spare wheel SATURN ION 2007 Owners Manual

Dinghy Towing (All Transaxles)
Notice:Dolly towing or dinghy towing your
vehicle may cause damage because of reduced
ground clearance. Always tow your vehicle
using the dolly towing or dinghy towing
procedure listed in this section or put your
vehicle on a atbed truck.
To tow your vehicle from the front with all four
wheels on the ground, do the following:
1. Set the parking brake.
2. Turn the ignition key to ACC (Accessory) to
unlock the steering wheel.3. Shift your transaxle to NEUTRAL.
4. Release the parking brake.
To prevent battery rundown on long trips, remove
the IP BATT 2 fuse (#41) from the engine
compartment fuse block. SeeEngine Compartment
Fuse Block on page 378for more information.
Once you have reached your destination, be sure
to replace this fuse back into its original location.
Notice:If you exceed 65 mph (105 km/h) while
towing your vehicle, it could be damaged.
Never exceed 65 mph (105 km/h) while towing
your vehicle.
Notice:Towing your vehicle from the rear
could damage it. Also, repairs would not
be covered by the warranty. Never have your
vehicle towed from the rear.
Notice:Don’t tow a vehicle with the front
drive wheels on the ground if one of the front
tires is a compact spare tire. Towing with
two different tire sizes on the front of the
vehicle can cause severe damage to the
transaxle.
257
ProCarManuals.com

Windshield Wiper Blade Replacement....... 327
Tires............................................................ 328
Winter Tires (Red Line)............................. 329
Tire Sidewall Labeling............................... 330
Tire Terminology and Denitions............... 334
Ination - Tire Pressure............................. 337
High-Speed Operation............................... 338
Tire Inspection and Rotation...................... 339
When It Is Time for New Tires.................. 341
Buying New Tires...................................... 341
Different Size Tires and Wheels................ 343
Uniform Tire Quality Grading..................... 344
Wheel Alignment and Tire Balance............ 346
Wheel Replacement.................................. 346
Tire Chains............................................... 348
If a Tire Goes Flat.................................... 349
Changing a Flat Tire................................. 350
Removing the Spare Tire and Tools.......... 351
Removing the Flat Tire and Installing
the Spare Tire....................................... 356
Storing a Flat or Spare Tire and Tools...... 362
Compact Spare Tire.................................. 365Appearance Care........................................ 366
Cleaning the Inside of Your Vehicle.......... 366
Fabric/Carpet............................................. 367
Instrument Panel, Vinyl, and Other
Plastic Surfaces..................................... 368
Care of Safety Belts.................................. 369
Weatherstrips............................................ 369
Washing Your Vehicle............................... 369
Cleaning Exterior Lamps/Lenses................ 370
Finish Care............................................... 370
Windshield and Wiper Blades.................... 370
Aluminum Wheels...................................... 371
Tires......................................................... 372
Sheet Metal Damage................................. 372
Finish Damage.......................................... 372
Underbody Maintenance............................ 372
Chemical Paint Spotting............................ 373
Vehicle Care/Appearance Materials............ 373
Vehicle Identication.................................. 374
Vehicle Identication Number (VIN)........... 374
Service Parts Identication Label............... 374
Section 5 Service and Appearance Care
268
ProCarManuals.com

If you choose to use winter tires:
Use tires of the same brand and tread type on
all four wheel positions.
Use only radial ply tires of the same size, load
range, and speed rating as your original
equipment tires.
Winter tires with the same speed rating as your
original equipment tires may not be available for H,
V, W and ZR speed rated tires. If you choose
winter tires with a lower speed rating, never
exceed the tire’s maximum speed capability.
Tire Sidewall Labeling
Useful information about a tire is molded into its
sidewall. The examples below show a typical
passenger vehicle tire and a compact spare tire
sidewall.(A) Tire Size:The tire size is a combination of
letters and numbers used to dene a particular
tire’s width, height, aspect ratio, construction type,
and service description. See the “Tire Size”
illustration later in this section for more detail.
Passenger (P-Metric) Tire Example
330
ProCarManuals.com

If your vehicle has 215/45ZR17 size tires, they are
directional tires and must roll in a certain direction
for the best overall performance. The direction is
shown by an arrow on the tire sidewall. Because
these tires are directional, they should be rotated as
shown here. These tires should only be moved from
front to rear and rear to front on the same side of
the vehicle.
Do not include the compact spare tire in your tire
rotation.After the tires have been rotated, adjust the front
and rear ination pressures as shown on the
Tire and Loading Information label. SeeLoading
Your Vehicle on page 250for an example of
the tire and loading information label and
its location on your vehicle. Make certain that all
wheel nuts are properly tightened. See “Wheel Nut
Torque” underCapacities and Specications on
page 384.
{CAUTION:
Rust or dirt on a wheel, or on the parts to
which it is fastened, can make wheel bolts
become loose after a time. The wheel
could come off and cause an accident.
When you change a wheel, remove any
rust or dirt from places where the wheel
attaches to the vehicle. In an emergency,
you can use a cloth or a paper towel to do
this; but be sure to use a scraper or wire
brush later, if you need to, to get all the
rust or dirt off. SeeChanging a Flat Tire
on page 350.Directional Tires
340
ProCarManuals.com

GM’s exclusive TPC Spec system considers over
a dozen critical specications that impact the
overall performance of your vehicle, including
brake system performance, ride and handling,
traction control, and tire pressure monitoring
performance. GM’s TPC Spec number is molded
onto the tire’s sidewall by the tire manufacturer.
If the tires have an all-season tread design,
the TPC spec number will be followed by an
MS for mud and snow. SeeTire Sidewall Labeling
on page 330for additional information.
{CAUTION:
Mixing tires could cause you to lose
control while driving. If you mix tires of
different sizes, brands, or types (radial
and bias-belted tires), the vehicle may not
handle properly, and you could have a
crash. Using tires of different sizes,
CAUTION: (Continued)
CAUTION: (Continued)
brands, or types may also cause damage
to your vehicle. Be sure to use the correct
size, brand, and type of tires on all
wheels. It is all right to drive with your
compact spare temporarily, as it was
developed for use on your vehicle.
SeeCompact Spare Tire on page 365.
{CAUTION:
If you use bias-ply tires on your vehicle,
the wheel rim anges could develop
cracks after many miles of driving. A tire
and/or wheel could fail suddenly, causing
a crash. Use only radial-ply tires with the
wheels on your vehicle.
342
ProCarManuals.com

A. Cover
B. Retainer
C. Spare Tire
D. Wing Nut
E. Jack and Wheel Wrench
F. Bolt
352
ProCarManuals.com

3. Remove the retainer (B) that holds down the
spare tire. SeeCompact Spare Tire on
page 365
4. Remove the spare tire (C) by gently pulling it
up and out of the trunk.
5. Remove the wing nut (D) that holds the jack
and remove the jack and wheel wrench (E).Models with a 2.0L L4 Supercharged
Engine
1. Open the trunk. SeeTrunk on page 98for
more information.
2. Lift the trunk liner to access the spare tire
and tools.
353
ProCarManuals.com

A. Retainer
B. Jack and Wheel Wrench
C. Spare Tire
D. Foam Support
E. Bolt
3. Remove the retainer (A) that holds down the
jack, wheel wrench (B) and spare tire (C).
4. Remove the spare tire by placing your hands
at the four and eight o’clock positions. Gently
pull it up and out of the trunk.
The tools you will be using include the jack (A)
and wheel wrench (B).
354
ProCarManuals.com

Removing the Flat Tire and
Installing the Spare Tire
1. If your vehicle has plastic wheel covers, use
the wheel wrench to loosen the plastic wheel
nut caps.
Once you have loosened the plastic wheel nut
caps with the wheel wrench, you can nish
loosening them with your ngers. The plastic
nut caps do not come off. Using the at
end of the wheel wrench, pry along the edge
of the wheel cover until it comes off.
If your vehicle has aluminum wheels, rst
remove the center cap by pulling it out with the
wheel wrench.2. Use the wheel wrench to loosen all the wheel
nuts. Do not remove them yet.
Notice:Make sure that the jack lift head is in
the correct position or you may damage
your vehicle. The repairs would not be covered
by your warranty.
356
ProCarManuals.com

3. Position the jack lift head at the jack location
nearest the at tire. The front location is about
7 inches (17.8 cm) rearward from the front
wheel opening. The rear location is about
2 inches (5.1 cm) forward of the rear wheel
opening.
Make sure the jack head is touching the metal
jacking ange under the body. Do not place
the jack under the plastic body panel.4. Put the compact spare tire near you.
{CAUTION:
Getting under a vehicle when it is jacked
up is dangerous. If the vehicle slips off
the jack you could be badly injured or
killed. Never get under a vehicle when it is
supported only by a jack.
357
ProCarManuals.com