fuses SUZUKI NEXA 2015 1.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine 0-5
WARRANTY POLICYMaruti Suzuki India Limited (hereinafter called “Maruti Suzuki”),
warrants that each new Maruti Suzuki vehicle distributed in India
by Maruti Suzuki and sold by an authorised Maruti Suzuki
N%8!dealer will be free, under normal use and service,
from anydefects in material and workmanship at the time of
manufactureSUBJECT TO THE FOLLOWING TERMS AND
CONDITIONS:
TheMarutiSuzuki vehicle must be delivered byan authorised
MarutiSuzuki N%8! dealer and serviced by DXWKRULVHG 0DUXWL
6X]XNLZRUNVKRS(2) Term:The term of the warranty shall be twenty-four (24) months or
40,000 kilometers (whichever occurs first) from the date of
delivery to the first owner.(3) Maruti Suzuki Warranty Obligation:If any defect(s) should be found in the vehicle within the term stip-
ulated above, Maruti Suzuki’s only obligation is to repair or replace
at its sole discretion any part shown to be defective, with a new
part or the equivalent at no cost to the owner for parts or labour,
when Maruti Suzuki acknowledges that such a defect is attribut-
able to faulty material or workmanship at the time of manufacture.
The owner is responsible for any repair or replacements which are
not covered by this warranty.
(4) Limitation:This warranty shall not apply to:
(a) Normal maintenance service required other than the three
free services, including without limitation, oil and fluid
changes, headlight aiming, fastener retightening, wheel bal-
ancing, wheel alignment and tyre rotation, cleaning of injec-
tors, adjustment of clutch and valve clearance.
(b) The replacement of normal wear parts including without lim-
itation, bulbs, tyres and tubes, spark plugs, belts, hoses, fil-
ters, wiper blades, brushes, contact points, fuses, clutch
disc, brake shoes, brake pads, cable and all rubber parts
(except oil seal and glass run).
(c) Any vehicle which has been used for competition or racing.
(d) Any repairs or replacement required as a result of accidents
or collision.
(e) Any defects caused by misuse, negligence, abnormal use or
insufficient care.
(f) Any vehicle which has been modified or altered, including
without limitation, the installation of performance accesso-
ries.
(g) Any vehicle on which parts or accessories not approved by
Maruti Suzuki have been used.
(h) Any vehicle which has not been operated in accordance with
the operating instructions in this Owner’s Manual and Ser-
vice Booklet.
(i) Any vehicle which has not received, during the warranty term,
the service inspections prescribed in this Owner’s Manual
and Service Booklet.
(j) Any vehicle which has been assembled, disassembled,
adjusted or repaired by other than authorised Maruti Suzuki
workshop.
(k) Any vehicle which has been usedfor purposes otherthan
what it was designed for.
(l) Any damage or deterioration caused by industrial pollution
and bird droppings.
(1) Qualification:To qualify for thiswarranty:

Downloaded from www.Manualslib.com manuals search engine 
,163(&7,21$1'0$,17(1$1&(
06(
51KM039
To remove the battery:
1) Disconnect the negative cable (1).
2) Disconnect the positive cable (2).
3) Remove the bracket bolt (3) and
remove the bracket (4).
4) Remove the battery.
To install the battery:
1) Install the battery in the reverse order of
removal.
64MS176
NOTE:
When putting the battery in the battery tray,
make sure the recess on the terminal side
bottom of the battery engages with the
convex portion of the tray.
2) Tighten the bracket bolt and battery
cables securely.
NOTE:
When the battery is disconnected, some of
the vehicle’s function will be initialized and/
or deactivated.
These function are required to reset after
the battery is reconnected.
)XVHVYour vehicle has three types of fuses, as
described below:
0DLQIXVH
The main fuse takes current directly from
the battery.
3ULPDU\IXVHV
These fuses are between the main fuse
and individual fuses, and are for electrical
load groups.
,QGLYLGXDOIXVHV
These fuses are for individual electrical cir-
cuits.
To remove a fuse, use the fuse puller (1)
provided in the fuse cover.
64MS198
(1)
(2)
(3)
(4)
(;$03/(
(;$03/(
(1)

Downloaded from www.Manualslib.com manuals search engine ,163(&7,21$1'0$,17(1$1&(
06(
)XVHVLQWKH(QJLQH&RPSDUWPHQW
61MM0B068
64MS177
The main fuse, primary fuses and some of the
individual fuses are located in the engine
compartment. If the main fuse blows, no elec-
trical component will function. If a primary fuse
blows, no electrical component in the corre-
sponding load group will function. When
replacing the main fuse, a primary fuse or an
individual fuse, use a 0DUXWL *HQXLQH3DUWTo
remove a fuse, use the fuse puller provided in
the fuse box. The amperage of eachfuse is
shown in the back of the fuse boxcover.
(6)
(7) (1)
(2)
(3)
(4)
(5)
(8)
(9)
(10)
(11)
(12)
(13)
(14)
(15)
(16)
(17)(18)
(19)
(20)
(21)
(22)
(23)(24)
(25)
(26)
(27)
(28)(29)
(30)
(31)
(32)
(33)
(34)
(35)
0$,1)86(35,0$5<)86(
(1) 60 A FL7
(2) 80 A FL6
(3)
100 A
FL5
(4)
80 A
FL4
(5)
100 A
FL3
(6)
100 A
FL2
(7)
120 A
FL1
(8) 7.5 AIgnition-1 signal 2 (D16AA)
(9) 30 A Radiator fan 2
(10) 20 A Front fog light
(11) 7.5 A Headlight 2
(12) 25 A ABS control module
(13) 25 A Headlight
(14) 30 A Back up
(15) 40 A Ignition switch
(16) 40 A ABS motor
(17) 30 A Starting motor
(18) 30 A Radiator fan
(19) 30 A FI main
(20) 20 A Fuel pump
(21) 10 A Air compressor
(22) 7.5 A ECM (D13A)
(23) 30 A Blower fan
(24) 10 A FI 2 (D13A)
(25) 20 A INJ DRV (D13A)
(26) 7.5 A Starting signal
(27) 15 A Headlight (Left)
(28) 15 A Headlight high (Left)
(29) 7.5 A FI 2 (D16AA)
(30) 20 A INJ DRV (D16AA)
(31) 15 A FI 3 (D16AA)
(32) 15 A Headlight (Right)
(33) 15 A Headlight high (Right)
(34) 50 A Ignition switch 2
(35) 50 A Battery

Downloaded from www.Manualslib.com manuals search engine 
,163(&7,21$1'0$,17(1$1&(
06(
60G111
NOTE:Make sure that the fuse box always carries
spare fuses.
)XVHVXQGHUWKH'DVK%RDUG
64MS181
64MS112
NOTE:
To approach the fuses, remove the clips
(1) by prying it off with a flat blade screw-
driver as shown in the illustration, then
remove the cover (2).
68LM701
:$ 5 1 , 1 *
,IWKHPDLQIXVHRUDSULPDU\IXVH
EORZVEHVXUHWRKDYH\RXUYHKLFOH
LQVSHFWHGE\DQ DXWKRULVHG 0DUXWL
6X]XNL ZRUNVKRS$OZD\VXVHD
0DUXWL *HQXLQH 3DUW 1HYHU XVH D
VXLWDEOH VXFK DV D ZLUH HYHQ IRU D
WHPSRUDU\ UHSDLU RU H[WHQVLYH
HOHFWULFDOGDPDJHDQGDILUHFDQUHVXOW
OK
BLOWN
(;$03/(
(1)
(2) (1)
(1)
(12)(10)
(13)
(36) (2) (3) (4)
(5) (6) (7) (8) (9)
(11) (14) (15)
(16) (17) (18) (19) (20) (21) (22)
(23) (24) (25) (26) (27) (28) (29)
(30) (31) (32) (33) (34) (35)
(;$03/(

Downloaded from www.Manualslib.com manuals search engine 63(&,),&$7,216
06(
,7(0(QJLQH
Type D13A (DOHC) D16AA (DOHC)
Number of cylinders 4 4
Bore 69.6 mm 79.5 mm
Stroke 82.0 mm 80.5 mm
Piston displacement 1248 cm
3
1598 cm
3
Compression ratio 17.6 : 1 16.5 : 1
,7(0(OHFWULFDO
Battery D13A DIN55L
D16AA DIN65L
Fuses See “INSPECTION AND MAINTENANCE” section.