brake SATURN VUE HYBRID 2008 Repair Manual

Parking Brake and Automatic
Transmission Park (P) Mechanism
Check
{CAUTION:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in
case it begins to roll. Be ready to apply the
regular brake at once should the vehicle begin
to move.
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
To check the parking brake’s holding ability: With
the engine running and the transmission in
NEUTRAL (N), slowly remove foot pressure from
the regular brake pedal. Do this until the vehicle is
held by the parking brake only.
To check the PARK (P) mechanism’s holding
ability: With the engine running, shift to PARK (P).
Then release the parking brake followed by the
regular brake.
Contact your dealer/retailer if service is required.
Underbody Flushing Service
At least every spring, use plain water to ush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.
Tire Sealant and Compressor Kit
Check the sealant expiration date printed on the
instruction label of the Tire Sealant and Compressor
Kit (if equipped) at least once a year. See your
dealer/retailer for a replacement canister.
6-11
ProCarManuals.com

Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name, part
number, or specication can be obtained from your
dealer/retailer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets
GM Standard GM6094M and
displays the American Petroleum
Institute Certied for Gasoline
Engines starburst symbol. To
determine the proper viscosity for
your vehicle’s engine, seeEngine
Oil on page 5-13.
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant on
page 5-20.
Hydraulic Brake
SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Windshield
WasherOptikleen
®Washer Solvent
Parking Brake
Cable GuidesChassis Lubricant
(GM Part No. 12377985,
in Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Usage Fluid/Lubricant
Automatic
TransmissionDEXRON®-VI Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Hood Latch
Assembly,
Secondary
Latch, Pivots,
Spring Anchor,
and Release
PawlLubriplate Lubricant Aerosol
(Saturn Part No. 21038869 or
GM Part No. U.S. 12346293, in
Canada 992723) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Hood, Liftgate
Door, and Rear
Folding Seat
HingesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Sunroof TrackLubriplate Lubricant Aerosol
(Saturn Part No. 21038869 or
GM Part No. U.S. 12346293, in
Canada 992723) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Weatherstrip
ConditioningWeatherstrip Lubricant
(GM Part No. U.S. 3634770,
in Canada 10953518) or
Dielectric Silicone Grease
(GM Part No. U.S. 12345579,
in Canada 992887).
6-12
ProCarManuals.com

Vehicle Data Recording and
Privacy
Your Saturn vehicle has a number of sophisticated
computers that record information about the vehicle’s
performance and how it is driven. For example,
your vehicle uses computer modules to monitor and
control engine and transmission performance, to monitor
the conditions for airbag deployment and deploy
airbags in a crash and, if so equipped, to provide
antilock braking to help the driver control the vehicle.
These modules may store data to help your
dealer/retailer technician service your vehicle. Some
modules may also store data about how you operate the
vehicle, such as rate of fuel consumption or average
speed. These modules may also retain the owner’s
personal preferences, such as radio pre-sets, seat
positions, and temperature settings.
Event Data Recorders
This vehicle has an Event Data Recorder (EDR). The
main purpose of an EDR is to record, in certain crash or
near crash-like situations, such as an airbag deployment
or hitting a road obstacle, data that will assist in
understanding how a vehicle’s systems performed. The
EDR is designed to record data related to vehicle
dynamics and safety systems for a short period of time,
typically 30 seconds or less. The EDR in this vehicle
is designed to record such data as:
How various systems in your vehicle were operating
Whether or not the driver and passenger safety
belts were buckled/fastened
How far, if at all, the driver was pressing the
accelerator and/or brake pedal
How fast the vehicle was traveling
This data can help provide a better understanding of the
circumstances in which crashes and injuries occur.
Important:EDR data is recorded by your vehicle only
if a non-trivial crash situation occurs; no data is
recorded by the EDR under normal driving conditions
and no personal data (e.g., name, gender, age,
and crash location) is recorded. However, other parties,
such as law enforcement, could combine the EDR
data with the type of personally identifying data routinely
acquired during a crash investigation.
7-15
ProCarManuals.com

A
About Driving Your Vehicle................................... iii
Accessories and Modications............................ 5-3
Adding Equipment to Your Airbag-Equipped
Vehicle.......................................................1-68
Additives, Fuel................................................. 5-7
Add-On Electrical Equipment............................5-89
Air Cleaner/Filter, Engine.................................5-18
Air Conditioning..............................................3-18
Airbag
Passenger Status Indicator...........................3-30
Readiness Light..........................................3-29
Airbag System................................................1-53
What Will You See After an Airbag Inates?........1-62
When Should an Airbag Inate?....................1-59
Where Are the Airbags?...............................1-56
Airbag Systems
Adding Equipment to Your Airbag-Equipped
Vehicle...................................................1-68
How Does an Airbag Restrain?......................1-61
Passenger Sensing System...........................1-63
Servicing Your Airbag-Equipped Vehicle..........1-68
What Makes an Airbag Inate?......................1-61
Antenna, Fixed Mast.......................................3-77
Antenna, XM™ Satellite Radio Antenna System.....3-77
Antilock Brake System (ABS)............................. 4-6Anti-lock Brake, System Warning Light...............3-33
Appearance Care
Aluminum Wheels........................................5-84
Care of Safety Belts....................................5-81
Chemical Paint Spotting...............................5-86
Cleaning Exterior Lamps/Lenses....................5-82
Fabric/Carpet..............................................5-80
Finish Care.................................................5-83
Finish Damage............................................5-85
Instrument Panel, Vinyl, and Other Plastic
Surfaces.................................................5-81
Interior Cleaning..........................................5-79
Sheet Metal Damage...................................5-85
Tires..........................................................5-85
Underbody Maintenance...............................5-86
Vehicle Care/Appearance Materials................5-86
Washing Your Vehicle...................................5-82
Weatherstrips..............................................5-82
Windshield and Wiper Blades........................5-84
Appointments, Scheduling Service....................... 7-8
Audio System.................................................3-59
Audio Steering Wheel Controls......................3-76
Fixed Mast Antenna.....................................3-77
Radio Reception..........................................3-76
Setting the Clock.........................................3-60
XM™ Satellite Radio Antenna System............3-77
1
ProCarManuals.com

Audio System(s).............................................3-62
Auto Stop Mode.............................................3-42
Automatic Climate Control System.....................3-18
Automatic Headlamp System............................3-15
Automatic Transmission
Fluid..........................................................5-20
Operation...................................................2-23
B
Battery..........................................................5-33
Run-Down Protection...................................3-17
Brake
Emergencies................................................ 4-6
Brakes..........................................................5-30
Regenerative Braking...................................2-26
System Warning Light..................................3-32
Braking........................................................... 4-5
Braking in Emergencies..................................... 4-6
Break-In, New Vehicle.....................................2-16
Bulb Replacement...........................................5-41
Front Turn Signal and Parking Lamps.............5-43
Halogen Bulbs............................................5-41
Headlamp Aiming........................................5-39
Headlamps.................................................5-42
License Plate Lamps....................................5-45Bulb Replacement (cont.)
Replacement Bulbs......................................5-45
Taillamps, Turn Signal, Stoplamps and
Back-up Lamps........................................5-44
Buying New Tires...........................................5-60
C
Calibration.....................................................3-48
California Fuel.................................................. 5-6
California Perchlorate Materials Requirements....... 5-4
California Proposition 65 Warning....................... 5-4
Canadian Owners................................................ ii
Capacities and Specications............................5-98
Carbon Monoxide...........................2-29, 4-17, 4-31
Care of
Safety Belts................................................5-81
Cargo Cover..................................................2-43
Cargo Management System.............................2-44
Cargo Tie Downs............................................2-43
CD, MP3 .......................................................3-70
Center Console Storage Area...........................2-42
Chains, Tire...................................................5-66
Charge/Assist Gage........................................3-43
Charging System Light....................................3-32
Check
Engine Light...............................................3-36
2
ProCarManuals.com

Instrument Panel
Brightness..................................................3-16
Cluster.......................................................3-26
Overview..................................................... 3-4
Storage Area..............................................2-42
Intermediate Voltage Devices and Wiring............5-88
J
Jump Starting.................................................5-34
K
Keyless Entry System....................................... 2-4
Keys............................................................... 2-3
L
Labeling, Tire Sidewall.....................................5-48
Lamps
Dome ........................................................3-16
Reading.....................................................3-17
Lap-Shoulder Belt...........................................1-25
LATCH System
Child Restraints...........................................1-41License Plate Lamps.......................................5-45
Liftgate
Carbon Monoxide.......................................... 2-9
Light
Airbag Readiness........................................3-29
Anti-lock Brake System (ABS) Warning...........3-33
Brake System Warning.................................3-32
Change Engine Oil......................................3-39
Charging System.........................................3-32
Cruise Control.............................................3-40
Electronic Stabilitrak Program Indicator...........3-34
Engine Coolant Temperature Warning.............3-35
Fuel Economy.............................................3-43
Highbeam On.............................................3-40
Low Fuel Warning.......................................3-42
Low Washer Fluid Warning...........................3-40
Malfunction Indicator....................................3-36
Oil Pressure...............................................3-38
Passenger Airbag Status Indicator..................3-30
Safety Belt Reminders..................................3-28
Security.....................................................3-40
TCS Warning Light......................................3-34
Tire Pressure..............................................3-35
Traction Control System (TCS) Warning..........3-34
Light, Auto Stop Mode.....................................3-42
Lighting
Entry.........................................................3-16
7
ProCarManuals.com

N
Navigation System, Privacy..............................7-16
New Vehicle Break-In......................................2-16
O
Odometer......................................................3-27
Odometer, Trip...............................................3-27
Off-Road Recovery..........................................4-12
Oil
Change Engine Oil Light...............................3-39
Engine.......................................................5-13
Pressure Light.............................................3-38
Oil, Engine Oil Life System..............................5-16
Older Children, Restraints................................1-31
Online Owner Center........................................ 7-4
OnStar, Privacy..............................................7-16
OnStar
®System, see OnStar®Manual...............2-33
Operation, Universal Home Remote System........2-37
Outlet Adjustment............................................3-23
Outlets
Accessory Power.........................................3-17Outside
Convex Mirror.............................................2-32
Heated Mirrors............................................2-32
Power Mirrors.............................................2-32
Owner Checks and Services.............................. 6-8
Owners, Canadian............................................... ii
P
Paint, Damage...............................................5-85
Park Brake....................................................2-26
Park (P)
Shifting Into................................................2-27
Shifting Out of............................................2-28
Parking
Over Things That Burn.................................2-29
Passenger Airbag Status Indicator.....................3-30
Passenger Compartment Air Filter.....................3-23
Passenger Sensing System..............................1-63
Passing.........................................................4-12
PASS-KEY
®III Electronic Immobilizer................2-14
PASS-Key®III+ Electronic Immobilizer
Operation...................................................2-15
Perchlorate Materials Requirements, California....... 5-4
9
ProCarManuals.com