check engine TOYOTA CAMRY HV 2012 Owner's Manual

5
When trouble arises
465
5-2. Steps to take in an emergency
If your vehicle overheats
Correction procedures■ If the rightmost segment of th e engine coolant temperature
display are flashing
Stop the vehicle in a safe place and turn off the air condition-
ing system.
Check to see if steam is coming out from the engine area.
If you see steam: Stop the hybrid system. Carefully lift the hood after the
steam subsides and then restart the hybrid system.
If you do not see steam: Leave the hybrid system operating and carefully lift the
hood.
Check to see if the cooling fans are operating.
If the fans are operating: Wait until the rightmost segm ent of the engine coolant tem-
perature display stops flashing and returns to normal dis-
play. Then stop the hybrid system.
If the fans are not operating: Stop the hybrid system immediately and call your Toyota
dealer.
The following may indicate that your vehicle is overheating:
●The rightmost segment of the engine coolant temperature dis-
play is flashing:
The engine may be overheating.
● “HYBRID SYSTEM OVERHEAT” is shown on the multi-informa-
tion display:
The electric motor or power control unit may be overheating.
Follow the correction procedure as described below.
STEP1
STEP2
STEP3

466 5-2. Steps to take in an emergency
After the hybrid system has
cooled down sufficiently, check
the engine coolant level and
inspect the radiator core (radia-
tor) for any leaks.
Add engine coolant if necessary.
Water can be used in an emer-
gency if engine coolant is unavail-
able.
( P. 477)
Have the vehicle inspected at the nearest Toyota dealer as soon as
possible.
■ If “HYBRID SYSTEM OVERHEAT” is shown on the multi-infor-
mation display
Stop the vehicle in a safe place and turn off the air condition-
ing system.
Leave the hybrid system operating and carefully lift the hood.
Check if the cooling fans are operating.
If the fans are operating: Wait until the “HYBRID SYSTEM OVERHEAT” message
disappears and then stop the hybrid system.
If the message does not disapp ear, call your Toyota dealer.
If the fans are not operating: Stop the hybrid system immediately and call your Toyota
dealer.
STEP4
STEP5
STEP1
STEP2
STEP3

5
When trouble arises
467
5-2. Steps to take in an emergency
After the hybrid system has
cooled down, check the power
control unit coolant level and
inspect the cooling system for
leaks.
Add power control unit coolant if
necessary.
Water can be used in an emer-
gency if power control unit cool-
ant is unavailable. (

P. 477)
Have the vehicle inspected at the nearest Toyota dealer as soon as
possible.
STEP4
STEP5
■Overheating
The following symptoms may occur when your vehicle is overheating:
●Hybrid system output decreases.
● Steam comes out from the engine area.
● “HYBRID SYSTEM OVERHEAT” is shown on the multi-information dis-
play.

468 5-2. Steps to take in an emergency
CAUTION
■To prevent an accident or injury when inspecting under the hood of
your vehicle
● If steam is seen coming from under the hood, do not open the hood until
the steam has subsided. The engine compartment may be very hot, caus-
ing serious injury such as burns.
● Check that on the multi-information display and the “READY” indi-
cator are off.
● For vehicle with a hybrid system, there are times when the gasoline
engine automatically starts to run or the cooling fans suddenly start to
operate. Do not touch or approach the rotating parts of the belt or fans.
Doing so may lead to fingers, clothes or tools getting caught, resulting\
in
injury.
● Do not loosen the coolant reservoir cap while the hybrid system and radia-
tor are hot.
Serious injury, such as burns, may result from hot coolant and steam
released under pressure.
NOTICE
■When adding engine/power control unit coolant
Wait until the hybrid system has cooled down before adding engine/power
control unit coolant.
When adding coolant, do so slowly. Adding cool coolant to a hot hybrid sys-
tem too quickly can cause damage to the hybrid system.
■ To prevent damage to the cooling system
Observe the following precautions:
●Avoid contaminating the coolant with foreign matter (such as sand or dust
etc.)
● Do not use commercially available coolant additives.

475
6-1. Specifications
6
Vehicle specifications
Lubrication system
*: The engine oil capacity is a reference quantity to be used when changing the
engine oil. Warm up the engine and turn off the hybrid system, wait more
than 5 minutes, and check the oil level on the dipstick.
■Engine oil selection
“Toyota Genuine Motor Oil” is used in your Toyota vehicle. Use
Toyota approved “Toyota Genuine Motor Oil” or equivalent to satisfy
the following grade and viscosity.
Oil grade: ILSAC GF-5 multigrade engine oil
Recommended viscosity: SAE 0W-20
SAE 0W-20 is the best choice for
good fuel economy and good
starting in cold weather.
If SAE 0W-20 is not available,
SAE 5W-20 oil may be used.
However, it must be replaced
with SAE 0W-20 at the next oil
change.
Oil capacity
(Drain and refill
 refer-
ence*) With filter
Without filter 4.6 qt. (4.4 L, 3.9 Imp. qt.)
4.2 qt. (4.0 L, 3.5 Imp. qt.)
Outside temperature

478 6-1. Specifications
Electrical system
Transmission
*: The fluid capacity is a reference quantity. If replacement is necessary, con-tact your Toyota dealer.
Battery
Open voltage* at
68 F (20 C): 12.6  12.8 V Fully charged
12.2  12.4 V Half charged
11 . 8
 12.0 V Discharged
(*: Voltage checked 20 minutes after the
engine and all the lights are turned off)
Charging rates 5 A max.
Fluid capacity* 3.9 qt. (3.7 L, 3.3 Imp. qt.)
Fluid typeToyota Genuine ATF WS
NOTICE
■Transmission fluid type
Using transmission fluid other than “Toyota Genuine ATF WS” may ulti-
mately damage the transmission of your vehicle.

524 Alphabetical index
Electric power steering ........... 210
Electronic keyIf the electronic key does not operate properly............ 458
Emergency flashers
Switch.................................... 408
Emergency, in case of If a warning light turns on ...... 413
If a warning message is
displayed............................. 423
If the electronic key does not
operate properly.................. 458
If the Hybrid system will not start ..................................... 454
If the shift lever cannot be shifted from P...................... 456
If the vehicle has a discharged
12-volt battery ..................... 461
If the warning buzzer sounds ................................ 413
If you have a flat tire ............. 442
If you lose your keys ............. 457
If you think something is wrong .................................. 412
If your vehicle becomes stuck ................................... 469
If your vehicle has to be stopped in an emergency ... 470
If your vehicle needs to be
towed .................................. 409
If your vehicle overheats ....... 465 Engine
Accessory mode ................... 159
Compartment ........................ 351
Hood ..................................... 348
How to start the
hybrid system ..................... 159
Identification number............. 472
If the hybrid system will not start............................... 454
Ignition switch ....................... 159
Overheating .......................... 465
“POWER” switch ................... 159
Engine coolant Capacity ................................ 477
Checking ............................... 356
Preparing and checking before winter ....................... 225
Engine coolan t temperature
display .................................... 174
Engine oil
Capacity ................................ 475
Checking ............................... 352
Preparing and checking before winter ....................... 225
Engine/power control unit coolant
Capacity ................................ 477
Checking ............................... 356
Preparing and checking before winter ....................... 225
Engine switch light .................. 286
EPS............................................ 207
EV drive mode .......................... 166
Event data recorder ................... 23E

532 Alphabetical index
Warning buzzersBrake system ........................ 413
Electric power steering
system ................................ 414
Open door ............................. 416
Seat belt reminder ................. 416
Warning lights Anti-lock brake system .......... 414
Brake assist system .............. 414
Brake system ........................ 413
Charging system .... ............... 414
Electric power steering system ................................ 414
Engine coolant
temperature ........................ 414
Engine oil pressure ............... 414
Low fuel level ........................ 416
Low tire pressure warning light ..................................... 416
Malfunction indicator lamp .... 414
Master warning light .............. 416
Open door ............................. 416
Pretensioners ........................ 414
Seat belt reminder light ......... 416
Slip indicator.......................... 414
SRS airbags .......................... 414
Warning messages Blind Spot monitor ......... 425, 426
Cruise control ........................ 425
EV drive mode....................... 426
Headlight ............................... 426
Hood...................................... 426
Hybrid system ....................... 424
Hybrid system overheat ........ 426
Maintenance.......................... 426
Moon roof .............................. 426
N position .............................. 426
Open door ............................. 426
Parking brake ........................ 426
P position .............................. 426
Smart key system.......... 425, 433
Steering lock ......................... 425
Traction battery ..................... 426 Trunk ..................................... 426
Washer fluid .......................... 426
Washer Checking ............................... 359
Preparing and checking before winter ....................... 225
Switch ................................... 200
Washing and waxing ............... 332
Weight
Cargo capacity ...................... 220
Load limits ............................. 224
Weight ................................... 472
Wheels ...................................... 377
Window glasses ........................ 97
Window lock switch................... 97
Windows Power windows ....................... 97
Rear window defogger .......... 239
Washer.................................. 200
Windshield wipers ................... 200
Wireless remote control key
Replacing the battery ............ 382
Wireless remote control .......... 66
WMA disc.................................. 255W