TOYOTA CAMRY HYBRID 2009 XV40 / 8.G Warranty And Maintenance Guide

Limitations
The performance of necessary repairs and adjustments is the exclusive
remedy under these warranties or any implied warranties. Toyota does
not authorize any person to create for it any other obligation or liability
in connection with this vehicle.
Any implied warranty of merchantability or fitness for a particular
purpose is limited to the duration of these written warranties.Some
states do not allow restrictions on how long an implied warranty lasts,
so this limitation may not apply to you.
Your Rights Under State Law
These warranties give you specific legal rights. You may also have
other rights that vary from state to state.
Your Warranties in Detail9
GENERAL WARRANTY PROVISIONS
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 9

WHAT IS COVERED AND HOW LONG
Basic Warranty
This warranty covers repairs and adjustments needed to correct defects
in materials or work manship of any part supplied by Toyota, subject to
the exceptions indicated under “What Is Not Covered” on pages 12–13.
Coverage is for 36 months or 36,000 miles, whichever occurs first,
with the exception of wheel alignment and wheel balancing, which are
covered for 12 months or 20,000 miles, whichever occurs first.
Hybrid System Warranty
This warranty covers repairs needed to correct defects in materials or
workmanship of the components listed here and supplied by Toyota,
subject to the exceptions indicated under “What Is Not Covered” on
pages 12–13:
Battery control module
Hybrid battery
Hybrid control module
Inverter with converter
Coverage is for 96 months or 100,000 miles, whichever occurs first.
Powertrain Warranty
This warranty covers repairs needed to correct defects in materials
or work manship of any component listed here and supplied by Toyota,
subject to the exceptions indicated under “What Is Not Covered” on
pages 12–13.
Coverage is for 60 months or 60,000 miles, whichever occurs first.
Engine
Cylinder block and head and all internal parts, timing gears and gas-
kets, timing chain/belt and cover, valve covers, oil pan, oil pump,
engine mounts, engine control computer, water pump, fuel pump,
seals and gaskets.
Transaxle/Motor/Generator
Case and all internal parts, transaxle mounts, seals and gaskets.
Front-Wheel-Drive System
Final drive housing and all internal parts, axle shafts, drive shafts,
constant velocity joints, front hub and bearings, seals and gaskets.
Your Warranties in Detail10
NEW VEHICLE LIMITED WARRANTY
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 10

Restraint Systems Warranty
This warranty covers repairs needed to correct defects in materials or
work man ship of any seatbelt or air bag system supplied by Toyota,
subject to the exceptions indicated under “What Is Not Covered” on
pages 12–13.
Coverage is for 60 months or 60,000 miles, whichever occurs first.
For vehicles sold and registered in the state of Kansas, the warranty for
seatbelts and related components is 10 years, regardless of mileage.
Corrosion Perforation Warranty
This warranty covers repair or replacement of any original body panel
that develops perforation from corrosion (rust-through), subject to the
exceptions indicated under “What Is Not Covered” on pages 12–13.
Coverage is for 60 months, regardless of mileage.
For information on how to protect your vehicle from corrosion, see the
section entitled “Corrosion Prevention and Appearance Care” in the
Owner’s Manual.
Towing
When your vehicle is inoperable due to failure of a warranted part,
towing service to the nearest authorized Toyota dealership is covered.
Your Warranties in Detail11
NEW VEHICLE LIMITED WARRANTY
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 11

WHAT IS NOT COVERED
This warranty does not cover damage or failures resulting directly or
indirectly from any of the following:
Fire, accidents or theft
Abuse or negligence
Misuse — for example, racing or overloading
Improper repairs
Alteration or tampering, including installation of non-Genuine
Toyota Accessories
Lack of or improper maintenance, including use of fluids other
than those specified in the
Owner’s Manual
Installation of non-Genuine Toyota Parts
Airborne chemicals, tree sap, road debris (including stone chips),
rail dust, salt, hail, floods, wind storms, lightning and other
environmental conditions
Water contaminationThis warranty also does not cover the following:
Tires
Tires are covered by a separate warranty provided by the tire manufac-
turer. See page 28.
Normal Wear and Tear
Noise, vibration, cosmetic conditions and other deterioration caused
by normal wear and tear.
Maintenance Expense
Normal maintenance services such as:
Engine tune-ups
Replacement of fluids and filters
Lubrication
Cleaning and polishing
Replacement of spark plugs and fuses
Replacement of worn wiper blades, brake pads/linings and
clutch linings
Your Warranties in Detail12
NEW VEHICLE LIMITED WARRANTY
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 12

Vehicles With Altered Odometer
Failure of a vehicle on which the odometer has been altered so that
actual vehicle mileage cannot be readily determined.
Salvage or Total-Loss Vehicles
Any vehicle that has ever been issued a “salvage” title or similar title
under any state’s law; or has ever been declared a “total loss” or equiv-
alent by a financial institution or insurer, such as by payment for a
claim in lieu of repairs because the cost of repairs exceeded the cash
value of the vehicle. This exclusion does not apply to the emission
control warranties.
Incidental Damages
Incidental or consequential damages associated with a vehicle failure.
Such damages include but are not limited to inconvenience; the cost
of transportation, telephone calls and lodging; the loss of personal or
commercial property; and the loss of pay or revenue.
Disclaimer of Extra Expenses and Damages
The performance of necessary repairs and adjustments is the
exclusive remedy under this warranty or any implied warranty.
Toyota does not authorize any person to create for it any other
obligation or liability in connection with this vehicle. Toyota shall
not be liable for incidental or consequential damages resulting
from breach of this written warranty or any implied warranty. Any
implied warranty of merchantability or fitness for a particular pur-
pose is limited to the duration of this written warranty, except in
states where this limitation is not allowed.
Your Warranties in Detail13
NEW VEHICLE LIMITED WARRANTY
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 13

DISPUTE RESOLUTION
If a dispute arises regarding your warranty coverage, please follow
the steps described under “If You Need Assistance” on pages 4–5.
Please note that you must use the Dispute Settlement Program (or,
in California, the CDSP) before seeking remedies through a court
action pursuant to the Magnuson-Moss Warranty Act. You may also
be required to use the Dispute Settlement Program or CDSP before
seeking remedies under the “Lemon Laws” of your state. Please check
the appropriate page of the
Owner’s Warranty Rights Notification
booklet (located in your glove box) for the requirements applicable
to your state.
Your Warranties in Detail14
NEW VEHICLE LIMITED WARRANTY
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 14

Emission Defect Warranty
Toyota warrants that your vehicle:
Was designed, built and equipped to conform at the time of sale with
applica ble federal emissions standards.
Is free from defects in materials and workmanship that may cause
the vehicle to fail to meet these standards.
Federal regulations require that this warranty be in effect for two years
or 24,000 miles from the vehicle’s in-service date, whichever occurs
first. However, under the terms of the Basic Warranty, Toyota provides
coverage of three years or 36,000 miles, whichever occurs first. Speci-
fic com ponents may have longer coverage under the terms of the
Powertrain Warranty. Additionally, components marked “8/80” in the
parts list on pages 16–17 have coverage of eight years or 80,000 miles,
whichever occurs first.
Emission Performance Warranty
Some states and localities have established vehicle inspection and
maintenance (I/M) programs to encourage proper vehicle maintenance.
If an EPA-approved I/M program is in force in your area, you are eligi-
ble for Emission Performance Warranty coverage.
Under the terms of the Emission Performance Warranty and federal
regulations, Toyota will make all necessary repairs if both of the
following occur:
Your vehicle fails to meet applicable emissions standards as
determined by an EPA-approved emissions test.
This failure results or will result in some penalty to you — such
as a fine or denial of the right to use your vehicle — under local,
state or federal law.
This warranty is in effect for two years or 24,000 miles from the vehi-
cle’s in-service date, whichever occurs first. Additionally, components
marked “8/80” in the parts list on pages 16–17 have coverage of eight
years or 80,000 miles, whichever occurs first.
WHAT IS COVERED AND HOW LONG
Your Warranties in Detail15
FEDERAL EMISSION CONTROL WARRANTY
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 15

WHAT IS NOT COVERED WARRANTY PARTS LIST
These warranty obligations do not apply to failures or noncompliance
caused by:
The use of replacement parts not certified in accordance with
aftermarket parts certification regulations.
The use of replacement parts not equivalent in quality or design
to original equipment parts.
Provisions under the “What Is Not Covered” section of the New Vehicle
Limited Warranty also apply to this warranty.
Air/Fuel Metering System

Air/fuel ratio feedback control system
Electronic fuel injection system components
– Airflow sensor
– Engine control module (8/80)
– Throttle body
– Other components
Air Induction System

Intake manifold and intake air surge tank
Catalyst System

Catalytic converter and protector (8/80)
Constricted fuel filler neck
Exhaust manifold
Exhaust pipe (manifold to catalyst and/or catalyst to catalyst)
Your Warranties in Detail16
FEDERAL EMISSION CONTROL WARRANTY
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 16

Evaporative Control System

Charcoal canister
Diaphragm valve
Fuel filler cap
Fuel tank
Hybrid System

Battery control module (8/80)*
Battery thermistor
Generator
Hybrid battery*
Hybrid control module (8/80)*
Inverter with converter*
Motor
System main relay and battery current sensor
Ignition System

Distributor and internal parts
Ignition coil and ignitor
Ignition wires
Spark plugs†
Positive Crankcase Ventilation (PCV) System

Oil filler cap
PCV valve or orifice
Other Parts Used in Above Systems

Data link connector (8/80)
Hoses, clamps, fittings, tubing and mounting hardware
Malfunction indicator light and bulb (8/80)
Pulleys, belts and idlers
Sealing gaskets and devices
Sensors, solenoids, switches and valves
FEDERAL EMISSION CONTROL WARRANTY
*
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.
Covered under the Hybrid System Warranty for eight years or 100,000
miles, whichever occurs first.†Warranted until first required maintenance under terms of the California
Emission Control Warranty.
Your Warranties in Detail17
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 17

MAINTENANCE REPLACEMENT PARTS
You are responsible for performance of the required maintenance indi-
cated in the
Owner’s Manualand the Scheduled Maintenance Guide.
Toyota will not deny a warranty claim solely because you do not have
records to show that you maintained your vehicle. However, any failure
or noncompliance caused by lack of maintenance is not covered by this
warranty.
When maintenance and repairs are paid for by you, these services
may be performed by you or by any automotive service provider you
choose. Toyota will not deny a warranty claim solely because you
used a service provider other than a Toyota dealership for mainte-
nance and repairs.However, any failure or noncompliance caused
by improper maintenance or repairs is not covered by this warranty.To ensure optimum performance and maintain the quality built into
your vehicle’s emission control systems, Toyota recommends the use
of Genuine Toyota Parts when servicing or repairing the systems.
Warranty coverage is not dependent upon the use of any particular
brand of replacement parts and you may elect to use non-Genuine
Toyota Parts for maintenance and repairs. However, use of replace-
ment parts that are not equiva lent in quality to Genuine Toyota Parts
may impair the effectiveness of the emission control systems.
If you use replacement parts that have maintenance or replacement
schedules different from those of Genuine Toyota Parts, you must fol-
low the maintenance and replacement schedules for the parts you are
using. In addition, you should ensure that such parts are warranted
by their manufacturers to be equivalent to Genuine Toyota Parts.
Your Warranties in Detail18
FEDERAL EMISSION CONTROL WARRANTY
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 18