transmission Ram Cargo Van 2015 Repair Manual

your authorized dealer immediately to have the trans-
mission fluid level checked. Operating the vehicle with
an improper fluid level can cause severe transmission
damage.
CAUTION!
If a transmission fluid leak occurs, visit your autho-
rized dealer immediately. Severe transmission dam-
age may occur. Your authorized dealer has the proper
tools to adjust the fluid level accurately.
Fluid And Filter Changes
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
In addition, change the fluid and filter if the fluid
becomes contaminated (with water, etc.), or if the trans-
mission is disassembled for any reason.
Appearance Care And Protection From Corrosion
Protection Of Body And Paint From Corrosion
Vehicle body care requirements vary according to geo-
graphic locations and usage. Chemicals that make roads
passable in snow and ice and those that are sprayed on
trees and road surfaces during other seasons are highly
corrosive to the metal in your vehicle. Outside parking,
which exposes your vehicle to airborne contaminants,
road surfaces on which the vehicle is operated, extreme
hot or cold weather and other extreme conditions will
have an adverse effect on paint, metal trim, and under-
body protection.
The following maintenance recommendations will enable
you to obtain maximum benefit from the corrosion
resistance built into your vehicle.
602 MAINTAINING YOUR VEHICLE

Cavity Cartridge FuseMini-FuseDescription
M25 –20 Amp Yellow Fuel Pump, Diesel Lift Pump – If Equipped
M26 –10 Amp Red Power Mirror Switch, Driver Window Switch
M27 –10 Amp Red Wireless Control Module,
Keyless Entry Module
M28 –10 Amp Red Powertrain, Transmission Control Module
M29 –10 Amp Red Occupant Classification Module
M30 –15 Amp Blue Rear Wiper Module, Power Folding Mirror
M31 –20 Amp Yellow Back-Up Lamps
M32 –10 Amp Red Airbag Module, THATCHUM – If Equipped
M33 –10 Amp Red Powertrain
M34 –10 Amp Red Park Assist, Heater Climate Control Module,
Headlamp Wash, Compass, Rear Camera,
Door Lamps, Flashlight, Relay Diesel Cabin Heater, Rad Fan Diesel – If Equipped
616 MAINTAINING YOUR VEHICLE

Chassis
ComponentFluid, Lubricant, or Genuine Part
Automatic Transmission Use Only ATF+4® Automatic Transmission Fluid. Fail-
ure to use ATF+4® fluid may affect the function or
performance of your transmission. We recommend
MOPAR® ATF+4® Fluid.
Brake Master Cylinder We recommend you use MOPAR® DOT 3. If DOT 3
brake fluid is not available, then DOT 4 is acceptable.
Power Steering Reservoir We recommend you use MOPAR® Power Steering Fluid
+4, MOPAR® ATF+4® Automatic Transmission Fluid.
7
MAINTAINING YOUR VEHICLE 627

Mileage or time passed
(whichever comes first)
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Change automatic transmission
fluid and filter if using your
vehicle for any of the following:
police, taxi, fleet, or frequent
trailer towing. X
Change automatic transmission
fluid and filter. X
Inspect and replace PCV valve if
necessary. X
** The spark plug change interval is mileage based only,
yearly intervals do not apply.
634 MAINTENANCE SCHEDULES

Disposal............................. .596
Anti-Lock Warning Light ....................289
Appearance Care ........................ .602
Ashtray ............................... .253
Assistance Towing ........................ .138
Assist, Hill Start ......................... .472
Auto Down Power Windows ..................47
Automatic Dimming Mirror ..................118
Automatic Door Locks ......................38
Automatic Headlights ..................... .200
Automatic Temperature Control (ATC) ..........420
Automatic Transmission ....................442
Adding Fluid ......................... .601
Fluid and Filter Changes ..................602
Fluid Change ......................... .602
Fluid Level Check ...................... .601
Fluid Type ........................... .600
Gear Ranges .......................... .447
Special Additives ...................... .601Torque Converter
...................... .454
Auto Up Power Windows ....................47
Battery ................................ .586
Jump Starting ......................... .562
Keyless Transmitter Replacement (RKE) ........28
Saving Feature (Protection) ................204
Belts, Seat .............................. .107
Body Builders Guide ........................6
Body Mechanism Lubrication .................590
B-Pillar Location ......................... .482
Brake Assist System ...................... .466
Brake Control System, Electronic ..............463
Brake Fluid ............................ .627
Brake System ........................... .462
Anti-Lock (ABS) ....................... .462
Fluid Check .......................... .599
Parking ............................. .460
Brake/T

ransmission Interlock .................444
10
INDEX 649

DipsticksAutomatic Transmission ..................601
Oil (Engine) .......................... .580
Power Steering ........................ .459
Disabled Vehicle Towing ....................569
Disposal Antifreeze (Engine Coolant) ................596
Door Locks Door Locks ............................35
KeyFob...............................35
Remote ...............................35
Remote Keyless Entry (RKE) ................35
Door Opener, Garage ...................... .232
Driving Through Flowing, Rising, or Shallow Standing
Water ............................... .456
Driving to Achieve Maximum Fuel Economy ......314
DVD Player (Video Entertainment System™) ......362E-85 Fuel
.............................. .516
Economy (Fuel) Mode ..................... .445
Electrical Power Outlets .....................244
Electric Remote Mirrors .....................119
Electronic Brake Control System ...............463
Brake Assist System .....................466
Electronic Speed Control (Cruise Control) ........212
Electronic Stability Control (ESC) ..............467
Electronic Vehicle Information Center (EVIC) ......303
Emergency, In Case of Hazard Warning Flasher ..................540
Jacking .............................. .543
Jump Starting ......................... .562
Overheating .......................... .540
Emission Control System Maintenance ..........577
Engine Air Cleaner .......................... .583
Block Heater ......................... .442
Break-In Recommendations ................105
652 INDEX

Maintenance.......................... .518
Replacement Parts ...................... .518
Starting ............................. .518
Flooded Engine Starting ....................440
Floor Console ........................... .261
Fluid Capacities ......................... .624
Fluid Leaks .............................110
Fluid Level Checks Automatic Transmission ..................601
Brake ............................... .599
Cooling System ........................ .592
Power Steering ........................ .459
Fluids, Lubricants and Genuine Parts ...........625
Fog Lights ............................. .289
Fog Light Service ........................ .621
Fold in Floor (Stow n Go) Seating.............174
Freeing A Stuck Vehicle .....................566
Fuel ...................................511
Adding ............................. .519Additives
............................ .514
Clean Air ............................ .512
Conserving ........................... .314
Economy Mode ....................... .445
Ethanol ............................. .512
Filler Cap (Gas Cap) .....................289
Filler Door (Gas Cap) ....................289
Gasoline ..............................511
Materials Added ....................... .514
Methanol ............................ .512
Octane Rating ..........................511
Requirements ..........................511
Saver Mode .......................... .314
Tank Capacity ......................... .624
Fuel, Flexible ........................... .516
Fueling ............................... .519
Fuel Optimizer .......................... .314
Fuel

Saver ............................. .314
Fuses ................................. .609
654 INDEX

Sliding Door.............................49
Snow Chains (Tire Chains) ...................500
Snow Tires ............................. .492
Spare Tire .............................. .494
Spark Plugs ............................ .625
Speed Control (Cruise Control) ................212
Starting ............................... .439
Automatic Transmission ..................439
Cold Weather ......................... .440
Engine Fails to Start .....................440
Remote ...............................30
Starting and Operating .....................439
Starting Procedures ....................... .439
Steering Power .............................. .458
Tilt Column .......................... .208
Wheel, Heated ........................ .209
Wheel, Tilt ........................... .208
Steering Wheel Audio Controls ...............409Steering Wheel Mounted Sound System Controls . . .409
Storage
............................... .617
Storage Bin ............................. .254
Storage, Vehicle .......................... .431
Storing Your Vehicle ...................... .617
Stow n Go (Fold in Floor) Seats ...............174
Sunglasses Storage ....................... .229
Sun Roof .............................. .241
Sway Control, Trailer ...................... .471
Synthetic Engine Oil ...................... .583
System, Remote Starting .....................30
Tachometer ............................. .289
Telescoping Steering Column .................208
Temperature Control, Automatic (ATC) ..........420
Tilt Steering Column ...................... .208
Tire and Loading Information Placard ...........482
Tire Markings ........................... .475
T

ires ..................................110
10
INDEX 663

Trailer Sway Control (TSC)..................471
Trailer Towing .......................... .524
Cooling System Tips .....................536
Hitches ............................. .527
Minimum Requirements ..................530
Tips................................ .535
Trailer and Tongue Weight .................529
Wiring .............................. .534
Trailer Towing Guide ...................... .528
Trailer Weight ........................... .528
Transmission ........................... .600
Automatic ........................... .442
Fluid ............................... .600
Transmitter
Battery Service (Remote Keyless Entry). . .28
Transmitter, Garage Door Opener (HomeLink®). . . .232
Transmitter, Remote Keyless Entry (RKE) .........20
Transporting Pets ........................ .104
Tread Wear Indicators ..................... .496
Trip Odometer .......................... .289Turn Signals
............................ .289
UCI Connector .......................... .355
Uconnect® Advanced Phone Connectivity ..............142
Operation ............................ .125
Phone Call Features .....................133
Phone Features ........................ .137
Things You Should Know About Your
Uconnect® Phone ...................... .143
Uconnect® 130 Operating Instructions Auxiliary Mode ........337
Operating Instructions CD Mode ............332
Operating Instructions Radio Mode ..........329
Playing MP3 Files ...................... .334
Uconnect® 130 With Satellite Radio Multimedia Satellite Radio .................350
Operating Instructions Radio Mode ..........338
Playing MP3 Files ...................... .346
10
INDEX 665