light SATURN ASTRA 2009 Manual Online

{CAUTION
Rust or dirt on a wheel, or on
the parts to which it is fastened,
can make wheel bolts become
loose after time. The wheel could
come off and cause an accident.
When you change a wheel,
remove any rust or dirt from
places where the wheel attaches
to the vehicle. In an emergency,
you can use a cloth or a paper
towel to do this; but be sure to
use a scraper or wire brush later,
if needed, to get all the rust or
dirt off. SeeChanging a Flat Tire
on page 9-61.8. Remove any rust or dirt from the
wheel bolts, mounting surfaces
and spare wheel.
Installing wheels with a good
metal-to-metal contact at
the mounting surface is
necessary to prevent the wheel
bolts from becoming loose.
To prevent corrosion or rust
build-up, apply a light coat of
wheel bearing grease to the
wheel hub center and to the
cone-shaped surface of each
wheel bolt at every wheel change.9. Place the compact spare tire on
the wheel-mounting surface.
10. Reinstall the wheel bolts with
the rounded end of the bolts
toward the wheel. Tighten each
bolt by hand until the wheel
is held against the hub.
11. Lower the vehicle by turning the
jack handle counterclockwise.
Lower the jack completely.
Vehicle Service and Care 9-65
ProCarManuals.com

Notice:If you leave the radio or
other accessories on during
the jump starting procedure,
they could be damaged. The
repairs would not be covered by
the warranty. Always turn off
the radio and other accessories
when jump starting the vehicle.
3. Turn off the ignition on both
vehicles. Unplug unnecessary
accessories plugged into
the cigarette lighter or the
accessory power outlet. Turn off
the radio and all lamps that
are not needed. This will avoid
sparks and help save both
batteries. And it could save
the radio!4. Open the hoods and locate the
batteries. Find the positive (+)
and negative (−) terminal
locations on each vehicle. Your
vehicle’s positive (+) terminal
is identied by “+” sign on battery
case or terminal. SeeEngine
Compartment Overview on
page 9-6.
{CAUTION
An electric fan can start up even
when the engine is not running
and can injure you. Keep hands,
clothing and tools away from any
underhood electric fan.
{CAUTION
Using a match near a battery can
cause battery gas to explode.
People have been hurt doing this,
and some have been blinded. Use
a ashlight if you need more light.
Be sure the battery has enough
water. You do not need to add
water to the battery installed in
your new vehicle. But if a battery
has ller caps, be sure the right
amount of uid is there. If it is
low, add water to take care of that
rst. If you don’t, explosive gas
could be present.
Battery uid contains acid that
can burn you. Do not get it on
you. If you accidentally get it in
your eyes or on your skin, ush
the place with water and get
medical help immediately.
9-70 Vehicle Service and Care
ProCarManuals.com

Towing
Towing Your Vehicle
To avoid damage, the disabled
vehicle should be towed with all
four wheels off the ground.
Consult your dealer/retailer or a
professional towing service if
the disabled vehicle must be towed.
SeeRoadside Assistance Program
on page 12-6.
Recreational Vehicle
Towing
Notice:Dolly towing or dinghy
towing the vehicle may cause
damage because of reduced
ground clearance. Always put the
vehicle on a atbed truck or
trailer.
The vehicle was neither designed
nor intended to be towed with any
of its wheels on the ground.
Towing a Trailer
The vehicle is neither designed nor
intended to tow a trailer.
Appearance Care
Interior Cleaning
Your vehicle’s interior will continue
to look its best if it is cleaned
often. Although not always visible,
dust and dirt can accumulate
on your upholstery. Dirt can damage
carpet, fabric, leather, and plastic
surfaces. Regular vacuuming is
recommended to remove particles
from the upholstery. It is important
to keep your upholstery from
becoming and remaining heavily
soiled. Soils should be removed as
quickly as possible. Your vehicle’s
interior may experience extremes of
heat that could cause stains to
set rapidly.
Lighter colored interiors may require
more frequent cleaning. Use care
because newspapers and garments
that transfer color to your home
furnishings may also transfer color
to your vehicle’s interior.
Vehicle Service and Care 9-73
ProCarManuals.com

If your vehicle has a basecoat/
clearcoat paint nish, the clearcoat
gives more depth and gloss to
the colored basecoat. Always use
waxes and polishes that are
non-abrasive and made for a
basecoat/clearcoat paint nish.
Notice:Machine compounding
or aggressive polishing on a
basecoat/clearcoat paint nish
may damage it. Use only
non-abrasive waxes and
polishes that are made for a
basecoat/clearcoat paint nish
on the vehicle.
Foreign materials such as calcium
chloride and other salts, ice
melting agents, road oil and tar,
tree sap, bird droppings, chemicals
from industrial chimneys, etc.,
can damage your vehicle’s nish if
they remain on painted surfaces.
Wash the vehicle as soon as
possible. If necessary, use
non-abrasive cleaners that are
marked safe for painted surfaces to
remove foreign matter.Exterior painted surfaces are
subject to aging, weather and
chemical fallout that can take
their toll over a period of years.
You can help to keep the paint nish
looking new by keeping your
vehicle garaged or covered
whenever possible.
Protecting Exterior Bright
Metal Parts
Bright metal parts should be
cleaned regularly to keep their
luster. Wash with water or
use chrome polish on chrome or
stainless steel trim, if necessary.
Use special care with aluminum trim.
To avoid damaging protective trim,
never use auto or chrome polish,
steam or caustic soap to clean
aluminum. A coating of wax, rubbed
to high polish, is recommended for
all bright metal parts.Washing Your Vehicle
The best way to preserve your
vehicle’s nish is to keep it clean by
washing it often.
Do not wash the vehicle in direct
sunlight. Use a car washing soap.
Notice:Certain cleaners contain
chemicals that can damage the
emblems or nameplates on the
vehicle. Check the cleaning
product label. If it states that it
should not be used on plastic
parts, do not use it on the vehicle
or damage may occur and it would
not be covered by the warranty.
Do not use cleaning agents that are
petroleum based or that contain
acid or abrasives, as they can
damage the paint, metal or plastic
on your vehicle. Approved cleaning
products can be obtained from
your dealer/retailer. Follow all
manufacturers’ directions regarding
correct product usage, necessary
safety precautions and appropriate
disposal of any vehicle care product.
Vehicle Service and Care 9-77
ProCarManuals.com

Maintenance Footnotes
(a)A fluid loss in any vehicle system
could indicate a problem. Have the
system inspected and repaired
and the fluid level checked. Add fluid
if needed.
(b)If driving regularly under dusty
conditions or in high-polluted
regions, replace the filter at each
engine oil change.
(c)Inspect brake lines and hoses for
proper hook-up, binding, leaks,
cracks, chafing, etc. Inspect disc
brake pads for wear and rotors for
surface condition. Inspect other
brake parts, including calipers,
parking brake, etc.
(d)Inspect front and rear suspension
and steering system for damaged,
loose, or missing parts or signs of
wear. Inspect power steering cables
for proper hook-up, binding, cracks,
chafing, etc. Inspect power steering
hydraulic lines and hoses for proper
hook-up, binding, leaks, cracks,
chafing, etc.(e)Inspect hoses and have them
replaced if they are cracked,
swollen, or deteriorated. Inspect all
pipes, fittings and clamps; replace
with genuine parts as needed.
To help ensure proper operation,
a pressure test of the cooling system
and pressure cap and cleaning
the outside of the radiator and
air conditioning condenser is
recommended at least once a year.
(f)Inspect wiper blades for wear,
cracking, or contamination.
Clean the windshield and wiper
blades, if contaminated. Replace
wiper blades that are worn or
damaged. See Windshield Wiper
Blade Replacement on page 9-21
and “Windshield and Wiper Blades”
in Exterior Cleaning on page 9-76.
(g)Make sure the safety belt
reminder light and safety belt
assemblies are working properly.
Look for any other loose or
damaged safety belt system parts.
If you see anything that might keep
a safety belt system from doingits job, have it repaired. Have any
torn or frayed safety belts replaced.
Also see Airbag System Check
on page 1-37.
(h)Lubricate all key lock cylinders,
door hinges and latches, hood
hinges and latches, and trunk lid
hinges and latches. More frequent
lubrication may be required
when exposed to a corrosive
environment. Applying silicone
grease on weatherstrips with a clean
cloth will make them last longer,
seal better, and not stick or squeak.
(i)Change automatic transmission
fluid if the vehicle is mainly driven
under one or more of these
conditions:
In heavy city traffic where the
outside temperature regularly
reaches 90°F (32°C) or higher.
In hilly or mountainous terrain.
When doing frequent trailer
towing.
Uses such as found in taxi, police,
or delivery service.
11-8 Service and Maintenance
ProCarManuals.com

Service Publications
Ordering Information
Service Manuals
A variety of publications are
available to you. Saturn service
manuals are written for trained
technicians, and in some cases,
specialized tools and equipment are
necessary to complete certain
repairs. However, the manuals are
available to owners who either
have the training, or wish to gain a
greater understanding of the
technical aspect of their Saturn.
For additional publications
information or to order publications
in the United States, call toll
free 1-800-2-SATURN or visit
Saturn-publications.com to order
on-line.
In Canada, Saturn service manuals
are available by calling toll free
1-800-551-4123.
Owner Publications
Information on how to obtain
product bulletins and as described
below is applicable only in the
fty U.S. states and the District of
Columbia, and only for cars and
light trucks with a Gross Vehicle
Weight Rating (GVWR) less
than 10,000 pounds (4 536 kg).
Copies of individual bulletins
are also at your participating Saturn
retailer. You can ask to see them.
In Canada, information relating
to product service bulletins can be
obtained by contacting your
Saturn retailer.
Service Bulletins
Saturn regularly sends its retailers
useful service bulletins about Saturn
products. Saturn monitors product
performance in the eld. We then
prepare bulletins for servicing
our products better. You can get
these bulletins, too.Bulletins cover various subjects.
Some pertain to the proper use
and care of your vehicle.
Some describe costly repairs.
Others describe inexpensive repairs
which, if done on time with the
latest parts, may avoid future costly
repairs.
Some bulletins tell a technician how
to repair a new or unexpected
condition. Others describe a quicker
way to x your vehicle. They can
help a technician service your
vehicle better.
Most bulletins apply to conditions
affecting a small number of vehicles.
Your Saturn retailer or a qualied
technician may have to determine if
a specic bulletin applies to your
vehicle. To order Saturn bulletins,
call Saturn Publications at
1-800-2-SATURN or visit
saturn-publications.com to order
online.
Customer Information 12-15
ProCarManuals.com

A
Accessories and
Modications...................... 9-3
Accessory Power Outlets......4-10
Adding Equipment to Your
Airbag-Equipped Vehicle....1-36
Additives, Fuel.....................8-34
Add-On Electrical
Equipment.......................9-34
Air Cleaner/Filter, Engine.......9-11
Air Conditioning..................... 7-1
Airbag
Passenger Status
Indicator.......................4-15
Readiness Light................4-14
System, Replacing Parts
After a Crash................1-37
Airbag System.....................1-24
Adding Equipment to Your
Airbag-Equipped
Vehicle........................1-36
Check.............................1-37
How Does an Airbag
Restrain?.....................1-28
Passenger Sensing
System........................1-30Airbag System (cont.)
Servicing Your
Airbag-Equipped
Vehicle........................1-35
What Makes an Airbag
Inate?........................1-28
What Will You See After
an Airbag Inates?........1-29
When Should an Airbag
Inate?........................1-27
Where Are the Airbags?.....1-26
Antenna, Fixed Mast............6-24
Antilock Brake
System (ABS)..................8-18
Antilock Brake, System
Warning Light...................4-17
Appearance Care
Chemical Paint Spotting.....9-80
Exterior Cleaning..............9-76
Finish Damage.................9-79
Interior Cleaning...............9-73
Sheet Metal Damage........9-79
Underbody Maintenance....
9-80
Appointments, Scheduling
Service...........................12-8Audio System........................ 6-1
Audio Steering Wheel
Controls.......................6-23
Fixed Mast Antenna..........6-24
Radio Reception...............6-24
Theft-Deterrent Feature......6-23
Audio System(s).................... 6-2
Automatic Transmission
Fluid...............................9-12
Operation.......................... 8-6
B
Battery...............................9-25
Run-Down Protection.......... 5-4
Brake Fluid.........................9-22
Brakes...............................9-22
System Warning Light.......4-16
Braking...............................8-17
Break-In, New Vehicle............ 8-2
Bulb Replacement
Daytime Running Lamp....... 5-2
Bulb Replacement
Center High-Mounted
Stoplamp (CHMSL)........9-29
Fog Lamp ......................... 5-2
Front Turn Signal Lamps . . . 9-28
INDEX i-1
ProCarManuals.com

Bulb Replacement (cont.)
Halogen Bulbs..................9-28
Headlamp Aiming..............9-26
Headlamps......................9-28
License Plate Lamps.........9-33
Replacement Bulbs...........9-34
Taillamps.................9-30, 9-32
Buying New Tires.................9-54
C
California Fuel.....................8-34
California Perchlorate
Materials Requirements....... 9-3
California Proposition 65
Warning............................ 9-3
Canadian Owners..................... ii
Capacities and
Specications...................10-2
Carbon Monoxide.........8-14, 8-27
Care, Safety Belts................1-23
Cargo Cover......................... 3-2
Cargo Tie Downs................... 3-2
Cautions and Notices............... iii
Center High-Mounted
Stoplamp (CHMSL)...........9-29Chains, Tire........................9-60
Charging System Light..........4-16
Check
Engine Lamp...................4-18
Chemical Paint Spotting........9-80
Child Restraints
Child Restraint Systems.....1-43
Infants and Young
Children.......................1-40
Lower Anchors and
Tethers for Children.......1-46
Older Children..................1-38
Securing..................1-51, 1-53
Where to Put the
Restraint......................1-44
Cleaning
Exterior...........................9-76
Interior............................9-73
Underbody Maintenance....9-80
Climate Control System.......... 7-1
Outlet Adjustment............... 7-4
Clutch, Hydraulic..................9-12
Collision Damage Repair.....12-10
Compact Spare Tire.............9-68
Content Theft-Deterrent.......... 2-9
Control of a Vehicle..............8-17Coolant
Engine............................9-16
Engine Temperature
Warning Light...............
4-18
Cooling System...................9-12
Courtesy
Transportation..........12-5, 12-9
Cruise Control....................... 4-5
Cruise Control Light..............4-23
Cupholders........................... 3-1
Customer Information
Courtesy
Transportation.......12-5, 12-9
Customer Assistance
Offices.........................12-5
Customer Satisfaction
Procedure....................12-1
GM Mobility
Reimbursement
Program.......................12-6
Online Owner Center.........12-4
Reporting Safety Defects
to Saturn....................12-14
Reporting Safety Defects
to the Canadian
Government................12-14
i-2 INDEX
ProCarManuals.com

Customer Information (cont.)
Reporting Safety Defects
to the United States
Government................12-14
Roadside Assistance
Program.......................12-6
Service Publications
Ordering Information.....12-15
D
Defensive Driving.................8-16
Delayed Headlamps............... 5-2
Doing Your Own
Service Work..................... 9-4
Dome Lamps ........................ 5-3
Door
Ajar Light........................4-23
Locks............................... 2-5
Power Door Locks.............. 2-6
Rear Door Security Locks.... 2-6
Driver Information
Center (DIC)....................4-25
DIC Operation and
Displays...............4-26, 4-32
DIC Warnings and
Messages....................4-36Driving
At Night..........................8-23
Before a Long Trip............8-25
Defensive........................8-16
Drunken..........................8-16
Highway Hypnosis............8-25
Hill and Mountain Roads....8-26
In Rain and on Wet
Roads.........................8-24
Rocking Your Vehicle to
Get it Out ....................8-29
Winter.............................8-27
Winter Mode Light............4-22
Driving for Better Fuel
Economy.........................8-15
E
EDR .................................12-16
Electrical System
Add-On Equipment............9-34
Engine Compartment
Fuse Block...................9-35
Fuses.............................9-35
Headlamp Wiring..............9-34
Rear Compartment Fuse
Block...........................9-37Engine
Air Cleaner/Filter...............9-11
Check and Service Engine
Soon Lamp..................4-18
Coolant...........................9-16
Coolant Temperature
Warning Light...............4-18
Drive Belt Routing...........11-15
Engine Compartment
Overview....................... 9-6
Exhaust...........................8-14
Oil ................................... 9-7
Oil Life System.................. 9-9
Overheating.....................9-18
Starting............................. 8-3
Engine Heater....................... 8-5
Entry Lighting........................ 5-3
Event Data Recorders.........12-16
Extender, Safety Belt............1-22
Exterior Lamps...................... 5-1
Exterior Lamps Off
Reminder........................4-23
INDEX i-3
ProCarManuals.com

F
Filter
Engine Air Cleaner............9-11
Final Drive
End Play Measurement....... 5-4
Finish Damage....................9-79
Fixed Mast Antenna.............6-24
Flashers, Hazard Warning....... 4-4
Flash-to-Pass........................ 4-8
Flat Tire..............................9-60
Flat Tire, Changing...............9-61
Flat Tire, Storing..................9-66
Fluid
Automatic Transmission.....9-12
Power Steering.................9-20
Windshield Washer...........9-20
Fog Lamp
Fog .................................. 5-2
Fog Lamp Light...................4-22
Fuel...................................8-34
Additives.........................8-34
California Fuel..................8-34
Driving for Better
Economy......................8-15
Filling a Portable Fuel
Container.....................8-37Fuel (cont.)
Filling the Tank.................8-36
Fuels in Foreign
Countries.....................8-35
Gage ..............................4-24
Gasoline Octane...............8-34
Gasoline Specications......8-34
Low Warning Light............4-24
Fuses.................................9-35
Engine Compartment
Fuse Block...................9-35
Rear Compartment
Fuse Block...................9-37
G
Gage
Fuel................................4-24
Speedometer...................4-13
Tachometer......................4-13
Gasoline
Octane............................8-34
Specications...................8-34
Glove Box............................ 3-1
GM Mobility Reimbursement
Program..........................12-6
H
Hazard Warning Flashers........ 4-4
Head Restraints..................... 1-5
Headlamp
Aiming ............................9-26
Headlamp Wiring.................9-34
Headlamps
Bulb Replacement.............9-28
Daytime Running Lamp....... 5-2
Delayed............................ 5-2
Exterior Lamps................... 5-1
Flash-to-Pass..................... 4-8
Front Turn Signal
Lamps .........................9-28
Halogen Bulbs..................9-28
High/Low Beam Changer..... 4-8
Heater................................. 7-1
Engine.............................. 8-5
Height Adjuster, Seat.............. 1-2
Highbeam On Light..............4-23
High-Speed Operation,
Tires...............................9-48
Highway Hypnosis................8-25
Hill and Mountain Roads.......8-26
Hood
Release............................ 9-5
i-4 INDEX
ProCarManuals.com