power steering VOLVO V60 2012 User Guide

06 During your journey
Towing and recovery
06
289 Towing
Find out the statutory maximum speed limit for
towing before towing begins.
1. Unlock the steering lock by inserting the
remote control key in the ignition switch
and giving a long press on the START/
STOP ENGINE button - key position II is
activated, see page 80 for more informa-
tion on key positions.
2. The remote control key must remain in the
ignition switch while the car is being towed.
3. Keep the towline taut when the towing
vehicle reduces speed by holding your foot
gently pressed on the brake pedal -
thereby avoiding unnecessary jerking.
4. Be prepared to brake to stop.
WARNING
•Check that the steering lock is unlocked
before towing.
•The remote control key must be in key
position II - in position I all airbags are
deactivated.
•Never remove the remote control key
from the ignition switch when the car is
being towed.
WARNING
The brake servo and power steering do not
work when the engine is switched off - the
brake pedal needs to be depressed
about 5 times more heavily and the steering
is considerably heavier than normal.
Manual gearboxPrior to towing:
–Move gear lever into neutral and release
the parking brake.
Automatic gearbox Geartronic
IMPORTANT
Note that the car must always be towed with
the wheels rolling forward.
•Cars with automatic gearbox must not
be towed at speeds above 80 km/h or
further than 80 km.
Prior to towing:
–
Move the gear selector to position N and
release the parking brake.
Automatic gearbox PowershiftThe model with Powershift transmission
should not be towed as it is dependent on the
engine running in order to receive sufficientlubrication. If towing still has to take place, the
route must be as short as possible and then
with very low speed.
In the event of uncertainty as to whether or not
the car is equipped with Powershift transmis-
sion, this can be verified by checking the des-
ignation on the decal number (5) under the
bonnet - see page 352. The designa-
tion ”MPS6” means that it is Powershift trans-
mission - otherwise it is Geartronic automatic
transmission.
IMPORTANT
Avoid towing.
•However, the car can be towed for a
short distance at low speed to move it
from a dangerous position - not further
than 10 km and not faster than
10 km/h. Note that the car must always
be towed with the wheels rolling for-
ward.
•In the event of moving a longer distance
than 10 km, the car must be transported
with the drive wheels raised from the
road - professional recovery is recom-
mended.
Prior to towing:
–
Move the gear selector to position N and
release the parking brake.
ProCarManuals.com

08 Maintenance and service
Engine compartment
08
312
General
Volvo service programmeTo keep the car as safe and reliable as possi-
ble, follow the Volvo service programme as
specified in the Service and Warranty Booklet.
Volvo recommends engaging an authorised
Volvo workshop to perform the service and
maintenance work. Volvo workshops have the
personnel, special tools and service literature
to guarantee the highest quality of service.
IMPORTANT
For the Volvo warranty to apply, check and
follow the instructions in the Service and
Warranty Booklet.
Check regularlyCheck the following oils and fluids at regular
intervals, e.g. when refuelling:
•Coolant
•Engine oil
•Power steering fluid
•Washer fluid
WARNING
Remember that the radiator fan (located at
the front of the engine compartment, behind
the radiator) may start automatically some
after the engine has been switched off.
Always have the engine cleaned by a work-
shop. There is a risk of fire if the engine is
hot.
Raising the car
NOTE
Volvo recommends only using the jack that
belongs to the car model in question. If a
jack is selected other than the one recom-
mended by Volvo, follow the instructions for
use supplied with the equipment.
If the car is raised with a workshop jack; posi-
tion the jack against the front edge on the
engine's subframe.
Do not damage the splashguard under the
engine. Ensure that the workshop jack is posi-
tioned so that the car cannot slide off the jack.
Always use axle stands or similar.
If you raise the car using a two-pillar workshop
lift, ensure that the front and rear lift arms are
fixed under the lifting points. See preceding
illustration.
Opening and closing the bonnet
The handle for bonnet opening is always on the
left-hand side.
ProCarManuals.com

08 Maintenance and service
Engine compartment
08
313
Turn the handle about 20-25 degrees
clockwise. You will hear when the catch
releases.
Move the catch to the left and open the
bonnet. (The catch hook is located
between the headlamp and grille, see illus-
tration.)
WARNING
Check that the bonnet locks properly when
closed.
Engine compartment, overview
The appearance of the engine compartment may
vary depending on engine variant.
Coolant expansion tank
Power steering fluid reservoir
Engine oil dipstick1
Radiator
Filling engine oil
Reservoir for brake and clutch fluid
(located on the driver's side)
Battery
Relay and fuse box
Filling washer fluid
Air filter
WARNING
The ignition system has very high voltage
and output. The voltage in the ignition sys-
tem is highly dangerous. The remote control
key must always be in 0 position when work
is being done in the engine compartment,
see page 80.
Do not touch the spark plugs or ignition coil
when the remote control key is in II position
or when the engine is hot.
Checking the engine oil
1Engines with electronic oil level sensor have no dipstick (5-cyl. diesel).
ProCarManuals.com

08 Maintenance and service
Engine compartment
08
318
Filling
Brake fluid reservoir location.
The fluid reservoir is protected under the cover
over the cold zone in the engine compartment.
The round cover must be removed first before
the reservoir cap can be reached.
1. Turn and open the cover located on the
covering.
2. Unscrew the reservoir cap and fill the fluid.
The level must be between the MIN and
MAX marks, which are located on the
inside of the reservoir.
IMPORTANT
Do not forget to refit the cap.
Power steering fluid
IMPORTANT
Keep the area around the power steering
fluid reservoir clean when checking. The
cover must not be opened.
Check the level frequently. The fluid does not
require changing. The fluid level must be
between the MIN and MAX marks. For capaci-
ties and recommended fluid grade, see
page 361.
NOTE
If a fault should arise in the power steering
system or if the engine is switched off and
the car must be towed, it can still be steered.
ProCarManuals.com

08 Maintenance and service
Fuses
08

* Option/accessory, for more information, see Introduction.335
General fuses, engine compartmentOn the inside of the cover there are tweezers
that facilitate the procedure for the removal
and fitting of fuses.
Positions (see preceding illustration)Engine compartment, upper
Engine compartment, front
Engine compartment, lower
These fuses are all located in the engine com-
partment box. The fuses in (C) are located
under (A).
On the inside of the cover is a label that shows
the location of the fuses.
•Fuses 1-7 and 42-44 are of the "Midi Fuse"
type and must only be replaced by a work-
shop
1.
•Fuses 8-15 and 34 are of the "JCASE" type
and should be replaced by a workshop1.
•Fuses 16-33 and 35-41 are of the "Mini
Fuse" type.
FunctionA
Primary fuse for the central elec-
tronic module (CEM) with fuse
box B under the glovebox
A
50
Primary fuse for the central elec-
tronic module (CEM) with fuse
box B under the glovebox50
Primary fuse for central electri-
cal unit in cargo areaA60
Primary fuse for central electri-
cal unit in passenger compart-
ment with fuse box A under the
glovebox
A
60
Primary fuse for central electri-
cal unit in passenger compart-
ment with fuse box A under the
glovebox
A
60
--
PTC element, air preheater*A100
Headlamp washers*20
Windscreen wipers30
FunctionA
Parking heater*25
Ventilation fanA40
--
ABS pump40
ABS valves20
--
Headlamp levelling*, Active
Xenon headlamps - ABL*10
Primary fuse for the central elec-
tronic module (CEM) with fuse
box B under the glovebox20
ABS5
Speed related power steering*5
Engine control module, Trans-
mission control module, Air-
bags10
Heated washer nozzles*10
1An authorised Volvo workshop is recommended.
ProCarManuals.com

08 Maintenance and service
Fuses
08

* Option/accessory, for more information, see Introduction.339
Box AFunctionA
Folding head restraint*15
Infotainment control module5
Audio control module*
Digital radio*, TV*10
Audio15
Telematics*, Bluetooth*5
--
Sun roof*, Interior lighting
roof, Climate sensor5
12 V socket, tunnel console15
Seat heating, rear right*15
Seat heating, rear left*15
--
Seat heating (passenger
side)15
Seat heating (driver's side)15
Box AFunctionA
Parking assistance*, Park-
ing camera*, Towbar control
module *
BLIS*5
AWD control module*10
Active chassis Four-C*10
Box BFunctionA
Rear window wiper15
--
Interior lighting, Driver's
door control panel, power
windows, Power seats,
front*, Remote controlled
garage door opener*7.5
Information display (DIM)5
Adaptive cruise control,
ACC*, collision warning sys-
tem*10
Interior lighting, Rain sensor7.5
Steering wheel module7.5
Box BFunctionA
Central locking system, fuel
filler flap10
Rear window washer15
Windscreen washers15
Unlocking, tailgate10
--
Fuel pump20
Climate panel5
Steering lock15
Siren alarm*, Data link con-
nector OBDII5
--
Airbags10
Collision warning system5
Accelerator pedal, PTC ele-
ment air preheater*, Dim-
ming, interior rearview mir-
ror*, Seat heating, rear*7.5
ProCarManuals.com

09 Specifications
Fluids and lubricants09

361 Other fluids and lubricants
Manual gearboxVolume (litres)Prescribed transmission fluid
MMT61.7BOT 350M3M661.9
Automatic gearboxVolume (litres)Prescribed transmission fluid
MPS67.3BOT 341
TF-80SC7.0AW1
TF-80SD7.0AW1
FluidSystemVolume (litres)Prescribed grade
CoolantT510.5
Coolant recommended by Volvo mixed with 50% waterA, see the packaging.
T6, D3 and D58.9
T3B, T4B, C and T4FC9.2
T4B, D and T4FD9.8
DRIVe10.5
Brake fluidBrake system0.6DOT 4+
Power steering
fluidPower steering-WSS M2C204-A2 or equivalent product.
ProCarManuals.com

10 Alphabetical Index
10
389
Electrical socket......................................217
cargo area........................................... 279
front seat............................................. 217
Electric parking brake.............................. 133
low battery voltage.............................133
releasing automatically....................... 134
releasing manually.............................. 134
Emergency equipment
warning triangle.................................. 302
Emergency puncture repair..................... 305
Emissions of carbon dioxide................... 277
Engine
overheating......................................... 283
starting................................................ 112
Engine block heater................................. 114
fuel-driven........................................... 162
Engine compartment
coolant................................................ 316
oil........................................................ 313
overview.............................................. 313
power steering fluid............................ 318
Engine drag control ................................168
Engine oil.........................................313, 359
adverse driving conditions.................. 359
capacities........................................... 359filter..................................................... 313
oil grade.............................................. 359
Engine specifications............................... 358
Environmental labelling, FSC, owner's
manual.......................................................12
Error messages
Driver Alert Control............................. 201
Lane Departure Warning..................... 203
see Messages and symbols.......135, 183
Error messages in BLIS........................... 213
Error messages in Distance Alert............ 186
Error messages in the Adaptive cruise con-
trol............................................................ 183
ETC, electronic temperature control ....... 156
Expectant mothers, seatbelt...................... 17
External dimensions................................354
F
Fan........................................................... 157
Fault tracing for the camera sensor. 190, 196
First aid equipment.................................. 302
First aid kit .............................................. 302Flexifuel.................................................... 114
adaptation........................................... 115
Fluids, capacities..................................... 361
Fluids and oils.......................................... 361
Fog lamps
rear........................................................ 90
Foot brake............................................... 131
FOUR-C – Active chassis........................170
FSC, environmental labelling..................... 12
Fuel.......................................................... 274
fuel consumption................................ 363
fuel economy...................................... 301
fuel filter.............................................. 276
Fuse box.................................................. 333
glovebox............................................. 338
Fuses.......................................................333
box in cargo area................................ 341
changing............................................. 333
cold zone............................................ 342
general................................................ 333
relay/fuse box in engine compart-
ment.................................................... 334
Start/Stop........................................... 342
Fuse table
fuses in engine compartment............. 335
ProCarManuals.com

10 Alphabetical Index
10
394
Seatbelt
rear seat................................................ 18
seatbelt tensioner................................. 18
Seatbelt reminder...................................... 18
Seatbelts.................................................... 16
Seats.......................................................... 82
head restraints, rear.............................. 84
heating................................................ 157
lowering the front backrest................... 82
lowering the rear backrest.................... 85
power seats.......................................... 83
Securing loads (Loading)......................... 279
Sensus....................................................... 79
Service programme................................. 312
Set time interval....................................... 185
Side airbags............................................... 24
Signal input, external.......................222, 240
SIPS bags.................................................. 24
Soot filter................................................. 276
Soot filter full............................................ 276
Spare wheel............................................. 299
Spin control............................................. 168
Spin control function...............................168
SST – Self Supporting run flat Tyres....... 304Stability and traction control system....... 168
Stability system....................................... 168
Stains....................................................... 346
Start assistance....................................... 116
Steering force, speed related.................. 170
Steering force level, see Steering force... 170
Steering lock............................................ 113
Steering wheel........................................... 87
keypad.......................... 87, 145, 171, 224
keypad, adaptive cruise control......... 177
steering wheel adjustment.................... 87
Stone chips and scratches...................... 347
Storage spaces in the passenger compart-
ment......................................................... 215
Sunroof
opening and closing...........................106
pinch protection.................................. 107
sunscreen........................................... 107
ventilation position.............................. 106
Sunscreen, sunroof.................................. 107
Surround.......................................... 220, 227
Symbols................................................... 169
indicator symbols................................. 74
information symbols............................. 74
warning symbols................................... 74Symbols and messages
Collision Warning with Auto
Brake..........................................191, 197
Distance Alert..................................... 186
Driver Alert Control............................. 201
Lane Departure Warning..................... 203
Symbols and messages in the Adaptive
cruise control........................................... 183
T
Tailgate
locking/unlocking.................................. 61
Temperature
actual temperature.............................152
Temperature control................................ 158
Theatre lighting.......................................... 93
Timer........................................................ 159
Total airing function...........................60, 153
Towbar
detachable, attachment ..................... 286
detachable, removal .......................... 287
Towbar, see Towing equipment.............. 284
Towing..................................................... 289
towing eye.......................................... 290
ProCarManuals.com