radiator RAM 1500 2023 User Guide

SERVICING AND MAINTENANCE351
Disposal Of Used Coolant
Used ethylene glycol-based coolant (antifreeze) is a
regulated substance requiring proper disposal. Check with
your local authorities to determine the disposal rules for
your community. To prevent ingestion by animals or
children, do not store ethylene glycol-based coolant in
open containers or allow it to remain in puddles on the
ground, clean up any ground spills immediately.
If ingested, seek emergency assistance immediately.
Checking Coolant Level — 3.6L Engine
The level of the coolant in the pressurized coolant bottle
should be between the “MIN” and “MAX” range on the
bottle when the engine is cold.
The radiator normally remains completely full, so there is
no need to remove the cap unless checking for coolant
freeze point or replacing engine coolant (antifreeze).
Advise your service attendant of this. As long as the engine
operating temperature is satisfactory, the coolant bottle
need only be checked once a month. When additional
engine coolant is needed to maintain the proper level, it
should be added to the coolant bottle. Do not overfill.
Checking Coolant Level — 5.7L Engines
With the engine off and cold, the level of the engine
coolant should be between the ADD and SAFE range on
the dipstick.
To check the coolant level:

1. Open the coolant reservoir.

2. Lift and remove the plastic dipstick from the
reservoir neck.

Coolant Reservoir Dipstick

3. Check the coolant level on the dipstick.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
engine coolant (antifreeze) freeze point or replacing
engine coolant. Advise your service attendant of this.
As long as the engine operating temperature is
satisfactory, the coolant bottle need only be checked
once a month.
When additional engine coolant is needed to maintain the
proper level, it should be added to the coolant bottle.
Do not overfill.
WARNING!
Do not open a hot engine cooling system. Never add
engine coolant (antifreeze) when the engine is over -
heated. Do not loosen or remove the cap to cool an
overheated engine. Heat causes pressure to build up
in the cooling system. To prevent scalding or injury,
do not remove the pressure cap while the system is
hot or under pressure.
 Do not use a pressure cap other than the one speci -
fied for your vehicle. Personal injury or engine
damage may result.
8

23_DT_OM_EN_USC_t.book Page 351

352SERVICING AND MAINTENANCE
(Continued)
Cooling System Notes
NOTE:When the vehicle is stopped after a few miles/kilometers
of operation, you may observe vapor coming from the front
of the engine compartment. This is normally a result of
moisture from rain, snow, or high humidity accumulating
on the radiator and being vaporized when the thermostat
opens, allowing hot engine coolant (antifreeze) to enter
the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
Do not overfill the coolant expansion bottle.
 Check the coolant freeze point in the radiator and in
the coolant expansion bottle. If engine coolant needs
to be added, the contents of the coolant expansion
bottle must also be protected against freezing.
 If frequent engine coolant additions are required, the
cooling system should be pressure tested for leaks.
 Maintain engine coolant concentration at a minimum
of 50% OAT coolant (conforming to MS.90032) and
distilled water for proper corrosion protection of your
engine which contains aluminum components.
 Make sure that the coolant expansion bottle overflow
hoses are not kinked or obstructed. 
Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
 Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory engine cooling performance,
poor gas mileage, and increased emissions.
BRAKE SYSTEM
In order to ensure brake system performance, all brake
system components should be inspected periodically
Úpage 334.
Fluid Level Check — Brake Master Cylinder
The fluid level of the brake master cylinder should be
checked whenever the vehicle is serviced, or immediately
if the Brake System Warning Light is on. If necessary, add
fluid to bring level within the designated marks on the side
of the reservoir of the brake master cylinder. Be sure to
clean the top of the master cylinder area before removing
cap. With disc brakes, fluid level can be expected to fall as
the brake pads wear. Brake fluid level should be checked
when pads are replaced. If the brake fluid is abnormally
low, check the system for leaks
Úpage 397.
WARNING!
Riding the brakes can lead to brake failure and possibly
a collision. Driving with your foot resting or riding on the
brake pedal can result in abnormally high brake
temperatures, excessive lining wear, and possible brake
damage. You would not have your full braking capacity
in an emergency.
WARNING!
Use only manufacturer's recommended brake fluid Úpage 397. Using the wrong type of brake fluid can
severely damage your brake system and/or impair its
performance. The proper type of brake fluid for your
vehicle is also identified on the original factory
installed hydraulic master cylinder reservoir.
 To avoid contamination from foreign matter or
moisture, use only new brake fluid or fluid that has
been in a tightly closed container. Keep the master
cylinder reservoir cap secured at all times. Brake
fluid in an open container absorbs moisture from the
air resulting in a lower boiling point. This may cause
it to boil unexpectedly during hard or prolonged
braking, resulting in sudden brake failure. This could
result in a collision.

23_DT_OM_EN_USC_t.book Page 352

396TECHNICAL SPECIFICATIONS
ENGINE FLUIDS AND LUBRICANTS
Component Fluid, Lubricant, or Genuine Part
Engine Coolant We recommend using Mopar® Antifreeze/Coolant 10 Year/150,000 Mile (240,000 km)
Formula OAT (Organic Additive Technology).
Motor Generator Unit – 3.6L Engine (If Equipped) We recommend using Mopar® Antifreeze/Coolant 10 Year/150,000 Mile (240,000 km)
Formula OAT (Organic Additive Technology).
Engine Oil – 3.6L & 5.7L Engine We recommend using Mopar® SAE 0W-20 Full Synthetic Engine Oil which meets the
requirements of the manufacturer Material Standard MS-6395. Equivalent full synthetic
SAE 0W-20 engine oil can be used but must have the API Starburst trademark
Úpage 341.
Fuel Selection – 3.6L Engine 87 Octane (R+M)/2 Method, 0-15% ethanol (Do not use E-85).
Fuel Selection – 5.7L Engine 89 Octane Recommended - 87 Octane Acceptable (R+M)/2 Method, 0-15% ethanol (Do
not use E-85).
CAUTION!

Mixing of engine coolant (antifreeze) other than specified Organic Additive Technology (OAT) engine coolant (antifreeze), may result in engine damage and may decrease corrosion
protection. Organic Additive Technology (OAT) engine coolant is different and should not be mixed with Hybrid Organic Additive Technology (HOAT) engine coolant (antifreeze) or
any “globally compatible” coolant (antifreeze). If a non-OAT engine coolant (antifreeze) is introduced into the cooling system in an emergency, the cooling system will need to be
drained, flushed, and refilled with fresh OAT coolant (conforming to MS.90032), by an authorized dealer as soon as possible.
 Do not use water alone or alcohol-based engine coolant (antifreeze) products. Do not use additional rust inhibitors or antirust products, as they may not be compatible with the
radiator engine coolant and may plug the radiator.
 This vehicle has not been designed for use with propylene glycol-based engine coolant (antifreeze). Use of propylene glycol-based engine coolant (antifreeze) is not recommended.

23_DT_OM_EN_USC_t.book Page 396

404
Brake Fluid .......................................................... 352, 397
Brake System ...................................................... 352, 392
Fluid Check.............................................................. 352
Master Cylinder ....................................................... 352
Parking .................................................................... 122
Warning Light .......................................................... 108
Brake/Transmission Interlock..................................... 125
Bulb Replacement ....................................................... 365
Bulbs, Light.......................................................... 313
, 365
CCamera ......................................................................... 163
Camera, AUX................................................................. 168
Camera, Rear ............................................................... 163
Camera, Surround View ............................................... 165
Camera, Trailer 360..................................................... 168
Capacities, Fuel............................................................ 395
Caps, Filler Oil (Engine) .............................................................. 337
Radiator (Coolant Pressure)................................... 350
Car Washes .................................................................. 388
Carbon Monoxide Warning .......................................... 313
Care And Maintenance ................................................ 388
Cargo Light ...................................................................... 49
CD.................................................................................. 226
Cellular Phone .............................................................. 252
Center High Mounted Stop Light................................. 369
Center Seat Storage Compartment ...............................60
Chart, Tire Sizing .......................................................... 371
Check Engine Light (Malfunction Indicator Light) ...... 117
Checking Your Vehicle For Safety ............................... 311
Checks, Safety.............................................................. 311
Child Restraint.............................................................. 298 Child Restraints
Booster Seats .......................................................... 301
Child Seat Installation ................................... 306
, 308
How To Stow An unused ALR Seat Belt .................305 Infant And Child Restraints ..................................... 300
Locating The LATCH Anchorages............................ 304
Lower Anchors And Tethers For Children............... 302
Older Children And Child Restraints....................... 300
Seating Positions ..................................................... 301
Clean Air Gasoline ........................................................ 393
Cleaning Wheels .....................................................................383
Climate Control ............................................................... 54 Automatic ................................................................... 54
Manual ....................................................................... 56
Compact Spare Tire ...................................................... 381
Connected Services ................ 236
, 237, 238, 239, 248
Contract, Service .......................................................... 400
Controls ......................................................................... 218
Cooling Pressure Cap (Radiator Cap) ..........................350
Cooling System ............................................................. 349 Adding Coolant (Antifreeze) ....................................350
Coolant Level ................................................. 349
, 351
Cooling Capacity ...................................................... 395
Disposal Of Used Coolant ....................................... 351 Drain, Flush, And Refill............................................349
Inspection ................................................................ 351
Points To Remember............................................... 352
Pressure Cap ...........................................................350
Radiator Cap ............................................................350Selection Of Coolant (Antifreeze) ........ 350
, 395, 396
Corrosion Protection ..................................................... 388
Cruise Control Accel/Decel.............................................................. 144 Cancel ...................................................................... 145
Resume.................................................................... 144
Cruise Control (Speed Control) ........................... 143
, 145
Cruise Light ..........................................................115, 116
Customer Assistance ................................................... 398
Cybersecurity ................................................................ 191
DDaytime Running Lights ................................................. 47 Dealer Service .............................................................. 341
Defroster, Windshield .................................... 54
, 56, 311
Deleting A Phone .......................................................... 231
Diagnostic System, Onboard ....................................... 116
Differential, Limited Slip .............................................. 140
Dimmer Control Switch .................................................. 51
Disable Vehicle Towing ................................................ 330
Disc Drive ...................................................................... 226
Disconnecting ............................................................... 231
Disposal Antifreeze (Engine Coolant) .................................... 351
Disturb........................................................................... 234
Door Ajar .............................................................. 108
, 110
Door Ajar Light ..................................................... 108, 110
Door Locks Automatic .................................................................. 27
Doors ............................................................................... 24
Driver Memory Presets ................................................ 224
Driver’s Seat Back Tilt .................................................... 30
Driving Through Flowing, Rising, Or Shallow Standing Water .................................................. 189
Driving Tips ................................................................... 189
Dual Rear Wheels......................................................... 392

23_DT_OM_EN_USC_t.book Page 404

408 N
Navigation .................................................................... 103
New Vehicle Break-In Period ....................................... 122
OOccupant Restraints .................................................... 282
Octane Rating, Gasoline (Fuel) ................................... 393
Off Road Pages ............................................................ 256 Accessory Gauges................................................... 259
Pitch And Roll .......................................................... 260
Status Bar ............................................................... 257Vehicle Dynamics.................................................... 258
Off-Pavement Driving (Off-Road) ................................. 190
Off-Road Driving (Off-Pavement) ................................. 190
Oil Filter, Change .......................................................... 342
Oil Filter, Selection ....................................................... 342
Oil Life Reset ¹ .............................................................. 101
Oil Pressure Light ......................................................... 109
Oil, Engine............................................................ 341
, 396
Capacity ................................................................... 395
Dipstick.................................................................... 340
Disposal................................................................... 342
Filter......................................................................... 342
Filter Disposal ......................................................... 342 Identification Logo .................................................. 341Materials Added To................................................. 342Pressure Warning Light .......................................... 109Recommendation .......................................... 341
, 395
Synthetic.................................................................. 342
Viscosity................................................................... 395
Onboard Diagnostic System ........................................ 116
Operating Precautions ................................................. 116 Operator Manual
Owner's Manual ....................................................... 401
Outside Rearview Mirrors............................................... 40
Overheating, Engine ..................................................... 327
PPaddle Shifters ............................................................. 129
Paint Care...................................................................... 388
Pair (Link) Uconnect Phone To A Mobile Phone

b
...230
Panic Alarm ..................................................................... 17
Parallel Parking ............................................................. 159
Parking Brake ............................................................... 122
Parking Lights ................................................................. 48
ParkSense Front And Rear......................................................... 152
ParkSense Active Park Assist ...................................... 157
ParkSense System, Rear.............................................. 152
Passive Entry................................................................... 25 Pedals, Adjustable .......................................................... 38
Pedestrian Warning System ......................................... 276
Pets ................................................................................ 311
Phone Mode .................................................................. 228
Pickup Box................................................................ 79
, 81
Pinch Protection.............................................................. 73
Placard, Tire And Loading Information ........................ 374
Power Distribution Center (Fuses)........................... 355
, 360
Door Locks ................................................................. 25
Mirrors ........................................................................ 41
Outlet (Auxiliary Electrical Outlet) ...................... 66
, 67
Seats .......................................................................... 32
Side Steps .................................................................. 25
Sliding Rear Window ................................................. 71
Steering ....................................................................141 Sunroof ...................................................................... 72
Windows .................................................................... 70
Power Seats Down .......................................................................... 32
Forward ...................................................................... 32
Rearward ................................................................... 32
Recline ....................................................................... 32
Tilt .............................................................................. 32
Up ............................................................................... 32
Power Steering ............................................................. 141
Pregnant Women And Seat Belts ................................ 287
Presets .......................................................................... 224
Pressure Washing ........................................................ 341
Pretensioners Seat Belts ................................................................ 287
Profile Settings ............................................................. 193
RRadial Ply Tires ............................................................. 378
Radiator Cap (Coolant Pressure Cap) ................349, 350
Radio Off Road Pages ....................................................... 256Presets ..................................................................... 224Settings.................................................................... 191
Sound Setting .......................................................... 211
Radio Controls .............................................................. 218
Radio Mode .................................................................. 218
Radio Operation ..................................................218
, 252
Radio Remote Controls ................................................ 218
Rain Sensitive Wiper System......................................... 53 RamBox........................................................................... 81
RamBox Safety ............................................................... 83Rear Axle (Differential) ................................................. 353
Rear Cargo Area Utility Rails .......................................... 80

23_DT_OM_EN_USC_t.book Page 408