WARNING VAUXHALL COMBO 2014 Repair Manual

Vehicle care143Tyre designationsE.g. 215/60 R 16 95 H215=Tyre width, mm60=Cross-section ratio (tyre
height to tyre width), %R=Belt type: RadialRF=Type: RunFlatC=Cargo or commercial use16=Wheel diameter, inches95=Load index e.g. 95 is
equivalent to 690 kgH=Speed code letter
Speed code letter:
Q=up to 100 mphS=up to 112 mphT=up to 118 mphH=up to 130 mphV=up to 150 mphW=up to 168 mph
Tyre pressure
Check the pressure of cold tyres at
least every 14 days and before any
long journey. Do not forget the spare
wheel.
Unscrew the valve cap.
Tyre pressure 3 174.
The tyre pressure data refers to cold
tyres. It applies to summer and winter tyres.
Always inflate the spare tyre to the
pressure specified for full load.
Incorrect tyre pressures will impair
safety, vehicle handling, comfort and fuel economy and will increase tyre
wear.
The driver is responsible for correct
adjustment of tyre pressures.9 Warning
If the pressure is too low, this can
result in considerable tyre warm-
up and internal damage, leading to tread separation and even to tyre
blow-out at high speeds.
Tread depth
Check tread depth at regular
intervals.
Tyres should be replaced for safety
reasons at a tread depth of 2-3 mm (4 mm for winter tyres).
For safety reasons, it is
recommended that the tread depth of
the tyres on one axle should not vary
by more than 2 mm.
The legally permissible minimum
tread depth (1.6 mm) has been
reached when the tread has worn
down as far as one of the tread wear
indicators (TWI). Their position is
indicated by markings on the
sidewall.
If there is more wear at the front than
the rear, swap round front wheels and
rear wheels periodically. Ensure that
the direction of rotation of the wheels
is the same as before.

144Vehicle care
Tyres age, even if they are not used.
We recommend tyre replacement
every 6 years.
Changing tyre and wheel
size
If tyres of a different size than those
fitted at the factory are used, it may be necessary to reprogramme the
speedometer as well as the nominal
tyre pressure and make other vehicle modifications.
After converting to a different tyre
size, have the label with tyre
pressures replaced.9 Warning
Use of unsuitable tyres or wheels
may lead to accidents and will
invalidate the vehicle type
approval.
Wheel covers
Wheel covers and tyres that are
factory approved for the respective
vehicle and comply with all of the
relevant wheel and tyre combination requirements must be used.
If the wheel covers and tyres used are
not factory approved, the tyres must
not have a rim protection ridge.
Wheel covers must not impair brake
cooling.9 Warning
Use of unsuitable tyres or wheel
covers could lead to sudden
pressure loss and thereby
accidents.
Tyre chains
Tyre chains are only permitted on the
front wheels.
Always use fine mesh chains that add no more than 10 mm to the tyre tread
and the inboard sides (including chain lock).
Do not exceed 30 mph when tyre
chains are fitted.
9 Warning
Damage may lead to tyre blowout.

Vehicle care145Tyre repair kit
Minor damage to the tyre tread can be
repaired with the tyre repair kit.
Do not remove foreign bodies from
the tyres.
Tyre damage exceeding 4 mm or that is at tyre's sidewall cannot be repairedwith the tyre repair kit.9 Warning
Do not drive faster than 50 mph.
Do not use for a lengthy period.
Steering and handling may be
affected.
If you have a flat tyre:
Apply the parking brake and engage
first or reverse gear.
The tyre repair kit may be located
under the front seat, in the glovebox,
or on the right side of the load
compartment behind a cover.
1. Take the tyre repair kit from the vehicle.
2. Remove the compressor.
3. Set the compressor upright near the tyre.
4. Unscrew valve cap from defective
tyre.5. Screw the flexible filler hose onto the tyre valve.
6. The switch on the compressor must be set to J.
7. Connect the compressor plug to the power outlet or cigarette
lighter socket.
To avoid discharging the battery,
we recommend running the
engine.

148Vehicle care
■ Do not start the vehicle when it israised on the jack.
■ Clean wheel nuts and thread with a
clean cloth before mounting the
wheel.9 Warning
Do not grease wheel bolt, wheel
nut and wheel nut cone.
1. Disengage wheel nut caps with a screwdriver and remove. Pull off
the wheel cover using a suitable
tool.
2. Attach wheel wrench securely and loosen each wheel nut by halfa turn.
3. Vehicle jacking points are located
at the front and rear.
4. Set the jack to the necessary height. Position it directly below
the jacking point in a manner that prevents it from slipping.

152Vehicle careJump startingDo not start with quick charger.
A vehicle with a discharged battery
can be started using jump leads and the battery of another vehicle.9 Warning
Be extremely careful when starting
with jump leads. Any deviation
from the following instructions can
lead to injuries or damage caused
by battery explosion or damage to the electrical systems of both
vehicles.
9 Warning
Avoid contact of the battery with
eyes, skin, fabrics and painted
surfaces. The fluid contains
sulphuric acid which can cause
injuries and damage in the event
of direct contact.
■ Never expose the battery to naked flames or sparks.
■ A discharged battery can alreadyfreeze at a temperature of 0 °C.
Defrost the frozen battery before
connecting jump leads.
■ Wear eye protection and protective
clothing when handling a battery.
■ Use a booster battery with the same voltage (12 Volts). Its
capacity (Ah) must not be much less than that of the discharged
battery.
■ Use jump leads with insulated terminals and a cross section of at
least 16 mm 2
(25 mm 2
for diesel
engines).
■ Do not disconnect the discharged battery from the vehicle.
■ Switch off all unnecessary electrical
consumers.
■ Do not lean over the battery during jump starting.
■ Do not allow the terminals of one lead to touch those of the other
lead.■ The vehicles must not come into contact with each other during the
jump starting process.
■ Apply the parking brake, transmission in neutral.
Lead connection order:
1. Connect the red lead to the positive terminal of the booster
battery.
2. Connect the other end of the red lead to the positive terminal of the
discharged battery.

Service and maintenance159Recommended fluids,
lubricants and parts
Recommended fluids andlubricants
Only use products that meet the
recommended specifications.
Damage resulting from the use of
products not in line with these
specifications will not be covered by
the warranty.9 Warning
Operating materials are
hazardous and could be
poisonous. Handle with care. Pay
attention to information given on
the containers.
Engine oil
Engine oil is identified by its quality
and its viscosity. Quality is more
important than viscosity when
selecting which engine oil to use. The oil quality ensures e.g. engine
cleanliness, wear protection and oil
ageing control, whereas viscosity
grade gives information on the oil's
thickness over a temperature range.
Dexos is the newest engine oil quality
that provides optimum protection for petrol and diesel engines. If it is
unavailable, engine oils of other listed qualities must be used.
Recommendations for petrol engines
are also valid for Compressed Natural
Gas (CNG) fuelled engines.
Select the appropriate engine oil
based on its quality and viscosity
3 162.
Topping up engine oil
Engine oils of different manufacturers and brands can be mixed as long as
they comply with the required engine
oil quality and viscosity.
Use of engine oil with only
ACEA A1/B1 or only A5/B5 quality is
prohibited, since it can cause long-
term engine damage under certain
operating conditions.
Select the appropriate engine oil
based on its quality and viscosity
3 162.Additional engine oil additives
The use of additional engine oil
additives could cause damage and
invalidate the warranty.
Engine oil viscosity
The SAE viscosity grade gives
information on the thickness of the oil.
Multigrade oil is indicated by two
figures, e.g. SAE 5W-30. The first
figure, followed by a W, indicates the low temperature viscosity and the
second figure the high temperature viscosity.
Select the appropriate viscosity grade 3 162.
All of the recommended viscosity
grades are suitable for high ambient
temperatures.
Coolant and antifreeze
Use only antifreeze approved for the
vehicle. Consult a workshop.
The system is factory filled with
coolant designed for excellent
corrosion protection and frost
protection down to approx. -28 °C. In
northern countries with very low

180IndexAAccessories and vehicle modifications .......................... 125
Adjustable air vents .....................99
Airbag activation ........................... 79
Airbag and belt tensioners ...........73
Airbag deactivation ..........45, 74, 79
Airbag system .............................. 41
Air conditioning regular operation ................................ 100
Air conditioning system ................ 96
Air intake .................................... 100
Air vents........................................ 99
Alert .............................................. 85
Antilock brake system ................ 112
Antilock brake system (ABS) .......75
Anti-Slip Regulator (ASR) ...........113
Anti-theft locking system .............. 26
Appearance care ........................155
Armrest ......................................... 35
Ashtrays ....................................... 67
ASR (Anti-Slip Regulator) ...........113
Audible warning chimes................ 85
Autoclose ...................................... 79
Automatic fuel cut-off ............85, 103
Automatic locking .........................79B
Battery ....................................... 130
Battery discharge protection ........94
Belts.............................................. 38 Bonnet ....................................... 127
Brake and clutch fluid .................159
Brake assist ............................... 113
Brake fluid .................................. 130
Brake pad wear ............................ 75
Brakes ............................... 112, 130
Brake system ............................... 74
Breakdown.................................. 153
Bulb replacement ....................... 132
C Capacities .................................. 173
Car Pass ...................................... 19
Catalytic converter .....................107
Central locking system ................21
Centre high-mounted brake light 135
Change engine oil .......................77
Changing tyre and wheel size ...144
Charging system .......................... 74
Child locks ................................... 22
Child restraint installation locations ................................... 49
Child restraints.............................. 47
Child restraint systems ................47

181
Child safety system for rearwindows .................................... 29
Chimes ......................................... 85
Cigarette lighter ........................... 66
Climate control ............................. 14
Climate control systems ...............95
Clock....................................... 63, 79
Control indicators.......................... 70
Control of the vehicle .................101
Controls ........................................ 61
Convex shape .............................. 27
Coolant and antifreeze ...............159
Cruise control ...................... 79, 115
Cupholders .................................. 54
D
Danger, Warnings and Cautions ...3
Date .............................................. 79
Daytime running lights ............79, 89
Diesel particle filter ...............76, 106
Distance to next service ...............79
Door open .................................... 79
Doors ...................................... 23, 25
Drain fuel filter ............................. 78
Driver Information Centre .............79
Driving characteristics and towing tips .............................. 123
Driving hints ................................ 101E
Eco mode (E).............................. 111
Electric adjustment ......................27
Electrical system......................... 138
Electronic climate control system 97
Electronic driving programmes ..111
Electronic Stability Program 76, 114
End-of-life vehicle recovery .......126
Engine compartment fuse box ...139
Engine coolant ........................... 128
Engine coolant temperature ........76
Engine coolant temperature gauge ....................................... 69
Engine data ............................... 164
Engine exhaust .......................... 106
Engine oil ................... 127, 159, 162
Engine oil pressure ......................77
ESP (Electronic Stability Program) ................................. 114
Event data recorders ..................177
Extendable load compartment cover ................................... 55, 59
Exterior care .............................. 155
Exterior light ................................. 78
Exterior lighting ......................11, 88
Exterior mirrors ............................. 27F
Fault ........................................... 111
Fixed air vents ........................... 100
Fog light ....................................... 79
Folding ......................................... 28
Folding seats ................................ 55
Front airbag system .....................44
Front fog lights ............................. 90
Front seats.................................... 33
Front turn signal light ..................132
Fuel............................................. 118
Fuel consumption .........................79
Fuel consumption - CO 2-
Emissions ............................... 122
Fuel cut-off system ...............85, 103
Fuel for diesel engines ..............119
Fuel for natural gas operation ...119
Fuel for petrol engines ...............118
Fuel gauge ................................... 68
Fuel selector ................................ 69
Fuel system messages .................85
Fuses ......................................... 138
G Gauges ......................................... 67
General information ...................123
Generic warning ........................... 73
Glovebox ..................................... 54
Gross Vehicle Weight ...................59

182
HHalogen headlights ....................132
Hand brake ................................. 112
Hazard warning flashers ..............90
Headlight flash ............................. 88
Headlight range adjustment ........89
Headlights..................................... 88
Headlights when driving abroad ..89
Head restraint adjustment .............8
Head restraints ............................ 32
Heated mirrors ............................. 28
Heated rear window ..................... 31
Heating ........................................ 35
Heating and ventilation system ...95
High beam ............................. 79, 88
Hill start assist ...................... 75, 113
Horn ....................................... 13, 62
I
Identification plate .....................161
Ignition switch positions .............102
Immobiliser ............................ 26, 78
Indicators ...................................... 67
Information displays...................... 79
Instrument cluster ........................67
Instrument panel fuse box .........140
Instrument panel illumination .....138
Instrument panel illumination control ...................................... 91Instrument panel overview ........... 10
Instrument panel storage ..............53
Interior care ............................... 156
Interior lighting ........................ 79, 91
Interior lights ........................ 92, 137
Interior mirrors .............................. 28
Introduction .................................... 3
ISOFIX child restraint systems ....52
J
Jump starting ............................. 152
K Kerb weight................................... 59Keys ............................................. 19
Keys, locks ................................... 19
L
Language ..................................... 79
Lashing eyes ......................... 58, 59
Light switch .................................. 88
Load compartment ................25, 55
Load compartment cover .............55
Load compartment lighting ...........93
Loading ......................................... 55
Loading information .....................59
Low engine oil level .....................78
Low fuel ....................................... 78M
Malfunction indicator light ............74
Manual adjustment ......................27
Manual anti-dazzle ......................28
Manual mode ............................. 110
Manual transmission .................. 107
Manual transmission automated 108
Manual windows ..........................29
Mirror adjustment ........................... 8
Misted light covers .......................91
Multifunction display .....................79
N New vehicle running-in ..............101
Number plate light .....................136
O Object detection systems ...........116
Odometer ..................................... 67
Oil, engine .......................... 159, 162
Operating windows from outside ..29
Outside temperature ....................63
Overhead console .......................54
Overrun cut-off ........................... 103
P Parking ................................ 17, 105
Parking assist ............................ 116
Parking brake ............................ 112
Particulate filter ........................... 106

183
Payload......................................... 59
Performance .............................. 166
Performing work ........................126
Pollen filter ................................. 100
Power outlets ............................... 65
Power steering fluid ....................129
Power windows ............................ 29
Preheating ................................... 76
Puncture ..................................... 147
R
Radio Frequency Identification (RFID) ..................................... 178
Radio info ..................................... 79
Radio remote control ...................20
Rear doors ................................... 23
Rear fog light ............................... 79
Rear fog lights ............................. 91
Rear parcel shelf .......................... 55
Rear seats ............................. 36, 55
Rear windows .............................. 31
Rear window wiper/washer .......... 63
Recommended fluids and lubricants ........................ 159, 162
Refuelling ................................... 120 Reversing lights ........................... 91
Ride control systems ..........113, 114
Roof load ...................................... 59
Roof rack ..................................... 58
Roof racks .................................... 59S
Safety belts ................................... 38
Seat adjustment ....................... 7, 33
Seat belt ........................................ 8
Seat belt reminder .......................73
Seat belt reminder warning chime 79
Seat belts ..................................... 38
Seat position ................................ 33
Selector lever ............................. 109
Service ............................... 100, 158
Service display ......................70, 79
Service information ....................158
Settings menu............................... 79
Side airbag system ......................45
Sidelights ...................................... 88
Side turn signal lights ................135
Sliding door .................................. 23
Sliding side door ........................... 23
Spare wheel ............................... 149
Speed limit warning chime............ 79
Speedometer ............................... 67
Standard display ........................... 79
Starting and operating ................101
Starting off ................................... 16
Starting the engine ............102, 108
Steering wheel adjustment ......9, 61
Steering wheel controls ...............61
Stop-start system.................. 78, 103
Storage ......................................... 53Storage compartments.................53
Sun visors .................................... 31
Symbols ......................................... 4
T
Tachometer ................................. 68
Tailgate ......................................... 25
Tail lights ................................... 134
Temperature ................................. 79
Three-point seat belt .................... 39 Tools .......................................... 142
Top-tether fastening eyes ............52
Towing ................................ 123, 153
Towing another vehicle .............154
Towing the vehicle .....................153
Traction Control system ............. 113
Trailer coupling ........................... 123
Trailer towing ............................. 123
Transmission ............................... 15
Transmission display .................108
Tread depth ............................... 143
Trip computer ......................... 79, 86
Trip odometer .............................. 67
Turn and lane-change signals .....90
Turn signal ................................... 73
Tyre chains ................................ 144
Tyre designations ......................143
Tyre pressure ............................ 143
Tyre pressures ........................... 174
Tyre repair kit ............................. 145