transmission fluid VOLVO S60 2009 Owner´s Manual

02 Instruments and controls
Indicator and warning symbols
02``53
If the BRAKE and ABS warning lights come
on at the same time, this could indicate a
fault in the brake system.
1. Stop the vehicle in a suitable place and
switch off the engine.
2. Restart the engine.
3. If both warning lights go off, no further
action is required.
4. If both lights are still on after the engine has
been restarted, switch off the engine again
and check the brake fluid level (see
page 193 for the location of the brake fluid
reservoir).
5.
If the brake fluid level is above the MIN
mark, drive carefully to a trained and quali-
fied Volvo service technician and have the
brake system inspected.
WARNING
If the fluid level is below the MIN mark in the
reservoir or if a "
Brake failure - Service
urgent
" message is displayed in the text
window:DO NOT DRIVE. Have the vehicle
towed to a trained and qualified Volvo serv-
ice technician and have the brake system
inspected.
PARK BRAKE - Parking brake appliedThis light will be on when the parking brake
(hand brake) is applied. The parking brake lever
is situated between the front seats. For addi-
tional information, see page 71.
Canadian models are equipped
with this symbol.Low oil pressure
2
If the light comes on while driving,
stop the vehicle and then stop the
engine immediately and check the
engine oil level, see page 191.
If the light stays on after restart, have the vehi-
cle towed to the nearest trained and qualified
Volvo service technician. After hard driving, the
light may come on occasionally when the
engine is idling. This is normal, provided it goes
off when the engine speed is increased.Generator warning light
If the light comes on while the
engine is running, have the charg-
ing system checked.
Rear fog light
This light indicates that the fog
light is on.
CHECK ENGINE - Malfunction indicator
lightOn-Board Diagnostics II (OBDII): As you drive,
a computer called "OBDII" monitors your vehi-
cle's engine, transmission, electrical and emis-
sion systems. The CHECK ENGINE light will
light up if the computer senses a condition that
potentially may need correcting. When this
happens, please have your vehicle checked by
a trained and qualified Volvo service technician
as soon as possible.
ACHECK ENGINE light may have many cau-
ses. Sometimes, you may not notice a change
in your vehicle's behavior. Even so, an uncor-
rected condition could hurt fuel economy,
emission cleanliness, and driveability.
Extended driving without correcting the cause
could even damage other components in your
vehicle.
Canadian models are equipped
with this warning light.
2On certain engines, the symbol for low oil pressure is not used. Instead, a text warning is provided in the information display.

06 Starting and drivingStarting the vehicle
06124
Starting the engine
WARNING
Before starting, check that the seat, steering
wheel and mirrors are adjusted properly.
Make sure the brake pedal can be
depressed completely. Adjust the seat if
necessary. See pages 94 and 94.1. Fasten the seat belt.
2. Apply the parking brake (hand brake) if not
already set. The gear selector (automatic
transmission) is locked in the (P)ark posi-
tion (SHIFTLOCK).
Manual transmission: the clutch must be
fully depressed.
3. Without touching the accelerator pedal,
turn the ignition key
1to the starting posi-
tion. Allow the starter to operate for up to
10 seconds. Release the key as soon as
the engine starts. If the engine fails to start,
repeat this step.
NOTE
•
If the key blade section of the remote is
not fully folded out when starting the
vehicle, the immobilizer function may
make it impossible to start the engine.
•
After a cold start, idle speed may be
noticeably higher than normal for a
short period. This is done to help bring
components in the emission control
system to their normal operating tem-
perature as quickly as possible, which
enables them to control emissions and
help reduce the vehicle's impact on the
environment.
•
To release the gear selector from the P
position, the engine must be running (or
the ignition key must be in position II)
and the brake pedal must be
depressed.
•
Select the desired gear. The gear
engages after a very slight delay which
is especially noticeable when selecting
R.
NOTE
Your vehicle is equipped with a KEYLOCK
system (automatic transmission). When the
engine is switched off, the gear selector
must be in the P position before the key can
be removed from the ignition switch.
When starting in cold weather, the trans-
mission may shift up at slightly higher
engine speeds than normal until the auto-
matic transmission fluid reaches normal
operating temperature.
WARNING
An extra mat on the driver's floor can cause
the accelerator pedal to catch. Check that
the movement of the accelerator pedal is
not impeded. No more than one protective
floor covering may be used at one time.
1If two of the keys to your vehicle are close together, e.g. on the same key ring, when you try to start the vehicle, this could cause interference in the immobilizer system and result in the vehicle not
starting. If this should occur, remove one of the keys from the key ring before trying to start the vehicle again.

06 Starting and driving
Starting the vehicle
06``125
WARNING
Always place the gear selector in Park or in
reverse on models with a manual transmis-
sion, and apply the parking brake before
leaving the vehicle. Never leave the vehicle
unattended with the engine running.
Always open garage doors fully before star-
ting the engine inside a garage to ensure
adequate ventilation. The exhaust gases
contain carbon monoxide, which is invisible
and odorless but very poisonous
CAUTION
Automatic transmission
The engine should be idling when you move
the gear selector. Never accelerate until
after you feel the transmission engage!
Accelerating immediately after selecting a
gear will cause harsh engagement and pre-
mature transmission wear.
SelectingP or N when idling at a standstill
for prolonged periods of time will help pre-
vent overheating of the automatic transmis-
sion fluid.Do not race a cold engine immediately after
starting.
Ignition switch and steering wheel lock
0 – Locked position:
Remove the key to lock
the steering wheel
A.
I – Intermediate posi-
tion
B – "radio position":
Certain accessories,
radio, etc. on, daytime
running lights off.
II – Drive position: The
key position when driving.
The vehicle's entire elec-
trical system is con-
nected.
III – Start position:
Release the key when the
engine starts. The key
returns automatically to
the Drive position.
A chime will sound if the key is left in the
ignition and the driver's door is opened.AThe gear selector must be in the P (Park) position (automatic
transmission).BPlease be aware that leaving the key in this position will
increase battery drain.
WARNING
Never turn the key to position 0 while driving
or when the vehicle is being towed.Steering wheel lockThe steering wheel lock might be under tension
when the vehicle is parked.
Turn the steering wheel slightly to free the igni-
tion key.
In order to help reduce vehicle theft, make
sure the steering wheel lock is engaged
before leaving the vehicle.

06 Starting and driving
Before a long distance trip
06
149
It is always worthwhile to have your vehicle
checked by a trained and qualified Volvo serv-
ice technician before driving long distances.
Your retailer or service technician will also be
able to supply you with bulbs, fuses, spark
plugs and wiper blades for your use in the event
that problems occur.
As a minimum, the following items should be
checked before any long trip:•
Check that engine runs smoothly and that
fuel consumption is normal.
•
Check for fuel, oil, and fluid leakage.
•
Check transmission oil level
1.
•
Check condition of drive belts.
•
Check state of the battery's charge.
•
Examine tires carefully (the spare tire as
well), and replace those that are worn.
Check tire pressures.
•
The brakes, front wheel alignment, and
steering gear should be checked by a
trained and qualified Volvo service techni-
cian only.
•
Check all lights, including high beams.
•
Reflective warning triangles are legal
requirement in some countries.
•
Have a word with your Volvo retailer if you
intend to drive in countries where it may be
difficult to obtain the correct fuel.
•
Consider your destination. If you will be
driving through an area where snow or ice
are likely to occur, consider snow tires.
1To prevent injury from contact with hot surfaces, do not inspect your vehicle's transmission fluid yourself. Have your vehicle's transmission fluid level inspected by a qualified Volvo service technician.

11 SpecificationsCapacities
11240
Specifications and capacitiesCategory
Specification
Capacity
Fuel tank
Volvo engines are designed to achieve rated horsepower,
torque, and fuel economy performance using premium 91
octane fuel.
Volvo recommends premium for best performance, but
using 87 octane or above will not affect engine reliability
18 US gal. (68 liters).
Engine oil (with filter
replacement)
B5254T2
Engine oil must meet the minimum ILSAC specification
GF-4, API SL, or ACEA A1/B1. Lower quality oils may not
offer the same fuel economy, engine performance, or
engine protection.
Volvo recommends Castrol.
5.8 US qts. (5.5 liters).
1.3 US qts (1.2 liters) between MIN and MAX
on dipstick
B5244T5
Automatic transmission oil
AW5
JWS 3309
Different types of oil should never be mixed.
7.6 US qts. (7.2 liters)
Manual transmission oil
M66
MTF 97309
2.1 US qts. (2.0 liters)
Coolant
Volvo original coolant/antifreeze
9.3 US qts (8.8 liters).
The thermostat begins to open at 194 °F
(90 °C).
Brake fluid
DOT 4+ boiling point >536 °F (280 °C).
0.69 US qts. (0.65 liters)

11 Specifications
Capacities
11
241
Category
Specification
Capacity
Power steering fluid
Volvo synthetic power steering fluid (Pentosin CHF 11S) P/
N 1161529 or equivalent
0.9 US qts. (0.9 liters)
Washer fluid reservoir
Use washer fluid solvent in cold weather conditions.
6.8 US qts (6.4 liters)
NOTE
The transmission oil does not normally need
to be changed during the service life of the
vehicle. However, it may be necessary to
replace the oil if the vehicle is often driven
in areas of sustained temperature extremes
(hot or cold), when towing a trailer over long
distances, for prolonged driving in moun-
tainous areas, or if the vehicle is often driven
short distances in temperatures under 40°F
(5°C).

12 Index
12248
AA/C (air conditioning)................................. 90
ABS.......................................................... 136
Airbag system............................................ 20
Air conditioning.......................................... 89
Air distribution................................ 88, 90, 91
Air quality sensor....................................... 91
Air vents..................................................... 88
Alarm........................................................ 116
All Wheel Drive......................................... 134
towing.................................................141
Anti-lock Brake System (ABS)................. 136
Audio system........................................... 216
CD changer (external)......................... 228
CD player.................................... 226, 227
Dolby Surround Pro Logic II............... 229
PI seek................................................ 223
selecting a sound source.................... 221
sound settings.................................... 220
storing radio stations.......................... 222
AUTO (climate control)............................... 89
Automatic transmission........................... 130
Geartronic........................................... 132
kickdown............................................ 131AWD......................................................... 134
BBackrest, rear seat, folding...................... 102
Battery..................................................... 187
maintenance....................................... 195
replacing............................................. 196
specifications...................................... 244
Belt check................................................ 187
Black Box (Vehicle Event Data)............... 184
Blower (fan)................................................ 90
Brake circuit............................................. 135
Brake fluid................................................ 193
Brake system........................................... 135
Bulbs
list of................................................... 243
replacing............................................. 198CCapacities, fluids..................................... 240
Capacity weight....................................... 163Catalytic converter, three-way................. 245
CD changer.............................................. 227
CD changer (external).............................. 228
CD player................................................. 226
Central locking system - remote control. 109
Changing a wheel.................................... 169
Changing coolant..................................... 188
Charge air cooler..................................... 242
Child restraints
recalls and registration......................... 44
Child safety................................................ 32
child restraints...................................... 34
Child safety lock...................................... 114
Climate system.......................................... 86
Coat hanger............................................. 101
Cold weather precautions........................ 148
Coolant.................................................... 192
changing..................................... 188, 192
checking level of................................. 187
Courtesy lighting........................................ 97
Cup holders
rear seat.............................................. 100
Curb weight............................................. 163

12 Index
12
251
Roof racks (load carriers)......................... 146
Rotating tires........................................... 168SSafety defects, reporting
Canada................................................. 17
USA....................................................... 16
Seat belt..................................................... 18
Service.....................................................184
Service key.............................................. 108
Shiftlock...................................................124
Side impact protection (SIPS) airbags....... 28
Ski hatch.................................................. 103
Snow chains............................................ 166
Snow tires................................................ 166
Spare wheel............................................. 105
Stability systems...................................... 138
Starting the car........................................ 124
Steering wheel lock.................................125
Stone chips, touching up......................... 180
Storage compartments..............99, 100, 101
Studded tires........................................... 166Suspension.............................................. 246
TTemperature control.................................. 89
Three-way catalytic converter................. 245
Tire designations.....................................160
Tire economy, improving......................... 155
Tire inflation............................................. 156
Tire inflation pressure, checking.............. 157
Tire inflation pressure table
Canadian models................................ 159
US models.......................................... 158
Tire Pressure Monitoring System............ 172
Tires
rotation............................................... 168
Towing - cars with All Wheel Drive.......... 141
Towing the car......................................... 140
Trailer hitch - detachable......................... 145
Transmission - automatic........................130
Tread wear indicator................................ 155
Trunk
opening from the inside...................... 113
unlocking/locking................................ 112
UUniform Tire Quality Grading................... 165
Unlocking the car..................................... 112
Unlocking the trunk.................................. 112
Upholstery, cleaning................................ 177VValet key.................................................. 108
Vanity mirror............................................... 98
Vehicle dimensions.................................. 236
Vehicle Event Data................................... 184
Vehicle Identification Number (VIN)......... 235
Vehicle loading......................................... 163
Volvo Inflatable Curtain.............................. 29
Volvo On Call Roadside Assistance........ 247WWarranties................................................ 184
Washer fluid reservoir......................189, 192
Washing the car....................................... 176