sensor VOLVO V60 2011 Workshop Manual

08 Maintenance and service
Engine compartment
08
308
When driving under adverse conditions, see
page 350.
IMPORTANT
In order to fulfil the requirements for the
engine's service intervals all engines are
filled with a specially adapted synthetic
engine oil at the factory. The choice of oil
has been made very carefully with regard to
service life, starting characteristics, fuel
consumption and environmental impact.
An approved engine oil must be used in
order that the recommended service inter-
vals can be applied. Only use a prescribed
grade of oil for both filling and oil change,
otherwise you will risk affecting service life,
starting characteristics, fuel consumption
and environmental impact.
Volvo Car Corporation disclaims all war-
ranty liability if engine oil of the prescribed
grade and viscosity is not used.
Volvo uses different systems for warning of
low/high oil level or low/high oil pressure. Cer-
tain variants have an oil pressure sensor, and
then the lamp for oil pressure is used. Other
variants have an oil level sensor, and then the
driver is informed via the warning symbol in the
centre of the instrument unit as well as by dis-play texts. Certain models have both variants.
Contact a Volvo dealer for more information.
Change the engine oil in accordance with the
intervals specified in the Service and Warranty
Booklet.
Using oil of a higher than specified grade is
permitted. If the car is driven in adverse con-
ditions, Volvo recommends using an oil of a
higher grade than that specified on the decal,
see page 351.
For capacities, see page 351 and onwards.
Engine with oil dipstick2
G021734
Dipstick and filler pipe.
Checking the oil level in a new car is especially
important before the first scheduled oil change.Volvo recommends checking the oil level every
2 500 km. The most accurate measurements
are made on a cold engine before starting. The
measurement will be inaccurate if taken imme-
diately after the engine is switched off. The
dipstick will indicate that the level is too low
because the oil has not had time to flow down
into the oil sump.
G021737
The oil level must be between the MIN and MAX
marks.
Measurement and filling if required1. Ensure that the car is level. After switching
off the engine it is important to wait
5 minutes to allow the oil time to run back
to the sump.
2. Pull up and wipe the dipstick.
2Only applies to petrol and 4-cyl. diesel.
ProCarManuals.com

08 Maintenance and service
Engine compartment
08

309
3. Re-insert the dipstick.
4. Pull it out and check the level.
5.
If the level is close to MIN then 0.5 litres
should be added. If the level is significantly
below, then an additional amount is
required.
6. If required, check the level again, do it after
driving a short distance. Then repeat steps
1 - 4.
WARNING
Never fill above the MAX mark. The level
should never be above MAX or below MIN
as this could lead to engine damage.
WARNING
Do not spill oil onto the hot exhaust manifold
due to the risk of fire.
Engine with electronic oil level sensor3
Filler pipe.4
You do not need to take action with respect to
the engine oil level before a message is shown
in the display, see the illustration below.
Message and graph in the display.
Message
Engine oil level
WARNING
If the message Oil service required is
shown, visit a workshop. The oil level may
be too high.
IMPORTANT
In the event of the message Engine oil
level Fill with 0.5 l oil, only fill with 0.5 litres.
3Only applies to 5-cyl. diesel.4Engines with electronic oil level sensor have no dipstick (5-cyl. diesel).
ProCarManuals.com

08 Maintenance and service
Fuses
08
328* Option/accessory, for more information, see Introduction.
FunctionA
Speed related power
steering*5
Engine control module,
Transmission control
module, Airbags10
Heated washer nozzles*10
Relay coil, relay, vacuum
pump (5-cyl. petrol and
2.0T)5
Headlamp control5
--
--
--
Internal relay coils5
Auxiliary lamps*20
Horn15
FunctionA
Relay coil, main relay,
engine management sys-
tem
Engine control module (5,
6-cyl. petrol)10
Transmission control
module15
Compressor A/C15
Relay coil, relay, compres-
sor A/C
Relay coils in central elec-
trical unit in engine com-
partment cold zone Start/
Stop5
Actuator solenoid, starter
motorA30
Ignition coils (4-cyl. pet-
rol), Glow control module
(diesel)10
Ignition coils (5, 6-cyl. pet-
rol)20
FunctionA
Engine control module
(petrol)10
Engine control module
(diesel)15
Valves (1.6 l petrol)
Mass air flow sensor
(DRIVe), Control valve, fuel
flow (DRIVe)10
Mass air flow sensor (5-
cyl. diesel), Control valves
(5-cyl. diesel), Injectors (5,
6-cyl. petrol), Engine con-
trol module (6-cyl.)15
Engine valves, Engine
control module (6-cyl.)
Solenoids, cam profile (6-
cyl.) Actuator motors,
intake manifold (6-cyl.)
Mass air flow sensor (4-
cyl. 2.0 l petrol)
Coolant pump (DRIVe)10
ProCarManuals.com

08 Maintenance and service
Fuses
08

* Option/accessory, for more information, see Introduction.331
Box
AFunctionA
Power seat passenger
side*20
Folding head restraint*15
Infotainment control mod-
ule5
Audio control module*,
TV*
Satellite radio*, Digital
radio*10
Audio15
Phone*5
--
Sun roof*, Interior lighting
roof, Climate sensor5
12 V socket, tunnel con-
sole15
Seat heating (passenger
side)15
Seat heating (driver's side)15
Box
AFunctionA
--
Seat heating, rear passen-
ger side right*15
Seat heating, rear passen-
ger side left*15
Parking assistance*, Park-
ing camera*, Towbar con-
trol module *
BLIS*5
AWD control module*10
Active chassis Four-C*10
Box
BFunctionA
Rear window wiper15
--
Box
BFunctionA
Interior lighting, Driver's
door control panel, power
windows, Power seats,
front*, Remote controlled
garage door opener*7.5
Information display (DIM)5
Adaptive cruise control,
ACC*, collision warning
system*10
Interior lighting, Rain sen-
sor7.5
Steering wheel module7.5
Central locking system
rear, Central locking sys-
tem fuel filler flap10
Rear window washer15
Windscreen washers15
Opening tailgate10
--
Fuel pump20
ProCarManuals.com

09 Specifications
Symbols in the display 09
374* Option/accessory, for more information, see Introduction.
SymbolMeaningPage
Left-hand direc-
tion indicators76
Right-hand
direction indica-
tors76
Other information symbols in the
combined instrument panel
SymbolMeaningPage
Adaptive cruise
control*167, 173,
179
Adaptive cruise
control*179
Adaptive cruise
control*, Distance
Alert*179, 182
Adaptive cruise
control*, Distance
Alert*179, 182
Adaptive cruise
control*179
SymbolMeaningPage
Adaptive cruise
control*, Distance
Alert*174, 181
Adaptive cruise
control*, Distance
Alert*174, 181
Adaptive cruise
control*173
Radar sensor*179,
182193
Adaptive cruise
control*179
Speed limiter169
Camera sensor*,
Laser sensor*187, 193,
196, 199
Auto Brake*, Dis-
tance Alert*, City
Safety
TM, Collision
warning system*
182, 187,
193
SymbolMeaningPage
G02510
2
Fuel-driven engine
block heater and
passenger com-
partment heater*159
ABL system*90
Fuel filler flap,
right-hand side269
Low battery159
Parking brake132
Rain sensor*98
Driver Alert Sys-
tem*196
Driver Alert Sys-
tem*, Lane Depar-
ture Warning*196, 199
ProCarManuals.com

10 Alphabetical Index
10
376
A
ACC – Adaptive cruise control................. 171
Active Bending Lights (ABL)...................... 90
Active chassis – FOUR-C........................166
Active Xenon headlamps........................... 90
Adapting driving characteristics.............. 166
Adaptive cruise control............................ 171
fault tracing......................................... 178
radar sensor........................................ 177
Adaptive cruise control fault tracing........ 178
Additional heater (Diesel)......................... 161
Adjusting headlamp pattern...................... 94
halogen headlamp................................ 95
Adjusting the steering wheel...................... 88
Airbag
activating/deactivating, PACOS........... 24
driver's and front passenger side......... 22
key switch off........................................ 24
AIRBAG ..................................................... 22
Airbag system ........................................... 21
Air conditioning........................................ 155
general................................................ 148
Air conditioning, AC................................. 155Air distribution.................................. 150, 156
Air quality system IAQS .......................... 155
Air vents................................................... 150
Alarm.......................................................... 67
alarm indicator...................................... 67
alarm signals......................................... 67
arming................................................... 67
checking the alarm............................... 51
deactivating.......................................... 67
deactivating a triggered alarm.............. 67
reduced alarm level.............................. 68
temporary disarming of the alarm........ 68
testing the alarm system...................... 68
Alcolock................................................... 109
Allergy and asthma inducing sub-
stances.................................................... 149
All-wheel drive, AWD............................... 128
All Wheel Drive (AWD).............................. 128
Approach light, duration............................ 94
Audio
settings....................................... 222, 223
surround.....................................216, 223
audio system .......................................... 218Audio system........................................... 216
functions............................................. 222
overview.............................................. 218
Audio volume .......................................... 219
phone.................................................. 250
phone/media player............................ 250
ring signal, phone............................... 250
Auto
climate control settings...................... 154
Automatic car washes.............................336
Automatic gearbox.................................. 116
manual gear positions (Geartronic)..... 117
towing and recovery........................... 284
trailer................................................... 279
Automatic locking...................................... 62
Automatic relocking................................... 61
Auxiliary heater........................................ 161
AUX input......................................... 218, 236
AWD, All-wheel drive............................... 128
B
Backrest..................................................... 83
front seat, lowering............................... 83
Backrest rear seat, lowering...................... 86
ProCarManuals.com

10 Alphabetical Index
10
377
Bag holder .............................................. 274
Battery.............................................321, 360
maintenance....................................... 321
Remote control .................................. 246
remote control key/PCC....................... 55
start assistance................................... 115
symbols on the battery....................... 321
warning symbols................................. 321
Blind spot (BLIS)...................................... 207
Blind Spot Information System, BLIS...... 207
Bluetooth
Ÿ
handsfree ........................................... 247
media ................................................. 239
microphone off ..................................249
streaming audio ................................. 239
transfer call to mobile ........................ 249
Bonnet, opening...................................... 306
Brake and clutch fluid..............................311
Brake light.................................................. 91
Brakes...................................................... 129
anti-lock braking system, ABS........... 129
brake light............................................. 91
brake system...................................... 129
electric parking brake......................... 131
Emergency Brake Assistance, EBA ... 129
emergency brake lights........................ 91filling brake fluid.................................. 311
symbols in the combined instrument
panel...................................................130
Bulbs, see Lighting.................................. 313
C
Calls
incoming............................................. 249
operation............................................. 249
Camera sensor................................185, 191
Car care................................................... 336
Car care, leather upholstery.................... 338
Cargo area
cargo cover......................................... 276
lighting.................................................. 93
loading................................................273
mounting points.................................. 274
safety grille.......................................... 276
safety net............................................ 275
Cargo cover............................................. 276
Car upholstery......................................... 338
Car wash.................................................. 336
Catalytic converter................................... 270
recovery..............................................284CD ........................................................... 232
Centre console........................................ 142
Chassis settings......................................166
Checking and topping up the coolant..... 310
Checking the engine oil level................... 307
Children..................................................... 33
child safety locks.................................. 40
child seats and side airbags................. 26
location in the car.................................33
safety.................................................... 33
Child safety locks...................................... 66
Child seat................................................... 33
Child seats................................................. 33
integrated two-stage booster cushion. 38
ISOFIX fixture system for child seats. . . 40
recommended...................................... 35
size classes for child seats with the ISO-
FIX fixture system................................. 40
upper mounting points for child seats. . 44
City Safety™............................................ 184
Cleaning
automatic car washes......................... 336
car wash............................................. 336
rims..................................................... 337
seatbelts............................................. 339
upholstery........................................... 338
ProCarManuals.com

10 Alphabetical Index
10
378
Clean Zone Interior Package (CZIP)........ 149
Climate control........................................ 148
general................................................ 148
sensors............................................... 148
Clock, setting............................................. 79
CO
2 emissions ........................................ 354
Collision..................................................... 32
Collision warning.............................188, 189
Collision warning system
radar sensor........................ 177, 184, 189
Collision Warning with Auto Brake*......... 188
Colour code, paint................................... 340
Combined instrument panel.................... 140
Comfort inside the passenger compart-
ment......................................................... 211
Compass................................................. 106
calibration........................................... 106
Condensation in headlamps.................... 336
controls
centre console ...........................219, 259
Controls
centre console.................................... 142
Cooling system........................................ 266
Corner Traction Control .......................... 164Crash, see Collision................................... 32
Cruise control.......................................... 167
CZIP (Clear Zone Interior Package)......... 149D
DAB Radio............................................... 229
Deadlocks.................................................. 64
deactivation.......................................... 64
temporary deactivation......................... 64
Defroster.................................................. 155
Diesel.......................................................271
Diesel particle filter..................................272
Dipstick, electronic.................................. 309
Direction indicators.................................... 92
Disengaging the gear selector inhibitor. . . 119
Display lighting.......................................... 89
Distance Alert.......................................... 181
Dolby Surround Pro Logic II.................... 216
Door mirrors............................................. 103
Driveable punctured tyres........................ 298
Driver Alert Control.................................. 195
Driver Alert System.................................. 195Driving...................................................... 266
cooling system.................................... 266
with the tailgate open.........................267
with trailer........................................... 278
Driving in water........................................ 266
Driving with a trailer
towball load........................................ 347
towing capacity..................................347
DSTC, see also Stability control system.. 164
DVD ......................................................... 232
E
ECC, electronic climate control...............151
Economical driving.................................. 266
ECO pressure.......................................... 295
Eco Start/Stop DRIVe.............................. 122
Electrical socket......................................213
cargo area........................................... 274
front seat............................................. 213
Electric parking brake.............................. 131
low battery voltage.............................131
releasing automatically....................... 132
releasing manually.............................. 132
ProCarManuals.com

10 Alphabetical Index
10
379
Emergency equipment
warning triangle.................................. 296
Emergency puncture repair..................... 299
Emissions of carbon dioxide................... 272
Engine
overheating......................................... 278
starting................................................ 113
Engine block heater
fuel-driven........................................... 158
Engine compartment
coolant................................................ 310
oil........................................................ 307
overview.............................................. 307
power steering fluid............................ 312
Engine drag control ................................164
Engine oil.........................................307, 350
adverse driving conditions.................. 350
capacities........................................... 350
filter..................................................... 307
oil grade.............................................. 350
Engine specifications............................... 349
Environmental labelling, FSC, owner's
manual.......................................................13Error messages
Driver Alert Control............................. 196
Lane Departure Warning..................... 199
see Messages and symbols............... 179
Error messages in BLIS........................... 209
Error messages in Distance Alert............ 182
Error messages in the Adaptive cruise con-
trol............................................................ 179
ETC, electronic temperature control ....... 152
Expectant mothers, seatbelt...................... 19
External dimensions................................346
F
Fan........................................................... 153
Fault tracing for the camera sensor. 186, 192
First aid equipment.................................. 296
First aid kit .............................................. 296
Fluids, capacities..................................... 352
Fluids and oils.......................................... 352
Fog lamps
rear........................................................ 91
Foot brake............................................... 129
FOUR-C – Active chassis........................166FSC, environmental labelling..................... 13
Fuel.......................................................... 270
fuel consumption................................ 354
fuel economy...................................... 295
fuel filter.............................................. 271
Fuse box.................................................. 325
glovebox............................................. 330
Fuses.......................................................325
box in cargo area................................ 333
changing............................................. 325
cold zone............................................ 334
general................................................ 325
relay/fuse box in engine compart-
ment.................................................... 326
Start/Stop........................................... 334
Fuse table
fuses in engine compartment............. 327
G
Gearbox...................................................116
automatic............................................ 116
manual................................................ 116
Gear selector inhibitor.............................118
Gear selector inhibitor, mechanical disen-
gagement................................................. 119
ProCarManuals.com

10 Alphabetical Index
10
382
Messages in BLIS.................................... 209
Messages in the combined instrument
panel........................................................140
Messages in the information display....... 164
Meters in the combined instrument panel
fuel gauge............................................. 76
speedometer......................................... 76
tachometer........................................... 76
Misting..................................................... 155
attending to the windows...................148
condensation in headlamps............... 336
remove with the air vents................... 156
timer function...................................... 155
Mobile phone
connect............................................... 250
handsfree............................................ 247
register phone..................................... 248
voice control....................................... 255
MY CAR................................................... 142
O
Oil, see also Engine oil............................. 350
Oil level low.............................................. 307
Overheating............................................. 278Owner's manual, environmental labelling. . 13
P
PACOS....................................................... 24
PACOS, switch.......................................... 24
Paintwork
colour code......................................... 340
damage and touch-up........................ 339
Panel lighting............................................. 89
Panic function............................................ 50
Park assist camera.................................. 204
Parking assistance................................... 201
parking assistance sensors................ 203
Parking brake........................................... 131
Parking heater.......................................... 158
battery and fuel................................... 158
parking on a hill..................................158
time setting......................................... 160
Passenger compartment.........................211
Passenger compartment filter................. 149
Passenger compartment heater
fuel-driven........................................... 158PCC – Personal Car Communicator
functions............................................... 49
range............................................... 50, 51
Pedestrian detection................................ 188
Petrol grade............................................. 270
Phone
connect............................................... 250
handsfree............................................ 247
incoming calls..................................... 249
making calls........................................ 249
phone book......................................... 251
phone book, shortcut.........................251
receiving a call.................................... 249
register phone..................................... 248
voice control....................................... 255
Pinch protection, sunroof........................108
Polishing.................................................. 337
Position/parking lamps.............................. 91
Power seat................................................. 84
Powershift gearbox..........................119, 284
Power sunroof......................................... 107
Power windows....................................... 101
Privacy locking........................................... 53
ProCarManuals.com