engine SUZUKI NEXA 2015 1.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine 9(+,&/(/2$',1*$1'72:,1*

06(
9(+,&/(/2$',1*$1'72:,1*9HKLFOH/RDGLQJ 
7UDLOHU7RZLQJ 

Downloaded from www.Manualslib.com manuals search engine 9(+,&/(/2$',1*$1'72:,1*
06(
9(+,&/(/2$',1*$1'
72:,1*9HKLFOH/RDGLQJYour vehicle was designed for specific
weight capacities. The weight capacities of
your vehicle are indicated by the Gross
Vehicle Weight Rating (GVWR) and the
Permissible maximum Axle Weight (PAW,
front and rear). The GVWR and PAW (front
and rear) are listed in the “SPECIFICA-
TIONS” section.
GVWR – Maximum permissible overall
weight of the fully loaded vehicle (including
all the occupants, accessories and cargo
plus the trailer nose weight if towing a
trailer).
PAW – (Front and Rear) Maximum permis-
sible weight on an individual axle.
Actual weight of the loaded vehicle and
actual loads at the front and rear axles can
only be determined by weighing the vehi-
cle. Compare these weights to the GVWR
and PAW (front and rear). If the gross vehi-
cle weight or the load on either axle
exceeds these ratings, you must remove
enough weight to bring the load down to
the rated capacity.
7UDLOHU7RZLQJ
:$ 5 1 , 1 *
1HYHU RYHUORDG \RXU YHKLFOH 7KH
JURVV YHKLFOH ZHLJKW VXP RI WKH
ZHLJKWV RI WKH YHKLFOH DOO WKH RFFX
SDQWV DFFHVVRULHV FDUJR SOXV WUDLOHU
QRVH ZHLJKW LI WRZLQJ D WUDLOHU PXVW
QHYHU H[FHHG WKH *URVV 9HKLFOH
:HLJKW 5DWLQJ *9:5 ,Q DGGLWLRQ
QHYHU GLVWULEXWH D ORDG VR WKDW WKH
ZHLJKWRQHLWKHUWKHIURQWRUUHDUD[OH
H[FHHGV WKH 3HUPLVVLEOH PD[LPXP
$[OH:HLJKW3$:
:$ 5 1 , 1 *
$OZD\V GLVWULEXWH FDUJR HYHQO\ 7R
DYRLG SHUVRQDO LQMXU\ RU GDPDJH WR
\RXU YHKLFOH DOZD\V VHFXUH FDUJR WR
SUHYHQW LW IURP VKLIWLQJ LI WKH YHKLFOH
PRYHV VXGGHQO\ 3ODFH KHDYLHU
REMHFWV RQ WKH IORRU DQG DV IDU IRU
ZDUG LQ WKH FDUJR DUHD DV SRVVLEOH
1HYHUSLOHFDUJRKLJKHUWKDQWKHWRS
RIWKHVHDWEDFNV
<RXU YHKLFOH ZDV RULJLQDOO\ GHVLJQHG WR
FDUU\ SHRSOH DQG D QRUPDO DPRXQW RI
FDUJR QRW WR WRZ D WUDLOHU 0$587,
68=8., GRHV QRW UHFRPPHQG \RX XVH
\RXU YHKLFOH WR WRZ D WUDLOHU 7RZLQJ D
WUDLOHU FDQ DGYHUVHO\ DIIHFW KDQGOLQJ
GXUDELOLW\DQGIXHOHFRQRP\

Downloaded from www.Manualslib.com manuals search engine ,163(&7,21$1'0$,17(1$1&(
06(
,163(&7,21$1'0$,17(1$1&(0DLQWHQDQFH6FKHGXOH  
3HULRGLF0DLQWHQDQFH6FKHGXOH  
'ULYH%HOW  
(QJLQH2LODQG)LOWHU  
(QJLQH&RRODQW  
$LU&OHDQHU  
*HDU2LO  
&OXWFK3HGDO  
)XHO)LOWHU  
%UDNHV  
6WHHULQJ  
7LUHV 
%DWWHU\  
)XVHV  
+HDGOLJKW$LPLQJ 
%XOE5HSODFHPHQW  
:LSHU%ODGHV  
:LQGVKLHOG:DVKHU)OXLG  
$LU&RQGLWLRQLQJ6\VWHP  
7

Downloaded from www.Manualslib.com manuals search engine ,163(&7,21$1'0$,17(1$1&(
06(
60A187S
:$ 5 1 , 1 *
<RX VKRXOG WDNH H[WUHPH FDUH ZKHQ
ZRUNLQJ RQ \RXU YHKLFOH WR SUHYHQW
DFFLGHQWDO LQMXU\ +HUH DUH D IHZ SUH
FDXWLRQV WKDW \RX VKRXOG EH HVSH
FLDOO\FDUHIXOWRREVHUYH

Downloaded from www.Manualslib.com manuals search engine 7-2
INSPECTION AND MAINTENANCE
64MS0-74E
Maintenance Schedule Periodic Maintenance
Schedule
“A” :Adjust
“C”: Clean
“R”: Replace or Change
“I”: Inspect, clean, adjust, lubricate or
replace as necessary
“L”: Lubricate
“T”: Tighten to Specified Torque
“O”: Rotate
NOTE:
This table includes services as scheduled
up to 80,000 km mileage. Beyond 80,000
km, carry out the same services at the
same intervals respectively.
WA R N I N G
NOTICE
Whenever it becomes necessary to
replace parts on your vehicle, it is
recommended that you use MARUTI
genuine replacement parts or their
equivalent.
The follow
ing table shows the t
imes when

you should perform regular ma
intenance

on your veh
icle
. Th
is table shows
in
KILOMETERS AND MONTHS WHEN YOU SHOULD
PERFORM INSPECTIONS ADJUSTMENTS LUBRICA
TIONANDOTHERSERVICES
0$587,68=8.,UHFRPPHQGVWKDW
PDLQWHQDQFHRQ\RXUYHKLFOHVKRXOG
EHSHUIRUPHGE\DXWKRULVHG0DUXWL
6X]XNLZRUNVKRS

Downloaded from www.Manualslib.com manuals search engine 7-3INSPECTION AND MAINTENANCE
64MS0-74E
Interval: This interval should be judged by odometer reading
or months, whichever comes first.
FREE INSPECTION
PERIODIC MAINTENANCE AT COST
km (x1000)
1
5
10
20
30
40
50
60
70
80
months
1
6
12
24
36
48
60
72
84
96
Engine
1-1
l
l
l
R
l
R
l
R
l
R
1-2- - RRRRRRRR
1-3
l
l
l
l
l
l
l
l
l
l
1-
))) )) )) )) )
1-
Engine Coolant (Level, Leakage)
Engine oil and engine oil
FILTER
Cooling system hoses and connections (Leakage and Damage)
Engine Mounting and -anifold &ixing.OISE,EAKAGE$AMAGEETC
Exhaust System (Noise, Leakage etc.
-l-l-I-I-l
1-Exhaust Gas Recirculation Valve
D13A engine ----C--C--
FUEL
2-1.
Air cleaner filter element
Paved-road
Clean after 5,000 KM. Replace after every 40,000 KM.
Dusty Condition
Clean after 2,500 KM or as required. Replace after every 40,000 KM.
Replace more frequently if dust condition is severe.
2-2.
Fuel tank cap, fuel lines and connections (Leakage and Damage)
-
l
-
-
-
l
-
-
-
l
2-3.
Fuel Filter and Water Draining
I
l
I
R
I
R
I
R
I
R
CLUTCH AND TRANSMISSION
3-1.
Clutch fluid (level, leakage)
l
l
l
R
l
R
l
R
l
R
3-2.Clutch slipping (Dragging or Excess Damage) llllllllll
3-3.
Manual Transmission/Transfer or Differential Oil (Level, Leakage)
Replace at 1,60,000 km or 10 years whichever comes first
I
I
I
I
I
I
I
I
I
I
DRIVE SHAFT
4-1.
Drive shaft boot (boot damage)
-
l
l
l
l
l
l
l
l
l
BRAKE
5-1.
Brake Fluid (Level, Leakage)
I
I
I
R
I
R
I
R
I
R
5-2. Brake pedal (pedal - wall clearance) I I I I I I I I I I
5-3.
Parking brake lever and cable (Play, damage)
I
I
I
I
I
I
I
I
I
I
5-4.Brake disc and pad (Wear) – I I I I I I I I I

Downloaded from www.Manualslib.com manuals search engine 7-4
INSPECTION AND MAINTENANCE
64MS0-74E
Interval: This interval should be judged by odometer reading
or months, whichever comes first.
FREE INSPECTION
PERIODIC MAINTENANCE AT COST
km (x1000)
1
5
10
20
30
40
50
60
70
80
months
1
6
12
24
36
48
60
72
84
96
5-5.
Brake drum and shoes (Wear)
-
-
I
I
I
I
I
I
I
I
5-6.Master cylinder and wheel cylinder or caliper, brake hoses and pipes (Fluid
leakage, damage)IIIIIIIIII
5-7.
Master cylinder sub assembly, wheel cylinder boot kit & caliper seal set
I
I
I
I
I
R
I
I
I
R
WHEEL
6-1.
Tyres (air pressure, abnormal wear, crack and rotation)
I
I&O
I&O
I&O
I&O
I&O
I&O
I&O
I&O
I&O
6-2. Wheels (Damage) I I I IIIIIII
6-3.
Front/Rear wheel bearing (Loose, damage)
I
I
I
I
I
I
I
I
I
I
FRONT / REAR SUSPENSION
7-1.
Suspension strut (Oil leakage, damage)
I
I
I
I
I
I
I
I
I
I
7-2. Suspension arms / Knuckle support (Loose, damage) – I I I I I I I I I
7-3.
Rear spring (Damage)
I
I
I
I
I
I
I
I
I
I
7-4.Shock absorbers (Oil leakage, damage) I I I I IIIIII
7-5.
All bolts and nuts (Loose)
–
T
T
T
T
T
T
T
T
T
7-6.Torsion rods – I I I I I I I I I
STEERING
8-1.
Steering wheel (Play, loose)
I
I
I
I
I
I
I
I
I
I
8-2.Steering column and tie rods (Loose, damage, wear) I I I I I I I I I I
ELECTRICAL
9-1.
Battery electrolyte (Level, leakage)
I
I
I
I
I
I
I
I
I
I
9-2. Wiring harness connection (Loose, damage) – I I I I I I I I I
9-3.
Lighting system (Operation, stains, damage)
I
I
I
I
I
I
I
I
I
I
9-4.Horn (Operation) IIIIII I II I
9-5.
System Voltage
)
I
I
I
I
I
I
I
I
I
BODY
10-1.
All chassis bolts and nuts (Tighten)
–
I
T
T
T
T
T
T
T
T
10-2. All latches, hinges and locks (Function)) I I&L I&L I&L I&L I&L I&L I&L I&L I&L

Downloaded from www.Manualslib.com manuals search engine 7-5INSPECTION AND MAINTENANCE
64MS0-74E
Interval: This interval should be judged by odometer reading
or months, whichever comes first.
FREE INSPECTION
PERIODIC MAINTENANCE AT COST
km (x1000)
1
5
10
20
30
40
50
60
70
80
months
1
6
12
24
36
48
60
72
84
96
ROAD TEST11-1.
Operation of Brakes, gear shifting and speedometer
I
I
I
I
I
I
I
I
I
I
11-2.
Body and chassis noise
I
I
I
I
I
I
I
I
I
I
AIR CONDITIONER
12-1.
Check belt tension
I
I
I
I
I
I
I
I
I
I
12-2. Tighten compressor mounting bolt – T T T T T T T T T
12-3.
All hose joint (Check, tighten)
I
I
I
I
I
I
I
I
I
I
12-4.Checkfun ctioningof RECIRCULATINGflap I I I I I I I I I I
12-5.
Clean condenser with low pressure water
–
C
C
C
C
C
C
C
C
C
12-6.Check belt for frayed edges I I I I I I I I I I
12-7.
Check all mounting bolts
I
I
I
I
I
I
I
I
I
I
12-8. Air conditioner filter element I I I I R I I R I I

Downloaded from www.Manualslib.com manuals search engine 
,163(&7,21$1'0$,17(1$1&(
06(
'ULYH%HOW7KH EHOWV VKRXOG EH H[DPLQHG WR HQVXUH
WKDW WKH\ DUH QRW GDPDJHG 7KH GULYH EHOW

Downloaded from www.Manualslib.com manuals search engine ,163(&7,21$1'0$,17(1$1&(
06(
2LO/HYHO&KHFN
84E012
(1) MIN
(2) MAX
(3) Engine oil dipstick
It is important to keep the engine oil at the
correct level for proper lubrication of your
vehicle’s engine. Check the oil level with
the vehicle on a level surface. The oil level
indication may be inaccurate if the vehicle
is on a slope. The oil level should be
checked either before starting the engine
or at least 5 minutes after stopping the
engine.
The handle of the engine oil dipstick is col-
ored yellow for easy identification.
Pull out the oil dipstick, wipe oil off with a
clean cloth, insert the dipstick all the way
into the engine, then remove it again. The
oil on the stick should be between the
upper and lower limits shown on the stick.
If the oil level indication is near the lowerlimit, add enough oil to raise the level to
the upper limit.
5HILOOLQJ
81A147
Remove the oil filler cap and pour oil slowly
through the filler hole to bring the oil level to
the upper limit on the dipstick. Be careful not
to overfill. Too much oil is almost as bad as
too little oil. After refilling, start the engine
and allow it to idle for about a minute. Stop
the engine, wait about 5 minutes and check
the oil level again.
(2) (1)(3)
NOTICE
)DLOXUHWRFKHFNWKHRLOOHYHOUHJXODUO\
FRXOG OHDG WR VHULRXV HQJLQH WURXEOH
GXHWRLQVXIILFLHQWRLO
NOTICE
'RQRWWRSXSWKHRLORYHUWKH
0$;OLPLW7RRPXFKRLOFDXVHV
VHULRXVHQJLQHWURXEOH
Close Open
(;$03/(