belt SAAB 9-7X 2007 Repair Manual

{CAUTION:
If you use bias-ply tires on your vehicle,
the wheel rim anges could develop
cracks after many miles of driving. A tire
and/or wheel could fail suddenly, causing
a crash. Use only radial-ply tires with the
wheels on your vehicle.
If you must replace your vehicle’s tires with those
that do not have a TPC Spec number, make
sure they are the same size, load range, speed
rating, and construction type (radial and
bias-belted tires) as your vehicle’s original tires.Vehicles that have a tire pressure monitoring
system may give an inaccurate low-pressure
warning if non-TPC Spec rated tires are installed
on your vehicle. Non-TPC Spec rated tires
may give a low-pressure warning that is higher or
lower than the proper warning level you would
get with TPC Spec rated tires. SeeTire Pressure
Monitor System on page 391.
Your vehicle’s original equipment tires are listed
on the Tire and Loading Information Label.
This label is attached to the vehicle’s center pillar
(B-pillar). SeeLoading Your Vehicle on page 296,
for more information about the Tire and Loading
Information Label.
399
ProCarManuals.com

Care of Safety Belts
Keep belts clean and dry.
{CAUTION:
Do not bleach or dye safety belts. If you
do, it may severely weaken them. In a
crash, they might not be able to provide
adequate protection. Clean safety belts
only with mild soap and lukewarm water.
Weatherstrips
Silicone grease on weatherstrips will make them
last longer, seal better, and not stick or squeak.
Apply silicone grease with a clean cloth. During
very cold, damp weather frequent application may
be required. SeeRecommended Fluids and
Lubricants on page 458.
Washing Your Vehicle
The paint nish on the vehicle provides beauty,
depth of color, gloss retention, and durability.
The best way to preserve the vehicle’s nish is to
keep it clean by washing it often with lukewarm
or cold water.
Do not wash the vehicle in the direct rays of the
sun. Use a car washing soap. Do not use
strong soaps or chemical detergents. Be sure to
rinse the vehicle well, removing all soap residue
completely. Approved cleaning products can
be obtained from your Saab dealer. SeeVehicle
Care/Appearance Materials on page 432.Do
not use cleaning agents that are petroleum based,
or that contain acid or abrasives. All cleaning
agents should be ushed promptly and not
allowed to dry on the surface, or they could stain.
Dry the nish with a soft, clean chamois or an
all-cotton towel to avoid surface scratches
and water spotting.
High pressure car washes may cause water to
enter the vehicle.
427
ProCarManuals.com

Maintenance Schedule................................ 448
Introduction............................................... 448
Maintenance Requirements........................ 448
Your Vehicle and the Environment............ 448
Using the Maintenance Schedule............... 448
Scheduled Maintenance............................. 450
Additional Required Services..................... 452
Maintenance Footnotes.............................. 453Owner Checks and Services..................... 455
At Each Fuel Fill....................................... 455
At Least Once a Month............................. 455
At Least Once a Year............................... 456
Recommended Fluids and Lubricants........ 458
Normal Maintenance Replacement Parts ... 460
Engine Drive Belt Routing......................... 461
Maintenance Record.................................. 462
Section 6 Maintenance Schedule
447
ProCarManuals.com

Additional Required Services (cont’d)
Service and Miles (Kilometers)25,000
(40 000)50,000
(80 000)75,000
(120 000)100,000
(160 000)125,000
(200 000)150,000
(240 000)
Engine cooling system service (or every
ve years, whichever occurs rst).
An Emission Control Service.
See footnote (i).•
Inspect engine accessory drive belt.
An Emission Control Service.
See footnote (l).•
Maintenance Footnotes
(a)Visually inspect brake lines and hoses for
proper hook-up, binding, leaks, cracks, chang,
etc. Inspect disc brake pads for wear and rotors for
surface condition. Inspect other brake parts,
including calipers, parking brake, etc.
(b)Visually inspect front and rear suspension and
steering system for damaged, loose, or missing
parts or signs of wear. Inspect power steering lines
and hoses for proper hook-up, binding, leaks,
cracks, chang, etc.(c)Visually inspect hoses and have them replaced
if they are cracked, swollen, or deteriorated. Inspect
all pipes, ttings and clamps; replace with genuine
parts as needed. To help ensure proper operation,
a pressure test of the cooling system and pressure
cap and cleaning the outside of the radiator and air
conditioning condenser is recommended at least
once a year.
(d)Visually inspect wiper blades for wear or
cracking. Replace wiper blades that appear worn
or damaged or that streak or miss areas of
the windshield.
453
ProCarManuals.com

(e)Make sure the safety belt reminder light and all
your belts, buckles, latch plates, retractors, and
anchorages are working properly. Look for
any other loose or damaged safety belt system
parts. If you see anything that might keep a safety
belt system from doing its job, have it repaired.
Have any torn or frayed safety belts replaced. Also
look for any opened or broken airbag coverings,
and have them repaired or replaced. The airbag
system does not need regular maintenance.
(f)Lubricate all key lock cylinders, hood latch
assembly, secondary latch, pivots, spring anchor,
release pawl, rear compartment hinges, outer
liftgate handle pivot points, rear door detent link,
roller mechanism, liftgate handle pivot points, latch
bolt, fuel door hinge, cargo door hinge, locks,
and folding seat hardware. More frequent
lubrication may be required when exposed to a
corrosive environment. Applying silicone grease on
weatherstrips with a clean cloth will make them
last longer, seal better, and not stick or squeak.
(g)Inspect hoses for cracks, chang, leaks, kinks,
and proper installation.(h)Change automatic transmission uid and lter
if the vehicle is mainly driven under one or
more of these conditions:
In heavy city traffic where the outside
temperature regularly reaches 90°F (32°C)
or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police, or delivery
service.
(i)Drain, ush, and rell cooling system.
This service can be complex; you should have
your dealer perform this service. See Engine
Coolant on page 344 for what to use. Inspect
hoses. Clean radiator, condenser, pressure cap,
and ller neck. Pressure test the cooling
system and pressure cap.
(j)A uid loss in any vehicle system could indicate
a problem. Have the system inspected and repaired
and the uid level checked. Add uid if needed.
(k)If you drive regularly under dusty conditions,
inspect the lter at each engine oil change.
(l)Visually inspect belt for fraying, excessive cracks,
or obvious damage. Replace belt if necessary.
454
ProCarManuals.com

Engine Drive Belt Routing
4.2L V6 Engine
5.3L V8 Engine
461
ProCarManuals.com

Vehicle Data Collection and Event
Data Recorders
Your vehicle, like other modern motor vehicles,
has a number of sophisticated computer systems
that monitor and control several aspects of the
vehicle’s performance. Your vehicle uses on-board
vehicle computers to monitor emission control
components to optimize fuel economy, to monitor
conditions for airbag deployment and, if so
equipped, to provide anti-lock braking and to help
the driver control the vehicle in difficult driving
situations. Some information may be stored
during regular operations to facilitate repair of
detected malfunctions; other information is stored
only in a crash event by computer systems,
such as those commonly called event data
recorders (EDR).
In a crash event, computer systems, such as the
Airbag Sensing and Diagnostic Module (SDM)
in your vehicle may record information about the
condition of the vehicle and how it was operated,
such as data related to engine speed, brake
application, throttle position, vehicle speed, safety
belt usage, airbag readiness, airbag performance,and the severity of a collision. If your vehicle is
equipped with StabiliTrak
®, steering performance,
including yaw rate, steering wheel angle, and
lateral acceleration, is also recorded. This
information has been used to improve vehicle
crash performance and may be used to improve
crash performance of future vehicles and
driving safety. Unlike the data recorders on many
airplanes, these on-board systems do not
record sounds, such as conversation of vehicle
occupants.
To read this information, special equipment is
needed and access to the vehicle or the device
that stores the data is required. Saab will not
access information about a crash event or share it
with others other than:
with the consent of the vehicle owner or,
if the vehicle is leased, with the consent of the
lessee,
in response to an official request of police or
similar government office,
as part of Saab’s defense of litigation through
the discovery process, or
as required by law.
473
ProCarManuals.com

A
Accessories and Modications..................... 322
Accessory Inator........................................ 404
Accessory Power Outlet(s).......................... 166
Adding Equipment to Your
Airbag-Equipped Vehicle............................ 81
Additives, Fuel............................................ 325
Add-On Electrical Equipment....................... 434
Adjustable Throttle and Brake Pedal............ 110
Air Cleaner/Filter, Engine............................. 339
Air Conditioning........................................... 167
Air Suspension............................................ 303
Airbag
Passenger Status Indicator....................... 179
Readiness Light....................................... 178
Airbag Sensing and Diagnostic
Module (SDM).......................................... 473
Airbag System............................................... 64
Adding Equipment to Your
Airbag-Equipped Vehicle......................... 81
How Does an Airbag Restrain?.................. 72
Passenger Sensing System....................... 74
Servicing Your Airbag-Equipped Vehicle..... 80
What Makes an Airbag Inate?.................. 72
What Will You See After an Airbag
Inates?................................................. 73Airbag System (cont.)
When Should an Airbag Inate?................. 70
Where Are the Airbags?............................. 67
All-Wheel Drive........................................... 368
All-Wheel-Drive (AWD) System.................... 275
All-Wheel-Drive Service Light....................... 192
Antenna, Fixed Mast................................... 261
Antenna, XM™ Satellite Radio Antenna
System.................................................... 261
Anti-Lock Brake System (ABS).................... 269
Anti-Lock Brake, System Warning Light....... 184
Appearance Care
Aluminum Wheels.................................... 429
Care of Safety Belts................................ 427
Chemical Paint Spotting........................... 431
Cleaning Exterior Lamps/Lenses.............. 428
Cleaning the Inside of Your Vehicle.......... 423
Fabric/Carpet........................................... 425
Finish Care.............................................. 428
Finish Damage......................................... 430
Instrument Panel, Vinyl, and Other
Plastic Surfaces.................................... 426
Leather.................................................... 426
Sheet Metal Damage............................... 430
Tires........................................................ 430
Underbody Maintenance........................... 431
483
ProCarManuals.com

Bulb Replacement (cont.)
Replacement Bulbs.................................. 376
Taillamps, Turn Signal, Sidemarker,
Stoplamps, and Back-Up Lamps........... 374
Buying New Tires........................................ 398
C
Calibration..........................................121, 123
California Fuel............................................. 324
California Proposition 65 Warning................ 322
Canadian Owners........................................... 3
Capacities and Specications...................... 445
Carbon Monoxide............... 98,119, 291, 305
Care of
Safety Belts............................................. 427
Your CD and DVD Player........................ 261
Your CDs and DVDs................................ 261
Cargo Cover............................................... 142
Cargo Tie Downs........................................ 143
CD, MP3 ..................................................... 233
Center Console Storage Area...................... 140
Chains, Tire................................................. 404
Charging System Light................................ 182Check
Engine Light............................................ 187
Gages Warning Light............................... 192
Check Gas Cap Light.................................. 194
Checking Things Under the Hood ................ 329
Chemical Paint Spotting .............................. 431
Child Restraints
Child Restraint Systems............................. 44
Infants and Young Children........................ 40
Lower Anchors and Tethers for
Children.................................................. 50
Older Children........................................... 38
Securing a Child Restraint in a
Rear Outside Seat Position.................... 57
Securing a Child Restraint in the
Center Rear Seat Position...................... 59
Securing a Child Restraint in the
Right Front Seat Position........................ 60
Where to Put the Restraint........................ 48
Cleaning
Aluminum Wheels.................................... 429
Exterior Lamps/Lenses............................. 428
Fabric/Carpet........................................... 425
Finish Care.............................................. 428
485
ProCarManuals.com

Cleaning (cont.)
Inside of Your Vehicle.............................. 423
Instrument Panel, Vinyl, and Other
Plastic Surfaces.................................... 426
Leather.................................................... 426
Tires........................................................ 430
Underbody Maintenance........................... 431
Washing Your Vehicle.............................. 427
Weatherstrips........................................... 427
Windshield, Backglass, and
Wiper Blades........................................ 429
Climate Control System
Climate Controls Personalization.............. 173
Dual Automatic......................................... 167
Outlet Adjustment..................................... 172
Rear........................................................ 173
Collision Damage Repair............................. 474
Comfort Guides, Rear Safety Belt................. 35
Compass............................................121, 123
Content Theft-Deterrent............................... 102
Control of a Vehicle..................................... 268
Coolant
Engine Temperature Gage........................ 186
Heater, Engine......................................... 110
Cooling System........................................... 349
Cruise Control............................................. 156Cruise Control Light.................................... 191
Cupholder(s)................................................ 139
Customer Assistance Information
Customer Assistance for Text
Telephone (TTY) Users ......................... 468
Customer Assistance Offices.................... 468
Customer Satisfaction Procedure.............. 466
Reporting Safety Defects to Saab............ 480
Reporting Safety Defects to the
Canadian Government.......................... 479
Reporting Safety Defects to the
United States Government.................... 479
Roadside Assistance Program.................. 469
Service Publications Ordering
Information........................................... 480
D
Daytime Running Lamps............................. 161
Defensive Driving........................................ 264
Delayed Locking............................................ 94
Disc, MP3................................................... 233
Doing Your Own Service Work.................... 323
Dome Lamp Override.................................. 163
Dome Lamps............................................... 163
486
ProCarManuals.com