trunk VOLVO S40 2009 Owner´s Manual

07 Wheels and tiresTire Sealing System
07192
IntroductionCertain models are equipped with a tire sealing
system that enables you to temporarily seal a
hole in the tread surface and re-inflate a flat tire,
or to adjust a tire’s inflation pressure.
The system consists of an air compressor, a
container for the sealing compound, wiring to
connect the system to the vehicle’s electrical
system via one of the 12-volt sockets, and a
hose used to connect the system to the tire’s
inflation valve.
The 12-volt sockets are located in the front
tunnel console and on the rear side of the tun-
nel console, in the rear seat.Accessing the tire sealing systemThe tire sealing system is stowed under the
floor of the trunk. To access it:
1. Fold up or remove any carpet or other floor
covering.
2. Open the floor hatch.
3. Lift out the tire sealing system.
NOTE
•
The tire sealing system is only intended
to seal holes on the tire’s tread area, not
the sidewall.
•
Tires with large holes or tears cannot be
repaired with the tire sealing system.WARNING
•
After using the tire sealing system, the
vehicle should not be driven farther than
approximately 120 miles (200 km).
•
Have the tire inspected by a trained and
qualified Volvo service technician as
soon as possible to determine if it can
be permanently repaired or must be
replaced.
•
The vehicle should not be driven faster
than 50 mph (80 km/h) while using a tire
that has been temporarily repaired with
the tire sealing system.
•
After using the tire sealing system, drive
carefully and avoid abrupt steering
maneuvers and sudden stops.
Tire sealing system–overview
G020400
Speed limit stickerOn/Off switchElectrical wireBottle holder (orange cover)Protective hose coverAir release knobHoseBottle with sealing compoundAir pressure gauge

09 Maintenance and servicing
Replacing bulbs
09``227
6. Insert a new bulb by turning it clockwise
(the profile on the bulb holder will corre-
spond with the profile in the base of the
bulb).
7.
Reinsert the bulb holder. The mark TOP
should be upward.Removing the taillight bulb holder
G020916
All bulbs in the taillight cluster can be replaced
from the trunk. To access the bulb holders:
1. Switch off all lights and turn the key to
position0.2. Remove the covers in the left/right panels
to access the bulb holders.
3. Disconnect the wiring connector from the
affected bulb holder.
4. Press the catches together and pull out the
bulb holder.
5. Replace the defective bulb.
6. Press the bulb holder into place and rein-
stall the cover.
Location of taillight bulbs
G018055
Location of taillight bulbs
Brake light (LED)
1
TaillightParking lightFog light (driver's side only)Turn signalBack-up lightNOTE
If the message indicating a burned out bulb
remains in the information display after the
bulb has been replaced, consult a trained
and qualified Volvo service technician.High-level brake lightThese bulbs should only be replaced by a
trained and qualified Volvo service technician.
1The wiring to the LED brake lights is permanently connected to the bulb holder. It should not be removed.

09 Maintenance and servicingReplacing bulbs
09228
License plate lighting
G014843
1. Switch off all lights and turn the key to
position0.
2. Remove the screws with a screw driver.
3. Detach the entire bulb housing and care-
fully pull it out. Turn the connector coun-
terclockwise and pull out the bulb.
4. Replace the defective bulb.
5. Reinstall the connector and turn it clock-
wise.
6. Reinstall the entire bulb housing and screw
it into place.
Footwell lighting
G020795
The footwell lighting is located under the dash-
board on the driver's and passenger's sides.
To replace a bulb:
1. Insert a screwdriver under the edge of the
lens. Turn the screwdriver gently to detach
the lens.
2. Remove the defective bulb.
3. Install a new bulb.
4. Press the lens back into place.
Trunk lighting
G020915
1. Insert a screwdriver and turn it gently to
detach the bulb housing.
2. Remove the defective bulb.
3. Install a new bulb.
4. Press the bulb housing back into place.

09 Maintenance and servicingFuses
09236
56.
Volvo Navigation System
remote control module
(option), alarm siren control
module
10A
57.
On-board diagnostic
socket, brake light switch
15A
58.
Right high beam, auxiliary
lights relay
7.5A
59.
Left high beam
7.5A
60.
Heated driver's seat
(option)
15A
61.
Heated passenger's seat
(option)
15A
62.
Moonroof (option)
20A
63.
Power window and door
lock – rear passenger's side
door
20A
64.
Audio system, Volvo Navi-
gation system (option)
5A
65.
Audio system
5A
66.
Audio system control mod-
ule (ICM), climate system
10A
67.
Not in use
68.
Cruise control
5A
69.
Climate system, rain sensor
(option), BLIS button
(option)
5A
70.
Not in use
71.
Not in use
72.
Not in use
73.
Moonroof, front ceiling
lighting, auto-dim mirror,
(option) seat belt reminder
5A
74.
Fuel pump relay
15A
75.
Not in use
76.
Not in use
77.
Auxiliary equipment control
module (AEM)
15A
78.
Not in use
79.
Back-up lights
5A
80.
Not in use
81.
Power window and door
lock – rear driver's side door
20A
82.
Power window – front pas-
senger's side door
25A
83.
Power window and door
lock – front driver's side
door
25A
84.
Power passenger's seat
25A
85.
Power driver's seat
25A
86.
Interior lighting relay, trunk
lighting, power seats
5A

12 Index
12280
Long distance trips.................................. 138
Lug nuts (wheel nuts)............................... 188MMaintenance............................................ 210
performed by the owner.....................212
Manual climate control.............................. 95
Manual transmission........................ 147, 148
Mirrors.................................................. 78, 79
Model plate.............................................. 263
Moonroof................................................... 81
Motor oil........................................... 216, 269
checking............................................. 216OOccupant safety........................................ 16
Occupant weight sensor............................ 26
Octane recommendations.......................140
Oil............................................................. 216
changing............................................. 216
checking............................................. 216On Call Roadside Assistance.................. 275
Opening the hood.................................... 214
Opening the trunk from the inside........... 127
Owner maintenance................................. 212
PPanel lighting, instrument.......................... 64
Park assist............................................... 168
Parking brake............................................. 75
Parking lights............................................. 63
Passenger’s side front airbag, disabling. . . 26
Periodic owner-performed maintenance. 212
Permissible axle weight........................... 183
Personal settings....................................... 83
Power door mirrors.................................... 79
Power front seat...................................... 105
memory function................................. 105
Power moonroof........................................ 81
Power steering fluid................................. 219
Power windows......................................... 76
Pregnancy, using seat belts during........... 19
Private locking......................................... 122
RRadio
Sirius satellite radio............................ 245
Radio functions........................................ 244
Rain sensor - windshield wipers................ 73
Rear fog light............................................. 64
Rear park assist....................................... 168
Rear seat backrests, folding down.......... 113
Rear seats
center head restraint........................... 113
Rearview mirror.......................................... 78
auto-dim function................................. 78
Rearview mirror with compass (option)..... 78
Recalls, child restraints.............................. 46
Refrigerant (A/C system).................... 92, 267
Refueling.................................................. 142
fuel tank volume.................................267
Registering child restraints........................ 46
Remote control........................................ 118
battery replacement............................ 120
functions............................................. 118
key blade............................................ 120
Replacing fuses....................................... 230

12 Index
12282
inflation pressure table, Canadian mod-
els.......................................................179
inflation pressure table, US models.... 178
load ratings......................................... 177
rotation............................................... 189
snow...................................................186
spare................................................... 187
speed ratings...................................... 177
storing................................................. 174
studded............................................... 186
tire pressure monitoring system......... 197
tire sealing system.............................. 192
tread wear indicator............................ 175
uniform tire quality grading................. 185
winter driving...................................... 186
Tire sealing system.................................. 192
Top tether anchors (child restraint sys-
tems).......................................................... 45
Towing a trailer........................................ 160
trailer hitch.......................................... 162
Towing the vehicle................................... 157
Trailer hitch - detachable......................... 162
Trailer towing........................................... 160Transmission
Geartronic........................................... 150
manual........................................ 147, 148
shiftlock override................................ 151
Tread wear indicator................................ 175
Treble....................................................... 242
Trip computer............................................ 68
Trips, long distance................................. 138
Trunk
opening from the inside...................... 127
Turn signals............................................... 66
indicator lights...................................... 53
UUniform Tire Quality Grading...................185VValet locking............................................ 122
Vehicle dimensions.................................. 264
Vehicle Event Data................................... 210
Vehicle loading......................................... 183
roof loads............................................ 163Vehicle maintenance
performed by the owner.....................212
Vehicle towing.......................................... 157
Vehicle weights........................................ 265
VIN (Vehicle Identification Number)......... 263
Volvo Inflatable Curtain.............................. 30
Volvo On Call Roadside Assistance........ 275
WWarning flashers, hazard........................... 74
Warning symbol......................................... 55
Warranties................................................ 210
Washer fluid..................................... 218, 267
Washer fluid reservoir......................215, 218
Water, driving through............................. 137
Weights.................................................... 265
Wheel nuts............................................... 188
Wheels.....................................................174
changing............................................. 190
storing................................................. 174
Whiplash Protection System (WHIPS)....... 32