door lock SSANGYONG MUSSO 2003 User Guide

SECTION 9P
DOORS
Caution: Disconnect the negative battery cable before removing or installing any electrical unit or when a tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable will help prevent personal injury and damage to the vehicle. The ignition must also be in LOCK unless otherwisenoted.TABLE OF CONTENTS
Schematic and Routing Diagrams . . . . . . . . 9P-2 Power Window . . . . . . . . . . . . . . . . . . . . . . . . 9P-2
Maintenance and Repair . . . . . . . . . . . . . . . 9P-3
On-Vehicle Service . . . . . . . . . . . . . . . . . . . . . . 9P-3Front Door . . . . . . . . . . . . . . . . . . . . . . . . . . . 9P-3
Rear Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9P-4
Tail Gate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9P-5

CONTROL UNITS AND SYSTEM 9U-3
FUNCTION DESCRIPTION
STICS Operating Functions
NO.Application Deseription
1 Wiper INT sensing vehicle speed By operating INT time control volume, variable time will be changed within 1.5 - 20 seconds.
2 Washer relating wiper Wiper begins to operate within 0.6 - 1 sec when the washer switch is ON and it operates 3 times after the washer switch is OFF while the IGN2 switch in ON.
3 Dimming room lamp
When room lamp is coupled with door, it turns on if door is opened. After closing the door it maintains 2 seconds of lightingand dims off whithin 3 seconds.
4 Time delayed power window control Power window can be operated within 30 seconds after turning
the IGN1 switch from ON to OFF. If driver ’s/passenger ’s door is
opened within the 30 seconds, time will be prolonged for more 30 seconds from that moment.
5 Rear defogger timer The rear defogger will be operated for 12 min. by turning ON the defogger switch while engine is running.
Defogger will be stopped by pushing the switch again.
The defogger will be operated 6 min, if push ON the switch within10 min. after 12 min. of operation.
6
Seat belt warning The warning lamp will be turned on for about 6 sec. with an intermittent chime bell when the IGN. switch is ON unlessfastening the seat belt.
7 Parking brake warning
The indicator lamp will flash if drive while the parking brake is applied.
8 Tail lamp lighting warning When the driver ’s door is opened while the tail lamp is still ON,
the buzzer operates intermittently. In this condition, the door will be automatically unlocked when it locked.
9 Door ajar warning
The indicator lamp will be blinking when the door is not closed completely and driving.
10 IGN key reminder
The chime will be operated intermittently if the driver ’s door is
opened while the IGN key is still remaining in the ignition switch. In this condition, the door will be automatically unlocked when itlocked.
11 Central door lock All doors will be locked/unlocked by locking/unlocking the driver ’s or passenger ’s door.

9U-4 CONTROL UNITS AND SYSTEM
NO. ApplicationDeseription
13 Ignition key hole illumination
Coupled with door switch, ignition key hole illumination lamp will turn on when the driver ’s door is opened and will dim off after 10
sec. after closing the door.
14 Auto door lock All doors will be locked automatically if the vehicle speed reaches 50km/h though the doors are in unlock.
15 Auto door unlock All doors will be automatically unlocked if the vehicle crashes while driving (over 15km/h).
16 Input checking function Self diagnostic function for each sensor switches and loads for the system.
12 Coupled with REKES Being coupled with REKES (remote keyless entry system), all doors will be locked/unlocked according to signals of transmitter when the ignition key is not inserted.

CONTROL UNITS AND SYSTEM 9U-7
After 1), the driver ’s or passenger ’s door should be
unlocked when it locked.
T1 : within 0.2±5 sec.
T2 : 5±0.5 sec.
9. Door ajar warning T1 : 0.3±0.1 sec.
T2 : 0.3±0.1 sec.V1 : 3 - 5km/h
10. IGN key reminder warning T1 : within 0.2 sec.
T2 : 5±0.5 sec.
T3 : 0.3±0.1 sec.
T4 : 0.3±0.1 sec.
T5 : 0.5±0.1 sec.

9U-8 CONTROL UNITS AND SYSTEM
11. Central door lockT1 : within 0.2 sec.
T2 : 0.5±0.1
12. Coupled with REKES mode T1 : 0.0 5±0.02 sec. (lock signal)
T2 : 0.1±0.02 sec. (unlock signal)
T3 : within 0.2±5 sec.
T4 : 0.5±0.1 sec.T5 : within 0.3 sec.
T6, T7 : 0.5±0.1 sec.
T8 : 1±0.25 sec.
13. Ignition key hole illumination

CONTROL UNITS AND SYSTEM 9U-9
14. Auto door lockV1 : 50±5km/h
T1 : 0.5±0.1 sec.
15. Auto door unlock T1 : 0.5±0.1 sec. V1 : 15km/h

MUSSO-SPORTS 1A-33
SUPPLEMENT
a. CONNECTOR INFORMATION
b. CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
C351
W/H DRIVER
DOOR
C103
W/H MAIN
C101
W/H MAIN
C361
W/H CO-DRIVER
DOOR TWEETER
12345 678910
11 12 13 14 15 16 17 18 19 20 21
68 9
34
5 2
1
11 7
12 13 14
10
16 1720 21 22 18 19
15
68 9
34
5 2
1
11 7
12 13 14
10
16 1720 21 22 18 19
15
Main - Engine Main - Engine Main - Driver DoorMain - Co-Driver Door Main MainMain
C101 (21Pin, Colorless) C103 (2Pin, White) C351 (22Pin, Blue)C361 (22Pin, White) S201 (Black) S202 (Black)G203 Inside The Engine Room Fuse BlockInside The Engine Room Fuse BlockUpper The I/P Fuse Block Inside Co-Driver Side Cowl Panel Behind The ClusterUnder Right The Audio Right The I/P Fuse Block
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESSCONNECTOR POSITION
12
1234 5678
9 101112
13 14 15 16

POSITION OF CONNECTORS AND GROUNDS 2-3
C361 C371C381C401C402C403 22
88626 White
ColorlessColorlessColorlessColorlessColorless Main - Co-Driver DoorFloor - Rear Left DoorFloor - Rear Right DoorFloor - Tail GateFloor - Tail GateFloor - Tail Gate
Inside Co-Driver Side Cowl PanelCenter 'B' PillarCenter Left 'B' PillarBehind The Left LampBehind The Left LampBehind The Left Lamp
2. CONNECTOR, GROUND AND SPLICE PACK INFORMATION
1) CONNECTOR
Connector
Number Connecting Wiring HarnessConnector PositionColorPin
Number
C101 C102C103C104C105C106C107 C108 C109C110C111C112C201C203C204C205 C206
C206B C207 C208C208
C208B C209C210C211C212 C213 C251C301C302C303 C304 C305 C351212 2
15 143 2
16 6
40 6 84
10 33
4 [6]
1616121584
1417 6 3
20 1614 12 6
22 Colorless Colorless
WhiteBlackBlackBlackBlack Black BlackBlackBlack Gray
White
Colorless WhiteBlackBlack Black BlackBlackBlackBlackBlackBlackBlack
White
Colorless Black
White WhiteWhite
Colorless White
Blue Main - Engine Main - EngineMain - EngineEngine - MainEngine - EngineGenerator - EngineGenerator - Engine Genertor - Engine Engine - MainMain - Engine MainEngine Main - ECM MainEngine Main - ECM MainMain - RoofMain Air BagMain - Driver SeatMain - T/MMain - Fuel Tank Main - Fuel Tank Main - T/MMain - T/MMain - T/MMain - T/MMain - T/MMain - T/MDLC Connector - MainMain - Air ConMain - ECM Main Driver Seat - Driver Seat, AUX Main - FloorMain - Floor Main - Floor Main - FloorMain - Floor Main - Driver DoorInside The Engine Room Fuse Block Inside The Engine Room Fuse BlockInside The Engine Room Fuse BlockUnder The Engine Room Fuse BlockBeside Pre-Heating Unit (DSL)Under The Air Cleaner Housing (DSL, Turbo)Under The Air Cleaner Housing (DSL, N/Turbo) Under The Air Cleaner Housing (GSL) Under The Coolant Reservoir TankBehind The ABS Module (HFM)Center The Engine Room Dash PanelCenter The Engine Room Dash PanelUpper The I/P Fuse BlockLeft The AudioUnder The Driver SeatUpper The T/C MotorUpper The T/C (DSL) Upper The T/C (GSL) Upper The T/CUpper The T/C (GSL)Upper The T/C (DSL)Upper The T/C (GSL)Upper The T/C (DSL)Upper The T/C (GSL)Beside The Steering ColumnBehind The Glove BoxBeside The ECM (MSE) Under The Driver Seat Beside The I/P Relay BlockBeside The I/P Relay BlockBeside The I/P Relay Block Inside Co-Driver Side Cowl Panel Beside Center ConsoleUpper The I/P Fuse Block
Connector
Number Connecting Wiring HarnessConnector PositionColorPin
Number
2) GROUND
G101 G102 G103G201 G202 G203G204G205 G206 G207G208 G209 G301G302G303 Ground Position
Wiring Harness
Ground
Number
Behind The Left LampBeside The Start Motor Behind The Right Head Lamp Right The I/P Fuse BlockBeside The STICSUpper The ECM Behind The Ashtray Beside The TCCUBeside The ABS Module Beside THe ECM Under THe CO-Driver SeatBeside The EBCMCenter The Left 'B' Pillar Beside The Left Rear Speaker Beside The Right Rear Speaker
Engine Engine Engine
Main MainMain Main MainMain Main MainMain
Floor Floor Floor
* [ ] : EURO III

POSITION OF CONNECTORS AND GROUNDS 2-9
S204 (DSL/GSL)
S101 (DSL/GSL)
11) SPLICE PACK S202 (DSL/GSL)
S201 (DSL/GSL)
S205 (DSL/GSL)
3 2 1Ef2
80A Ef6
40A
Ef14
15A
WFusible Link Box
Head Lamp Relay (Low) '30' Fog Lamp Relay '30'
Tail Lamp Relay '30'GL
GL
GL GL
GL
1 2 3 4
5 6 7 8
5C204
LW
LW
DLC '2' Stics '29'
EGR Control unit '3' (DLC) Clock '3'VSS '3' F24 (10A)
Seat Warmer Control unit '9'
Stop Lamp Switch '3' (GSL)
LW LW LW LW LW
1 2 3 4
5 6 7 8RY RY RY RY
RYRY RY RYStics '1'
F17 (10A)
Seat belt Switch '3'
Chime Bell '2', Buzzer '3' DLC '14'
Key Reminder Switch '3' Clock '1'
C212 '10' Audio '5'
S203 (DSL/GSL)
1 2 3 4
5 6 7 8
16
Thermo AMP '3'(DSL)
Thermo AMP '4'(GSL)
Rear Wiper/WasherSwitch '8'LW
LW LW
C212
LWF19 (10A)
Blower Relay 'S1'A/C Switch '3'
S401 (DSL/GSL)
1 2 3 4
5 6 7 84
7
Ef10
10A
C212 C101ECS Switch '4'
Rear Wiper/Washer Switch '6'
A/C Control Panel '11' Tail Lamp Relay '87'
Door unlock Switch '4' Defroster Switch '4'
Audio '3', 4WD Switch '7'
Front Cigar Lighter '2'
Seat Warmer Switch '6' Fog Lamp Switch '4'
Hazard Switch '2'Clock '4'GW GW
GW
GW GW
GW
GW GW
1 2 3 4
5 6 7 8BrW BrW BrB YW
BrBBrB BrW LYECM '38'
'37' ECM
TCM 'A23' 'A24' TCM
TOD 'A10' 'A11' TOD
RESISTOR (M/T)
1 2 3 4
8 9
10 11B B
BRear RH Combi Lamp '4' Rear LH Combi Lamp '4'
5 6 7
12 13 14
2
Door lock Actuator '2'
G302B
B B
C402 BRear Wiper Motor '3' High Maunted Stop Lamp '2'
BLicense Lamp '2'
License Lamp '2'

4-2 USAGE AND CAPACITY OF FUSES IN FUSE BOX
60A 80A 80A30A30A40A40A60A60A10A10A15A15A15A15A10A10A30A
Ef1Ef2Ef3Ef4Ef5Ef6Ef7Ef8Ef9
Ef10Ef11Ef12Ef13Ef14Ef15Ef16Ef17Ef18
1. ENGINE ROOM FUSE & RELAY BOX
1) ENGINE ROOM FUSE BLOCK
2) USAGE OF FUSE IN ENGINE ROOM FUSE BOX
* 30 : Battery(+) Power Supply
Front
fog
Lamp
Head
Lamp
(LOW)
Head
Lamp (HI)
Illumination
Relay
Horn
Relay
A/CON C101
C102 C103 S101
Cooling fan-2
Cooling fan-1
Ef10 10ATAIL LAMP LH
Ef11 10ATAIL LAMP RH
Ef12 15AHEAD LAMP LH
Ef13 15AHEAD LAMP RH
Ef14 15AFRT FOG LAMP
Ef15 15ADOOR LOCK
Ef16 10AHORN
Ef17 10AA/CON COMP
Ef18 30ABLOWER
DSL GSL
COMP RESIS
TOR
109876 5432121 20 19 18 17 16 15 14 13 12 11
21
123
12
Ef9 60A
BATT1
Ef8 60ABATT2
Ef7 40AIGNITION SWITCH
Ef6 40A
FUSIBLE LINK
HEADLAMP
Ef5 30ACOOLING FAN
Ef4 30APOWER
WINDOW
2) FUSIBLE LINK FUSE BOX
80A 80A 60A
E
f3Ef2Ef1
3) RELAY TERMINAL NUMBER
8687
8530
S
BL8587a
30
87
86
4PIN RELAY 3PIN RELAY 5PIN RELAY ABS & ABD
Generator
Preheating
Power Window
Cooling FanHead Lamp
Ignition Switch Battery 2 Battery 1
Tail Lamp LH
Tail Lamp RH
Head Lamp LH
Head Lamp RH
Front Fog Lamp Door LockHorn
A/C Compressor
Blower
Fuse No Capacity UsagePower Supply
30 BAT(+)
Illumination(58)
30 BAT(+)