TOYOTA AYGO 2011 Owners Manual

SPECIFICATIONS291
Section 8
SPECIFICATIONS
DDimensions 292...........................................
DWeights 293...............................................
DEngine 294................................................
DFuel 294..................................................
DService specifications 294..................................
DTires 299.................................................
DFuses 300................................................
AYGO WE 99E37E11 02.18

292SPECIFICATIONS
Dimensions
mm (in.):
Overall length
3415 (134.4)
Overall width1615 (63.6)
Overall height1465 (57.7)
Wheelbase2340 (92.1)
Front tread1420 (55.9)
Rear tread1410 (55.5)
AYGO WE 99E37E11 02.18

SPECIFICATIONS293
Weights
kg (lb.):
Model
∗Gross vehicle mass
(GVM)
Maximum permissible axle
capacity (MPAC)
Model(GVM)FrontRear
KGB10L−AGMRKW1180 (2601)695 (1532)695 (1532)
KGB10R−AGMRKW1180 (2601)695 (1532)695 (1532)
KGB10L−AGMGKW1180 (2601)695 (1532)695 (1532)
KGB10R−AGMGKW1180 (2601)695 (1532)695 (1532)
KGB10L−AHMRKW1190 (2623)695 (1532)695 (1532)
KGB10R−AHMRKW1190 (2623)695 (1532)695 (1532)
KGB10L−AHMGKW1190 (2623)695 (1532)695 (1532)
KGB10R−AHMGKW1190 (2623)695 (1532)695 (1532)
KGB10L−AGGGKW1180 (2601)695 (1532)695 (1532)
KGB10L−AHGGKW1190 (2623)695 (1532)695 (1532)
KGB10R−AGGGKW1180 (2601)695 (1532)695 (1532)
KGB10R−AHGGKW1190 (2623)695 (1532)695 (1532)
∗: The model code appears on the manufacturer ’s plate with the heading “MODEL”.
See “Your Toyota’s identification” on page 206 in Section 2 for the manufacturer ’s
label location.
AYGO WE 99E37E11 02.18

294SPECIFICATIONS
Engine
Model:
1KR−FE
Type:
3 cylinder in line, 4cycle, gasoline
Bore and stroke, mm (in.):
71.0×84.0 (2.79×3.30)
Displacement, cm
3(cu. in.):
998 (60.9)
Fuel
Fuel type:
EU area:
Unleaded gasoline conforming to Euro-
pean standard EN228, Research Oc-
tane Number of 95 or higher
Except EU area:
Unleaded gasoline, Research Octane
Number of 95 or higher
Fuel tank capacity, L (gal., lmp. gal.):
35 (9.2, 7.7)
Service specifications
ENGINE
Valve clearance (engine cold), mm (in.):
Intake 0.145—0.235 (0.006—0.009)
Exhaust 0.275—0.365 (0.011—0.014)
Spark plug type:
DENSO K16HR−U11
Spark plug gap, mm (in.):
1.1 (0.043)
Drive belt deflection with 98 N (10 kgf, 22
lbf) thumb force (used belt), mm (in.):
9.0—11.0 (0.35—0.43)
AYGO WE 99E37E11 02.18

SPECIFICATIONS295
MS81001
Generator
Water
pump
Crankshaft
Generator
Water
pump
Crankshaft
Air conditioning
compressor
ENGINE LUBRICATION
Oil capacity (drain and refill), L(qt., Imp.
qt.):
With filter 3.3 (3.5, 2.9)
Without filter 3.1 (3.3, 2.7)
Your Toyota vehicle is filled with “Toyota
Genuine Motor Oil” at the factory. Toyota
recommends the use of approved “Toyota
Genuine Motor Oil”. Another motor oil of
matching quality can also be used.
Oil grade:
0W−20, 5W−20, 5W−30 and 10W−30:
API grade SL “Energy−Conserving”,
SM “Energy−Conserving” or ILSAC
multigrade engine oil
15W−40 and 20W−50:
API grade SL or SM multigrade engine
oil
Recommended viscosity (SAE):
SOIL35
Temperature range anticipated before
next oil change.Preferred
Please contact any authorized Toyota
dealer or repairer, or another duly quali-
fied and equipped professional, for further
details.
AYGO WE 99E37E11 02.18

296SPECIFICATIONS
COOLING SYSTEM
Total capacity, L (qt., Imp. qt.):
0Q07
∗
4.4 (4.6, 3.9)
0Q01, 0Q02∗
4.0 (4.2, 3.5)
∗: The identification code are stamped on
the locations shown in the below il-
lustration.
MS81013
On the back side
Coolant type:
Your Toyota vehicle is filled with “Toyota
Super Long Life Coolant” at the factory.
In order to avoid technical problems,
only use “Toyota Super Long Life
Coolant” or similar high quality ethylene
glycol based non−silicate, non−amine,
non−nitrite, and non−borate coolant with
long−life hybrid organic acid technology.
(Coolant with long−life hybrid organic
acid technology is a combination of low
phosphates and organic acids.)
Do not use plain water alone.
BATTERY
Open voltage
∗at 20_C(68_F):
12.6—12.8 V Fully charged
12.2—12.4 V Half charged
11.8—12.0 V Discharged
∗: Voltage that is checked 20 minutes af-
ter the key is removed with all the
lights turned off
Charging rates:
5Amax.
CLUTCH
Pedal free play, mm (in.):
18—28 (0.7—1.1)
AYGO WE 99E37E11 02.18

SPECIFICATIONS297
MANUAL TRANSAXLE
Oil capacity, L (qt., Imp. qt.):
1.7 (1.8, 1.5)
Oil type:
TOYOTA Genuine Manual Transmission
Gear Oil LV API GL−4
Recommended oil viscosity:
SAE 75W
Change manual transmission gear oil
only as necessary.
Generally, it is necessary to change
manual transmission gear oil only if your
vehicle is driven under one of the
Special Operating Conditions listed in
your “Toyota Service Booklet” or “Toyota
Warranty Booklet”. When changing the
manual transmission gear oil, use only
“TOYOTA Genuine Manual Transmission
Gear Oil LV API GL−4 SAE 75W” to aid
in assuring optimum transmission
performance.
Notice: Using manual transmission
gear oil other than “TOYOTA Genuine
Manual Transmission Gear Oil LV API
GL−4 SAE 75W” may cause occur-
rence of idle rattling noise and bad
fuel consumption.
Please contact any authorized Toyota
dealer, or repairer or another duly quali-
fied and equipped professional, for fur-
ther details.MULTI−MODE MANUAL TRANSAXLE
Oil capacity, L (qt., Imp. qt.):
1.7 (1.8, 1.5)
Oil type:
TOYOTA Genuine Manual Transmission
Gear Oil LV API GL−4
Recommended oil viscosity:
SAE 75W
Change manual transmission gear oil
only as necessary.
Generally, it is necessary to change
manual transmission gear oil only if your
vehicle is driven under one of the
Special Operating Conditions listed in
your “Toyota Service Booklet” or “Toyota
Warranty Booklet”. When changing the
manual transmission gear oil, use only
“TOYOTA Genuine Manual Transmission
Gear Oil LV API GL−4 SAE 75W” to aid
in assuring optimum transmission
performance.
Notice: Using manual transmission
gear oil other than “TOYOTA Genuine
Manual Transmission Gear Oil LV API
GL−4 SAE 75W” may cause occur-
rence of idle rattling noise and bad
fuel consumption.
Please contact any authorized Toyota
dealer, or repairer or another duly quali-
fied and equipped professional, for fur-
ther details.
AYGO WE 99E37E11 02.18

298SPECIFICATIONS
BRAKES
Minimum pedal clearance when depressed
with a force of 490 N (50 kgf, 110 lbf)
with the engine running, mm (in.):
Left−hand drive vehicle
84 (3.3)
Right−hand drive vehicle
77 (3.0)
Pedal free play, mm (in.):
1—6 (0.04—0.24)
Parking brake adjustment when pulled with
the force of 196 N (20 kgf, 44 lbf):
5—8 clicks
Fluid type:
SAE J1704 or FMVSS No.116 DOT 4
STEERING
Wheel free play:
Less than 30 mm (1.2 in.)
AYGO WE 99E37E11 02.18

SPECIFICATIONS299
Tires
Tire size and cold tire inflation pressure:
For driving at 160 km/h (100 mph) or over
kPa (kgf/cm
2or bar, psi)
Tire size
For driving under 160 km/h
(100 mph)For driving at 160 km/h
(100 mph) or over
Tiresize
FrontRearFrontRear
155/65R14 75T220 (2.2, 32)220 (2.2, 32)230 (2.3, 34)230 (2.3, 34)
Wheel bolts torque, N·m (kgf·m, ft·lbf):
103 (10.5, 76)
NOTE: For complete information on tires (e.g. replacing tires or replacing wheels), see
“Checking tire inflation pressure” through “Aluminum wheel precautions”, pages
269 through 275, in Section 7−2.
AYGO WE 99E37E11 02.18

300SPECIFICATIONS
Fuses
MS81007a
Engine room R/B (top side)
MS81012a
Engine room R/B (back side)
MS81008a
Instrument panel J/B (left side)
MS81009a
Instrument panel J/B (right side)
MS81010a
Instrument panel J/B (back side)
AYGO WE 99E37E11 02.18