airbag SAAB 9-7X 2007 Service Manual

Service
Your dealer knows your vehicle best and wants
you to be happy with it. We hope you will go
to your dealer for all your service and parts needs.
Accessories and Modications
When you add non-Saab accessories to your
vehicle they can affect your vehicle’s performance
and safety, including such things as, airbags,
braking, stability, ride and handling, emissions
systems, aerodynamics, durability, and electronic
systems like anti-lock brakes, traction control,
and stability control. Some of these accessories
may even cause malfunction or damage not
covered by warranty.Saab accessories are designed to complement
and function with other systems on your vehicle.
Your Saab dealer can accessorize your vehicle
using genuine Saab accessories. When you go to
your Saab dealer and ask for Saab accessories,
you will know that Saab-trained and supported
service technicians will perform the work
using genuine Saab accessories.
California Proposition 65 Warning
Most motor vehicles, including this one, contain
and/or emit chemicals known to the State of
California to cause cancer and birth defects or
other reproductive harm. Engine exhaust,
many parts and systems (including some inside
the vehicle), many uids, and some component
wear by-products contain and/or emit these
chemicals.
322
ProCarManuals.com

Doing Your Own Service Work
{CAUTION:
You can be injured and your vehicle could
be damaged if you try to do service work
on a vehicle without knowing enough
about it.
Be sure you have sufficient knowledge,
experience, the proper replacement
parts, and tools before you attempt any
vehicle maintenance task.
Be sure to use the proper nuts, bolts,
and other fasteners. English and metric
fasteners can be easily confused. If you
use the wrong fasteners, parts can later
break or fall off. You could be hurt.
If you want to do some of your own service work,
you will want to use the proper service manual.
It tells you much more about how to service your
vehicle than this manual can.Your vehicle has an airbag system. Before
attempting to do your own service work, see
Servicing Your Airbag-Equipped Vehicle on
page 80.
You should keep a record with all parts receipts
and list the mileage and the date of any service
work you perform. SeeMaintenance Record
on page 462.
Adding Equipment to the Outside
of Your Vehicle
Things you might add to the outside of your
vehicle can affect the airow around it. This may
cause wind noise and affect windshield washer
performance. Check with your dealer before
adding equipment to the outside of your vehicle.
323
ProCarManuals.com

Electrical System
Add-On Electrical Equipment
Notice:Do not add anything electrical to your
vehicle unless you check with your dealer
rst. Some electrical equipment can damage
your vehicle and the damage would not
be covered by your warranty. Some add-on
electrical equipment can keep other
components from working as they should.
Add-on equipment can drain your vehicle’s battery,
even if your vehicle is not operating.
Your vehicle has an airbag system. Before
attempting to add anything electrical to your
vehicle, seeServicing Your Airbag-Equipped
Vehicle on page 80.
Headlamps
The headlamp wiring is protected by fuses, one
for each headlamp, in the fuse block. An electrical
overload will cause the lamps to turn off. If this
happens, have your headlamp wiring checked
right away.
Windshield Wiper Fuses
The windshield wiper motor is protected by a
circuit breaker and a fuse. If the motor overheats
due to heavy snow or ice, the wiper will stop
until the motor cools. If the overload is caused by
some electrical problem, be sure to get it xed.
434
ProCarManuals.com

Fuses Usage
5 Driver’s Side Headlamp High-Beam
6 Driver’s Side Headlamp Low-Beam
7 Windshield Wiper
8 Automatic Transfer Case
9 Windshield Washer
10 Powertrain Control Module B
11 Fog Lamps
12 Stoplamp
13 Cigarette Lighter
15 Electric Adjustable Pedals
16 Ignition B
18 Airbag System
19 Electric Brake
20 Cooling Fan
21 Horn
22 Ignition E
23 Electronic Throttle ControlFuses Usage
24Instrument Panel Cluster/Driver
Information Center (DIC)
25 Brake Transmission Shift Interlock
26Transmission Control Module (TCM)
Canister
27 Backup
28 Powertrain Control Module 1
29 Oxygen Sensor
30 Air Conditioning
31 Truck Body Controller 1
50 Passenger’s Side Trailer Turn
51 Driver’s Side Trailer Turn
52 Hazard Flashers
53 Headlamp Driver Module
54 Air Injection Reactor Solenoid
57 Ignition A1
59 Regulated Voltage Control
437
ProCarManuals.com

Fuses Usage
5 Driver’s Side Headlamp High-Beam
6 Driver’s Side Headlamp Low-Beam
7 Windshield Wiper
8 Automatic Transfer Case
9 Windshield Washer
10 Powertrain Control Module B
11 Fog Lamps
12 Stoplamp
13 Cigarette Lighter
14 Ignition Coils
15Transmission Control
Module/Canister
16 Ignition B
18 Airbag System
19 Electric Brake
20 Cooling Fan
21 Horn
22 Ignition E
23 Electronic Throttle Control
24Instrument Panel Cluster/Driver
Information CenterFuses Usage
25 Brake Transmission Shift Interlock
26 Engine 1
27 Backup
28 Engine Control Module 1
29 Engine Control Module
30 Air Conditioning
31 Injector Bank A
50 Passenger’s Side Trailer Turn
51 Driver’s Side Trailer Turn
52 Hazard Flashers
53 Transmission
54 Oxygen Sensor B
55 Oxygen Sensor A
56 Injector Bank B
57 Headlamp Driver Module
58 Truck Body Controller 1
59 Electric Adjustable Pedals
61 Ignition A1
66 Regulated Voltage Control
440
ProCarManuals.com

(e)Make sure the safety belt reminder light and all
your belts, buckles, latch plates, retractors, and
anchorages are working properly. Look for
any other loose or damaged safety belt system
parts. If you see anything that might keep a safety
belt system from doing its job, have it repaired.
Have any torn or frayed safety belts replaced. Also
look for any opened or broken airbag coverings,
and have them repaired or replaced. The airbag
system does not need regular maintenance.
(f)Lubricate all key lock cylinders, hood latch
assembly, secondary latch, pivots, spring anchor,
release pawl, rear compartment hinges, outer
liftgate handle pivot points, rear door detent link,
roller mechanism, liftgate handle pivot points, latch
bolt, fuel door hinge, cargo door hinge, locks,
and folding seat hardware. More frequent
lubrication may be required when exposed to a
corrosive environment. Applying silicone grease on
weatherstrips with a clean cloth will make them
last longer, seal better, and not stick or squeak.
(g)Inspect hoses for cracks, chang, leaks, kinks,
and proper installation.(h)Change automatic transmission uid and lter
if the vehicle is mainly driven under one or
more of these conditions:
In heavy city traffic where the outside
temperature regularly reaches 90°F (32°C)
or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police, or delivery
service.
(i)Drain, ush, and rell cooling system.
This service can be complex; you should have
your dealer perform this service. See Engine
Coolant on page 344 for what to use. Inspect
hoses. Clean radiator, condenser, pressure cap,
and ller neck. Pressure test the cooling
system and pressure cap.
(j)A uid loss in any vehicle system could indicate
a problem. Have the system inspected and repaired
and the uid level checked. Add uid if needed.
(k)If you drive regularly under dusty conditions,
inspect the lter at each engine oil change.
(l)Visually inspect belt for fraying, excessive cracks,
or obvious damage. Replace belt if necessary.
454
ProCarManuals.com

Vehicle Data Collection and Event
Data Recorders
Your vehicle, like other modern motor vehicles,
has a number of sophisticated computer systems
that monitor and control several aspects of the
vehicle’s performance. Your vehicle uses on-board
vehicle computers to monitor emission control
components to optimize fuel economy, to monitor
conditions for airbag deployment and, if so
equipped, to provide anti-lock braking and to help
the driver control the vehicle in difficult driving
situations. Some information may be stored
during regular operations to facilitate repair of
detected malfunctions; other information is stored
only in a crash event by computer systems,
such as those commonly called event data
recorders (EDR).
In a crash event, computer systems, such as the
Airbag Sensing and Diagnostic Module (SDM)
in your vehicle may record information about the
condition of the vehicle and how it was operated,
such as data related to engine speed, brake
application, throttle position, vehicle speed, safety
belt usage, airbag readiness, airbag performance,and the severity of a collision. If your vehicle is
equipped with StabiliTrak
®, steering performance,
including yaw rate, steering wheel angle, and
lateral acceleration, is also recorded. This
information has been used to improve vehicle
crash performance and may be used to improve
crash performance of future vehicles and
driving safety. Unlike the data recorders on many
airplanes, these on-board systems do not
record sounds, such as conversation of vehicle
occupants.
To read this information, special equipment is
needed and access to the vehicle or the device
that stores the data is required. Saab will not
access information about a crash event or share it
with others other than:
with the consent of the vehicle owner or,
if the vehicle is leased, with the consent of the
lessee,
in response to an official request of police or
similar government office,
as part of Saab’s defense of litigation through
the discovery process, or
as required by law.
473
ProCarManuals.com

A
Accessories and Modications..................... 322
Accessory Inator........................................ 404
Accessory Power Outlet(s).......................... 166
Adding Equipment to Your
Airbag-Equipped Vehicle............................ 81
Additives, Fuel............................................ 325
Add-On Electrical Equipment....................... 434
Adjustable Throttle and Brake Pedal............ 110
Air Cleaner/Filter, Engine............................. 339
Air Conditioning........................................... 167
Air Suspension............................................ 303
Airbag
Passenger Status Indicator....................... 179
Readiness Light....................................... 178
Airbag Sensing and Diagnostic
Module (SDM).......................................... 473
Airbag System............................................... 64
Adding Equipment to Your
Airbag-Equipped Vehicle......................... 81
How Does an Airbag Restrain?.................. 72
Passenger Sensing System....................... 74
Servicing Your Airbag-Equipped Vehicle..... 80
What Makes an Airbag Inate?.................. 72
What Will You See After an Airbag
Inates?................................................. 73Airbag System (cont.)
When Should an Airbag Inate?................. 70
Where Are the Airbags?............................. 67
All-Wheel Drive........................................... 368
All-Wheel-Drive (AWD) System.................... 275
All-Wheel-Drive Service Light....................... 192
Antenna, Fixed Mast................................... 261
Antenna, XM™ Satellite Radio Antenna
System.................................................... 261
Anti-Lock Brake System (ABS).................... 269
Anti-Lock Brake, System Warning Light....... 184
Appearance Care
Aluminum Wheels.................................... 429
Care of Safety Belts................................ 427
Chemical Paint Spotting........................... 431
Cleaning Exterior Lamps/Lenses.............. 428
Cleaning the Inside of Your Vehicle.......... 423
Fabric/Carpet........................................... 425
Finish Care.............................................. 428
Finish Damage......................................... 430
Instrument Panel, Vinyl, and Other
Plastic Surfaces.................................... 426
Leather.................................................... 426
Sheet Metal Damage............................... 430
Tires........................................................ 430
Underbody Maintenance........................... 431
483
ProCarManuals.com

I
Ignition Positions......................................... 107
Infants and Young Children, Restraints.......... 40
Ination - Tire Pressure............................... 388
Instrument Panel
Overview.................................................. 148
Instrument Panel (I/P)
Brightness................................................ 163
Cluster..................................................... 175
J
Jump Starting.............................................. 362
K
Keyless Entry System................................... 89
Keys............................................................. 87
L
Labeling, Tire Sidewall................................. 381
Lamps
Battery Run-Down Protection................... 165
Dome....................................................... 163
Dome Lamp Override............................... 163
Electric Power Management..................... 164
Fog .......................................................... 162
Reading................................................... 164
LATCH System
Child Restraints......................................... 50
License Plate Lamps................................... 376
Liftgate/Liftglass............................................. 98
Liftglass/Liftgate............................................. 98
Light
Airbag Readiness..................................... 178
Anti-Lock Brake System Warning............. 184
Brake System Warning............................. 183
Charging System..................................... 182
Check Gages Warning............................. 192
Check Gas Cap....................................... 194
Cruise Control.......................................... 191
Gate Ajar................................................. 193
Highbeam On.......................................... 192
490
ProCarManuals.com

Light (cont.)
Low Fuel Warning.................................... 194
Malfunction Indicator................................ 187
Passenger Airbag Status Indicator............ 179
Passenger Safety Belt Reminder.............. 177
Reduced Engine Power............................ 191
Safety Belt Reminder............................... 177
Security................................................... 191
Service All-Wheel-Drive............................ 192
StabiliTrak
®Indicator................................ 185
StabiliTrak®Service.................................. 185
Tire Pressure........................................... 186
Lighting
Entry........................................................ 164
Exit.......................................................... 164
Limited-Slip Rear Axle................................. 271
Loading Your Vehicle................................... 296
Lockout Protection......................................... 97
Locks
Delayed Locking........................................ 94
Door.......................................................... 92
Lockout Protection..................................... 97
Power Door............................................... 93
Programmable Automatic Door Locks......... 94
Rear Door Security Locks.......................... 97Loss of Control........................................... 280
Low Fuel Warning Light............................... 194
Luggage Carrier.......................................... 141
Lumbar
Power Controls............................................ 9
M
Maintenance Schedule
Additional Required Services.................... 452
At Each Fuel Fill...................................... 455
At Least Once a Month............................ 455
At Least Once a Year .............................. 456
Introduction.............................................. 448
Maintenance Footnotes............................ 453
Maintenance Record................................ 462
Maintenance Requirements...................... 448
Normal Maintenance
Replacement Parts............................... 460
Owner Checks and Services.................... 455
Recommended Fluids and Lubricants....... 458
Scheduled Maintenance........................... 450
Using....................................................... 448
Your Vehicle and the Environment............ 448
Malfunction Indicator Light........................... 187
491
ProCarManuals.com