check engine TOYOTA RAV4 2002 XA20 / 2.G Owner's Guide

’02 Rav4_U (L/O 0108)
2412002 MY RAV4_U (OM42503U)
c. Tighten the holddown clamp onlyenough to keep the battery firmly in
place. Overtightening may damage the
battery case.
After checking the battery, reinstall the
battery cover.
NOTICE
 Be sure the engine and all accesso-
ries are off before performing main-
tenance.
 When checking the battery, remove
the ground cable from the negative
terminal (“” mark) first and rein-
stall it last.
 Be careful not to cause a short cir-
cuit with tools.
 Take care no solution gets into the
battery when washing it.
Ty p e A
Green Dark Clear or
light yellow
Ty p e B Blue White Red
CHECKING BY INDICATOR
Check the battery condition by the indi-
cator color.
Indicator color
ConditionTy p e ATy p e B
GreenBlueGood
DarkWhite
Charging necessary.
Have battery
checked by your
Toyota dealer.
Clear orlight
yellow
RedHave battery
checked by your
Toyota dealer.
During recharging, the battery is pro-
ducing hydrogen gas.
Therefore, before recharging:
1. If recharging with the battery installed on the vehicle, be sure to disconnect
the ground cable.
2. Be sure the power switch on the re- charger is off when connecting the
charger cables to the battery and when
disconnecting them.
CAUTION
Always charge the battery in an un-
confined area. Do not charge the
battery in a garage or closed room
where there is not sufficient ventila-
tion.
Only do a slow charge (5 A or
less). Charging at a quicker rate is
dangerous. The battery may ex-
plode, causing personal injuries.
NOTICE
Never recharge the battery while the
engine is running. Also, be sure all
accessories are turned off.
—Checking battery c ondition Battery recharging pr ecautions

’02 Rav4_U (L/O 0108)
2432002 MY RAV4_U (OM42503U)
If the new fuse immediately blows out,
there is a problem with the electrical sys-
tem. Have your Toyota dealer correct it as
soon as possible.
CAUTION
Never use a fuse with a higher am-
perage rating, or any other object, in
place of a fuse. This may cause ex-
tensive damage and possibly a fire.
If any washer does not work, the wash-
er tank may be empty. Check the wash-
er fluid level on the level gauge. If the
washer fluid level is below “LOW”, add
washer fluid.
You may use plain water as washer fluid.
However, in cold areas where tempera-
tures range below freezing point, use
washer fluid containing antifreeze. This
product is available at your Toyota dealer
and most auto parts stores. Follow the
manufacturer ’s directions for how much to
mix with water.
NOTICE
Do not use engine antifreeze or any
other substitute because it may dam-
age your vehicle’s paint.
Adding washer fluid

’02 Rav4_U (L/O 0108)
2572002 MY RAV4_U (OM42503U)
BRAKES
Minimum pedal clearance when depressed
with the force of 490 N (50 kgf, 110 lbf)
with the engine running, mm (in.):118 (4.6)
Pedal free play, mm (in.): 1—6 (0.04—0.24)
Pad wear limit, mm (in.): 1.0 (0.04)
Lining wear limit, mm (in.): 1.0 (0.04)
Parking brake adjustment when pulled with
the force of 196 N (20 kgf, 44 lbf): 6—8 clicks
Fluid type: SAE J1703 or FMVSS No.116 DOT 3 STEERING
Wheel free play:
Less than 30 mm (1.2 in.)
Power steering fluid type: Automatic transmission fluid DEXRON II
or III Tire size:
215/70R16 99S
235/60R16 100H
Tire pressure, kPa (kgf/cm
2 or bar, psi):
200 (2.0, 29)
Wheel size: Steel wheel 16 61/2J
Aluminum Wheel 16 7JJ
Wheel nut torque, N
·m (kgf·m, ft·lbf):
103 (10.5, 76)
NOTE: For a complete information on tires (e.g. replacing tires or re-
placing wheels), see “Checking
tire pressure” through “Aluminum
wheel precautions”, pages 231
through 237, in Section 72.
Tires

’02 Rav4_U (L/O 0108)
2662002 MY RAV4_U (OM42503U)
A
Adding washer fluid243
. . . . . . . . . . . . . . . . . .
Adjustment
Front seats 29
. . . . . . . . . . . . . . . . . . . . . . . . .
Rear seats 30
. . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt 40
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Air cleaner 230
. . . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 128
. . . . . . . . . . . . . . .
Airbags 50
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 237
. . . . . . . . . .
Antiglare inside rear view mirror 76 . . . . . . .
Antilock brake system warning light 90 . . . .
Antitheft steering column lock 98
. . . . . . . . .
Appearance care
Cleaning the interior 209
. . . . . . . . . . . . . . . .
Protecting your Toyota from corrosion 206
. . . . . . . . . . . . . . . . . . .
Washing and waxing 207
. . . . . . . . . . . . . . . .
Automatic transmission
Driving with an automatic transmission 99
. . . . . . . . .
Shift lock override button 202
. . . . . . . . . . . .
Shift pattern 99
. . . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 99
. . . . . . . . . . . . . . . . . . . . . .
Automatic transmission fluid temperature warning light 90
. . . . . . . . . . . .
Auxiliary boxes 141
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 22
. . . . . . . . . . .
B
Back door 21
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Back door lock 21
. . . . . . . . . . . . . . . . . . . . . . . . Battery
Checking battery condition 240
. . . . . . . . . .
Gas caution 240
. . . . . . . . . . . . . . . . . . . . . . .
Handling safety 240
. . . . . . . . . . . . . . . . . . . .
Recharging precautions 241
. . . . . . . . . . . . .
Winter driving tips 173
. . . . . . . . . . . . . . . . . .
Before starting the engine 170
. . . . . . . . . . . . .
Brake pad wear limit indicators 164 . . . . . . . .
Brake system 161
. . . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 90
. . . . . . . . . . . . .
Brakes
Fluid level 229
. . . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 164
. . . . . . . . . . . .
Parking 104
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Breakin tips 155
. . . . . . . . . . . . . . . . . . . . . . . .
Brightness control 82
. . . . . . . . . . . . . . . . . . . . .
C
Car audio system 110
. . . . . . . . . . . . . . . . . . . .
Carbon monoxide caution 159
. . . . . . . . . . . . .
Cassette player 110
. . . . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 242
. . . . . . . . .
Checking brake fluid 229
. . . . . . . . . . . . . . . . . .
Checking the engine oil level 226
. . . . . . . . . .
Checking the radiator and condenser 228
. . . . . . . . . . . . . . . . . . . . . . . . .
Child restraint
Child restraint system 58
. . . . . . . . . . . . . . .
Installation 60
. . . . . . . . . . . . . . . . . . . . . . . . .
Installation with ISOFIX rigid anchor 72
. . . . . . . . . . . . . . . . . . . . . .
Precautions 57
. . . . . . . . . . . . . . . . . . . . . . . . Types of child restraint system 59
. . . . . . . .
Using a top strap 69
. . . . . . . . . . . . . . . . . . . .
Cigarette lighter and ashtrays 136
. . . . . . . . .
Cleaning the interior 209
. . . . . . . . . . . . . . . . . .
Clock 136
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather
Operation 173
. . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc auto changer controller 110
. . . . . . . . . . . . . . . . . .
Compact disc player 110
. . . . . . . . . . . . . . . . . .
Condenser
Checking the condenser 228
. . . . . . . . . . . .
Controls, Instrument panel 2,4
. . . . . . . . . . . .
Cooling system
Coolant level 227
. . . . . . . . . . . . . . . . . . . . . .
Engine overheating 188
. . . . . . . . . . . . . . . . .
Radiator and reservoir 227
. . . . . . . . . . . . . .
Radiator cap 188
. . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 173
. . . . . . . . . . . . . . . . . .
Corrosion prevention 206
. . . . . . . . . . . . . . . . .
Cruise control 105
. . . . . . . . . . . . . . . . . . . . . . .
Cup holder
Front 143
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear 143
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D
Defogger
Out side rear view mirror 85 . . . . . . . . . . . . .
Rear window 85
. . . . . . . . . . . . . . . . . . . . . . . .
Differential, Limited slip 165
. . . . . . . . . . . . . . .
Dimmer switch, Headlight 80
. . . . . . . . . . . . . .
Dinghy towing 174,175
. . . . . . . . . . . . . . . . . . .
Directional signals 80
. . . . . . . . . . . . . . . . . . . .

’02 Rav4_U (L/O 0108)
2672002 MY RAV4_U (OM42503U)
Discharge warning light90
. . . . . . . . . . . . . . . .
Doityourself maintenance
Parts and tools 221
. . . . . . . . . . . . . . . . . . . . .
Service precautions 219
. . . . . . . . . . . . . . . .
Does your vehicle need repairing? 215 . . . . .
Doors
Side doors 12
. . . . . . . . . . . . . . . . . . . . . . . . .
Driver ’s seat belt reminder buzzer 90 . . . . . . .
Driver ’s seat belt reminder light 90
. . . . . . . . .
Driving
Automatic transmission 99
. . . . . . . . . . . . . .
Driving tips 170
. . . . . . . . . . . . . . . . . . . . . . . .
Manual transmission 103
. . . . . . . . . . . . . . .
Driving tips
Driving tips in various conditions 171 . . . . .
Driving with a manual transmission 103
. . . . . . . . . . . .
Driving with an automatic transmission 99
. . . . . . . . .
Economical driving 181
. . . . . . . . . . . . . . . . .
Good driving practice 99,103
. . . . . . . . . . . .
Winter driving tips 173
. . . . . . . . . . . . . . . . . .
During
Breakin 155
. . . . . . . . . . . . . . . . . . . . . . . . . .
E
Economical driving
Saving money on both fuel and repairs 181 . . . . . . . . . . . . . . . . . .
Electric moon roof 25 . . . . . . . . . . . . . . . . . . . . . Electrical system
Battery 240,241 . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 219 . . . . . . . . . . . . . . . . . . . . .
Fuses 242 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 81 . . . . . . . . . . . . . .
Emergency, In case of
Blown fuse 242 . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 81 . . . . . . . . . . . .
Flat tire 189 . . . . . . . . . . . . . . . . . . . . . . . . . . .
If you cannot shift automatic transmission selector lever 202 . . . . . . . .
If you lose your keys 203 . . . . . . . . . . . . . . . .
If you lose your wireless remote control transmitter 203 . . . . . . . . . . . . . . . .
If your engine stalls while driving 188 . . . . .
If your vehicle needs to be towed 198 . . . . .
If your vehicle will not start 184 . . . . . . . . . .
Jump starting 185 . . . . . . . . . . . . . . . . . . . . . .
Overheating 188 . . . . . . . . . . . . . . . . . . . . . . .
Towing 198 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emissions Inspection and Maintenance (I/M) programs 216 . . . . . . . . .
Engine
Air cleaner 230 . . . . . . . . . . . . . . . . . . . . . . . .
Before starting the engine 170 . . . . . . . . . . .
Checking the coolant level 227 . . . . . . . . . .
Emission control device 158 . . . . . . . . . . . . .
Engine compartment 218 . . . . . . . . . . . . . . .
Exhaust gas caution 159 . . . . . . . . . . . . . . . .
Hood release 22 . . . . . . . . . . . . . . . . . . . . . . .
Oil consumption 159 . . . . . . . . . . . . . . . . . . . .
Oil level 226 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating 188 . . . . . . . . . . . . . . . . . . . . . . . Starting procedure 170
. . . . . . . . . . . . . . . . .
Threeway catalytic converter 158 . . . . . . .
Engine coolant
Temperature gauge 88 . . . . . . . . . . . . . . . . . .
Winter driving tips 173 . . . . . . . . . . . . . . . . . .
Engine coolant temperature gauge 88 . . . . . .
Engine immobiliser system 11 . . . . . . . . . . . . .
Engine oil
Winter driving tips 173 . . . . . . . . . . . . . . . . . .
Exhaust gas caution 159 . . . . . . . . . . . . . . . . . .
F
Facts about engine oil consumption 159 . . . .
Flasher, Headlight 80 . . . . . . . . . . . . . . . . . . . . .
Flat tire
After changing wheels 197 . . . . . . . . . . . . . .
Changing tire 194 . . . . . . . . . . . . . . . . . . . . . .
If you have a flat tire 189 . . . . . . . . . . . . . . . .
Jack point 193 . . . . . . . . . . . . . . . . . . . . . . . . .
Jacking precautions 189 . . . . . . . . . . . . . . . .
Jacking up 193 . . . . . . . . . . . . . . . . . . . . . . . .
Loosening wheel nuts 193 . . . . . . . . . . . . . . .
Lowering vehicle 195 . . . . . . . . . . . . . . . . . . .
Stowing flat tire 196 . . . . . . . . . . . . . . . . . . . .
Wheel block 192 . . . . . . . . . . . . . . . . . . . . . . .
Wheel nuts 195 . . . . . . . . . . . . . . . . . . . . . . . .
Floor mat 151 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid level
Brake 229 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power steering 229 . . . . . . . . . . . . . . . . . . . . .
Washer fluid 243 . . . . . . . . . . . . . . . . . . . . . . .
Fog light switch, Front 82 . . . . . . . . . . . . . . . . .
Foreign countries, Operation in 157 . . . . . . . .

’02 Rav4_U (L/O 0108)
2692002 MY RAV4_U (OM42503U)
Low windshield washer fluid level warning light 90 . . . . . . . . . . . . . . . . . . . . . . . .
Luggage cover 146 . . . . . . . . . . . . . . . . . . . . . . .
Luggage stowage precautions 164 . . . . . . . . .
M
Maintenance
Doityourself maintenance 219 . . . . . . . . .
Does your vehicle need repairing? 215 . . . . . . . . . . . . . . . . . .
General maintenance 213 . . . . . . . . . . . . . . .
Maintenance requirements 212 . . . . . . . . . .
Parts and tools 221 . . . . . . . . . . . . . . . . . . . . .
Where to go for service 212 . . . . . . . . . . . . .
Malfunction indicator lamp 90,216 . . . . . . . . .
Manual transmission
Driving with a manual transmission 103 . . . . . . . . . . . .
Shift pattern 103
. . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 103
. . . . . . . . . . . . . . . . . . . . .
Maximum allowable speed
Automatic transmission 99
. . . . . . . . . . . . . .
Manual transmission 103
. . . . . . . . . . . . . . .
Mirror
Antiglare inside rear view 76
. . . . . . . . . . .
Mirrors
Folding rear view 75
. . . . . . . . . . . . . . . . . . . .
Outside rear view 74
. . . . . . . . . . . . . . . . . . .
Power rear view 75
. . . . . . . . . . . . . . . . . . . . .
Vanity 77
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Moon roof 25
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
N
New vehicle breakin 155
. . . . . . . . . . . . . . . . .
O
Odometer 89
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Offroad driving precautions 172
. . . . . . . . . .
Offroad vehicle precautions 154
. . . . . . . . . .
Oil
Consumption 159
. . . . . . . . . . . . . . . . . . . . . .
Power steering 229
. . . . . . . . . . . . . . . . . . . . .
Viscosity and grade 226
. . . . . . . . . . . . . . . .
Oil consumption 159
. . . . . . . . . . . . . . . . . . . . .
Open door warning light 90
. . . . . . . . . . . . . . . .
Operation in foreign countries 157
. . . . . . . . .
Overdrive switch 99
. . . . . . . . . . . . . . . . . . . . . .
Overheating, Engine 188
. . . . . . . . . . . . . . . . . .
Overheating, Engine coolant 88
. . . . . . . . . . .
Overview
Engine compartment 218
. . . . . . . . . . . . . . .
P
Parking brake
Operation 104 . . . . . . . . . . . . . . . . . . . . . . . . .
Reminder light 104 . . . . . . . . . . . . . . . . . . . . .
Personal light 83 . . . . . . . . . . . . . . . . . . . . . . . . .
Polishing 207 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Positioning the jack 222 . . . . . . . . . . . . . . . . . .
Power outlet 137 . . . . . . . . . . . . . . . . . . . . . . . . .
Power rear view mirror control 75 . . . . . . . . . .
Power steering
Fluid level 229 . . . . . . . . . . . . . . . . . . . . . . . . .
Power window switches 19 . . . . . . . . . . . . . . . . Preloaders (seat belt pretensioners) 48
. . . . .
Pretensioners (seat belt pretensioners) 48 . . . . . . . . . . . . .
R
Radiator
Checking the radiator 228 . . . . . . . . . . . . . . .
Coolant, Engine 227 . . . . . . . . . . . . . . . . . . . .
Radio 110 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear cup holder 143 . . . . . . . . . . . . . . . . . . . . . .
Rear seats 30 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear view mirror
Antiglare inside 76 . . . . . . . . . . . . . . . . . . . .
Rear view mirrors
Folding 75 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside 74 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power 75 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear window and outside rear view mirror defogger switch 85 . . . . . . . . . . . . . . .
Rear window wiper and washer switch 84 . . . . . . . . . . . . . . . . . . . . . .
Reporting safety defects for U.S. owners 262 . . . . . . . . . . . . . . . . . . . . . . .
Roof luggage carrier 150 . . . . . . . . . . . . . . . . . .
S
Seat adjustment precautions
Front seats 28 . . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt extender 46 . . . . . . . . . . . . . . . . . . . . .
Seat belts
Cleaning 209 . . . . . . . . . . . . . . . . . . . . . . . . . .
Fastening 40 . . . . . . . . . . . . . . . . . . . . . . . . . .