... 279
Limited-Slip.............................................. 200
Rearview Mirror with OnStar
®........................ 93
Rearview Mirrors........................................... 93
Reclining Seatbacks........................................ 9
Recreational Vehicle Towing........................ 231
Reduced Engine Power Light...................... 143
Remote Keyless Entry (RKE) System............ 61
Remote Keyless Entry (RKE)
System, Operation..................................... 62
Replacement Bulbs..................................... 283
392