fuel cap SATURN ION 2007 User Guide

Tire Terminology and Denitions
Air Pressure:The amount of air inside the tire
pressing outward on each square inch of the
tire. Air pressure is expressed in pounds
per square inch (psi) or kilopascal (kPa).
Accessory Weight:This means the combined
weight of optional accessories. Some examples of
optional accessories are, automatic transmission,
power steering, power brakes, power windows,
power seats, and air conditioning.
Aspect Ratio:The relationship of a tire’s height
to its width.
Belt:A rubber coated layer of cords that is
located between the plies and the tread. Cords
may be made from steel or other reinforcing
materials.
Bead:The tire bead contains steel wires wrapped
by steel cords that hold the tire onto the rim.
Bias Ply Tire:A pneumatic tire in which the plies
are laid at alternate angles less than 90 degrees
to the centerline of the tread.Cold Tire Pressure:The amount of air pressure
in a tire, measured in pounds per square inch
(psi) or kilopascals (kPa) before a tire has built up
heat from driving. SeeInation - Tire Pressure
on page 337.
Curb Weight:This means the weight of a motor
vehicle with standard and optional equipment
including the maximum capacity of fuel, oil, and
coolant, but without passengers and cargo.
DOT Markings:A code molded into the sidewall
of a tire signifying that the tire is in compliance
with the U.S. Department of Transportation (DOT)
motor vehicle safety standards. The DOT code
includes the Tire Identication Number (TIN),
an alphanumeric designator which can also identify
the tire manufacturer, production plant, brand,
and date of production.
GVWR:Gross Vehicle Weight Rating.
SeeLoading Your Vehicle on page 250.
GAWR FRT:Gross Axle Weight Rating for the
front axle. SeeLoading Your Vehicle on page 250.
GAWR RR:Gross Axle Weight Rating for the
rear axle. SeeLoading Your Vehicle on page 250.
334
ProCarManuals.com

Ination - Tire Pressure
Tires need the correct amount of air pressure to
operate effectively.
Notice:Do not let anyone tell you that
under-ination or over-ination is all right. It is
not. If your tires do not have enough air
(under-ination), you can get the following:
Too much exing
Too much heat
Tire overloading
Premature or irregular wear
Poor handling
Reduced fuel economy
If your tires have too much air (over-ination),
you can get the following:
Unusual wear
Poor handling
Rough ride
Needless damage from road hazardsA Tire and Loading Information label is attached to
the vehicle’s center pillar (B-pillar). This label shows
your vehicle’s original equipment tires and the
correct ination pressures for your tires when they
are cold. The recommended cold tire ination
pressure, shown on the label, is the minimum
amount of air pressure needed to support your
vehicle’s maximum load carrying capacity.
For additional information regarding how much
weight your vehicle can carry, and an example of
the Tire and Loading Information label, see
Loading Your Vehicle on page 250. How you load
your vehicle affects vehicle handling and ride
comfort. Never load your vehicle with more weight
than it was designed to carry.
When to Check
Check your tires once a month or more. Do not
forget to check the compact spare tire, it should be
at 60 psi (420 kPa). For additional information
regarding the compact spare tire, seeCompact
Spare Tire on page 365.
337
ProCarManuals.com

ApplicationCapacities
English Metric
Fuel Tank
2.2L L4 Engine (with NU6 emissions) sold new in CA, ME,
VT, NY, NH, MA (see your dealer for bordering states13.5 gal 51.1 L
2.2L L4 Engine (without NU6 emissions) sold new in all
other states (see your dealer for more information)13.0 gal 49.2 L
2.4L and 2.0L Supercharged L4 Engine sold new in
all states13.0 gal 49.2 L
Transaxle, Automatic 7.0 qt 6.6 L
Transaxle, Manual (Complete Drain and Rell)
2.2L L4 and 2.4L L4 Engines 1.7 qt 1.6 L
2.0L L4 Engine Supercharged 1.6 qt 1.5 L
Wheel Nut Torque 100 lb ft
140Y
All capacities are approximate. When adding, be sure to ll to the approximate level, as recommended in this
manual. Recheck uid level after lling.
385
ProCarManuals.com

Audio System (cont.)
Radio with CD................................190, 195
Setting the Time..............................187, 188
Understanding Radio Reception............... 214
XM™ Satellite Radio Antenna System...... 215
Automatic Headlamp System....................... 151
Automatic Transaxle
Fluid........................................................ 292
Operation................................................. 110
B
Battery........................................................ 311
Run-Down Protection............................... 153
Battery Warning Light.................................. 170
Before Leaving on a Long Trip.................... 241
Boost Gage................................................. 180
Brake
Emergencies............................................ 225
Parking.................................................... 115
Brakes........................................................ 308
System Warning Light.............................. 170
Braking....................................................... 222
Braking in Emergencies............................... 225
Break-In, New Vehicle................................. 104Bulb Replacement....................................... 318
Center High-Mounted
Stoplamp (CHMSL)............................... 324
Front Turn Signal, Parking and
Daytime Running Lamps..............322, 323
Halogen Bulbs......................................... 318
Headlamp Aiming..................................... 318
Headlamps......................................319, 320
License Plate Lamps................................ 326
Replacement Bulbs.................................. 326
Taillamps, Turn Signal, Stoplamps and
Back-up Lamps..................................... 324
Buying New Tires........................................ 341
C
Calibration..........................................122, 125
California Fuel............................................. 273
California Proposition 65 Warning................ 271
Canadian Owners........................................... 3
Capacities and Specications...................... 384
Carbon Monoxide............... 98,120, 244, 259
Care of
Safety Belts............................................. 369
Your CD Player........................................ 215
Your CDs ................................................. 215
428
ProCarManuals.com

Fuel (cont.)
Fuels in Foreign Countries....................... 274
Gage....................................................... 179
Gasoline Octane...................................... 272
Gasoline Specications............................ 273
Low Warning Message............................. 185
Fuses
Engine Compartment Fuse Block............. 378
Floor Console Fuse Block........................ 376
Fuses and Circuit Breakers...................... 375
Windshield Wiper..................................... 375
G
Gage
Boost....................................................... 180
Engine Coolant Temperature.................... 173
Fuel......................................................... 179
Speedometer........................................... 165
Tachometer.............................................. 165
Gas, Check Cap Message........................... 185
Gasoline
Octane..................................................... 272
Specications........................................... 273
Glove Box................................................... 133
GM Mobility Reimbursement Program.......... 415
H
Hazard Warning Flashers............................ 142
Head Restraints............................................ 13
Headlamp
Aiming..................................................... 318
Headlamps................................150, 319, 320
Bulb Replacement.................................... 318
Daytime Running Lamps.......................... 151
Flash-to-Pass........................................... 145
Halogen Bulbs......................................... 318
High/Low Beam Changer ......................... 145
Heater................................................155, 157
Height Adjuster, Driver Seat............................ 9
Highbeam On Light..................................... 179
High-Speed Operation, Tires........................ 338
Highway Hypnosis....................................... 242
Hill and Mountain Roads............................. 242
Hood
Checking Things Under............................ 278
Release................................................... 279
Horn............................................................ 142
How to Use This Manual................................ 3
How to Wear Safety Belts Properly............... 24
Hydraulic Clutch.......................................... 293
432
ProCarManuals.com

Locks (cont.)
Power Door............................................... 95
Programmable Automatic Door Locks......... 96
Rear Door Security Locks.......................... 96
Loss of Control........................................... 233
Low Fuel Warning Message........................ 185
Lumbar
Manual Controls.......................................... 9
M
Maintenance Schedule
Additional Required Services.................... 394
At Each Fuel Fill...................................... 398
At Least Once a Month............................ 398
At Least Once a Year.............................. 399
Introduction.............................................. 388
Maintenance Footnotes............................ 395
Maintenance Record................................ 406
Maintenance Requirements...................... 388
Normal Maintenance
Replacement Parts............................... 404
Owner Checks and Services.................... 397
Recommended Fluids and Lubricants....... 402
Scheduled Maintenance........................... 391
Using....................................................... 389
Your Vehicle and the Environment............ 388Malfunction Indicator Light........................... 174
Manual Lumbar Controls................................. 9
Manual Seats.................................................. 8
Manual Transaxle
Fluid........................................................ 293
Operation................................................. 112
Manual Windows......................................... 100
Map Lamps................................................. 153
Message
Center..................................................... 182
Change Engine Oil................................... 183
Check Gage............................................ 184
Check Gas Cap....................................... 185
Cruise Control.......................................... 183
Error........................................................ 185
Low Fuel Warning.................................... 185
Low Traction............................................ 182
Power Steering........................................ 184
Traction Off.............................................. 182
Transaxle Fluid Hot.................................. 183
Trunk Ajar Warning.................................. 184
Mirrors
Automatic Dimming Rearview with
Compass and Temperature Display....... 125
Automatic Dimming Rearview with OnStar
®,
Compass and Temperature Display........ 122
Outside Convex Mirror............................. 129
434
ProCarManuals.com