VOLVO V90 2019 Warranty and Maintenance Records Information

49
WARRANTY
If an emergency occurs and an authorized Volvo
retailer is not reasonably available, repairs may be
performed at any available service establishment
or by any individual, using any replacement part.
When a warranted part is not available within
thirty (30) days or the repair cannot be completed
within thirty (30) days, repairs may be performed
at any available service establishment or by any
individual, using any replacement part.
Volvo will reimburse the owner for emergency
repairs (including diagnosis) that are covered
under this warranty. The expenses, however,
cannot exceed our suggested retail price for
all warranted parts replaced and labor charges,
based on Volvo’s recommended time allowance
for the warranty repair and the geographically
appropriate hourly labor rate. Replaced parts
and paid invoices must be presented at a Volvo
retailer as a condition of reimbursement for
emergency repairs not performed by a Volvo
retailer.
Failure to notify the owner of a decision to
honor or deny a Performance Warranty Claim
within thirty (30) days from the time the vehicle
is initially presented for repair shall result in
the vehicle manufacturer being responsible for
repairing the vehicle without charge to the vehicle
owner, unless such failure is attributable to the
vehicle owner or to events beyond the control of
the vehicle manufacturer or the repair facility.You are advised to have all recommended
maintenance or repairs on your new 2019
Volvo vehicle performed. Volvo will not deny
a warranty claim solely because you have no
record of maintenance; however, we may deny a
warranty claim if your failure to perform required
maintenance resulted in the failure of a warranted
part.
Receipts and/or maintenance records covering
the performance of regular maintenance should,
therefore, be retained in the event questions arise
concerning maintenance.
Inspection ProgramCalifornia, Connecticut, Delaware, Maine,
Massachusetts, Maryland, New Jersey,
New York, Oregon, Pennsylvania, Rhode
Island, Vermont and Washington
Non-hybrid models The following provisions apply to vehicles
which fail to pass the California, Connecticut,
Delaware, Maine, Massachusetts, Maryland,
New Jersey, New York, Oregon, Pennsylvania,
Rhode Island, Vermont or Washington Smog
Inspection. Should your vehicle fail a smog check
test during the warranty period, you may choose
to have the vehicle repaired at any authorized
Volvo retailer. The authorized Volvo retailer will
make the necessary repairs within the three (3)
year/50,000-mile period so that the vehicle will
pass the inspection. After three (3) years/50,000
miles, but before a period of use of seven (7)
years/70,000 miles, the authorized Volvo dealer
will repair or replace only those parts listed in the
article “2019 Model Year Emission Parts List”
in this booklet. After seven (7) years/70,000
miles, but before a period of use of eight (8)
years/80,000 miles, the authorized Volvo retailer
will cover only the catalytic converter, engine
control module, central electronic module and
onboard diagnostic device. Volvo will pay for the
repair unless the failure was caused by abuse,
neglect, improper maintenance, or the use of
leaded fuel or fuels not recommended in your
Owner’s Manual or this booklet. If the failure is
covered under this warranty, Volvo shall be liable

50
WARRANTYfor diagnostic and repair expenses. If the failure
is caused by a combination of warrantable and
nonwarrantable conditions, the owner shall not
be liable for the portion of diagnostic and repair
costs relating to the warrantable condition.
If the failure is caused by a nonwarrantable
condition, the vehicle owner shall be liable for
all diagnostic and repair expenses, but not to
exceed the maximum permissible under the
inspection program. The owner may choose
to have the vehicle repaired at a facility other
than a Volvo retailer; however, if a warrantable
condition is found, the owner must bring the
vehicle to an authorized Volvo retailer to have
the repairs completed at no cost for parts,
labor, and diagnosis. Volvo will not reimburse
the owner for diagnostic costs incurred at the
unauthorized service facility except in the case of
an emergency.Hybrid models The following provisions apply to vehicles
which fail to pass the California, Connecticut,
Delaware, Maine, Massachusetts, Maryland,
New Jersey, New York, Oregon, Pennsylvania,
Rhode Island, Vermont or Washington Smog
Inspection. Should your vehicle fail a smog check
test during the warranty period, you may choose
to have the vehicle repaired at any authorized
Volvo retailer. The authorized Volvo retailer will
make the necessary repairs within the three (3)
year/50,000-mile period so that the vehicle will
pass the inspection. After three (3) years/50,000
miles, but before a period of use of seven (7)
years/70,000 miles, the authorized Volvo dealer will repair or replace only those parts listed in the
article “2019 Model Year Emission Parts List” in
this booklet. After seven (7) years/70,000 miles,
but before a period of use of eight (8) years/
80,000 miles, the authorized Volvo retailer will
cover only the catalytic converter, engine control
module, central electronic module and onboard
diagnostic device. TZEV vehicles identified in the
article “Volvo’s 2019 New Vehicle Warranties &
Complimentary Factory Scheduled Maintenance
Program” in this booklet have all emissions
components covered for a period of fifteen (15)
years or 150,000 miles. Volvo will pay for the
repair unless the failure was caused by abuse,
neglect, improper maintenance, or the use of
leaded fuel or fuels not recommended in your
Owner’s Manual or this booklet. If the failure is
covered under this warranty, Volvo shall be liable
for diagnostic and repair expenses. If the failure
is caused by a combination of warrantable and
nonwarrantable conditions, the owner shall not
be liable for the portion of diagnostic and repair
costs relating to the warrantable condition.
If the failure is caused by a nonwarrantable
condition, the vehicle owner shall be liable for
all diagnostic and repair expenses, but not to
exceed the maximum permissible under the
inspection program. The owner may choose
to have the vehicle repaired at a facility other
than a Volvo retailer; however, if a warrantable
condition is found, the owner must bring the
vehicle to an authorized Volvo retailer to have
the repairs completed at no cost for parts,
labor, and diagnosis. Volvo will not reimburse the owner for diagnostic costs incurred at the
unauthorized service facility except in the case of
an emergency.
What Is Not Warranted (applies to all
models)1. Required maintenance services as specified
in the article “Maintenance Service
Operations” in this booklet. Items that affect
emissions and require scheduled replacement
are warranted up to their first replacement
point [such as spark plugs, filters, belts, etc.].
Once these parts have been replaced at the
scheduled replacement point, they are no
longer covered by this Emission Warranty.
2. Malfunctions in any part caused by misuse,
improper adjustments (by other than a
Volvo dealer during warranty repair work),
modification, alteration, tampering or
disconnection of system parts.
3. Damage resulting from accidents, acts of
nature, or events beyond the control of Volvo.
4. The use of fuel and/or oil, or other fluids
which do not meet the Volvo-approved
standards as set forth in the Owner’s Manual
or in the articles “Fuel requirements” and
“Engine oil” in this booklet, may not be
warranted.


51
WARRANTY
5. Repairs on vehicles for which the true
odometer mileage cannot be readily
determined.
6. Parts other than genuine Volvo replacement
or remanufactured parts used for
maintenance, repair or replacement affecting
components of the emission control system.
7. Any loss of time, inconvenience, loss of
vehicle use or commercial loss.
Limitations and DisclaimersCalifornia, Connecticut, Delaware, Maine,
Massachusetts, Maryland, New Jersey,
New York, Oregon, Pennsylvania, Rhode
Island, Vermont and Washington Volvo’s written warranty is exclusive and in
lieu of all warranties, whether oral or written,
expressed or implied.
No implied warranty of merchantability or
fitness for a particular purpose shall apply
except during the applicable periods of this
warranty.
Volvo does not authorize any individual or
corporation to create for it any obligation,
liability or other warranty in connection with
this vehicle.
Volvo’s liability, if any, for product(s) furnished
under this warranty shall in no event
exceed the cost of correcting defects in the
product(s) as herein provided and upon the
expiration of this warranty, any such liability
shall terminate.
NOTE
This warranty gives you specific legal
rights and you may also have other rights.
California, Connecticut, Delaware, Maine,
Massachusetts, Maryland, New Jersey,
New York, Oregon, Pennsylvania, Rhode
Island, Vermont and Washington may not
allow limitations on how long an implied
warranty lasts, so the above limitations
may not apply to you. These states may not
allow the exclusion or limitation of incidental
or consequential damages, so the above
limitations or exclusions may not apply to you.

52
WARRANTY2019 Model Year Emission Parts ListNon-hybrid models only
California, Connecticut, Delaware, Maine,
Massachusetts, Maryland, New Jersey, New York,
Oregon, Pennsylvania, Rhode Island, Vermont and
Washington The components listed in the chart below apply to
non-hybrid models and are covered by the Long
Term Defect and Performance Warranty for seven (7) years or 70,000 miles/113,000 kilometers,
whichever occurs first.
ENGINE VIN CODE NUMBER
A2 10 16 AC
Catalytic Converter
A
XXXX
Charge Air Cooler XXXX
CVVT Timing Device (Exhaust)XXXX
CVVT Timing Device (Inlet)XXXX
Electronic Throttle Module (ETM)XXXX
Engine Control Module
A
XXXX
Fuel Pump XXXX
Fuel Tank AssemblyXXXX
Transmission Control Module XXXX
Turbocharger XXXX
Supercharger X
Supercharger Bypass ValveX
A The Engine Control Module and Catalytic Converter are also covered by the 8-year or 80,000-mile Long Term Emissions Warranty. Please see the list in the article “2019 Emission Warranty Parts List –
Federal – U.S. and Canada” in this booklet.

53
WARRANTY
Transitional Zero Emissions (TZEV)
VehiclesModel year 2019 vehicles with engine VIN code
BR sold and registered in California, Connecticut,
Maine, Massachusetts, Maryland, New Jersey,
New York, Oregon, Rhode Island or Vermont are
classified as Transitional Zero Emissions
(TZEV) vehicles. TZEV vehicles have a defects
and performance emissions warranty on all
emissions components for fifteen (15) years or
150,000 miles, whichever occurs first.
Complimentary Factory Scheduled
Maintenance (FSM) Program (U.S.
Only)General InformationTo further enhance the Volvo ownership
experience, your 2019 model year Volvo
vehicle sold new and registered in the US by
an authorized Volvo retailer includes the Volvo
Complimentary Factory Scheduled Maintenance
(FSM) Program. This maintenance program is
designed to complement your Volvo warranty and
will help ensure trouble free operation of your
Volvo vehicle.
The Volvo Complimentary FSM program is
honored at any authorized Volvo retailer in the
United States. Coverage begins with the date the
vehicle is delivered to the original purchaser or
the original lessee, or on the date the vehicle is
placed in service as a demonstrator. This program
is associated with the vehicle and cannot be
transferred to another vehicle.
The Volvo Complimentary Factory Scheduled
Maintenance (FSM) program is transferred
automatically to subsequent owners of the vehicle
within the program period.
Volvo reserves the right to make changes to or
terminate this program at any time.
Program coverageThe Volvo Complimentary Factory Scheduled
Maintenance (FSM) program offers:
• Scheduled maintenance coverage for the first
3 (three) years or up to 36,000 miles
• The first three regularly scheduled
maintenance services at 10,000, 20,000 and
30,000 miles as outlined in the table in the
article “Maintenance Service Operations” in
this booklet.Owner’s ResponsibilitiesEach recommended service must be performed
within 1,500 miles of the normal service interval
listed, see the table in the article “Maintenance
Service Operations” in this booklet.
You will be responsible for maintenance
costs when mileage precede or exceeds the
recommended interval by 1,500 miles
8.
Service intervals missed will not be performed.
Authorized Volvo retailers will perform the service
that is appropriate for the mileage or age of the
vehicle.
Items Not Covered• Wear items outlined in the article “Volvo’s
2019 New Vehicle Limited Warranty–U.S./
New Vehicle Warranty–Canada” in this
booklet.

8 Volvo recommends that you bring your vehicle in for service at least once a year regardless of mileage. In such cases Volvo will cover the recommended services at one (1) per year for the first three (3) years.

54
WARRANTY• Damage to the vehicle resulting from normal
wear and tear or abuse.
• Vehicles severely damaged and/or declared to
be a total loss by an insurer.
• Severe operating conditions requiring
additional services.
• Owner requested services or Volvo retailer
suggested services not specified in the
table in the article “Maintenance Service
Operations” in this booklet. 

55
NOTES

56
NOTES

Volvo Ownership Change Request (U.S. ONLY)
WARRANTY


WARRANTY
PLACE
STAMP
HERE
VOLVO CAR USA, LLC.
VOLVO CUSTOMER CARE CENTER
1 VOLVO DRIVE
ROCKLEIGH, NEW JERSEY 07647