brake fluid TOYOTA RAV4 PLUG-IN HYBRID 2022 Owners Manual

261
5
5-1. Before driving
Driving
WARNING
OThe brake system consists of 2 or more individual hydraulic systems;
if one of the systems fails, the other will still operate. In this case, the brake pedal should be depressed
more firmly than usual and the braking distance will increase. Have your brakes fixed immediately.
QIf the vehicle becomes stuck
Do not spin the wheels excessively
when any of the tires is up in the air, or the vehicle is stuck in sand, mud, etc. This may damage the driveline
components or propel the vehicle for- ward or backward, causing an acci-dent.
NOTICE
QWhen driving the vehicle
ODo not depress the accelerator and brake pedals at the same time
during driving, as this may restrain the hybrid system output.
ODo not use the accelerator pedal or depress the accelerator and brake
pedals at the same time to hold the vehicle on a hill.
QAvoiding damage to vehicle parts
ODo not turn the steering wheel fully
in either direction and hold it there for an extended period of time.Doing so may damage the power
steering motor.
OWhen driving over bumps in the
road, drive as slowly as possible to avoid damaging the wheels, under-side of the vehicle, etc.
QIf you get a flat tire while driving
A flat or damaged tire may cause the
following situations.
OIt may be difficult to control your vehicle.
OThe vehicle will make abnormal sounds or vibrations.
OThe vehicle will lean abnormally.
Hold the steering wheel firmly and gradually depress the brake pedal to
slow down the vehicle.
Information on what to do in case of a flat tire ( P.522, 533)
QWhen encountering flooded roads
Do not drive on a road that has flooded after heavy rain, etc. Doing so may cause the following serious dam-
age to the vehicle:
OEngine stalling
OShort in electrical components
OEngine damage caused by water
immersion
In the event that you drive on a
flooded road and the vehicle is flooded, be sure to have any autho-rized Toyota retailer or Toyota autho-
rized repairer, or any reliable repairer check the following:
OBrake function
OChanges in quantity and quality of oil and fluid used for the engine,
hybrid transaxle (front and rear), etc.
OLubricant condition for the bearings and suspension joints (where possi-ble), and the function of all joints,
bearings, etc.
OComponents connected to the trac-
tion battery.
QWhen parking the vehicle
Always set the parking brake, and shift the shift lever to P. Failure to do so may cause the vehicle to move or
the vehicle may accelerate suddenly if the accelerator pedal is accidentally depressed.

449
7 7-2. Maintenance
Maintenance and care
request that a record of maintenance
be kept.
QDoes your vehicle need repairs?
Be on the alert for changes in perfor-
mance and sounds, and visual tip-offs
that indicate service is needed. Some
important clues are:
OEngine missing, stumbling or pinging
OAppreciable loss of power
OStrange engine noises
OA fluid leak under the vehicle (How-
ever, water dripping from the air con-
ditioning system after use is normal.)
OChange in exhaust sound (This may
indicate a dangerous carbon monox-
ide leak. Drive with the windows open
and have the exhaust system checked
immediately.)
OFlat-looking tires, excessive tire
squeal when cornering, uneven tire
wear
OVehicle pulls to one side when driven
straight on a level road
OStrange noises related to suspension
movement
OLoss of brake effectiveness, spongy
feeling brake pedal, pedal almost
touches the floor, vehicle pulls to one
side when braking
OEngine coolant temperature continu-
ally higher than normal (P.551)
If you notice any of these clues, take
your vehicle to any authorized Toyota
retailer or Toyota authorized repairer, or
any reliable repairer as soon as possi-
ble.
Your vehicle may need adjustment or
repair.

451
7
7-3. Do-it-yourself maintenance
Maintenance and care
WARNING
QWhen working on the engine compartment
OMake sure that “IGNITION ON” on the multi-information display and the “READY” indicator are both off.
OKeep hands, clothing and tools away from the moving fan.
OBe careful not to touch the engine, power control unit, radiator, exhaust
manifold, etc. right after driving as they may be hot. Oil and other flu-ids may also be hot.
ODo not leave anything that may burn easily, such as paper and
rags, in the engine compartment.
ODo not smoke, cause sparks or
expose an open flame to fuel. Fuel fumes are flammable.
OTake care because brake fluid can harm your hands or eyes and dam-age painted surfaces. If fluid gets
on your hands or in your eyes, flush the affected area with clean water immediately. If you still experience
discomfort, consult a doctor.
QWhen working near the electric
cooling fan or radiator grille
Be sure the power switch is off. With the power switch in ON, the
electric cooling fan may automatically start to run if the air conditioning is on and/or the coolant temperature is
high. ( P.458)
QSafety glasses
Wear safety glasses to prevent flying or falling material, fluid spray, etc., from getting in your eyes.
NOTICE
QIf you remove the air cleaner fil-ter
Driving with the air cleaner filter removed may cause excessive engine wear due to dirt in the air.
QIf the fluid level is low or high
It is normal for the brake fluid level to
go down slightly as the brake pads wear or when the fluid level in the accumulator is high.
If the reservoir needs frequent refill- ing, it may indicate a serious problem.

5068-2. Steps to take in an emergency
5Securely attach cables or chains
to the towing eyelet.
Take care not to damage the vehicle
body.
6 Enter the vehicle being towed
and start the hybrid system.
Turn off the Parking Support Brake
function. (if equipped): P.379
If the hybrid system does not start, turn the power switch to ON.
7 Shift the shift lever to N and
release the parking brake.
Turn automatic mode off. ( P.283)
When the shift lever cannot be shifted:
 P.279
QWhile towing
If the hybrid system is not running, the power assist for the brakes and steering will not function, making steering and
braking more difficult.
QWheel nut wrench (if equipped)
Wheel nut wrench is installed in the deck under tray. ( P.523, 534)
Fluid leaks under the vehicle
(Water dripping from the air con-
ditioning after use is normal.)
 Flat-looking tires or uneven tire
wear
 High coolant temperature warn-
ing light flashes or come on
 Changes in exhaust sound
 Excessive tire squeal when cor-
nering
 Strange noises related to the
suspension system
 Pinging or other noises related to
the hybrid system
 Engine missing, stumbling or
running roughly
 Appreciable loss of power
If you think something is
wrong
If you notice any of the follow-
ing symptoms, your vehicle
probably needs adjustment or
repair. Contact any authorized
Toyota retailer or Toyota
authorized repairer, or any reli-
able repairer as soon as possi-
ble.
Visible symptoms
Audible symptoms
Operational symptoms

5088-2. Steps to take in an emergency
QBrake system warning light (warning buzzer)
QBrake system warning light
If a warning light turns on or a warning buzzer sounds
Calmly perform the following actions if any of the warning lights
comes on or flashes. If a light comes on or flashes, but then goes
off, this does not necessarily indicate a malfunction in the system.
However, if this continues to occur, have the vehicle inspected by
any authorized Toyota retailer or Toyota authorized repairer, or any
reliable repairer.
Actions to the warning lights or warning buzzers
Warning lightDetails/Actions
(Red)
Indicates that:
 The brake fluid level is low; or
 The brake system is malfunctioning
 Immediately stop the vehicle in a safe place
and contact any authorized Toyota retailer or
Toyota authorized repairer, or any reliable
repairer. Continuing to drive the vehicle may
be dangerous.
Warning lightDetails/Actions
(Yellow)
Indicates a malfunction in:
 The parking brake system;
 The regenerative braking system; or
 The electronically controlled brake system
 Have the vehicle inspected by any authorized
Toyota retailer or Toyota authorized repairer,
or any reliable repairer immediately.

5649-1. Specifications
*: The fluid capacity is the quantity of reference.
If replacement is necessary, contact any authorized Toyota retailer or Toyota
authorized repairer, or any reliable repairer.
*: Minimum pedal clearance when depressed with a force of 300 N (30.5 kgf, 67.4
lbf) while the hybrid system is operating.
QFull-size tire
Type A
Rear differential (rear electric motor)
Fluid capacity*1.7 L (1.8 qt., 1.5 Imp.qt.)
Fluid typeToyota Genuine ATF WS
NOTICE
QRear differential fluid type
Using differential fluid other than the above type may cause abnormal noise or vibration, or ultimately damage the differential of your vehicle.
Brakes
Pedal clear-
ance*
Left-hand drive
vehicles128 mm (5.0 in.) Min.
Right-hand drive
vehicles95 mm (3.7 in.) Min.
Pedal free play1.0  6.0 mm (0.04  0.24 in.)
Fluid typeSAE J1703 or FMVSS No. 116 DOT 3
SAE J1704 or FMVSS No. 116 DOT 4
Steering
Free playLess than 30 mm (1.2 in.)
Tires and wheels
Tire size225/60R18 100H

591Alphabetical Index
Electronic sunshade .................... 250
Jam protection function .............. 251
Operation ................................... 250
Emergency, in case of
If a warning buzzer sounds ........ 508
If a warning light turns on ........... 508
If a warning message is displayed
................................................. 518
If the 12-volt battery is discharged
................................................. 546
If the electronic key does not operate
properly.................................... 544
If the fuel filler door cannot be
opened..................................... 543
If the hybrid system will not start 541
If the vehicle is submerged or water
on the road is rising ................. 501
If you have a flat tire........... 522, 533
If you lose your keys .................. 543
If you think something is wrong.. 506
If your vehicle becomes stuck .... 555
If your vehicle has to be stopped in
an emergency .......................... 500
If your vehicle needs to be towed
................................................. 503
If your vehicle overheats ............ 551
Emergency brake signal .............. 392
Emergency flashers ..................... 500
Emergency tire puncture repair kit
..................................................... 522
Energy monitor ............................. 193
Engine
Compartment ............................. 455
Exhaust gas precautions.............. 47
Hood .......................................... 452
How to start the hybrid system... 273
Identification number.................. 559
If the hybrid system will not start 541
If your vehicle has to be stopped in
an emergency .......................... 500
Overheating ............................... 551Power switch .............................. 273
Engine coolant
Capacity ..................................... 562
Checking .................................... 457
High coolant temperature warning
light .......................................... 509
Preparing and checking before win-
ter ............................................. 398
Warning light .............................. 509
Engine coolant temperature gauge
..................................................... 172
Engine oil
Capacity ..................................... 561
Checking .................................... 455
Preparing and checking before win-
ter ............................................. 398
Warning light .............................. 509
EPS (Electric Power Steering)
Function ..................................... 392
Warning light .............................. 510
EV/HV mode selection switch........ 86
EV driving range ........................... 102
EV mode ..........................................85
Exhaust gas precautions ............... 47
Extended Headlight Lighting system
..................................................... 289
F
Flat tire ................................... 522, 533
Tire pressure warning system .... 465
Floor mats ....................................... 32
Fluid
Brake .......................................... 564
Hybrid transmission.................... 563
Rear differential .......................... 564
Washer ....................................... 459
Fog lights
Replacing light bulbs ..................491
Switch......................................... 293
Footwell lights............................... 419
Front fog lights

600Alphabetical Index
Vanity lights................................ 430
Wattage...................................... 565
Vanity mirrors ............................... 430
Vehicle data recordings ................... 7
Vehicle identification number ..... 558
Vehicle Stability Control (VSC) ... 391
Ventilators (seat ventilators) ....... 416
VSC (Vehicle Stability Control) ... 391
W
Warning buzzers
Approach warning ...................... 339
Brake hold .................................. 514
Brake Override System .............. 514
Brake system ............................. 508
BSM OFF indicator .................... 513
Charging system ........................ 509
Downshifting ...................... 279, 281
Drive-Start Control ..................... 514
Electric power steering............... 510
High coolant temperature........... 509
Hybrid system overheat ............. 509
Low engine oil pressure ............. 509
LTA (Lane Tracing Assist) . 318, 511
Open door .................................. 206
Open hood ................................. 206
Open window ............................. 248
PKSB OFF indicator................... 512
Pre-collision warning .......... 311, 511
Radar cruise control ................... 339
RCTA (Rear Crossing Traffic Alert)
................................................. 349
RCTA OFF indicator .................. 513
RSA (Road Sign Assist) ............. 328
Seat belt reminder.............. 515, 516
Shift position ...................... 280, 281
Toyota parking assist ................. 371
Toyota parking assist-sensor OFF
indicator ................................... 512
Vehicle sway warning ................ 322
Warning lightsABS ............................................ 510
Brake hold operated indicator .... 514
Brake Override System .............. 514
Brake system .............................508
BSM OFF indicator..................... 513
Charging system ........................ 509
Driver’s seat belt reminder light.. 515
Drive-Start Control ..................... 514
Electric power steering ............... 510
Engine ........................................510
Front passenger’s seat belt reminder
light .......................................... 515
High coolant temperature ........... 509
Hybrid system overheat ............. 509
Low engine oil pressure ............. 509
Low fuel level .............................515
LTA indicator .............................. 511
Malfunction indicator lamp ......... 510
Parking brake indicator .............. 514
PCS warning light.......................511
PKSB OFF indicator ................... 512
PKSB.......................................... 512
RCTA OFF indicator................... 513
Rear passengers’ seat belt reminder
lights......................................... 516
Seat belt reminder light ...... 515, 516
Slip indicator............................... 513
SRS ............................................ 510
Tire pressure .............................. 515
Toyota parking assist-sensor OFF
indicator ...................................512
Warning messages .......................518
Washer
Checking .................................... 459
Low washer fluid warning message
......................................... 459, 518
Preparing and checking before win-
ter ............................................. 398
Switch................................. 294, 296
Washing and waxing .................... 442
Wheels ........................................... 473