battery VOLVO 240 1990 User Guide

Volvo 1990 240 Model
dealer.

Condition: Starter fails to operate (or operates very slowly)
Possible cause Correction
Weak battery or dead cell. With the starting (ignition) switch in the "Driving"
or "On" position, check to see if the warning lights
on the dashboard come on and if they stay on when
the starter is engaged. If the lights do not come on or
if they go off when the starter is engaged, the battery
is discharged or see below.
Loose or corroded battery cable terminals. Check battery terminals and clamps. Clean or
replace if necessary. Check that the starter cable is
secure at its terminals.
The ground strap, which connects the battery
negative (-) terminal to the engine, should also be
checked for corrosion or looseness.
Open circuit between starting (ignition) switch
and starting (ignition) switch terminal on
starter. The circuit is closed if a clicking sound is heard
from the starter when it is engaged. If no clicking
sound is heard, check that the blue wire at the starter
is secure. If still no clicking sound is heard, the
starting (ignition) switch or the wire is defective.
Starter motor defective. If the above checks have been performed, and no
fault is evident, the starter may be defective. NOTE:
In this case the headlight intensity will not dim when
the starter is engaged.
pg. 93 Service diagnosis
Condition: Starter motor operates but engine does not start

file:///K|/ownersdocs/1990/1990_240/90240_19.htm (3 of 7)12/30/2006 8:\
25:13 AM

Volvo 1990 240 Model
Battery:
-capacity 450 A/90 min
Alternator:
-rated output 1120W, 80A Lights, 12 V US bulb
No. Power
Socket No.
of
bulbs
Headlights HBI/9004 45 W/65
W 2
Position lights, front 1157NA 21 W/24
cp
5 W/2.2 cp BaY 15d
2
Turn signals, front 1157NA 21 W/24
cp
5 W/2.2 cp BaY 15d
2
Turn signals, rear 1156 21 W/32
cp Ba 15 s
2
Brake light/ tail light 1157 21 W/31
cp
5 W/3 cp BaY 15d
2
High-mounted brake light 1156 21 W/32
cp Ba 15 s
1
Back-up lights 1156 21 W/32
cp Ba 15 s
2
Rear fog lights 1156 21 W/32
cp Ba 15 s
2
The following bulbs may be obtained from your nearest Volvo dealer:
file:///K|/ownersdocs/1990/1990_240/90240_20.htm (8 of 14)12/30/2006 8\
:25:15 AM