belt Ram 1500 2011 Workshop Manual

Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.
CAUTION!
Do not use chemical flushes in your air conditioning
system as the chemicals can damage your air condi-
tioning components. Such damage is not covered by
the New Vehicle Limited Warranty.
WARNING!
•Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause
the system to fail, requiring costly repairs. Refer to
Warranty Information Book, located on the DVD,
for further warranty information.
•The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced repairman.
NOTE: Use only manufacturer approved A/C System
Sealers, Stop Leak Products, Seal Conditioners, Compres-
sor Oil, or Refrigerants.
538 MAINTAINING YOUR VEHICLE

cleaner. Use caution when cleaning the inside rear win-
dow equipped with electric defrosters or the right rear
quarter window equipped with the radio antenna. Do
not use scrapers or other sharp instruments which may
scratch the elements. When cleaning the rearview mirror,
spray cleaner on the towel or rag that you are using. Do
not spray cleaner directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft rag. A mild soap solution may be
used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
rag.
2. Dry with a soft cloth.
Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the car to
wash them. Dry with a soft cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Spray-On Bedliner – If Equipped
During ownership, the shine and luster of the Spray-On
Bedliner can fade from oxidation, road dirt, heavy-duty
hauling and hard water stains. Weathering and UV
exposure will lead to fading, dulling, and loss of gloss
over time.
562 MAINTAINING YOUR VEHICLE

120,000 Miles (195,000 km) or 90 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before
120,000 miles (195 000 km).
❏ Lube the front drive shaft fitting (2500/3500 (4x4) models only).
❏ Inspect the CV joints.
❏ Inspect exhaust system.
❏ Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet,
off-road or frequent trailer towing.
❏ Change the automatic transmission fluid and filter(s).
❏ Replace the accessory drive belt(s).
Odometer Reading Date
Repair Order #Dealer Code
Signature, Authorized Service Center
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S598 MAINTENANCE SCHEDULES

Fluid and Filter Changes............... 557
Fluid Level Check ..............554,555,556
Fluid Type ...................... 554,583
Gear Ranges ........................ 314
Shifting ........................... 318
Special Additives ..................... 555
Torque Converter .................... 318
Axle Fluid .......................... 553,583
Axle Lubrication (Axle Fluid) ............... 553
B-Pillar Location ........................ 411
Back-Up Camera ........................ 147
Bar, Stabilizer/Sway System ................ 344
Battery ............................... 536
Keyless Transmitter Replacement (RKE) ..... 24
Saving Feature (Protection) .............. 127
Belts, Seat ............................ 39,83
Body Builders Guide ....................... 6
Body Mechanism Lubrication ............... 539Brake Assist System
...................... 396
Brake Control System, Electronic ............. 395
Brake Fluid ......................... 551,583
Brake System ........................ 394,550
Anti-Lock (ABS) ..................... 395
Fluid Check ........................ 551
Master Cylinder ..................... 551
Parking ........................... 392
Warning Light ....................... 219
Brake/Transmission Interlock ............... 313
Break-In Recommendations, New Vehicle ........ 81
Bulb Replacement ....................... 571
Bulbs, Light .......................... 85,570
Cab Top Clearance Lights .................. 576
Calibration, Compass ..................... 241
Camera, Rear ........................... 147
Camper ............................... 198
Capacities, Fluid ........................ 580
10
INDEX 615

Caps, FillerOil (Engine) ........................ 534
Power Steering ...................... 391
Radiator (Coolant Pressure) ............. 547
Car Washes ............................ 558
Carbon Monoxide Warning ...............82,447
Cargo Light ............................ 126
Cellular Phone ....................... 101,290
Center High Mounted Stop Light ............ 575
Center Lap Belts ......................... 48
Center Seat Storage Compartment ............ 174
Certification Label ....................... 453
Chart, Tire Sizing ........................ 407
Check Engine Light
(Malfunction Indicator Light) .............223,530
Checking Your Vehicle For Safety ............. 82
Checks, Safety ........................... 82
Child Restraint ........................ 67,68
Child Restraint Tether Anchors .............72,76Child Seat
............................ 68,74
Cigar Lighter ........................... 166
Cleaning Wheels ............................ 560
Climate Control ......................... 290
Clock ............................. 250,260
Cold Weather Operation ................... 310
Compact Disc (CD) Maintenance ............. 290
Compact Spare Tire ...................... 419
Compass .............................. 240
Compass Calibration ..................... 241
Compass Variance ....................... 241
Computer, Trip/Travel .................... 237
Connector UCI ........................... 274,280
Universal Consumer Interface (UCI) ....274,280
Conserving Fuel ...................... 235,237
Console, Overhead ....................... 150
Contract, Service ........................ 607
616 INDEX

Information Center, Vehicle................. 227
Inside Rearview Mirror .................... 93
Instrument Cluster ................. 206,208,210
Instrument Panel and Controls .............. 205
Instrument Panel Lens Cleaning ............. 562
Integrated Power Module (Fuses) ............ 564
Integrated Trailer Brake Controls ............. 466
Interior Appearance Care .................. 560
Interior Lights .......................... 125
Intermittent Wipers (Delay Wipers) ........... 130
Introduction ............................. 4
Inverter Outlet (115V) ..................... 167
Jack Location ........................... 491
Jump Starting .......................... 510
Key-In Reminder ......................... 15
Key, Programming ........................ 17
Key, Replacement ........................ 17 Key, Sentry (Immobilizer)
................... 16
Keyless Entry System ...................... 20
Keys ................................. 12
Lane Change and Turn Signals .............. 128
Lane Change Assist ...................... 128
Lap Belts .............................. 48
Lap/Shoulder Belts ....................... 39
LATCH (Lower Anchors and Tether for
CHildren) .............................. 72
Latches ................................ 85
Leaks, Fluid ............................ 86
Life of Tires ............................ 422
Light Bulbs ............................. 85
Lights .............................. 85,121
Airbag ...................... 61,65,83,224
Alarm ............................ 214
Anti-Lock .......................... 225
Automatic Headlights ................. 123
622 INDEX

Brake Assist Warning.................. 403
Brake Warning ...................... 219
Bulb Replacement ................. 570,571
Cap Top Clearance ................... 576
Cargo ............................. 126
Center Mounted Stop .................. 575
Check Engine (Malfunction Indicator) ...... 223
Courtesy/Reading .................... 150
Daytime Running .................... 127
Electronic Stability Program (ESP) Indicator . . 403
Exterior ............................ 85
Fog ......................... 124,225,573
Four-Wheel Drive Indicator ............. 329
Hazard Warning Flasher ............... 491
Headlights ......................... 123
High Beam ...................... 129,219
High Beam Indicator .................. 219
High Beam/Low Beam Select ............ 129
Illuminated Entry ..................... 19 Instrument Cluster
................. 206,210
Interior ......................... 125,150
Lights On Reminder .................. 127
Low Fuel .......................... 218
Oil Pressure ........................ 221
Passing ............................ 128
Seat Belt Reminder ................... 226
Security Alarm (Theft Alarm) ............ 214
Service ......................... 570,571
Side Marker ........................ 579
Theft Alarm (Security Alarm) ............ 214
Tire Pressure Monitoring (TPMS) .......221,430
Traction Control ..................... 403
Transfer Case ....................... 329
Turn Signal ................. 85,128,571,573
Warning (Instrument Cluster
Description) ..................... 206,210
Limited-Slip Differential ................365,554
Loading Vehicle ......................... 453
10
INDEX 623

Parking Brake.......................... 392
Passing Light ........................... 128
Pedals, Adjustable ....................... 133
Personal Settings ........................ 242
Pets .................................. 81
Pets, Transporting ........................ 81
Phone, Cellular ......................... 101
Phone, Hands-Free (Uconnect™) ............. 101
Pickup Box ............................ 184
Placard, Tire and Loading Information ......... 411
Power Door Locks ......................... 30
Mirrors ............................ 96
Outlet (Auxiliary Electrical Outlet) .....162,167
Seats ............................. 102
Sliding Rear Window .................. 181
Steering ........................ 390,391
Sunroof ........................... 158
Windows ........................... 34 Power Steering Fluid
..................... 583
Pregnant Women and Seat Belts .............. 52
Pretensioners Seat Belts ........................... 50
Programmable Electronic Features ............ 242
Programming Transmitters
(Remote Keyless Entry) .................... 20
Radial Ply Tires ......................... 418
Radiator Cap (Coolant Pressure Cap) .......544,547
Radio Operation ........................ 290
Ramp Travel Index ....................... 347
Rear Axle (Differential) .................... 553
Rear Cargo Area Utility Rails ............... 196
Rear Park Sense System ................... 138
Rear Seat, Folding ..................... 111,112
Rear Window Features .................... 180
Rear Window, Sliding ..................... 181
Reclining Front Seats ..................... 109
626 INDEX

Reclining Rear Seats...................... 110
Recorder, Event Data ...................... 66
Recreational Towing ...................... 478
Shifting into Transfer Case Neutral(N) . . . 481,483
Shifting out of Transfer Case
Neutral (N) ...................... 482,486
Reformulated Gasoline .................... 444
Refrigerant ............................ 539
Reminder, Seat Belt ....................... 51
Remote Control Starting System ....................... 26
Remote Keyless Entry (RKE) ................. 20
Remote Sound System (Radio) Controls ........ 288
Remote Starting System .................... 26
Replacement Keys ........................ 17
Replacement Parts ....................... 531
Replacement Tires ....................... 423
Reporting Safety Defects ................... 608
Resetting Oil Change Indicator ...........217,235Restraint, Head
......................... 114
Restraints, Child ....................... 67,74
Restraints, Occupant ...................... 38
Rotation, Tires .......................... 428
Safety Checks Inside Vehicle ................. 83
Safety Checks Outside Vehicle ............... 85
Safety Defects, Reporting .................. 608
Safety Information, Tire ................... 406
Safety Tips ............................. 82
Safety, Exhaust Gas ....................... 82
Satellite Radio Antenna ................... 271
Schedule, Maintenance .................... 586
Seat Belt Maintenance .................... 562
Seat Belt Reminder ....................... 51
Seat Belts .......................... 38,39,83
Adjustable Upper Shoulder Anchorage ...... 47
And Pregnant Women .................. 52
Child Restraint ..................... 67,70
10
INDEX 627

Extender........................... 52
Front Seat .......................... 39
Inspection .......................... 83
Pretensioners ........................ 50
Reminder .......................... 226
Untwisting Procedure .................. 47
Seats .............................. 101,110
Adjustment ......................... 101
Child .............................. 70
Folding Floor ....................... 181
Heated ............................ 104
Memory ........................... 116
Power ............................ 102
Rear Folding ..................... 111,112
Reclining .......................... 109
Reclining Rear ....................... 110
Security Alarm (Theft Alarm) ................ 18
Selection of Coolant (Antifreeze) ..........545,582
Sentry Key (Immobilizer) ................... 16 Sentry Key Programming
................... 17
Sentry Key Replacement ................... 17
Service Assistance ....................... 605
Service Contract ......................... 607
Service Manuals ........................ 609
Setting the Clock ..................... 250,260
Settings, Personal ........................ 242
Shift Lever Override ...................... 516
Shifting ............................... 312
Automatic Transmission .............313,318
Transfer Case ....................... 328
Transfer Case, Shifting into Transfer Case
Neutral (N) ...................... 481,483
Transfer Case, Shifting out of Transfer Case
Neutral (N) ...................... 482,486
Shoulder Belt Upper Anchorage .............. 47
Shoulder Belts ........................... 39
Signals, Turn ...................... 85,128,210
628 INDEX