service indicator TOYOTA RAV4 2006 XA30 / 3.G User Guide

’06 Rav4_U (L/O 0601)
136
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
(q) Engine Oil Replacement ReminderLight
This light acts as a reminder to replace
the engine oil.
This light will come on when the ignition
key is turned to “ON” and will go off after
about a few seconds.
When you drive for about 7200 km (4500
miles) after the engine oil replacement,
this light illuminates for about 3 seconds
and then flashes for about 12 seconds
with the ignition key turned to the “ON”
position. If you continue driving without
replacing the engine oil, and if the dis-
tance driven exceeds 8000 km (5000
miles), the light will come on after the
ignition key is turned to “ON” position.
The light will remain on thereafter.
If the light is flashing, we recommend that
you replace the engine oil at an early
opportunity depending on the driving and
road conditions. If the light comes on,
replace it as soon as possible. The system must be reset after the en-
gine oil replacement. Reset the system by
the following procedure:
1. Turn the ignition key to the “OFF” posi- tion with the trip meter A reading
shown. (For details, see “Odometer and
two trip meters” on page 125 in this
Section.)
2. Turn the ignition key to the “ON” posi- tion while holding down the trip meter
reset knob.
Hold down the knob for at least 5 sec-
onds. The odometer indicates “000000”
and the light goes off.
If the system fails to reset, the light will
continue flashing.
(r) Key Reminder Buzzer
This buzzer acts as a reminder to remove
the key when you open the driver’s door
with the ignition key in the “ACC” or
“LOCK” position. CHECKING SERVICE REMINDER
INDICATORS (except the low fuel level
warning light
and low windshield
washer fluid level warning light)
1. Apply the parking brake.
2. Open one of the doors. The open door warning light should
come on.
3. Close the door. The open door warning light should go
off.
4. Turn the ignition key to “ON”, but do not start the engine.
All the service reminder indicators ex-
cept the open door warning light should
come on.
The following service reminder indica-
tors go off after a few seconds:
Engine oil replacement reminder light
Automatic transmission fluid tempera-
ture warning light
“ABS” warning light
“VSC” warning light
Tire pressure warning light
“4WD” warning light
Electric power steering system warning
light

’06 Rav4_U (L/O 0601)
137
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
“AUTO LSD” indicator light
(two−wheel drive models)
Slip indicator light
Downhill assist control system indicator
light
Four −wheel drive lock indicator light
The SRS warning light goes off after
about 6 seconds.
If any service reminder indicator or warn-
ing buzzer does not function as described
above, have it checked by your Toyota
dealer as soon as possible.

’06 Rav4_U (L/O 0601)
149
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
When the vehicle speed exceeds 40 km/h
(25 mph), the four−wheel drive lock will
be cancelled automatically.
The four −wheel drive lock indicator will
come on for a few seconds when the
ignition key is turned to “ON”.
If the indicator light does not come on
when the ignition key is turned to “ON” or
the four −wheel drive lock switch is
pushed, contact your Toyota dealer.
NOTICE
Use the fourwheel drive lock only
when driving on the loose surfaces,
such as sand, gravel, or deep snow,
or if the vehicle gets stuck. After the
fourwheel drive lock is used to pro-
vide traction, cancel the fourwheel
drive lock. Using the fourwheel drive
lock at other times may cause dam-
age to the fourwheel drive system.SYSTEM FAILURE WARING
The “4WD” warning light warns that there
is a problem somewhere in the active
torque control 4WD system.
The light will come on when the ignition
key is turned to “ON”. When the system
works properly, the light turns off after a
few seconds.
If the warning light does not come on
when the ignition key is turned to “ON”,
contact your Toyota dealer to service the
vehicle. If the “4WD” warning light flashes...
This indicates that the driveline tempera-
ture has become too high. Without turning
off the engine, do either of the following
to cool the driveline:
Reduce vehicle speed until the light
goes off.
Stop the vehicle at a safe place and
allow the engine to idle until the light
goes off.
If operation of the vehicle is continued
while the light is flashing, the system au-
tomatically shuts off the engine torque that
is applied to the rear wheels to protect
the driveline. If this happens, the light will
flash faster.
When the driveline temperature falls
enough, the light will go off.
If the “4WD” warning light remains on...
This indicates that the system may not
work properly. Contact your Toyota dealer
to service your vehicle.

’06 Rav4_U (L/O 0601)
287
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
For an explanation of this system’s warn-
ing light, see “Service reminder indicators
and warning buzzers” on page 127 in Sec-
tion 1−6.
The brake pad wear limit indicators on
your disc brakes give a warning noise
when the brake pads are worn to where
replacement is required.
If you hear a squealing or scraping noise
while driving, have the brake pads
checked and replaced by your Toyota
dealer as soon as possible. Expensive ro-
tor damage can result if the pads are not
replaced when necessary. The electric power steering system, us-
ing an electric motor, assists the turn-
ing of the steering wheel.
In the following cases, you may feel the
steering becomes heavy. However, the
electric power steering system warning
light does not come on. (Because it is
not a malfunction.)
When maneuvering or turning frequently
over a long time
The power steering effect will be re-
duced to prevent the system from over-
heating. Avoid turning the steering
wheel, or stop the vehicle and turn the
ignition key to “ACC” or “LOCK”. The
system will become cool in a
bout 10
minutes.
NOTICE
Frequent maneuvering and turning
over a long time may cause damage
to the system in which the mecha-
nism prevents overheating of the elec-
tric power steering system.
Brake pad wear limit
indicators Electric power steering system

’06 Rav4_U (L/O 0601)
356
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
Exhaust system
If you notice any change in the sound of
the exhaust or smell exhaust fumes, have
the cause located and corrected immedi-
ately. (See “Engine exhaust cautions” on
page 281 in Section 2.)
INSIDE THE VEHICLE
Items listed below should be checked
regularly, e.g. while performing periodic
services, cleaning the vehicle, etc.
Lights
Make sure the headlights, stop lights, tail
lights, turn signal lights, and other lights
are all working.
Service reminder indicators and warning
buzzers
Check that all service reminder indicators
and warning buzzers function properly.
Steering wheel
Check that it has the specified free play.
Be alert for changes in steering condition,
such as hard steering or strange noise.Seats
Check that all seat controls such as seat
adjusters, seatback recliner, etc. operate
smoothly and that all latches lock securely
in any position. For folding
−down rear
seatbacks, check that the latches lock se-
curely.
Seat belts
Check that the seat belt system such as
buckles, retractors and anchors operate
properly and smoothly. Make sure the belt
webbing is not cut, frayed, worn or dam-
aged.
Accelerator pedal
Check the pedal for smooth operation and
uneven pedal effort or catching.
Brake pedal
Check the pedal for smooth operation and
that the pedal has the proper clearance.
Check the brake booster function.
Brakes
In a safe place, check that the brakes do
not pull to one side when applied. Parking brake
Check that the lever has the proper travel
and that, on a safe incline, your vehicle
is held securely with only the parking
brake applied.
Automatic transmission “Park” mecha-
nism
On a safe incline, check that your vehicle
is held securely with the selector lever in
“P” position and all brakes released.
OUTSIDE THE VEHICLE
Items listed below should be performed
from time to time, unless otherwise
specified.
Fluid leaks
Check underneath for leaking fuel, oil, wa-
ter or other fluid after the vehicle has
been parked for a while. If you smell fuel
fumes or notice any leak, have the cause
found and corrected immediately.
Doors and engine hood
Check that all doors and back door oper-
ate smoothly and all latches lock securely.
Make sure the engine hood secondary
latch secures the hood from opening when
the primary latch is released.

’06 Rav4_U (L/O 0601)
358
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
Some states have vehicle emission in-
spection programs which include OBD
(On−Board Diagnostics) che cks.
The OBD system monitors the operation
of the emission control system. When the
OBD system determines that a problem
exists somewhere in the emission control
system, the malfunction indicator lamp
comes on. In this case, your vehicle may
not pass the I/M test and need to be
repaired. Contact your Toyota dealer to
service the vehicle.
Even if the malfunction indicator lamp
does not come on, your vehicle may not
pass the I/M test as readiness codes
have not been set in the OBD system.
Readiness codes are automatically set
during ordinary driving. However, when the
battery is disconnected or run down, the
codes are erased. Also, depending on
your driving habits, the codes may not be
completely set.
Also, if the malfunction indicator lamp had
come on recently due to temporary mal-
function such as a loose fuel tank cap,
your vehicle may not pass the I/M test. The malfunction indicator lamp will go off
after taking several driving trips, but the
error code in the OBD system will not be
cleared unless about 40 trips or more are
taken.
If your vehicle does not pass the I/M test
even the malfunction indicator lamp does
not come on, contact your Toyota dealer
to prepare the vehicle for re
−testing.
Emissions Inspection and
Maintenance (I/M) programs

’06 Rav4_U (L/O 0601)
409
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
L
Light bulbs386
. . . . . . . . . . . . . . . . . . . . . . . . . .
Light bulbs
Back −up light 389
. . . . . . . . . . . . . . . . . . . . . .
Front fog light 389
. . . . . . . . . . . . . . . . . . . . . .
Front side marker light 389
. . . . . . . . . . . . . .
Front turn signal light 389
. . . . . . . . . . . . . . .
Headlight 388
. . . . . . . . . . . . . . . . . . . . . . . . . .
License plate light 390
. . . . . . . . . . . . . . . . . .
Parking light 389
. . . . . . . . . . . . . . . . . . . . . . .
Rear side marker light 389
. . . . . . . . . . . . . .
Rear turn signal light 389
. . . . . . . . . . . . . . .
Light, Interior
Interior light 117
. . . . . . . . . . . . . . . . . . . . . . .
Personal light 117
. . . . . . . . . . . . . . . . . . . . . .
Light, Luggage compartment 118
. . . . . . . . . .
Load capacity 300
. . . . . . . . . . . . . . . . . . . . . . . .
Lock
Back door 26
. . . . . . . . . . . . . . . . . . . . . . . . . .
Side doors 22
. . . . . . . . . . . . . . . . . . . . . . . . .
Steering column 140
. . . . . . . . . . . . . . . . . . .
Low engine oil pressure
warning light 127
. . . . . . . . . . . . . . . . . . . . . . .
Low fuel level warning light 127
. . . . . . . . . . . .
Low windshield washer fluid level warning light 127
. . . . . . . . . . . . . . . . . .
Luggage compartment light 118
. . . . . . . . . . . .
Luggage cover 264
. . . . . . . . . . . . . . . . . . . . . . .
Luggage storage box 260
. . . . . . . . . . . . . . . . .
M
Maintenance
Do −it−yourself maintenance 363 . . . . . . . . .
Does your vehicle need repairing? 357 . . . . . . . . . . . . . . . . . . . . . . .
General maintenance 355 . . . . . . . . . . . . . . .
Maintenance requirements 354 . . . . . . . . . .
Parts and tools 364 . . . . . . . . . . . . . . . . . . . . .
Where to go for service 354 . . . . . . . . . . . . .
Malfunction indicator lamp 358 . . . . . . . . . . . .
Malfunction indicator lamp
Emissions Inspection and Maintenance (I/M) programs 127 . . . . . . .
Service reminder indicator 127 . . . . . . . . . .
Manual air conditioning system 238 . . . . . . . .
Maximum allowable speed
Automatic transmission 141,145 . . . . . . . . .
Mirror
Anti −glare inside rear view 110 . . . . . . . . . .
Mirrors
Folding rear view 110 . . . . . . . . . . . . . . . . . . .
Outside rear view 108 . . . . . . . . . . . . . . . . . .
Power rear view 109 . . . . . . . . . . . . . . . . . . . .
Vanity 111 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Moon roof 30 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
N
New vehicle break −in 277 . . . . . . . . . . . . . . . . .
O
Odometer 125
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Off −road driving precautions 308
. . . . . . . . . .
Oil
Consumption 282
. . . . . . . . . . . . . . . . . . . . . .
Viscosity and grade 368
. . . . . . . . . . . . . . . .
Oil consumption 282
. . . . . . . . . . . . . . . . . . . . .
Open door warning light 127
. . . . . . . . . . . . . . .
Operation in foreign countries 279
. . . . . . . . .
Outside temperature display 126
. . . . . . . . . . .
Overheating, Engine 324
. . . . . . . . . . . . . . . . . .
Overheating, Engine coolant 124
. . . . . . . . . .
Overview
Engine compartment 360
. . . . . . . . . . . . . . .
P
Parking brake
Operation 165 . . . . . . . . . . . . . . . . . . . . . . . . .
Reminder light 165 . . . . . . . . . . . . . . . . . . . . .
Polishing 347 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Positioning the jack 365 . . . . . . . . . . . . . . . . . .
Power outlet 256,257 . . . . . . . . . . . . . . . . . . . . .
Power rear view mirror control 109 . . . . . . . . .
Power steering 287 . . . . . . . . . . . . . . . . . . . . . . .
Power window switches 24 . . . . . . . . . . . . . . . .
Preloaders
(seat belt pretensioners) 62 . . . . . . . . . . . . .
Pretensioners
(seat belt pretensioners) 62 . . . . . . . . . . . . .
Protecting your Toyota
from corrosion 346 . . . . . . . . . . . . . . . . . . . . .

’06 Rav4_U (L/O 0601)
410
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
R
RadiatorChecking the radiator 371 . . . . . . . . . . . . . . .
Coolant, Engine 370 . . . . . . . . . . . . . . . . . . . .
Radio 170 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear audio/video system
Rear seat entertainment system 191 . . . . .
Rear cargo net 269 . . . . . . . . . . . . . . . . . . . . . . .
Rear console box 261 . . . . . . . . . . . . . . . . . . . .
Rear cup holder 262 . . . . . . . . . . . . . . . . . . . . . .
Rear seat
Third seat entry 40 . . . . . . . . . . . . . . . . . . . . .
Rear seat precautions 38 . . . . . . . . . . . . . . . . .
Rear step bumper 289 . . . . . . . . . . . . . . . . . . . .
Rear view mirror
Anti −glare inside 110 . . . . . . . . . . . . . . . . . . .
Rear view mirrors
Folding 110 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside 108 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power 109 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear window and outside rear view
mirror defogger switch 122 . . . . . . . . . . . . . .
Rear window wiper and washer switch 121 . . . . . . . . . . . . . . . . . . . . .
Rear/second seat 39 . . . . . . . . . . . . . . . . . . . . .
Remote controls 189 . . . . . . . . . . . . . . . . . . . . .
Reporting safety defects for U.S. owners 404 . . . . . . . . . . . . . . . . . . . .
Roof luggage carrier 272 . . . . . . . . . . . . . . . . . .
S
Seat adjustment precautions
Front seats 35 . . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt extender 60 . . . . . . . . . . . . . . . . . . . . .
Seat belts
Cleaning 349 . . . . . . . . . . . . . . . . . . . . . . . . . .
Fastening 53 . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt precautions 53 . . . . . . . . . . . . . . . .
Seat belt pretensioners 62 . . . . . . . . . . . . . .
Seat heater switch 52 . . . . . . . . . . . . . . . . . . . .
Seating capacity 300 . . . . . . . . . . . . . . . . . . . . .
Seats 34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Second seat 40 . . . . . . . . . . . . . . . . . . . . . . . . . .
Separation net fixing hook 268 . . . . . . . . . . . . .
Service and maintenance 354 . . . . . . . . . . . . .
Service reminder indicator 127 . . . . . . . . . . . .
Side door locks 22 . . . . . . . . . . . . . . . . . . . . . . .
Side doors 22 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Side vents 251 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spare fuse 384 . . . . . . . . . . . . . . . . . . . . . . . . . .
Spare tire 326 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spark plugs
Iridium −tipped spark plugs 283 . . . . . . . . . .
Specifications 392 . . . . . . . . . . . . . . . . . . . . . . .
SRS driver airbag and front
passenger airbag 64 . . . . . . . . . . . . . . . . . . .
SRS side airbags and curtain shield airbags 71 . . . . . . . . . . . . . . . . . . . . . . .
SRS warning light 127 . . . . . . . . . . . . . . . . . . . . Starting
Cold weather 306 . . . . . . . . . . . . . . . . . . . . . .
Engine 306 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 321 . . . . . . . . . . . . . . . . . . . . . .
Steering
Adjusting steering wheel 108 . . . . . . . . . . . .
Electric power steering system 287 . . . . . .
Steering column
Column lock 140
. . . . . . . . . . . . . . . . . . . . . . .
Sun visors 111
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension and chassis 291
. . . . . . . . . . . . . .
Switch
Emergency flasher 115
. . . . . . . . . . . . . . . . .
Headlight, dimmer and turn signal 114 . . . .
Ignition 140
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside rear view mirror defogger 122 . . . .
Rear window defogger 122
. . . . . . . . . . . . . .
Rear window wiper and washer 121 . . . . . .
Windshield wiper and washer 120 . . . . . . . .
T
Tachometer 125
. . . . . . . . . . . . . . . . . . . . . . . . .
Telescopic steering column 108
. . . . . . . . . . . .
Theft prevention labels 291
. . . . . . . . . . . . . . .
Three −way catalytic converters 280 . . . . . . . .
Tie −down hooks 263
. . . . . . . . . . . . . . . . . . . . .
Tilt steering wheel 108
. . . . . . . . . . . . . . . . . . . .
Tire pressure warning light 127,161 . . . . . . . .
Tire pressure warning system 161
. . . . . . . . .

’06 Rav4_U (L/O 0601)
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
Publication No. OM42620U
Part No. 01999-42620
Printed in Japan 01-0601-00
I
 ( U)
Quick index
If a service reminder indicator or warning buzzer comes on 127 . . . . . . . .
 If your vehicle will not start 320 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. .
 If your engine stalls while driving 323 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 If your vehicle overheats 324 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . .
 If you have a flat tire 325 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . .
 If your vehicle needs to be towed 337 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 Tips for driving during break −in period 277 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 How to start the engine 306 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . .
 General maintenance 355 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . .
 Complete index 405 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . .
Gas station information
Fuel type:
UNLEADED gasoline, Octane Rating 87 (Research Octane Number 91) or
higher
See page 277 for detailed information.
Fuel tank capacity:
60 L (15.9 gal., 13.2 Imp. gal.)
Engine oil:
ILSAC multigrade engine oil is recommended.
See page 369 for detailed information.
Tire information: See pages 372 through 380.
Tire inflation pressure: See page 397.
U6