AUDI A4 1999 B5 / 1.G AWM Engine Lubrication System Components User Guide

AUDI A4 1999 B5 / 1.G AWM Engine Lubrication System Components User Guide A4 1999 B5 / 1.G AUDI AUDI https://www.carmanualsonline.info/img/6/939/w960_939-0.png AUDI A4 1999 B5 / 1.G AWM Engine Lubrication System Components User Guide
Trending: oil dipstick, air suspension, automatic transmission, oil temperature, oil viscosity, warning light, lock

Page 11 of 35

AUDI A4 1999 B5 / 1.G AWM Engine Lubrication System Components User Guide 17-11
 
  
Oil pan, removing and installing
 
Special tools and equipment  
 
Support bar 10-222A
 Lifting tackle 2024 A
 Socket 3249
 Workshop crane VAG 1202 A
 Electric drill with plastic brush atta

Page 12 of 35

AUDI A4 1999 B5 / 1.G AWM Engine Lubrication System Components User Guide 17-12
      
Removing  
     
Engine in vehicle 
     Lock carrier must be in service position   
Page 13
-1 . 
    
-  Unbolt bracket for sound insulation -arrow-.
-  Remove air duct hose on bottom l

Page 13 of 35

AUDI A4 1999 B5 / 1.G AWM Engine Lubrication System Components User Guide 17-13
 
    
-  Remove seal from plenum chamber cover in direction of arrow.
-  Remove plenum chamber cover -1- from front.
    
-  Remove nut -arrow- from top of left engine mounting. 
Pa
ge 13 of 35

Page 14 of 35

AUDI A4 1999 B5 / 1.G AWM Engine Lubrication System Components User Guide 17-14
 
    
-  Set up support bar 10-222 A on fender panel flanges.
    
-  Remove lifting eye from lifting tackle 2024 A.
-  Replace pin -1- in center hole on lifting tackle and secure with locking

Page 15 of 35

AUDI A4 1999 B5 / 1.G AWM Engine Lubrication System Components User Guide 17-15
 
    
CAUTION! 
The hooks and locating pins of the lifting tackle must be secured 
with locking pins -arrows in illustration-.  -  Engage lifting tackle 2024 A in front and rear lifting eyes on

Page 16 of 35

AUDI A4 1999 B5 / 1.G AWM Engine Lubrication System Components User Guide 17-16
      
Vehicles with automatic transmission: 
     
Note:  
     Observe cleanliness rules when working on the 
automatic transmission: 
     
       Repair Manual, 5 Spd. Automatic 
Transmissio

Page 17 of 35

AUDI A4 1999 B5 / 1.G AWM Engine Lubrication System Components User Guide 17-17
 
    
-  Where present unclip operating rod of vehicle level sender from lower 
transverse link -arrow-. 
    
-  Cut through cable ties -arrows-. Open retainer for starter cable and 
take out

Page 18 of 35

AUDI A4 1999 B5 / 1.G AWM Engine Lubrication System Components User Guide 17-18
 
    
Note:  
Different mounting holes are provided for the different engine versions.  -  Mark positions of mountings -1- and locating sleeves -2- on left and 
right engine mountings (lower).

Page 19 of 35

AUDI A4 1999 B5 / 1.G AWM Engine Lubrication System Components User Guide 17-19
 
    
Note:  
The subframe should be disconnected and lowered at the front only, 
otherwise it will be necessary to check the wheel alignment. 
Vehicles with manual transmission  -  Remove fron

Page 20 of 35

AUDI A4 1999 B5 / 1.G AWM Engine Lubrication System Components User Guide 17-20
      
Vehicles with automatic transmission: 
    
All models:  -  Loosen rear bolt -2- on left transmission mounting a few turns; remove 
front bolt -1- on left transmission mounting. 
    
-
Page:   < prev 1-10 11-20 21-30 31-40 next >
Trending: lock, automatic transmission, wiring, oil temperature, oil viscosity, oil change, oil