instrument panel Seat Leon 5D 2010 Workshop Manual

Wheels and tyres
240Wear indicators
The original tyres on your vehicle have 1.6 mm high tread wear indicators
⇒ page 239, fig. 152 , running across the tread. Depending on the make,
there will be 6 to 8 of them evenly spaced around the tyre. Markings on the
tyre sidewall (for instance the letters “TWI” or other symbols) indicate the
positions of the tread wear indicators. The minimum tread depth required by
law is 1.6 mm (measured in the tread grooves next to the tread wear indica-
tors). Worn tyres must be replaced. Different figures may apply in export
countries ⇒.
Tyre pressure
Incorrect tyre pressure causes premature wear and could cause tyre blow-out.
For this reason, the tyre pressure should be checked at least once per month
⇒ page 237.
Driving style
Fast cornering, heavy acceleration and hard braking all increase tyre wear.
Changing wheels around
If the front tyres are worn considerably more than the rear ones it is advisable
to change them around as shown ⇒page 239, fig. 153. All the tyres will then
last for about the same time.
Wheel balance
The wheels on new vehicles are balanced. However, various factors encoun-
tered in normal driving can cause them to become unbalanced, which results
in steering vibration.
Unbalanced wheels should be rebalanced, as they otherwise cause excessive
wear on steering, suspension and tyres. A wheel must also be rebalanced
when a new tyre is fitted.
Incorrect wheel alignment
Incorrect wheel alignment causes excessive tyre wear, impairing the safety of
the vehicle. If tyres show excessive wear, you should have the wheel align-
ment checked by an Authorised Service Centre.
WARNING
There is a serious danger of accidents if a tyre bursts during driving!•The tyres must be replaced at the latest when the tread is worn down to
the tread wear indicators. Failure to do so could result in an accident. Worn
tyres do not grip well at high speeds on wet roads. There is also a greater
risk of aquaplaning.•At continuously high speeds, a tyre with insufficient pressure flexes
more. This causes it to overheat. This can cause tread separation and tyre
blow-out. Risk of accident. Always observe the recommended tyre pres-
sures.•I f t y r e s s h o w e x ce s s i v e w e a r, y o u s h o u l d h a v e t h e r u n n i n g g e a r ch e cke d
by an Authorised Service Centre.•Keep chemicals such as oil, fuel and brake fluid away from tyres.•Damaged wheels and tyres must be replaced immediately!For the sake of the environment
Under-inflated tyres will increase fuel consumption.Run-flat tyres
Run-flat tyres allow you to continue driving even with a punc-
tured tyre, in the majority of cases.In vehicles that are factory-fitted with run-flat tyres
25) the loss of tyre
pressure is indicated on the instrument panel.
25)Depending upon version and country.
Leon_EN.book Seite 240 Mittwoch, 1. September 2010 6:16 18

Wheels and tyres241
Safety First
Operating Instructions
Practical Tips
Technical Specifications
Driving with run-flat tyres (emergency running)
– Leave the ESP/TCS (Electronic Stability Programme) switched on,
or switch on ⇒page 186.
– Continue driving carefully and slowly (80 km/h maximum).
– Avoid sudden manoeuvres and sharp turns.
– Avoid driving over obstacles (for example kerbs) or potholes.
– Look out for the ESP/TCS intervening often, smoke coming from the tyres or the smell of rubber, the vehicle vibrating or a clat-
tering noise. If any of these occur, stop the vehicle.The run-flat tyres have a tag on the side of the tyre, with the description:
“DSST”, “Eufonia”, “RFT”, “ROF”, “RSC”, “SSR” or “ZP”.
The sides of this type of tyre are reinforced. When the tyres lose air they are
supported on the sides (emergency driving).
The loss of pressure in the tyre is shown on the instrument panel. You can
then drive a maximum of 80 km and if the circumstances are favourable (for
example, low load), even more.
The damaged tyre should be changed as soon as possible. The rim should be
checked in a specialised workshop to detect possible damage and replace it
if necessary. We recommend you contact Technical Service. If more than one
tyre is being used under emergency conditions, this reduces the distance
which can be travelled.
Starting driving in emergency conditions
When loss in tyre pressure is displayed on the instrument panel, this means
that at least one tyre is being driven in emergency conditions ⇒.
End of emergency operation
Do not drive on if:
•smoke is coming from one of the tyres,•there is a smell of rubber,•the vehicle vibrates,•there is a rattling noise.
When is it no longer possible to continue driving even using run-flat tyres?•If one of the tyres has been severely damaged in an accident, etc. If a tyre
has been badly damaged there is a risk that parts of the tread can be thrown
off and cause damage to the fuel lines, brake pipes or fuel filler.•It is also advisable to stop driving if severe vibrations occur, or if the wheel
starts overheating and gives off smoke.WARNING
When driving in emergency conditions, the driving quality of the vehicle is
considerably impaired.•The maximum permitted speed of 80 km/h is subject to road and
weather conditions. Please observe legal requirements when doing so.•Avoid sharp turns and rapid manoeuvres, and brake earlier than usual.•Avoid driving over obstacles (for example kerbs) or potholes.•If one or more tyres are being driven in emergency conditions, the
driving quality of the vehicle is impaired and there is a risk of accident.Note
•The run-flat tyres do not “deflate” on losing pressure because they are
supported on the reinforced sides. Therefore defects in the tyre cannot be
detected with a visual inspection.•Snow chains must not be used on front tyres used in emergency
conditions.
Leon_EN.book Seite 241 Mittwoch, 1. September 2010 6:16 18

If and when257
Safety First
Operating Instructions
Practical Tips
Technical Specifications
Fuses on left side of dash panelFusesNumber
Consumer
Amps
1
Diagnosis Switchboard/ Instrument lighting/
Headlight control switchboard/ Flow meter/
Heated wipers/ Engine management/ AFS Head-
lamps
10
2
Engine control unit/ ABS-ESP switchboard/ Auto-
matic gearbox/ Instrument panel/ Trailer switch-
board/ Light switch / Brake sensor/ Power
steering/ Right and left headlights
10
3
Airbag
5
4
Heating/ Reverse switch/ ASR-ESP switch/ Elec-
trochrome mirror/ Park Pilot/ Oil level sensor
5
5
Right xenon headlight
10
6
Left xenon headlight
10
7
Vaca n t
8
Trailer hook pre-installation assistant
5
9
Vaca n t
10
Vaca n t
11
Vaca n t
12
Central locking
15
13
Diagnosis/ Light switch/ Rain sensor/ Heated rear
window
10
14
Automatic gearbox / Heating/ Automatic gearbox
lever
10
15
Vaca n t
16
Vaca n t
17
Alarm
5
18
Kombi / levers with START STOP
5
19
Fog light aid
20
20
Navigation/radio with START STOP
15
21
Engine management
10
22
Fan switch
40
23
Electric windows (front)
30
24
Body Control Unit
20
25
Heated rear window
25
26
Rear electric windows
30
27
Engine (fuel control unit/pump relay)
15
28
Convenience controls
30
29
Vaca n t
30
Vaca n t
31
Vacu um pu m p
20
32
Vaca n t
33
Sunroof
25
34
Comfort switchboard/Central locking system
25
35
Vaca n t
36
Headlight washer system
20
37
Heated seats
30
38
Engine management
10
39
Telephone with START STOP
10
Number
Consumer
Amps
Leon_EN.book Seite 257 Mittwoch, 1. September 2010 6:16 18

If and when
258Some of the electrical items listed in the table are only fitted on certain
models or are optional extras.
Please note that the above list, while correct at the time of printing, is subject
to alterations. If discrepancies should occur, please refer to the sticker on the
inside of the fuse cover for the correct information for your model.Fuses layout, engine compartment, left partFuses
40
Fan switch
40
41
Rear wiper motor / Switchboard wiring
20
42
12 V socket/ Cigarette lighter
20
43
Trailer bracket preinstallation
15
44
Trailer bracket preinstallation
20
45
Trailer bracket preinstallation
15
46
Vacant
47
Engine management
10
48
Engine management
10
49
Vacant
Number
Consumer
Amps
1
Windscreen wipers
30
2
DQ200 gearbox
30
3
Cable control unit
5
Number
Consumer
Amps
4
ABS
20
5
AQ gearbox
15
6
Instrument panel/Steering column
5
7
Ignition key
40
8
Radio
15
9
Telephone/TomTom Navigator
5
10
Engine management
5
Engine management
10
11
Vacant
12
Electronic control unit
5
13
Petrol injection module supply
15
Diesel injection module supply
30
14
Coil
20
15
Engine management
5
Pump relay
10
16
Right lighting
30
17
Horn
15
18
Vacant
19
Clean
30
20
Water pump
10
Pressure sensor pump for 1.8 engine
20
21a)
Lambda probe
15
22
Brake pedal, speed sensor
5
Number
Consumer
Amps
Leon_EN.book Seite 258 Mittwoch, 1. September 2010 6:16 18

Index301
Headlights
Driving abroad . . . . . . . . . . . . . . . . . . . . . . . 198
Fog lights . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
Headlight washer system* . . . . . . . . . . . . . 131
Heated front seats . . . . . . . . . . . . . . . . . . . . . . . 139
Heated rear window 2C-Climatronic . . . . . . . . . . . . . . . . . . . . . . . 155
Heating element wires . . . . . . . . . . . . . . . . 207
Heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 148
High pressure cleaners . . . . . . . . . . . . . . . . . . . 205
Hill-start aid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 177
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
How to jump start description . . . . . . . . . . . . . 268
Hydraulic Brake Assist . . . . . . . . . . . . . . . . . . . . 185IIdentification number . . . . . . . . . . . . . . . . . . . . 274
Identification plate . . . . . . . . . . . . . . . . . . . . . . 274
Ignition key . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162
Ignition lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162
Information in the multifunction display Memory displays . . . . . . . . . . . . . . . . . . . . . . 64
Information messages in the display . . . . . . . . . 66
Instrument and switch lighting . . . . . . . . . . . . . 121
Instrument lighting . . . . . . . . . . . . . . . . . . . . . . . 55
Instrument panel menus Configuration menu . . . . . . . . . . . . . . . . . . . . 74
Example of menu use . . . . . . . . . . . . . . . . . . 68
Lights and visibility menu . . . . . . . . . . . . . . . 76 Main menu . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
Vehicle status menu . . . . . . . . . . . . . . . . . . . 73
Instruments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Interior lights . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Interior mirror . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
ISOFIX system . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
JJump leads . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 267
Jump-starting . . . . . . . . . . . . . . . . . . . . . . . . . . . 267KKeys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105LLeather cleaning . . . . . . . . . . . . . . . . . . . . . . . . 210
Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
Load compartment in the luggage compartment See Loading the luggage compartment . . . . 16
Loading the luggage compartment . . . . . . . . . . 16
Locker . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 141
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 207
LPG . . . . . . . . . . . . . . . . . . . . . . . . . . . 60, 166, 216
LPG system Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 166
Filler neck adapter . . . . . . . . . . . . . . . . . . . . 218
Level indicator . . . . . . . . . . . . . . . . . . . . . . . . 60
Refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . . 216 Luggage compartment . . . . . . . . . . . . . . . . . . . 146
See also Loading the luggage compartment 16
MMain beam . . . . . . . . . . . . . . . . . . . . . . . . 117, 124
Main beam headlights
Indicator lamp . . . . . . . . . . . . . . . . . . . . . . . . 84
Main headlight bulbs . . . . . . . . . . . . . . . . . . . . 260
Maintenance Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Maintenance and cleaning . . . . . . . . . . . . . . . . 203
Manual gearbox . . . . . . . . . . . . . . . . . . . . . . . . . 170
Manual mode 2C-Climatronic . . . . . . . . . . . . . . . . . . . . . . . 157
MEDIA-IN connector . . . . . . . . . . . . . . . . . . . . . . 145
MFI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Mirrors Exterior mirrors . . . . . . . . . . . . . . . . . . . . . . 132
Interior mirror . . . . . . . . . . . . . . . . . . . . . . . . 131
Vanity mirrors . . . . . . . . . . . . . . . . . . . . . . . 127
Mobile phones and two-way radios . . . . . . . . . 213
Multifunction display . . . . . . . . . . . . . . . . . . . . . 63NNumber of seats . . . . . . . . . . . . . . . . . . . . . . . . . 19OObservations . . . . . . . . . . . . . . . . . . . . . . . . . . . 198
Leon_EN.book Seite 301 Mittwoch, 1. September 2010 6:16 18

Index
302Octane number . . . . . . . . . . . . . . . . . . . . . . . . . 219
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
224
Oil change . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 227
Oil properties . . . . . . . . . . . . . . . . . . . . . . . . . . . 225
One-touch opening and closing
Electric windows . . . . . . . . . . . . . . . . . . . . . 113
Opening and locking . . . . . . . . . . . . . . . . . . . . 110
Outside temperature display . . . . . . . . . . . . 65, 73
Overview Control lamps . . . . . . . . . . . . . . . . . . . . . . . . 77
Dash panel . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Indicator lamps . . . . . . . . . . . . . . . . . . . . . . . 80
Instruments . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Warning lamps . . . . . . . . . . . . . . . . . . . . 77, 80PPaintworkPolishing . . . . . . . . . . . . . . . . . . . . . . . . . . . 206
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 176
Parking lights . . . . . . . . . . . . . . . . . . . . . . . . . . 124
Parking system . . . . . . . . . . . . . . . . . . . . . . . . . 178
Parking system plus . . . . . . . . . . . . . . . . . . . . . 179
Parts replacement . . . . . . . . . . . . . . . . . . . . . . . 212
Passenger See Correct sitting position . . . . . . . . . . 11, 12
Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Petrol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 219 Driving abroad . . . . . . . . . . . . . . . . . . . . . . . 198
Petrol additives . . . . . . . . . . . . . . . . . . . . . . . . . 220 Physical principles of a frontal collision . . . . . . 21
Plastic parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . 206
Plastic parts cleaning . . . . . . . . . . . . . . . . . . . . 209
Pollen filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 158
Pollution filter . . . . . . . . . . . . . . . . . . . . . . . . . . 158
Power steering . . . . . . . . . . . . . . . . . . . . . . . . . . 191
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 88
Products for vehicle maintenance . . . . . . . . . . 203
RRadio frequency remote control . . . . . . . . . . . . 106 Changing the battery . . . . . . . . . . . . . . . . . 107
Radio navigation steering wheel controls Audio + telephone version . . . . . . . . . . . . . . 96
Audio version . . . . . . . . . . . . . . . . . . . . . . . . 96
Rain sensor* . . . . . . . . . . . . . . . . . . . . . . . . . . . 129
Rear fog light Indicator lamp . . . . . . . . . . . . . . . . . . . . . . . . 83
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . 117
Rear interior lights . . . . . . . . . . . . . . . . . . . . . . 126
Rear reading lights . . . . . . . . . . . . . . . . . . . . . . 126
Rear seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Rear shelf . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 147
Rear window automatic wiper/washer . . . . . . 130
Rear window wiper . . . . . . . . . . . . . . . . . . . . . . 130
Recommended gear display . . . . . . . . . . . . . . . . 62
Refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 214
Registration light . . . . . . . . . . . . . . . . . . . . . . . . 266 Remote control key
Buttons . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106
Synchronising . . . . . . . . . . . . . . . . . . . . . . . 107
Removing and fitting the wheel . . . . . . . . . . . . 251
Repairs Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Replacement keys . . . . . . . . . . . . . . . . . . . . . . . 105
Rev counter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Reverse gear Manual gearbox . . . . . . . . . . . . . . . . . . . . . 170
Roll-back function Sliding/tilting sunroof . . . . . . . . . . . . . . . . 116
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . 113
Roof aerial* . . . . . . . . . . . . . . . . . . . . . . . . . . . . 213
Roof rack* . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 147
Rubber seals . . . . . . . . . . . . . . . . . . . . . . . . . . . 207
Run-flat tyres . . . . . . . . . . . . . . . . . . . . . . . . . . . 240
Running in Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
SSafe driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Safe security system . . . . . . . . . . . . . . . . . . . . . 100
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Safety equipment . . . . . . . . . . . . . . . . . . . . . . . . . 7
Safety instructions
Coolant temperature . . . . . . . . . . . . . . . . . . . 83
Safety notes Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Curtain airbags . . . . . . . . . . . . . . . . . . . . . . . 42
Leon_EN.book Seite 302 Mittwoch, 1. September 2010 6:16 18