lock VOLKSWAGEN BORA 1998 Manual Online

Downloaded from www.Manualslib.com manuals search engine 01-195


V.A.G 1551 print-
out Possible cause
Repair
00285
Right front ABS
wheel speed
sensor -G45-
1)
Implausible signal
Open circuit; short to ground or loose
contact in wiring between Right front ABS
wheel speed sensor -G45- and ABS
control module (w/EDL) -J104- - Check wiring and
Connection using wiring
diagram
- Perform electrical
check Page 01
-288
Electrical interferences from other sources
(high frequency radiation e.g. uninsulated
ignition cable) - Read measured value
block Page 01
-240
Display Group number
001
1) This DTC is only recognized above 20 km/h (13 mph) (carry out test drive).
Стр. 37из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-196


V.A.G 1551 print-
out Possible cause
Repair
00285
Right front ABS
wheel speed sensor
-G45-
Mechanical
malfunction
1)
Excessive air gap between
Right front ABS wheel speed
sensor-G45- and rotor
(signal not OK)
Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ABS system on
front and rear axles - Check installation of right front
ABS wheel speed sensor -G45- and
rotor
- Read measured value block
Page 01
-240 Display group
numbers 001 and 002
- Perform test drive


Short to positive or ground in
wiring - Check wiring and connections
using wiring diagram
- Perform electrical check Page
01-288

Right front ABS wheel speed
sensor -G45- faulty
Repair Manual, Brake System,
Repair Group 45 - Replace Right front ABS wheel
speed sensor -G45-
1) This DTC is only recognized above 20 km/h (13 mph) (carry out test drive).
Стр. 38из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-197


V.A.G 1551 print-
out Possible cause
Repair
00287
Right rear ABS
wheel speed
sensor -G44-
1)
Electrical
malfunction in
current circuit
Open circuit in wiring between
Right rear ABS wheel speed
sensor -G44- and ABS control
module (w/EDL) -J104-
Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ABS system on
front and rear axles - Check wiring and connections
using wiring diagram
- Perform electrical check Page
01-288
- Read measured value block
Page 01
-240 Display group number
001
Right rear ABS wheel speed
sensor -G44- faulty - Replace right rear ABS wheel
speed sensor -G44-
Repair Manual, Brake System,
Repair Group 45
1) This malfunction is recognized when vehicle is stationary.
Стр. 39из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-198


V.A.G 1551 print-
out Possible cause
Repair
00287
Right rear ABS
wheel speed
sensor -G44-
1)
Implausible signal
Open circuit; short to ground or loose
contact in wiring between Right rear ABS
wheel speed sensor -G44- and ABS
control module (w/EDL) -J104- - Check wiring and
connections using wiring
diagram

- Perform electrical
check Page 01
-288
Electrical interferences from other sources
(high frequency radiation e.g. uninsulated
ignition cable) - Read measured value
block Page 01
-240
Display group number
001
1) This DTC is only recognized above 20 km/h (13 mph) (carry out test drive).
Стр. 40из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-199


V.A.G 1551 print-
out Possible cause
Repair
00287
Right rear ABS
wheel speed
sensor -G44-
1)
Mechanical
malfunction
Excessive air gap between
Right rear ABS wheel speed
sensor -G44- and rotor
(signal not OK) Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ABS system on
front and rear axles - Check installation of speed sensor
-G44- and rotor
- Read measured value block
Page 01
-240 Display group numbers
001 and 002
- Perform test drive

Short to positive or ground in
wiring - Check wiring and connections
using wiring diagram
- Perform electrical check Page
01-288
Right rear ABS wheel speed
sensor -G44- faulty
Repair Manual, Brake System,
Repair Group 45 - Replace speed sensor -G44-
1) This DTC is only recognized above 20 km/h (13 mph) (carry out test drive).
Стр. 41из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-200


V.A.G 1551
print-out Possible cause
Repair
00290
Left rear ABS
wheel speed
sensor -G46-
1)
Open circuit; short to positive or ground,
or loose contact in connections between
Left rear ABS wheel speed sensor -
G46- and ABS control module (w/EDL) -
J104-
Repair Manual, Brake
System, Repair Group 45;
Removing and installing parts of
ABS system on front and rear
axles - Check wiring and connections
using wiring diagram
- Perform electrical check
Page 01
-288
- Read measured value block
Page 01
-240 Display group
number 001
If the malfunction occurs again:


Left rear ABS wheel speed sensor -
G46- faulty
Repair Manual, Brake
System, Repair Group 45 - Replace Left rear ABS wheel
speed sensor -G46-
1) This DTC is recognized when vehicle is stationary.
Стр. 42из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-201


V.A.G 1551 print-
out Possible cause
Repair
00290
Left rear ABS
wheel speed
sensor -G46-
1)
Implausible
signal
Open circuit; short to ground or loose
contact in wiring between Left rear ABS
wheel speed sensor -G46- and ABS
control module (w/EDL) -J104- - Check wiring and
connections using wiring
diagram

- Perform electrical check
Page 01
-288
Electrical interferences from other sources
(high frequency radiation e.g. uninsulated
ignition cable) - Read measured value
block Page 01
-240
Display group number
001
1) This DTC is only recognized above 20 km/h (13 mph) (carry out test drive).
Стр. 43из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-202


V.A.G 1551 print-
out Possible cause
Repair
00290
Left rear ABS
wheel speed
sensor -G46-
1)
Mechanical
malfunction
Excessive air gap between
Left rear ABS wheel speed
sensor -G46- and rotor
(signal not OK) Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ABS system on
front and rear axles - Check installation of speed sensor -
G46- and rotor
- Read measured value block
Page 01
-240 Display group numbers
001 and 002
- Perform test drive

Short to positive or ground in
wiring - Check wiring and connections
using wiring diagram
- Perform electrical check Page
01-288
Left rear ABS wheel speed
sensor -G46- faulty
Repair Manual, Brake System,
Repair Group 45 - Replace Left rear ABS wheel speed
sensor -G46-
1) This DTC is only recognized above 20 km/h (13 mph) (carry out test drive).
Стр. 44из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-205


V.A.G 1551
print-out Possible cause
Repair
00526
Brake light
switch -F-
1)
Implausible
signal

- Read measured value block Page 01
-240
Display group number 002

Open circuit, short to
positive or ground in the
wiring - Check wiring and connections using wiring
diagram
- Perform electrical check Page 01
-288

Brake light switch
improperly adjusted

Brake light switch faulty Repair Manual, Brake System, Repair Group 46; Brake pedal - Assembly overview;
Adjusting brake light switch - Adjust brake light switch
1) For ABS/EDL/ASR/ESP and ABS/EDL/ASR/ESP 4MOTION
Стр. 47из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-209


V.A.G 1551
print-out Possible cause
Repair
00778
Steering angle
sensor -G85-
1)
Mechanical
malfunction


Steering wheel has been
removed and no subsequent
zero compensation performed - Perform a zero compensation:
- Initiate basic settings Page 01
-
264 Display group number 060

Check specification from
steering angle sensor -G85- - Read measured value block
Page 01
-240 Display group number
004

Steering geometry of
suspension is not OK.
Repair Manual, Suspension,
Wheels, Steering, Repair Group 44;
Vehicle alignment - Check vehicle alignment

Installation of steering angle
sensor -G85- is not OK - Check installation of steering angle
sensor -G85-


Steering angle sensor -G85-
faulty
Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ESP system - Replace steering angle sensor -
G85-
1) For ABS/EDL/ASR/ESP and ABS/EDL/ASR/ESP 4MOTION
Стр. 51из 129 On Board Diagnostic (OBD), performing