Spark VOLKSWAGEN PASSAT 1999 Owners Manual

Service at km) -ALL
Engine:
Engine:
Exhaust system:
Fuel filter: Replace (TDl engine
(Golf, Jetta, New Beetle)
Spark p lugs: Rep lace (except Touareg VB)
Air cleane r: Replace filter element
Dust and pollen filter (where applicable): Replace
V-belt:
belt: change (Touareg VB only)
Windshield washer:
Automatic shift lock: operation including park/neutral/safety switch
Automatic transmission:
Manual transmission : oil leve l; add if necessary; check for leaks
Continued on next page
19

Battery
Can cause blindness or severe burns.
Flush eyes immediately with water. Get medical help fast.
Always keep the battery
Always wear eye protec­tion. Do not let battery acid or any lead particles
get on your skin or clo­
thing.
Do not expose the battery
to an open flame, electric sparks or an open light. Do
not smoke. Do not reverse polarity.
Battery acid contains sul­
furic acid. Always wear
gloves and eye protection. Do not tilt the battery be­
cause acid could leak out of the
ventilation openings.
get a doctor imme­
diately.
of California to
cause cancer and reproductive harm. Wash hands after handling.
45

is on the
driver's side so that it is from th e out­
side through the
-see tion above.
The safety compliance sticker
is your assurance that your new Motor
Safety Standards which were in ef­
fect at the time the
can find this sticker on the
shows the mon th and year of production
and the
(perforat ion) as as the
Gross
Weight Rating (GAWR).
The high
is on the carrier.
The spark ignition system meets require­
ments of th e sin g Equipment
in chapter compart­
and chapter
AND
is on the side of th e rear
contains the
designation
Engine output in
Paint no.
4 -
found in your Mainte­
nance
------------- -----3

rpm
Ma xi
mum torque SAE net 166 ft. rpm
(225
Nm at
(1.781cm 3)
Stroke
in (
86.4 mm)
Bore 3.19 in ( mm)
ratio 9.5: 1
Premium 1
Capacities
tank in gal. 62
Reserve in gal.
in
washer container in quarts. 6.2
E ng ine
in quarts.
Automatic Manual
transmission transmission
w ithout brakes in lbs.
with brakes in lbs. kg) (91
in lbs. 165 (75 kg)
Note For maximum engine performance.
The engine be checked topping up.
The spark ignition system meets
-see AND
chapter

net
rpm)
No .
of 6
(2.771cm3)
Stroke 3.40
in ( 86.4 mm)
Bore
3.24 in ( 82 .5 mm)
or
Capacities
tank in gal.
capacity )
liters 6.8/6.2
Engine
with brakes in lbs. /kg
Tongu e in lbs. /kg 165/75
Note 1
l For maximum engine performance, Premium is recommended.
Further see tank." chapter
2l The engine topping up.
The spark ignition system meets requirements of the Canadian ference-Causing Equipment tions.
Do not -see "Engine chapter AND
3l towing," chapter AND PROTECTING

Engine data
Maximum output
rpm
Nm at
1
1l or
Capacities
tank in gal. 62
Reserve
in gal.
washer container in quarts. 6.2
Engine in quarts.
Maximum
without bra kes in lbs. kg
with brakes in lbs. !kg
in lbs.
For maximum engine performance.
LING booklet 3.2 .
be checked while
topp ing up.
The spark ignition system meets requirements of the Canadian ference-Causing Equipment
-see .. Engine ... chapter
chap ter

Passat
at 2. rpm
(370 Nm at
ratio 10.8: 1
Reserve in gallons (included in
Engine in quarts
with brakes in lbs. /kg
Tongue in lbs. /kg 185
is recommended.
Fur1herdetails see
See Booklet 3.2 . 2l The engine topping up.
The spark ignition system meets
-see AND See Booklet 3.2.
chapter AND See Booklet 3.2.
6------------------------------------------------------

Passat
Maximum output SAE net 275 hp at rpm
Maximum torque SAE net 272 ft. rpm Nm at 2.
mm)
Bore 3.29 in ( mm)
Premium1l
Capacities
tank in gallons
Reserve in gallons capacity )
Engine in quarts 8.3
Maximum
without brakes in lbs.
with brakes in lbs.
Tongue in lbs.
Note l) For maximum engine performance.
chapter
The engine topping up.
The spark ignition system meets requirements of the Canadian
chapter
Booklet 3.2 .
AND Booklet 3.2.
8------------------------------------------------------