radiator AUDI A5 COUPE 2014 User Guide
[x] Cancel search | Manufacturer: AUDI, Model Year: 2014, Model line: A5 COUPE, Model: AUDI A5 COUPE 2014Pages: 286, PDF Size: 70.99 MB
Page 217 of 286

Do not fill coolant above the "MAX" mark. Ex
cess coolant will be forced out through the pressure relief valve in the cap when the en
gine becomes hot .
_& WARNING
-The cooling system is under pressure and
can get very hot. Reduce the risk of
scalding from hot coolant by following
these steps .
- Turn
off the engine and allow itto cool
down.
- Protect your face, hands and arms from escaping fluid and steam by covering
the cap with a large, thick rag.
- Turn the cap slowly and very carefully in a counter-clockwise direction while
applying light, downward pressure on
the top of the cap .
- To avoid being burned, do not spill an
tifreeze or coolant on the exhaust sys
tem or hot engine parts . Under certain
conditions, the ethylene glycol in en
gine coolant can catch fire.
- Antifreeze is poisonous. Always store an
tifreeze in its original container and well
out of the reach of children.
- If you drain the coolant, it must be
caught and safely stored in a proper con
tainer clearly marked "poison".
(D Note
- Do not add coolant if the expansion tank
is empty. Air could enter the cooling sys
tem and damage the engine. If this is
the case, do not continue driving . Seek
professional assistance.
- Coolant pollutes the environment and
could cause an engine fire . Excess cool
ant will be forced out through the pres
sure relief valve in the cap when the en
gine becomes hot.
- If, in an emergency, only water can be
added, the correct ratio between water
and antifreeze
¢ page 213 must be re
stored as soon as possible.
Checking and filling 215
'
@) For the sake of the environment
Drained coolant should not be reused. Al
ways dispose of used coolant while observ
ing all environmental regulations.
Radiator fan
The radiator fan switches on automatically by
itself .
The radiator fan is driven by the engine via the
V-belt. The viscous clutch regulates the speed
of the fan according to the temperature of the coolant.
An auxiliary electric radiator fan* switches on
and
off depending on coolant temperature
and other vehicle operating conditions.
After you switch the engine
off, the auxiliary
fan can continue running for up to 10 minutes
- even with the ignition
off. It can even switch
on again later by itself ¢.&. , if
- the temperature of the engine coolant rises
du e to the h eat build-up from th e engin e in
the engine compartment, or
- the engine compartment heats up because
the vehicle is parked in intense sunlight.
_& WARNING ~
-To reduce the risk of personal injury nev-
er touch the radiator fan .
- The auxiliary electric fan is temperature
controlled and can switch on suddenly
even when the engine is not running.
- The auxiliary radiator fan switches on au
tomatically when the engine coolant reaches a certain temperature and will
continue to run until the coolant temper
ature drops. •
•
Page 267 of 286

complexity of today's automobi les, have
steadi ly reduced the scope of maintenance
and repairs which can be carried out by vehicle
owners.
Also, safe ty and e nvir onm en tal con
cerns place very strict limits on the nature of
repairs and adjustments to engine and trans
miss io n pa rts which an owner can perform .
Maintenance, adjustments and repairs usua lly
require special tools, testing devices and oth
er equipment avai lab le to specially trained
workshop personnel in order to assure prope r
performance, reliab ility and safety of the vehi
cle and its many systems .
Improper ma intenance, adjustments and re
pa irs can impair the operation and reliability
of your vehicle and even void your vehicle war ranty. The refo re, p roof of servic ing in accord
ance w ith the maintenance sched ule may be a
condition for upholding a poss ible war ranty
claim made within the warranty period.
Above all, operational safety can be adversely
affected, crea ting unnecessary risks for you
and your passengers.
If in doubt about any servicing, have it done
by your authorized Audi dealer or any properly
equ ipped and qua lified workshop. We st rong
l y urge you to g ive your authorized Audi dea ler
the opportunity to perform all scheduled
maintenance and necessary repairs . Your dea l
er has the facilities, original parts and trained
specialists to keep your veh icle running prop
erly.
Performing limit ed m aintenance you rself
The following pages describe a limited num
ber of procedures which can be performed on
your vehicle with ordinary too ls, should the
need arise and trained personnel be unavaila
ble. Before performing any of these proce
dures, always thoroughly read all of the appli
cable text and carefully follow the instruc
tions given. Always rigorously obse rve the
WARNINGS provided.
B efore you check anything in th e engine
compartment, a lways re ad and heed all
Con sumer In formation 265
WARNINGS ¢ & and ¢ & in Working in the
engine comportment on page 206 .
A WARNING
-Ser ious personal injury may occur as a re
sult of improperly performed mainte
nance, adjustments or repa irs.
-Always be extremely careful when work
ing on the vehicle. Always follow com
mon ly accepted safety practices and gen
eral common sense. Never r isk personal
lnJUry.
- Do not attempt any of the ma intenance,
checks or repairs descr ibed on the fol
lowing pages if you are not fully fam iliar
wit h these or othe r pro cedures with re
spect to t he veh icle, or are uncerta in how
to p roceed .
- Do not do any work without the proper
too ls and equipment. Have the necessary
work done by your authorized A udi deal
er or any properly equipped and qualified
wo rkshop.
- The engine compartment o f any motor
veh icle is a potentially hazardous area.
Never reach into the area around or
touch the radiator fan. It is temperature
contro lled and can switch on suddenly -
even when the engine is off and the igni
tion key has been removed. The rad iator
fan switches on automat ica lly when the
coo lant reaches a certai n temperatu re
and will cont inue to run until the coo lan t
tempera ture drops .
- Always remove the ign itio n key befo re
anyone gets under the vehicle.
- Always support your veh icle with safety
s tands i f it is necessary to work under
neath the vehicle. The jack s upplied with
the vehicle is not adequate for this pur
pose and cou ld collapse causing serio us
personal injury.
- If you must work underneath the vehicle
with the wheels on the ground, a lways
make sure the vehicle is on leve l ground,
that the wheels are a lways securely
blocked a nd that the engine cannot be
started.
•
•
Page 275 of 286

Engine compartment
Safety instructions ................ . 206
Working the engine compartment 206
Engine coolant
Indicator light . . . . . . . . . . . . . . . . . . . . . 17
Engine coolant system .......... ... .. 213
Adding coolant .............. ... ... 214
Checking coolant level ..... .. .. .. .. . 213
Checking the engine coolant level . . . . . 213
Radiator fan ............. .. .. .. .. . 215
Engine coolant temperature Temperature gauge .......... .... ... 10
Engine hood Closing .. .. .. ........... .. .. .. ... 206
How to release the hood ... .. .. .. .. . 206
Engine oil ... ................ ... ... 208
Adding .... ................ ... ... 211
Additives . .. .. ........... .. .. .. ... 211
Changing .. ............. .... .. ... 212
Check oil level ........... .... .. ... 211
Consumption ............... ... ... 211
Indicator light . . . . . . . . . . . . . . . . . 17, 21
Oil consumption . ...... ... .. .. .. .. . 210
Oil grades ..................... ... 208
Pressure malfunction ...... .. .. .. .. .. 17
Sensor defective . . . . . . . . . . . . . . . . . . . . 21
Specification and viscosity ... ... .. .. . 208
Engine speed limitation .......... .... . 21
Environment Break-in period ........... .. .. .. ... 188
Catalytic converter ............ ... .. 189
Disposing of your vehicle battery ..... 220
Driving at high speeds .......... .... 190
Driving to minim ize pollution and noise 190
Fu el . .. .. .. .. .. ........... .. .. ... 204
Fu el economy ..................... 190
Leaks under your vehicle ............ 206
Letting the vehicle stand and warm up. 191
Proper disposal of drained brake fluid . 216
Proper disposal of drained engine cool-
ant . .... .. .. ............. .. .. ... 214
Proper disposal of drained engine
oil ...... ... ............. ... 211,212
Recycling used engine oil . .. .. .. .. .. . 211
Roof rack . . . . . . . . . . . . . . . . . . . . . . . . . 62
Unleaded fuel . ........... .. .. .. ... 201
What should I do with an old battery? . 220
Index 273
EPC
refer to Electronic power control . . . . . . 20
Ethyl alcohol (Fuel) . ................. 202
Event Data Recorder (EDR) ........ .... 180
Exhaust tail pipes Cleaning ... ..... .. ............... 197
Expansion tank .. .... ... ....... ..... 213
Exterior lighting . .. ................. . 43
Exterior m irrors
Adjusting ..... .... ................ 46
Dimming ... ..... .. ................ 47
Heating ........................... 46
F
Fan
Radiator
Fastening 215
Booster seats .. ...... ......... .... 169
Convertible child safety seats .... .... 168
Infant seats
Flat tire 167
Changi ng ... .. .. .. .. ........... .. 244
flexible fuel ... .. .... ............... 202
Floor mats ... ..... .. ............... 124
Fog lights/rear fog lig ht(s) . . . . . . . . . . . . . 43
Folding the rear seats ... ............. . 63
Foot pedals . .. .. .. .. ............... 124
For the sake of the environment Gasoline fumes and the environment .. 204
Letting the engine warm up . . . . . . 71, 74
Refueling . .. .. .. ................. 204
Saving fuel by early upsh ifting ... .. .. . 11
Front airbags Description . . . . . . . . . . . . . . . . . . . . . . . 141
How they work ... .. . .. .... ........ 146
Frontal collisions and the laws of physics 130
Front passenger's door emergency locking 37
Front seats Adjusting ....... .. ..... .......... 121
Child restraints in the front seat ...... 138
Fuel Additives .... .. ...... ............. 201
Blended gasoline ... . .. .... ........ 201
Consumption .. ... ............... .. 25
Filler neck . .. .. .... .......... ..... 203
Fuel gauge . . . . . . . . . . . . . . . . . . . . . . . . 12
•
•