Seat Exeo ST 2010 Maintenance programme

SEAT maintenance programme9
Please observe inspection intervals and en sure your vehicle is serviced as
required. Please note that failure to obse rve the inspection intervals may
lead to damage to your vehicle.
Note
•We recommend that you visit an Authorised SEAT Service Centre whenever
you require any work done on your vehicle.•SEAT keeps its Technical Services up-to-da te on new product develop-
ments. They have tools and highly specia lised personnel who can guarantee
the safety and performance of your vehicle.•Scrupulously following the General Programme for Inspection Services in
Authorised SEAT Services will ensure you m aintain greater value for your
vehicle.Oil change serviceOperations to be performed on your vehicl e:•Engine oil and oil filter: Replace.•Front and rear brake pads: Check.•Service interval indicator: Reset to zero.•“Next service” sticker: Write the date and mile age, and attach it onto the
door frame.
Inspection Service every 30,000 km (20,000 miles) or 2 yearsOperations to be performed on your vehicle:•Battery: Check condition•Self-diagnosis: Check fault memory in all systems.•Service interval indicator: Reset to zero.•Sunroof: Check operation, clean guttering a nd lubricate guides.•Windscreen wiper and headlight wiper system : Check operation and look
for possible damage, fill if necessary.•Tyres (including the spare wheel): Check sur face, tread and tyre pressure.•Engine oil and oil filter: Replace.•Front and rear brake pads: Check.•Brake system: Check for leaks and damage•Engine and engine compartment componen ts (from below) : Check for
leaks and damage•Steering ball joints: Check fastenings and a bsence of leaks and damage,
and verify play.•Engine and engine well components (from abov e): Visual check for leaks
and damage.•Brake fluid level, according to brake pad w ear: Check.•Servo steering hydraulic system: Check for leaks and check fluid levels,
topping up with hydraulic oil where necess ary.•Test run, brake system, parking brake, gear c ontrol, steering system, air
conditioning: Check operation.•“Next service” sticker: Write the date and mile age, and attach it onto the
door frame.
Prog Manto Exeos_EN.book Seite 9 Die nstag, 31. August 2010 4:49 16

SEAT maintenance programme
10Inspection Service every 60,000 km (40,000 miles) or 4 yearsOperations to be performed on your vehicle:•Battery: Check condition•Front/rear lights, luggage compartment lighti ng, indicators and hazard
lights: Check operation.•Interior and glove compartment lighting, lig hter, warning lights and horn:
Check operation.•Self-diagnosis: Check fault memory in all syste ms.•Service interval indicator: Reset to zero.•Door and tailgate hinges: Lubricate.•Door arresters, lock cylinders and bonnet arrester hooks: Lubricate•Sunroof: Check operation, clean guttering and lubricate guides.•Windscreen wiper and headlight wiper system: Check operation and look
for possible damage, fill if necessary.•Tyres (including the spare wheel): Check sur face, tread and tyre pressure.•Engine oil and oil filter: Replace.•Front and rear brake pads: Check.•Exhaust system : Check fastenings and abse nce of leaks and damage•Underside protection: Check visually for damage•Brake system: Check for leaks and damage•Engine and engine compartment component s (from below) : Visual check
for leaks and damage.•Steering knuckles: Check attachment s and check for leaks and damage.
Check for play.
•Engine and engine well components (from abov e): Visual check for leaks
and damage.•Coolant system : Check coolant and frost pr otection level.•Brake fluid level, according to brake pad wear : Check.•Servo steering hydraulic system: Check for leaks and check fluid levels,
topping up with hydraulic oil where nece ssary.•Headlights: Checking their adjustment.•Test run, brake system, parking brake, gear control, steering system, air
conditioning: Check operation.•“Next service” sticker: Write the date and mil eage, and attach it onto the
door frame.Additional tasksIn addition to the Inspection Service, addit ional maintenance jobs may have
to be carried out, depending on the conditions i n which your vehicle is used
and on the equipment carried. This addi tional work should be carried out in
accordance with time/distance travelled to en sure your vehicle remains reli-
able. Your Technical Service will provide detailed information about the addi-
tional work that may be necessary. This can be done independently of the
obligatory services, taking into account the notes on the Maintenance
Programme (or the label: Next service). Your SEAT Service Centre will be
happy to advise you and quote the prices for this add itional work. Additional
jobs completed are marked on the work shop sheet with the receipt.
Prog Manto Exeos_EN.book Seite 10 Di enstag, 31. August 2010 4:49 16

SEAT maintenance programme11
Every 7,500 km (5,000 miles)•Engine oil and oil filter: Replace (only engines using high sulphur content
diesel fuel).Every 30,000 km (20,000 miles) or every 2 years•Dust and pollen filter: Replace.Every 60,000 km (40,000 miles)•Automatic gearbox: Change oil.•Fuel filter: Change (only diesel engines)Every 60,000 km (40,000 miles) or every 4 years•Air filter: Clean casing and replace filter ele ment (only diesel CR engines).•Spark plugs : Replace (except 2.0 TFSI engine s).Every 90,000 km (60,000 miles) or every 6 years•Spark plugs : Replace (only 2.0 TFSI engines).•Air filter: Clean casing and replace filter element (only petrol engines).
At 90,000 km (60,000 miles) the first time, then every 30,000 km (20,000 miles)•Timing belt: Check condition and replace as necessary (only 1.6 MPI
petrol engines up to 180,000 km (120,000 mi les)Every 180,000 km (120,000 miles)•Timing belt: Replace (petrol engines).•Particulate filter: Check (TDI Common Rail engines).Every 210,000 km (130,000 miles)•Timing belt for camshaft: Replace (TDI Commo n Rail engines).•Camshaft timing belt tension roller: Replace (TDI Common Rail engines).After 3 years the first time, then every 2 years•Brake fluid: Replace.Every 4 years•Anti-puncture kit: Check the expiry date on the sealing compound and
replace if necessary.
Prog Manto Exeos_EN.book Seite 11 Di enstag, 31. August 2010 4:49 16

SEAT maintenance programme
12
Note•We recommend that you visit an Authorised SEAT Service Centre whenever
you require any work done on your vehicl e.•SEAT keeps its Technical Services up-to-date on new product develop-
ments. They have tools and highly special ised personnel who can guarantee
the safety and performance of your vehicle.•Scrupulously following the General Program me for Inspection Services in
Authorised SEAT Services will ensure you maintain greater value for your
vehicle.
Prog Manto Exeos_EN.book Seite 12 Di enstag, 31. August 2010 4:49 16

Other services available13
Other services availableLegal Inspection ServiceThe legal inspections must be carried out at the interva ls
prescribed.Many countries have legal requirements ob liging owners to have their vehicle
tested at specified intervals for safety for the user and for other traffic, as well
as ensuring that vehicle exhaust emissions meet the countries' regulations.
These revisions must be overseen by officially certified centres.
Your Technical Service can advise of the ins pections required by law, and can
check your vehicle in the course of an In spection Service. This will save you
both time and money.
The Technical Service can also carry out the inspections required by law at the
client's request.
Even if you do not wish to take advanta ge of this service and decide to take
your car to an officially certified centre for t his check, we recommend that you
speak to the manager of your Technica l Service first.
This person will be able to inform you of any p oints that require attention so
that your car does not fail the test and ha ve to be re-tested.Approved spare partsAll parts of your vehicle have been approved by SEAT, especially those parts
on which your safety depends. For this reason, the parts used in the
Programmed Inspection Services or in a ny vehicle repair must correspond
exactly to the manufacturer-defined requiremen ts. The approved SEAT spare parts have been designed especially for y
our vehicle. For this reason, we
recommend that Genuine approved SEAT spar es are always used.
In the Authorised SEAT Service Centres you will find the most important
approved spare parts. If in an exceptional case, th e necessary parts are not in
stock, they can, in general, be obtained s wiftly.
The SEAT Service Centres in the EU provide a 24 month warranty
1) for
Approved Spare parts from the date they are fi tted or sold. It is therefore
advisable to retain the original invoice from the Technical Service as proof of
the existing warranty.
More information about this may be obtain ed from your Technical Service.
Approved SEAT exchange partsThe approved SEAT exchange parts, conforming to the manufacturer’s
requirements, constitute an additional service at your disposal, offering you
the possibility to replace entire assemb lies, the most common being: the
lightened engine, gearboxes, cylinder head s, control units, electrical
elements, etc.
Of course these are Approved parts and, as they have the same class as the
manufacturer parts, they share the same SEA T approved spare parts warranty.
However, these parts are considerably cheape r as they are factory-recondi-
tioned used parts. Keep the invoice for the a pproved SEAT exchange parts as
proof of the start of the existing warranty.
More information about this may be obtai ned at the Technical Service.1)The warranty is not available for all export markets. For more information, ple ase ask
your Authorised SEAT Technical Service.
Prog Manto Exeos_EN.book Seite 13 Di enstag, 31. August 2010 4:49 16

Other services available
14Genuine accessoriesWe recommend that you use only Genuine SEAT Accessori es
and accessories approved by SEAT.If you wish to equip your car with accessories , you should remember the
following points:
We recommend that you use only genuine SE AT and SEAT approved accesso-
ries.
SEAT provides a warranty for Genuine Accesso ries valid from the date of
purchase or fitting. It is therefore advisable to retain the original invoice from
the Technical Service as proof of the existi ng warranty.
More information about this may be ob tained from your Technical Service.
The accessories service also offers you expert ad vice and, if required, fitting
by a specialist.
In addition, Technical Services can supply car ca re products and parts subject
to normal wear, such as tyres, batteries an d light bulbs.
Paintwork and body serviceSEAT vehicles are designed in such a way th at, in case of bodywork damage,
there is only need to replace and paint the par ts that have been really
affected.
Both operations must be carried out ac cording to the requirements of the
manufacturer; this is an essential condition fo r conservation of the bodywork
and paintwork warranties.
Prog Manto Exeos_EN.book Seite 14 Di enstag, 31. August 2010 4:49 16

Warranty15
WarrantyFault-free operation warrantyAccording to the clauses of the warranty applie d to SEAT vehicles in the sales
contract, A fault-free operation warranty of 2 years in ac cordance with legal
requirements
2) 3) is provided from the date of delivery.
We hope that it is understood that natural wear as well as damage caused by
the abuse of vehicle performance throug h inappropriate use or by unaccept-
able modifications are excluded from the warran ty. The warranty is also
invalid when the vehicle is damaged by th e use of parts and accessories that
are not SEAT approved or damage due to ignoring th e maintenance and repair
requirements.
Paintwork and body warrantyTech nical Services provide a warranty on bodywork and
paintwork for vehicles sold in the EU.In addition to the warranty conditions for bra nd new SEAT vehicles (as
d e ta ile d i n t he pu rchase cont ra ct ) , a d e f ine d p e r i od war rant y is a ls o p rovi de d
covering paintwork and bodywork rusting:•The additional warranty on paint faults cove rs the first 3 years following
delivery
•Covered against perforation rusting on the b ody during the first 12 years
following delivery.
I f , h o w e v e r , t h i s t y p e o f d a m a g e s h o u l d o c c u r , i t w i l l b e r e p a i r e d f r e e o f ch a r g e
including parts and labour by any SEAT Tec hnical Service in Europe.
Warranty claims will not be accepted in the following circumstances:•if damage is caused by external influence or carelessness, or•if damage to the body is not repaired promp tly and appropriately in
accordance with the manufacturer's inst ructions using genuine, approved
spare parts and materials, or•if perforation rusting is caused by the use of non-genuine parts and mate-
rials for body repairs and if these repairs were not carried out in accordance
with the manufacturer's instructions.
If the bodywork is repaired or painted, you r Technical Service will certify your
warranty against through-rusting for the repair ed sections.Approved SEAT exchange partsThe approved SEAT exchange parts, conforming to the manufacturer’s
requirements, constitute an additional service at your disposal, offering you
the possibility to replace entire assemb lies, the most common being: the
lightened engine, gearboxes, cylinder head s, control units, electrical
elements, etc.
Of course these are Approved parts and, as they have the same class as the
manufacturer parts, they share the same SEA T approved spare parts warranty.
2)The warranty is not available for all export markets. For more information, ple ase ask
your Authorised SEAT Technical Service.3)As well as the legally required warran ty, SEAT offers an extended warranty to t heir cli-
ents in some European countries. The s pecific conditions of this extended warranty
are detailed in the vehicle sales cont ract.
Prog Manto Exeos_EN.book Seite 15 Di enstag, 31. August 2010 4:49 16

Warranty
16However, these parts are considerably chea per as they are factory-recondi-
tioned used parts. Keep the invoice for the approved SEAT exchange parts as
proof of the start of the existing warranty.
More information about this may be ob tained at the Technical Service.Genuine accessoriesWe recommend that you use only Genuine SEAT Accessori es
and accessories approved by SEAT.If you wish to equip your car with accessories , you should remember the
following points:
We recommend that you use only genuine SE AT and SEAT approved accesso-
ries.
SEAT provides a warranty for Genuine Accesso ries valid from the date of
purchase or fitting. It is therefore advisable to retain the original invoice from
the Technical Service as proof of the existing warranty.
More information about this may be obta ined from your Technical Service.
The accessories service also offers you expert ad vice and, if required, fitting
by a specialist.
In addition, Technical Services can supply car ca re products and parts subject
to normal wear, such as tyres, batteries and light bulbs.
Paintwork and body serviceSEAT vehicles are designed in such a way that, in case of bodywork damage,
there is only need to replace and paint the par ts that have been really
affected.
Both operations must be carried out ac cording to the requirements of the
manufacturer; this is an essential condition fo r conservation of the bodywork
and paintwork warranties.
Prog Manto Exeos_EN.book Seite 16 Di enstag, 31. August 2010 4:49 16

Service Record17
Service RecordService RecordIn the sections appearing after, the Technic al Service will record the comple-
tion of the corresponding scheduled Inspection and Maintenance Services
using a stamp. A cross or mark in the co rrect box will indicate if the services
have been carried out or not. This will make it much easier to check these.
Prog Manto Exeos_EN.book Seite 17 Dienstag, 31. August 2010 4:49 16

Service Record
18Service records
Note
We recommend that you visit an Authorised SEAT Service Centre whenever
you require any work done on your vehicle. Sc rupulously following the Serv-
ices (Oil, Inspection) at an Authorised SEAT Service will increase the value of
your vehicle.
LongLife Service:
YES NO
Inspection Service every 30,000 km (20,000 mi les) or 2 years
cc
Inspection Service every 60,000 km (40,000 miles) or 4 years
cc
Service dependent on time/distance travelled: YES NO
Oil change
cc
Inspection Service every 30,000 km (20,00 0 miles) or 2 years
cc
Inspection Service every 60,000 km (40,000 miles) or 4 years
cc
Additional jobs:YES NO YES NO
Brake/clutch fluid
cc
Air filter
cc
Spark plugs
cc
Fuel filter
cc
Dust and
pollen filters
cc
Timing belt
cc
Automatic gearbox: oil
and filter
cc
Particulate filter
cc
Date
Km/Miles:
Invoice number
Repair recommendation:
Service carried out by:
Official SEAT Service stamp
Next Service to be carried out:
Date:
Km/Miles: (whichever is first)
Prog Manto Exeos_EN.book Seite 18 Di enstag, 31. August 2010 4:49 16