ECU SATURN VUE 2004 Service Manual

4. Pull up the release clip, located at the connecting
point of the blade and the arm. Then, pull the
blade assembly down toward the glass to remove it
from the wiper arm.
5. Push the new wiper blade securely on the
wiper arm until you hear the release clip “click”
into place.
6. Push the release clip, from Step 4, down to secure
the wiper blade into place.To replace the backglass mounted wiper blade, do the
following:
1. Turn the rear wiper off.
2. Pull the wiper away from the backglass.
3. Pull up the release clip, located at the connecting
point of the blade and the arm. Then, pull the
blade assembly down toward the glass to remove it
from the wiper arm.
4. Push the new wiper blade securely on the
wiper arm until you hear the release clip “click”
into place.
5. Push the release clip, from Step 3, down to secure
the wiper blade into place.
5-61
ProCarManuals.com

Notice:If your vehicle has a tire size other than
P235/65R16, P235/60R17 or 245/50R18 size tires, use
tire chains only where legal and only when you must.
Use only SAE Class “S” type chains that are the
proper size for your tires. Install them on the front
tires and tighten them as tightly as possible with the
ends securely fastened. Drive slowly and follow the
chain manufacturer’s instructions. If you can hear the
chains contacting your vehicle, stop and retighten
them. If the contact continues, slow down until it
stops. Driving too fast or spinning the wheels with
chains on will damage your vehicle.
If a Tire Goes Flat
It’s unusual for a tire to “blowout” while you’re driving,
especially if you maintain your tires properly. If air goes
out of a tire, it’s much more likely to leak out slowly.
But if you should ever have a “blowout,” here are a few
tips about what to expect and what to do:
If a front tire fails, the at tire will create a drag that
pulls the vehicle toward that side. Take your foot off the
accelerator pedal and grip the steering wheel rmly.
Steer to maintain lane position, and then gently brake to
a stop well out of the traffic lane.A rear blowout, particularly on a curve, acts much like a
skid and may require the same correction you’d use
in a skid. In any rear blowout, remove your foot from the
accelerator pedal. Get the vehicle under control by
steering the way you want the vehicle to go. It may be
very bumpy and noisy, but you can still steer. Gently
brake to a stop, well off the road if possible.
{CAUTION:
Lifting a vehicle and getting under it to do
maintenance or repairs is dangerous without
the appropriate safety equipment and training.
The jack provided with your vehicle is
designed only for changing a at tire. If it is
used for anything else, you or others could be
badly injured or killed if the vehicle slips off
the jack. Use the jack provided with your
vehicle only for changing a at tire.
If a tire goes at, the next part shows how to use your
jacking equipment to change a at tire safely.
5-77
ProCarManuals.com

Storing a Flat or Spare Tire and Tools
{CAUTION:
Storing a jack, a tire, or other equipment in the
passenger compartment of the vehicle could
cause injury. In a sudden stop or collision,
loose equipment could strike someone. Store
all these in the proper place.
1. Place the wheel wrench into the bag and use the
Velcro
®straps to secure the bag to the jack.
2. Install the jack in the
driver’s side panel of
the rear cargo area and
secure with the
wingbolt.3. Remove the wheel stow rod from the upper left side
of the oor compartment.
4. Screw the threaded wheel stow rod onto the spare
tire bracket. The nal position of the wheel stow rod
must be rotated to the farthest forward position
so that the top of the rod faces forward.
5. Reverse steps 1 through 4 of Removing the Spare
Tire and Tools to replace the oor cargo organizer
and lock in place.
5-87
ProCarManuals.com

Notice:It is important to check your oil regularly
and keep it at the proper level. Failure to keep your
engine oil at the proper level can cause damage
to your engine not covered by your warranty.
Engine Coolant Level Check
Check the engine coolant level and add
DEX-COOL®coolant mixture if necessary.
SeeEngine Coolant on page 5-28for further details.
Windshield Washer Fluid Level Check
Check the windshield washer uid level in the windshield
washer tank and add the proper uid if necessary.
At Least Once a Month
Tire Ination Check
Visually inspect your tires and make sure tires are
inated to the correct pressures. Do not forget to check
your spare tire. SeeTires on page 5-62for further
details. Check to make sure the spare tire is stored
securely. Push, pull and then try to turn the spare tire.
If it moves, tighten it. SeeChanging a Flat Tire on
page 5-78.
At Least Once a Year
Starter Switch Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the vehicle
moves, you or others could be injured.
1. Before you start, be sure you have enough room
around the vehicle.
2. Firmly apply both the parking brake and the regular
brake. SeeParking Brake on page 2-23if
necessary.
Do not use the accelerator pedal, and be ready to
turn off the engine immediately if it starts.
3. On automatic transaxle vehicles, try to start the
engine in each gear. The starter should work
only in PARK (P) or NEUTRAL (N). If the starter
works in any other position, contact your Saturn
retailer for service.
6-11
ProCarManuals.com

Model, year, color, and license plate number
Mileage, Vehicle Identication Number and delivery
date of the vehicle
Description of the problem
While we hope you never have the occasion to use our
service, it is added security while traveling for you
and your family. Remember we are only a phone call
away. Saturn Roadside Assistance: 1-800-553-6000;
text telephone (TTY) users, call 1-800-833-6000.
Saturn reserves the right to limit services or
reimbursement to an owner or driver when, in Saturn’s
judgment, the claims become excessive in frequency
or type of occurrence.
Roadside Assistance is not part of or included in the
coverage provided by the New Vehicle Limited Warranty.
Saturn reserves the right to make any changes or
discontinue the Roadside Assistance program at any
time without notication.
Canadian Roadside Assistance
Vehicles purchased in Canada have an extensive
Saturn Roadside Assistance program accessible
from anywhere in Canada or the United States.
Please refer to the Warranty and Owner Assistance
Information book.
Vehicle Data Collection and Event
Data Recorders
Your vehicle, like other modern motor vehicles,
has a number of sophisticated computer systems that
monitor and control several aspects of the vehicle’s
performance. Your vehicle uses on-board vehicle
computers to monitor emission control components to
optimize fuel economy, to monitor conditions for air bag
deployment and, if so equipped, to provide anti-lock
braking and to help the driver control the vehicle
in difficult driving situations. Some information may be
stored during regular operations to facilitate repair
of detected malfunctions; other information is stored only
in a crash or near crash event by computer systems
commonly called event data recorders (EDR).
In a crash or near crash event, computer systems, such
as the Air Bag Sensing and Diagnostic Module (SDM)
in your vehicle may record information about the
condition of the vehicle and how it was operated, such
as engine speed, brake applications, throttle position,
vehicle speed, safety belt usage, air bag readiness, air
bag performance data, and the severity of a collision.
This information has been used to improve vehicle
crash performance and may be used to improve crash
performance of future vehicles and driving safety.
Unlike the data recorders on many airplanes, these
on-board systems do not record sounds, such as
conversation of vehicle occupants.
7-7
ProCarManuals.com

Care of
Safety Belts................................................5-92
Your CD and DVD Player.............................3-75
Your CDs and DVDs....................................3-75
Cargo Lamp...................................................3-19
CD Messages........................................3-49, 3-61
Center Console Storage Area...........................2-36
Center High-Mounted Stoplamp (CHMSL)...........5-58
Chains, Tire...................................................5-76
Changing a Tire When Trailer Towing................4-61
Check
Engine Light...............................................3-35
Checking Coolant............................................5-30
Checking Engine Oil........................................5-15
Checking Things Under the Hood......................5-10
Chemical Paint Spotting...................................5-95
Child Restraints
Child Restraint Systems...............................1-34
Infants and Young Children...........................1-31
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-40
Older Children.............................................1-28
Securing a Child Restraint Designed
for the LATCH System..............................1-42
Securing a Child Restraint in a Rear
Seat Position...........................................1-42
Securing a Child Restraint in the Right
Front Seat Position...................................1-45Child Restraints (cont.)
Top Strap...................................................1-37
Top Strap Anchor Location............................1-39
Where to Put the Restraint...........................1-36
Cleaning
Inside of Your Vehicle..................................5-89
Outside of Your Vehicle................................5-92
Underbody Maintenance...............................5-95
Weatherstrips..............................................5-92
Cleaning Aluminum Wheels..............................5-94
Cleaning Exterior Lamps/Lenses.......................5-93
Cleaning Fabric/Carpet....................................5-89
Cleaning Glass Surfaces..................................5-91
Cleaning Interior Plastic Components.................5-91
Cleaning the DVD Player.................................3-71
Cleaning the Mirror.................................2-31, 2-33
Cleaning the Top of the Instrument Panel...........5-91
Cleaning the Video Screen...............................3-71
Cleaning Tires................................................5-94
Cleaning Vinyl................................................5-91
Cleaning Windshield and Wiper Blades..............5-94
Climate Control System...................................3-21
Air Filter, Passenger Compartment.................3-23
Clutch, Hydraulic.............................................5-28
Compact Spare Tire........................................5-88
Compass Calibration...............................2-30, 2-32
Compass Operation.........................................2-32
Compass Variance..................................2-30, 2-32
3
ProCarManuals.com

Control of a Vehicle.......................................... 4-7
Coolant
Engine Temperature Gage............................3-34
Engine Temperature Warning Light.................3-33
Heater, Engine............................................2-17
Low Warning Light.......................................3-34
Surge Tank Pressure Cap.............................5-31
Cooling System..............................................5-34
Cruise Control........................................3-11, 3-14
Customer Assistance Information
Customer Assistance for Text
Telephone (TTY) Users............................... 7-4
Customer Satisfaction Procedure..................... 7-2
GM Mobility Program for Persons with
Disabilities................................................ 7-5
Reporting Safety Defects to Saturn.................. 7-9
Reporting Safety Defects to the Canadian
Government.............................................. 7-9
Reporting Safety Defects to the United
States Government.................................... 7-8
Roadside Assistance Program......................... 7-6
Service Publications Ordering Information......... 7-9
D
Daytime Running Lamps..................................3-17
Daytime Running Lamps Indicator Light.............3-40
Defensive Driving............................................. 4-3Defogging and Defrosting.................................3-22
Delayed Locking............................................... 2-8
Dinghy Towing (All-Wheel Drive and
Front-Wheel Drive with VTi Transaxle)............4-46
Dinghy Towing (Manual or Five-Speed
Automatic Transaxle*)...................................4-47
Disabling the Theft-Deterrent Feature.................3-74
Doing Your Own Service Work........................... 5-4
Dolly Towing (All-Wheel Drive Vehicles)..............4-48
Dolly Towing (Front-Wheel Drive Vehicles)..........4-48
Dome Lamp...................................................3-19
Door
Delayed Locking........................................... 2-8
Locks.......................................................... 2-7
Power Door Locks......................................... 2-8
Programmable Automatic Door Locks............... 2-9
Rear Door Security Locks............................... 2-9
Driver
Position, Safety Belt.....................................1-15
Seat Height Adjuster...................................... 1-3
Six-Way Power Seat...................................... 1-3
Driver Behavior................................................ 4-2
Driving
At Night.....................................................4-30
City...........................................................4-35
Defensive..................................................... 4-3
Drunken....................................................... 4-4
Environment................................................. 4-2
4
ProCarManuals.com

If You Are Caught in a Blizzard.........................4-42
If You Do Decide to Pull a Trailer......................4-56
Ignition Positions.............................................2-14
Infants and Young Children, Restraints...............1-31
Ination - Tire Pressure...................................5-69
Instrument Panel
Cluster.......................................................3-26
Overview..................................................... 3-4
Instrument Panel Brightness.............................3-19
Instrument Panel Fuse Block............................5-99
Interior Lamps................................................3-19
J
Jump Starting.................................................5-45
K
Keyless Entry System....................................... 2-3
Keys............................................................... 2-2
L
Lamps
Exterior......................................................3-17
Fog Lamps.................................................5-57
Interior.......................................................3-19Lap-Shoulder Belt...................................1-15, 1-23
LATCH System
Child Restraints...........................................1-40
Securing a Child Restraint Designed for
the LATCH System...................................1-42
Leaving Your Vehicle.......................................2-10
Leaving Your Vehicle With the Engine Running . . . 2-25
Liftgate..........................................................2-10
Liftgate Lamps................................................3-19
Light
Airbag Readiness........................................3-28
Anti-Lock Brake System Warning...................3-31
Battery Warning..........................................3-29
Brake System Warning.................................3-30
Change Engine Oil......................................3-39
Daytime Running Lamps Indicator..................3-40
Engine Coolant Temperature Warning.............3-33
Gate Ajar...................................................3-40
Low Coolant Warning...................................3-34
Low Fuel Warning.......................................3-42
Low Traction...............................................3-33
Malfunction Indicator....................................3-35
Oil Pressure...............................................3-38
Reduced Engine Power................................3-39
Safety Belt Reminder...................................3-28
Security.....................................................3-39
Service Vehicle Soon...................................3-40
8
ProCarManuals.com

Light (cont.)
TCS Warning Light......................................3-32
Traction Control System (TCS) Warning..........3-32
Up-Shift.....................................................3-30
Load Floor Storage Box...................................2-37
Loading Your Vehicle.......................................4-49
Loading Your Vehicle for Off-Road Driving..........4-18
Lockout Protection..........................................2-10
Locks
Delayed Locking........................................... 2-8
Door........................................................... 2-7
Leaving Your Vehicle....................................2-10
Lockout Protection.......................................2-10
Power Door.................................................. 2-8
Programmable Automatic Door Locks............... 2-9
Rear Door Security Locks............................... 2-9
Loss of Control...............................................4-16
Low Coolant Warning Light..............................3-34
Low Fuel Warning Light...................................3-42
Low Traction Light..........................................3-33
Lumbar
Manual Controls............................................ 1-4
M
Maintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill.........................................6-10Maintenance Schedule (cont.)
At Least Once a Month................................6-11
At Least Once a Year..................................6-11
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-9
Maintenance Record....................................6-18
Maintenance Requirements............................. 6-2
Normal Maintenance Replacement Parts.........6-16
Owner Checks and Services.........................6-10
Recommended Fluids and Lubricants.............6-14
Scheduled Maintenance................................. 6-4
Using Your................................................... 6-2
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-61
Making Turns.................................................4-59
Malfunction Indicator Light................................3-35
Manual Lumbar Controls.................................... 1-4
Manual Seats................................................... 1-2
Manual Transaxle............................................2-15
Fluid..........................................................5-27
Operation...................................................2-21
Manual Windows............................................2-11
Map Lamps....................................................3-20
Matching Transmitter(s) to Your Vehicle............... 2-5
Mirrors
Automatic Dimming Rearview with Compass
and Temperature Display...........................2-31
9
ProCarManuals.com

Playing the Single CD Player...........................3-54
Playing the Six-Disc CD Player.........................3-56
Power............................................................. 1-3
Accessory Outlets........................................3-20
Door Locks.................................................. 2-8
Electrical System.........................................5-98
Reduced Engine Light..................................3-39
Windows....................................................2-12
Pretensioners, Safety Belt................................1-28
Programmable Automatic Door Locks.................. 2-9
Q
Questions and Answers About Safety Belts.........1-14
R
Radio Data System (RDS)...............................3-49
Radio Personalization......................................3-62
Radios..........................................................3-42
AM-FM Radio.............................................3-43
Care of Your CD and DVD Player..................3-75
Care of Your CDs and DVDs........................3-75
Radio with CD....................................3-45, 3-49
Setting the Time for Radios with
Radio Data Systems (RDS).......................3-43
Setting the Time for Radios without
Radio Data Systems (RDS).......................3-43Radios (cont.)
Theft-Deterrent............................................3-72
Understanding Reception..............................3-74
RDS Messages..............................................3-53
Rear Door Security Locks.................................. 2-9
Rear Safety Belt Comfort Guides......................1-25
Rear Seat Entertainment System.......................3-62
Rear Seat Passengers, Safety Belts..................1-23
Rear Window Defogger....................................3-23
Rear Window Wiper/Washer.............................3-10
Rearview Mirror, Automatic Dimming with
Compass and Temperature Display................2-31
Rearview Mirror, Automatic Dimming
with OnStar
®, Compass and
Temperature Display....................................2-29
Rearview Mirrors.............................................2-29
Reclining Seatbacks.......................................... 1-5
Recommended Fluids and Lubricants.................6-14
Recovery Hook...............................................4-45
Recreational Vehicle Towing.............................4-46
Reduced Engine Power Light............................3-39
Remote Control..............................................3-68
Remote Keyless Entry System............................ 2-3
Remote Keyless Entry System, Operation............ 2-4
Removing the Flat Tire and Installing the
Spare Tire..................................................5-82
Removing the Spare Tire and Tools...................5-78
Removing the Wheel.......................................5-82
11
ProCarManuals.com