engine TOYOTA CAMRY 1994 XV10 / 4.G Wiring Diagrams Owners Manual

225
A21 AUTO ANTENNA MOTOR AND RELAY
9±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ON POSITION
5±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ACC OR ON POSITION
7±GROUND : ALWAYS APPROX. 12 VOLTS
8±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ACC OR ON POSITION AND RADIO SW ON
3±GROUND : CONTINUITY (UPPER LIMIT SW ON) UNLESS ANTENNA AT UP STOP
2±GROUND : CONTINUITY (DOWN LIMIT SW ON) UNLESS ANTENNA AT DOWN STOP
4±3 : CLOSED WITH IGNITION SW AT ACC OR ON POSITION AND RADIO SW ON AND PLAYER SW OFF UNTIL ANTENNA
AT UPPERMOST POSITION
1±2 : CLOSED WITH IGNITION SW AT ACC OR ON POSITION AND RADIO SW OFF AND PLAYER SW OFF UNTIL ANTENNA
AT LOWERMOST POSITION
1±2 : CLOSED WITH IGNITION SW OFF UNTIL ANTENNA AT LOWERMOST POSITION
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
A2136 (W/G)J 536 (W/G)R 333
J 333R 233S 833
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1C20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1H20FLOOR NO. 1 WIRE J/B NO. 1 (INSTRUMENT PANEL LEFT)
1L20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
2G22COWL WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
II242INSTRUMENT PANEL WIRE AND COWL WIRE
IM242INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE
IG142FLOOR NO. 1 WIRE AND INSTRUMENT PANEL WIRE
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
46 (S/D)
BL48 (C/P)UNDER THE LEFT QUARTER PILLARBL
50 (W/G)
UNDER THE LEFT QUARTER PILLAR
12
345 6
3
8X
3
89X
X9 A21R2
R3 S8BLUECC CC
CC C C CCJ5
BB BBJ3
B B
(
HINT : SEE PAGE 7)1
(
HINT : SEE PAGE 7)
SERVICE HINTS

227
S 8(A), S 9(B) STEREO COMPONENT AMPLIFIER
(A) 7±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ON OR ACC POSITION
(B) 7±GROUND : ALWAYS CONTINUITY
(B)10±GROUND : ALWAYS APPROX. 12 VOLTS
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
F1028 (1MZ±FE), 30 (5S±FE)J 333S 8A33
F1134 (S/D), 35 (C/P)R 233S 9B33
F1234 (S/D), 35 (C/P)R1234 (S/D), 35 (C/P)
F1334 (S/D), 35 (C/P)R1334 (S/D), 35 (C/P)
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1C
1K20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1L
20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
2G22COWL WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
IG142FLOOR NO. 1 WIRE AND INSTRUMENT PANEL WIRE
IH142FRONT DOOR LH WIRE AND INSTRUMENT PANEL WIRE
II242INSTRUMENT PANEL WIRE AND COWL WIRE
IM142INSTRUMENT PANEL WIRE AND CONSOLE BOX WIREIM242INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE
IT244FRONT DOOR RH WIRE AND INSTRUMENT PANEL WIRE
IU144FLOOR NO. 2 WIRE AND INSTRUMENT PANEL WIRE
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
IH42INSTRUMENT PANEL BRACE RH
: SPLICE POINTS
CODESEE PAGEWIRE HARNESS WITH SPLICE POINTSCODESEE PAGEWIRE HARNESS WITH SPLICE POINTS
I1544CONSOLE BOX WIRE
1
212B B A A
AABBBB
134 567
8 X 11 12 13 14 1521
6 4 3 X 1
7X9101112 145
1312
534
678910 AB F10, F11 F12, F13 J 3 R 2 R12, R13
S8 S9(
HINT : SEE PAGE 7)BLUE BLACK
SERVICE HINTS

229
R 3(B) RADIO AND PLAYER
(B) 3±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ON OR ACC POSITION
(B) 4±GROUND : ALWAYS APPROX. 12 VOLTS
(B) 7±GROUND : ALWAYS CONTINUITY
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
F1028 (1MZ±FE), 30 (5S±FE)R 3B33R1334 (S/D), 35 (C/P)
F1134 (S/D), 35 (C/P)R 4A33
J 333R1234 (S/D), 35 (C/P)
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1C
1K20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1L
20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
2G22COWL WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
IG142FLOOR NO. 1 WIRE AND INSTRUMENT PANEL WIRE
IH142FRONT DOOR LH WIRE AND INSTRUMENT PANEL WIRE
II242INSTRUMENT PANEL WIRE AND COWL WIRE
IT244FRONT DOOR RH WIRE AND INSTRUMENT PANEL WIRE
IU144FLOOR NO. 2 WIRE AND INSTRUMENT PANEL WIRE
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
IH42INSTRUMENT PANEL BRACE RH
1
2B B A A
AABBB B12 34
5678912
3X 6
21 F10, F11 J 3R12, R13 BA R3 R4BLUE BLUE
(
HINT : SEE PAGE 7) BLACK
SERVICE HINTS

232
RADIO AND PLAYER (W/G 8 SPEAKER)
S 8(A), S 9(B) STEREO COMPONENT AMPLIFIER
(A) 7±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ON OR ACC POSITION
(B) 7±GROUND : ALWAYS CONTINUITY
(B)10±GROUND : ALWAYS APPROX. 12 VOLTS
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
F1136 (W/G)J 536R1536 (W/G)
F1236 (W/G)R 233S 8A33
F1336 (W/G)R1236 (W/G)S 9B33
F1436 (W/G)R1336 (W/G)
J 333R1436 (W/G)
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1C
1K20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1L
20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
2G22COWL WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
IG142FLOOR NO. 1 WIRE AND INSTRUMENT PANEL WIRE
IH142FRONT DOOR LH WIRE AND INSTRUMENT PANEL WIRE
II242INSTRUMENT PANEL WIRE AND COWL WIRE
IM142INSTRUMENT PANEL WIRE AND CONSOLE BOX WIREIM242INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE
IT244FRONT DOOR RH WIRE AND INSTRUMENT PANEL WIRE
Bb150 (W/G)LUGGAGE ROOM NO. 1 WIRE AND FLOOR NO. 1 WIRE
Bc350 (W/G)BACK DOOR NO. 1 WIRE AND FLOOR NO. 1 WIRE
Bd150 (W/G)BACK DOOR NO. 1 WIRE AND BACK DOOR NO. 2 WIRE
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
IH42INSTRUMENT PANEL BRACE RH
: SPLICE POINTS
CODESEE PAGEWIRE HARNESS WITH SPLICE POINTSCODESEE PAGEWIRE HARNESS WITH SPLICE POINTS
I1544CONSOLE BOX WIRE
SERVICE HINTS

233
RADIO AND PLAYER (W/G 6 SPEAKER)
R 3(B) RADIO AND PLAYER
(B) 3±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ON OR ACC POSITION
(B) 4±GROUND : ALWAYS APPROX. 12 VOLTS
(B) 7±GROUND : ALWAYS CONTINUITY
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
F1136 (W/G)R 3B33R1436 (W/G)
F1236 (W/G)R 4A33R1536 (W/G)
J 333R1236 (W/G)
J 536R1336 (W/G)
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1C
1K20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1L
20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
2G22COWL WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
IG142FLOOR NO. 1 WIRE AND INSTRUMENT PANEL WIRE
IH142FRONT DOOR LH WIRE AND INSTRUMENT PANEL WIRE
II242INSTRUMENT PANEL WIRE AND COWL WIRE
IT244FRONT DOOR RH WIRE AND INSTRUMENT PANEL WIRE
IU144FLOOR NO. 2 WIRE AND INSTRUMENT PANEL WIRE
Bb150 (W/G)LUGGAGE ROOM NO. 1 WIRE AND FLOOR NO. 1 WIRE
Bc350 (W/G)BACK DOOR NO. 1 WIRE AND FLOOR NO. 1 WIRE
Bd150 (W/G)BACK DOOR NO. 1 WIRE AND BACK DOOR NO. 2 WIRE
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
IH42INSTRUMENT PANEL BRACE RH
SERVICE HINTS

236
COMBINATION METER
AB
IJ1 5IJ111 IJ118
BX1 3 BX1 2 BX1 1 IP3 2
IP3 6
IP1 8IP 3 11 IP314
IP3 5
IP3 161
ED1 A 4
A 8A7A6A 5A12 B 11 B7B10 C 8C7C 4
123
23
4
1 I9
I9 C C
6 FROM POWER SOURCE SYSTEM(
SEE PAGE 64)
R±L
R±L R±L R±L
BRY±L Y±R
BR BR BR Y±L Y±R Y±R
Y±L
BR
BR BR
B Y±G
BY±G
B
P
LG GG±B
G±B G±B
R±W
Y±B Y±BV±Y
R±L JUNCTION
CONNECTOR
BR
BR
FROM E NGINE CONTROL MODULE
(
E NGINE A ND E LE CTRONIC CONTROLLED
TRANSMISSION ECU)(
A/T)
FROM E NGINE CONTROL MODULE
(
ENGINE ECU)(
M/T)
FROM CRUISE CONTROL ECU
SPEEDFUEL
FUEL
WATER TEMP.
TA CHO
ABS
SEAT BELT
OIL
FUEL SENDER
WATER TEMP.
SENDER
IGNITER
VEHICLE SPEED
SENSOR
(
SPEED SENSOR)
TO AB S ECU
TO INTEGRATION
RELAY
OIL P RES SURE
SW
J2
B
W2
I2
V5
O1F1 5C
COMBINATION METER C8 ,C9 , C10
TO BACK±UP LIGHT SW(
M/T)
TO PARK/NEUTRAL POSITION SW
(
NEUTRAL START SW)(
A/T)
TO GENERA TOR(
ALTERNATOR) R±L
R±L
I18 6
TA C
COOLING FAN
ECU C14
BR
B
B JUNCTION CONNECTOR J7
(
*6) (
*6)
(
*7)A
A
(
*7)
(
*6)
1B 6 1D 610A
GAUGE
3D 13
3D 12
1D 121D 13
3C 133C 12

237
*
1 : W/O A/T INDICATOR LIGHT
* 2 : W/ A/T INDICATOR LIGHT
*
3 : MALFUNCTION INDICATOR LAMP
(
CHECK ENGINE WARNING LIGHT)
*7 : 5S±FE *
6 : 1MZ±FE * 5 : TMM MADE
*
4:TMCMADE
AB
C
COMBINATION METER1
IEIF 2 1B 15 B3B9B13
B 12B 8B14 C 1 C 3 A 9A 10C 2
II1 4
11B DE 18 A
FB E D
8 A
FAFROM POWER SOURCE SYSTEM(
SEE PAGE 64)
B±W
R±Y
R±GW±R Y±G B±W
B±O G± L
G±R
R±Y R±Y W±BG±RG± L
±B W±B
R±W R±W
R±W
G±O
Y
B±Y
R±BB±YY G±O R±Y
R±Y
R±W 10A
STARTER
TO LIGHT FAILURE
SENSOR
FROM º HEAD RHº FUSE
FROM º HEAD(
UP R±RH)
ºFUSE
(
CA NADA) (
USA) CRUISE
(
*3)
BRAKE
BULB
CHECK
RE AR LIGHT
O/D OFF
CHARGE
SRS
HIGH BEAM
PKB BRK
TOO/DMAINSW
TO GENERATOR(
ALTERNATOR)
TO CENTER AIRBAG
SENSOR ASSEMBLY
TO DIMMER SW
[COMB. SW] TO CRUISE CONTROL ECU
TO E NGINE CONTROL MODULE
(
ENGINE AND ELECTRONIC CONTROLLED
TRANSMISSION ECU)(
A/T)
TO E NGINE CONTROL MODULE
(
ENGINE ECU)(
M/T)
BRAKE FLUID
LEVEL SWJUNCTION
CONNECTOR
JUNCTION
CONNE CTOR
DAYTIME RUNNING
LIGHT RELAY
(
MAIN) PARKING
BRAKE SW
PARKING
BRAKE SW(
EX. 1MZ±FE A/T)
(
1MZ±FE A/T)
JUNCTION
CONNECTOR
JUNCTION
CONNECTOR (
USA)
(
CANA DA) C8 ,C9 , C10
J2
J2 B2
P3
P2 D4
J2
J3(
*1) (
*1)
(
USA)
II1 2
I6
G±O
G±O G±O
(
*2) FROM A/T
INDICATOR LIGHT
W±B
(
CA NADA)(
*5) (
*5)
O
(
*4)O
(
*4)
4
3B 203C 2
1D 31F3 7. 5A
IGN7. 5A
SRS
3B 19 3D19 3B 83D18
3D 83C8 3A 10
1M 51C 8
W

238
COMBINATION METER* 1 : W/O A/T INDICATOR
AB
A 11 A2A1
A 3
C13 B5 B 16
IGB 4
G
R R RG±B G±YL±R
R±YW±BB B
W±B W±B
GG
FROM ELECTRONIC
CONTROLLED
TRANSMISSION PATT
SELECT SW
FROM HA ZA RD S W(
TR)
FROM HA ZA RD S W(
TL) METER
ILLUMINATION
POWER
TURN RH
TURN LH
OPEN DOOR TO RHEOSTAT
TO DOOR COURTESY SW
COMBINATION METER C8 ,C9 ,C10AI13 II16
TO E NGINE CONTROL
MODULE(
ENGINE AN
ELECTRONIC CONTRO
TRANSMISSION ECU)
L±R
L±R L±R
(
*1)
(
*1)
2G 220A
DOME
G
15A
TA IL
1D 14
3C 4
3D 5
3D 203D 9
1C 5
3A 161C 1
3C 14
1D10
1D11
1L 83C183D 6 1D 2
1M 11C 11
FROM POWER SOURCE SYSTEM(
SEE PAGE 64)
ERN
D
LLED

239
B 2 BRAKE FLUID LEVEL SW1±2 : CLOSED WITH FLOAT DOWN
C 8(A), C 9(B), C10(C)
COMBINATION METER(A)2, (B)6, (B)9±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ON POSITION
(A)3, (B)14, (C)8±GROUND : ALWAYS CONTINUITY
F15
FUEL SENDER2±3 : APPROX. 3
WITH FUEL FULL
APPROX. 110.0
WITH FUEL EMPTY
O 1
OIL PRESSURE SW1±GROUND : CLOSED WITH OIL PRESSURE BELOW 0.2 KG/CM2 (2.84 PSI, 19.61 KPA)
P 2
PARKING BRAKE SW (1MZ±FE A/T)1±GROUND : CLOSED WITH PARKING BRAKE PEDAL DEPRESSED
P 3
PARKING BRAKE SW (EX. 1MZ±FE A/T)1±GROUND : CLOSED WITH PARKING BRAKE LEVER PULLED UP
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
B 228 (1MZ±FE), 30 (5S±FE)D 432P 233
C 8A32F1534 (S/D), 35 (C/P), 36 (W/G)P 333
C 9B32I 228 (1MZ±FE), 30 (5S±FE)V 528 (1MZ±FE), 30 (5S±FE)
C10C32J 233W 228 (1MZ±FE), 30 (5S±FE)
C1432O 128 (1MZ±FE), 30 (5S±FE)
: RELAY BLOCKS
CODESEE PAGERELAY BLOCKS (RELAY BLOCK LOCATION)
125R/B NO. 1 (LEFT KICK PANEL)
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1B
1C
1D20COWL WIRE AND J/B NO 1 (INSTRUMENT PANEL LEFT)1F20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1L
1M
2G22COWL WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
3A
3B24COWL WIRE AND J/B NO 3 (BEHIND COMBINATION METER)3C24COWL WIRE AND J/B NO. 3 (BEHIND COMBINATION METER)
3D
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
II142COWL WIRE AND INSTRUMENT PANEL WIRE
IJ142FLOOR NO. 1 WIRE AND COWL WIRE
IP144ENGINE WIRE AND COWL WIREIP344ENGINE WIRE AND COWL WIRE
46 (S/D)
BX148 (C/P)FUEL GAUGE WIRE AND FLOOR NO. 1 WIREBX1
50 (W/G)
FUEL GAUGE WIRE AND FLOOR NO. 1 WIRE
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
ED38 (1MZ±FE)INTAKE MANIFOLD LHED40 (5S±FE)INTAKE MANIFOLD LH
IE42LEFT KICK PANELIF42LEFT KICK PANEL
IG42INSTRUMENT PANEL BRACE LH
: SPLICE POINTS
CODESEE PAGEWIRE HARNESS WITH SPLICE POINTSCODESEE PAGEWIRE HARNESS WITH SPLICE POINTS
I 644INSTRUMENT PANEL WIREI1344COWL WIRE
I 944COWL WIREI1844ENGINE WIRE
SERVICE HINTS

241
RADIATOR FAN AND CONDENSER FAN (5S±FE)
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
A 130E 530 (5S±FE)
A 230 (5S±FE)R 130 (5S±FE)
: RELAY BLOCKS
CODESEE PAGERELAY BLOCKS (RELAY BLOCK LOCATION)
526R/B NO. 5 (ENGINE COMPARTMENT LEFT)
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1A20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
2B22ENGINE ROOM MAIN WIRE AND J/B NO 2 (ENGINE COMPARTMENT LEFT)2E22ENGINE ROOM MAIN WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
3A24COWL WIRE AND J/B NO 3 (BEHIND COMBINATION METER)3C24COWL WIRE AND J/B NO. 3 (BEHIND COMBINATION METER)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
EA140 (5S±FE)ENGINE ROOM MAIN WIRE AND ENGINE ROOM NO. 3 WIRE
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
EB40 (5S±FE)FRONT LEFT FENDER
: SPLICE POINTS
CODESEE PAGEWIRE HARNESS WITH SPLICE POINTSCODESEE PAGEWIRE HARNESS WITH SPLICE POINTS
E 540 (5S±FE)ENGINE ROOM MAIN WIRE