oil AUDI A6 2017 User Guide

co
co
.... N
" N .... 0 0 <..:l - is empty or until no more fluid flows into the
tank .
.,. Remove the canister and close the fi ller tube
c:> page 197 , Comple ting AdBlue refill .
CD Note
Only use refi ll canisters that are approved for
your vehicle. Us ing other systems can cause
Ad Blue to leak.
(D Tips
- An authorized Audi dealer or authorized
Audi repair facility can tell you which ref ill
canisters are approved for your vehicle.
- A permitted refill canister conta ins approxi­
mately 1.3 gallons (5 liters) of AdBlue.
Completing AdBlue refill
Applies to: vehicles with selective catalytic reduction
Clo sing the filler nec k
.,. Tu rn the cap on the filler neck to the right with
the wheel wrench until the cap clicks into place.
This t ightens the cap to the specification c::> .&.
in Filling AdBlue on page 196, c:> 0 in Filling
AdBlue on page 196.
.,. The n press on the left side of the tank doo r un-
t il it latches .
After filling
The vehicle must be dr iven so that the system
recognizes that the Ad Bl ue was refilled . Th is can
take severa l m inutes.
.,. If there was no Ad Blue left in the tank and a
range of O mi (0 km) was shown in the display,
switch the ign ition on for about 30 seconds be­
fore starting the engine.
(D Tips
Ad Blue can freeze at very low temperatures.
If th is happens , the system will not detect
that the Ad Blue was refilled and it will contin­
ue to inform yo u of the low Ad B lue level. The
message turns off as soon as the tank thaws
out again .
Ch eck ing and Filling
Catalytic converter
Applies to: vehicles with gasoline engine
It is very important that your emission control
system (cataly tic converter) is functioning prop­
erly to ensure that your vehicle is running in an
environmentally sound manner.
.,. Always use lead-free gasoline c:> page 190 , Fuel
supply.
.,. Never run the tank down all the way to empty .
.,. Never put too much motor o il in your engine
c:> page 203, Adding engine oil.
.,. Never try to push- or tow-start your vehicle.
The catalytic co nverter is an efficient "clean -up"
device built into the exhaust system of the ve hi­
cle. The catalyt ic converter b urns many of the
po llutants in the exhaust gas before they are re­
leased into the atmosphere.
The exclusive use of un leaded fuel is cr itically im­
portant for the life of the catalytic converte r and
prope r funct ion ing of the eng ine .
_&. WARNING
The tempera ture of t he exhaus t sys tem is
h igh, bot h when driv ing and a fter stopping
the engine .
- Never tou ch the exhaust tail pipes once they
have become hot. This cou ld resu lt in burns.
- Do not park or operate the vehicle in ar eas
where the hot exhaus t sys tem may come in
contact with dry grass, b rush, fuel spill or
other material which can ca use a fire.
- Do not app ly additiona l undercoating or
r u stp roofing on or near the exhaust mani­
fold, exha ust pipes, cata lytic converter or
heat shields . D uring driving, the substance
used for undercoat ing could overheat and
cause a fire.
CD Note
- Be aware that just one tank fi lling with
leaded fuel w ill already seriously degrade
the performance of the catalytic converter .
- Do not exceed the correct engine oil leve l
c:> page 203.
197

co
co
.... N
" N .... 0 0 <..:l ' -Do not remove the engine cover under any
circumstances . This increases the risk of
burns.
- If tests need to be performed with the en­
gine running, there is additional danger due
to moving components (such as the ribbed belt, alternator and radiator fan) and from
the high voltage ignition system.
- Do not under any circumstances give gas in­
advertently (for example, by hand from the
engine compartment) if the vehicle is sta­
tionary but the engine is running and a gear
is engaged. Otherwise, the vehicle will start
to move immediately and this could result
in an accident.
- Pay attention to the following warnings list­
ed when work on the fuel system or on the
electrical equipment is required.
- Do not smoke .
- Never work near open flames.
- Always have a working fire extinguisher
nearby
- All work on the battery or electrical system
in your vehicle can result in injuries, chemi•
cal burns, accidents or burns. Because of
this, all work must be performed
only by an
authorized Audi dealer or authorized Audi
Service Facility.
- To reduce the risk of electric shock and in­
jury, never touch the following components when the engine is running or is being start­
ed :
- Ignition cable
- Other components in the electronic high-
voltage ignition system
- If you must check or perform work on the
engine while it is running:
- Set the parking brake and place the selec­
tor lever in the P (park) position first .
- Always proceed with extreme caution so
that clothing, jewelry or long hair do not
become caught in the radiator fan, fan
belt or other moving components or do not come into contact with hot compo­
nents. Tie back long hair before beginning
work and do not wear clothing that can
hang down into the engine .
Checking and Filling
-Limit your exposure to exhaust and chemi­
cals to as short a time as possible
c:> A .
A WARNING
-California Proposition 65 Warning:
- Engine exhaust, some of its constituents,
and certain vehicle components contain or
emit chemicals known to the State of Cali­
fornia to cause cancer and birth defects and
reproductive harm . In addition, certain flu­
ids contained in vehicles and certain prod­
ucts of component wear contain or emit
chemicals known to the State of California
to cause cancer and birth defects or other
reproductive harm.
- Battery posts, terminals and related acces­
sories contain lead and lead compounds,
chemicals known to the State of California
to cause cancer and reproductive harms. Wash hands after handling.
(D Note
When filling fluids, be sure not to mix the flu­
ids up. Otherwise severe malfunctions and en­
gine damage will occur.
@ For the sake of the environment
You should regularly check the ground under
your vehicle in order to detect leaks quickly. If
there are visible spots from oil or other fluids, bring your vehicle to an authorized Audi deal­
er or authorized Audi Service Facility to be
checked.
199

co
co
.... N
" N .... 0 0 <..:l 'SI'
Checking and Filling
Engine compartment overview
The most important check points .
Fig. 182 Typ ical locatio n of t he rese rvoi r and the engine o il filler opening
(D Jump start po int(-) with hex head screw
¢ page 207, ¢ page 249
@ J ump start point(+) under a cover
¢ page 20 7, ¢ page 249
® Eng ine oi l label* w ith VW standard
¢page201
© B rake fluid reservoi r (0)) ¢ page 2 06
® Eng ine oil filling opening ('t::r.) ¢ page 203
@ Coolant reservo ir (- L) ¢ page 205
0 Washer fluid rese rvoir (0) ¢ page 208
The engine oil fill ing opening (item@) may be
l oca ted in a different area depend ing on the en­
g ine version.
A WARNING 1 =
Read an d follow the WAR NINGS befo re
checking anything in the engine compartment
¢ A in Working in the engine compartment
on page 198.
Engine oil
Engine oil specifications
The engine oil used mus t conform to exact speci­
fications.
T he serv ice interv al d isplay in the instrument
cl uster of yo ur vehicle will inform you when it is
t ime for an oi l change. We recommend that you
have yo ur oil changed by an authorized Audi Serv­
ice Adv isor.
If you mu st add oil betwee n oil c hanges, use an
o il that matches the Audi oil qua lity standard
li sted on the sticker. The sticker is located at the
front of the eng ine compartment ¢
page 201,
fig. 182.
Audi recommends
~Castrol / /gfj;;j;f!K[g Frtfl7?-:<:"£Jl.JAi.
Audi recommends Longlife high performance
eng ine oil from Aud i Genuine Parts
II>
201

Check ing and F illing
Using the proper engine oil is impo rtant for the
functionality and service life of the engine. Your
engine was facto ry-filled with a h igh-quality oi l
which can usually be used throughout the entire
year.
@) Note
Your Limited New Vehicle War ranty does not
cover damage or malfunctions due to failure
to follow recommended maintenance and use
requirements as set forth in the Audi Owner's
Manual and Warran ty
& Maintenance booklet.
- Use only a high quality eng ine oil t hat ex-
p ressly complies with the Audi oil qua lity
standard specified for your vehicle's engine.
Using a ny o ther oil can cause serious engine
d am age.
- D o not mix any lubricants o r other addit ives
i nto the engine oil. Doing so ca n cause en­
g ine damage.
(D Tips
I f you need to add oil and there is none availa­
ble t hat meets the Audi o il quality standard
your eng ine requi res, you m ay ad d a tot al of
no more than 0.5 q t (0.5
l) of a h igh-quali ty
"synthe tic"oil that meets t he following speci ­
fications.
- Applies to: gasoline engine: ACEA A3 or
API SM with a viscosity g rade of SAE 0W-30,
SAE SW -30 or SAE SW-40.
- Applies to: diesel engine: ACEA C3 or API C F
with a viscosity grade of SAE 0W-30 or
SAE SW-30.
- Fo r more information about engine o il that
has been approve d for your ve hicle, please
contact either you r authorized Audi dea ler
or Audi C ustome r Relat ions at
1 (800) 822-2834 or visit our web site at
www.audiusa.com or www .aud icanada .ca.
Engine oil consumption
The engine in your vehicle depends on an ade­
quate amount of oil to lubricate and cool all of
its moving parts .
In order to provide effective lubr ication and cool­
ing of internal engine components, a ll inter nal
202
combust ion engines consume a certa in amo unt
of oil. Oil consumption varies from engine to en­
gine and may change signi ficantly over the life of
the engine. Typically, engines w ith a specified
break-in period (see
c:::;, page 66) consume more
o il dur ing the break-in per iod than they consume
af ter o il consumption has stab ilized .
Under normal cond itions, the rate of oil con­
sumption depends on the quality and viscos ity of
the oil, the RPM (revo lutions per m inute) at
wh ich the engine is operated, the amb ient tem­
perature and road condit ions. Furt her facto rs a re
the amo unt of o il di lution from wate r condensa ­
t ion or fue l resid ue an d the oxidation level of the
o il. As any engine is sub je ct to wear as mileage
builds up, the oi l cons umption may increase ove r
time unt il replacement of worn components may
become necessary.
With a ll these va riab les coming into p lay, no
standard rate of oil consumption can be estab ­
li shed or spec ified. The re is no alte rnative to reg­
ul ar and freq uent checking of the oi l level, see
Note .
If the yellow engine oi l level warning symbo l in
the instr ument cluster
El lights up, yo u should
check the o il level as soon as possible
c:::;, page 203. Top off the o il at your ea rliest con­
venience
c:::;, page 203.
A WARNING
Before you check a nyth ing in the e ng ine com­
par tment, always read and heed all WARN­
IN GS
c:::;, .&. in Working in the engin e compart­
ment on page 198.
(D Note
Drivi ng w it h an insuff ic ient oil level is likely to
cause severe damage to the eng ine.
(D Tips
- The oil pressure warn ing d isplay. is not
an indicator of the oil level. Do not rely on
it. Instead, check the oil level in your en­
gine at regular intervals, preferably each
time you refuel, and alway s before going
on a long trip .

co
co
.... N
" N .... 0 0 <..:l ' -If you have the im pression your engine con­
sumes excessive amounts of oil, we recom­
mend that you cons ult your Audi dealer to
have the cause of your concern properly di­
agnosed. Keep in mind that the accurate
measurement of oil consumption requires
great care and may take some time. Your
A udi dealer has instructions about how to
measure oil consumption accurate ly.
Checking the engine oil level and adding
engine oil
The engine oil level can be checked in the Info­
tainment system
Fig. 183 Eng ine compartment : eng ine oil filler opening
cover
Obse rve the safety precautions¢ &. in Working
in the engine compartment on page 198 .
Checking the engine oil level
.,. Park the vehicle on a level surface.
.,. Shut the engine off when it is warm. Wait ap­
prox imately two m inutes so that the engine oil
can flow back in to the oil pan .
.,. Switch only the ignition back on.
.,. Se lect: the
ICARI function button > (Car )* Sy s­
tems
control button > Service & checks > Oil
le vel.
.,. Read the oil level in the Infota inment system.
Add engine oil if the bar in the oil level indica­
tor is just before "min".
Adding engine o il
.,. Turn the engine off.
.,. Unscrew the engine oil filler opening cap
"t!:r.
¢fig.183, ¢page 201, fig.182.
.,. Carefully add 0.5 quart (0.5 liter) of the correct
o il
¢ page 201.
Check ing and Filling
.,. Close the engine oi l filler open ing cap "t!:r. .
.,. Close the hood, restart the ignition after two
m inutes and read the current o il leve l in the In­
fotainment system.
A WARNING
-When adding oil, do not let oi l dr ip onto hot
e ngine components. This increases the risk
of afire.
- You must seal the cap on the oil filler open­
ing correctly so that oi l does not leak ou t
onto the hot engine and exhaust system
when the engine is runn ing, be ca use this is
a fire hazard.
- Always clean sk in thoro ughly if it comes into
con ta ct w ith eng ine oi l.
d) Note
-The e ngine o il level must not be under the
"min" marking, beca use this increases the
r is k of engine damage.
- If the message
Oil level is too full. Pleas e
reduce
oil level. appea rs, the re is too m uch
oil in the engine and the re is a r is k of cata­
lyt ic converte r and engine damage. Do no t
start the eng ine. Co ntact an a uthorized Audi
dea ler or authorized Audi Service Facility to
have excess engine oil extracted if necessa­
ry.
-Do not mix any ad ditiona l lubricants into
the engine oil. Damage caused by such add i­
tives is not covered by the warranty .
@ For the sake of the environment
- Oil sho uld never enter the sewer system or
come into contact with the ground .
- Pay attention to lega l req uiremen ts when
disposing of empty oil containers .
(D Tips
- T he oil level in dicator in the inst rumen t
cl uster display is only an informationa l dis ­
play. If the o il level is too low, a minim um
oil warn ing appears in the instrument clus­
ter. Add oil and close the hood. The c urrent
oil level is d isplayed in the Infotainment
203

Checking and Filling
system the next time the ignition is
switched on.
- The engine oil consumption may be up to
0.5 quart/600 miles (0.5 liter/1 ,000 km),
depending on driving style and operating
conditions . Consumption may be higher
during the first 3,000 miles (5,000 km). Be­
cause of this, the engine oil level must be
checked regularly .
It would be best to check
each time you refuel your vehicle and before
long drives .
Changing the engine oil
We recommend that have your oil changed by an
authorized Audi dealer or a qualified service sta­
tion.
Before you check anything in the engine compart ­
ment ,
always read and heed all WARNINGS q .&.
in Working in the engine compartment on
page 198.
The engine oil must be changed according to the
intervals specified in your Warranty
& Mainte­
nance booklet. This is very important because the
lubricating properties of oil diminish gradually
during normal vehicle use.
Under some circumstances the engine oil should
be changed more frequently . Change oil more of­
ten if you drive mostly short distances , operate
the vehicle in dusty areas or under predominantly
stop-and-go traffic conditions, or have your vehi­
cle where temperatures remain below freezing
for extended periods.
Detergent additives in the oil will make fresh oil
look dark after the engine has been running for a
short time. This is normal and is not a reason to
chang e the oil more often than recommended.
Because of the problem of proper disposal, along
with the special tools and necessary expertise re­
quired, we strongly recommend that you have
your oil changed by an authorized
Audi dealer or
a qualified service station .
If you choose to change your oil yourself, please
note the following important information:
204
A WARNING
-
To reduce the risk of personal injury if you
must change the engine oil in your vehicle
yourself:
- Wear eye protection.
- To reduce the risk of burns from hot engine
-
oil, let the engine cool down to the touch .
- When removing the oil drain plug with your
fingers, stay as far away as possible. Always keep your forearm parallel to the ground to
help prevent hot oil from running down your
arm .
- Drain the oil into a container designed for
this purpose, one large enough to hold at
least the total amount of oil in your engine.
- Engine oil is poisonous . Keep it well out of
the reach of children.
- Continuous contact with used engine oil is
harmful to your skin . Always protect your
skin by washing oil off thoroughly with soap
and water.
(D Note
Never mix oil additives with your engine oil.
These additives can damage your engine and
adversely affect your Audi Limited New Vehi­
cle Warranty.
@ For the sake of the environment
- Before changing your oil, first make sure you know where you can properly dispose of
the used oil.
- Always dispose of used engine oil properly .
Do not dump it on garden soil, wooded
areas, into open streams or down sewage
drains.
- Recycle used engine oil by taking it to a used
engine oil collection facility in your area, or
contact a service station .
Cooling system
Coolant
The engine cooling system is filled with a mixture
of purified water and coolant additive at the fac-
tory. This coolant must not be not changed. ..,.

co
co
.... N
" N .... 0 0 <..:l 'SI'
The coolant leve l is monitored through the. in­
dicator light
c::> poge 14. However, we do recom­
mend occasionally check ing the coo lant level
manually.
If you m ust add coolant, use a m ixture o f water
and coolant additive . M ixing the coolant additive
w ith d istilled water is recommended.
Coolant additive
The coolan t addi tive is made of ant i-freez ing and
corrosion protection agents. Only use the fo llow­
i n g coo lant additives . These additives may be
mixed wit h each other .
Coolant additive Specification
Gl3 TL774J
Gl2++ TL 774 G
The amount of coo lant add itive that needs to be
mixed with water depends on the climate where
the veh icle will be ope rated. If the coolant addi­
tive percentage is too low, the cool ant can freeze
and damage the engine.
Coolant Freeze protec-
additive tion
Warm regions min . 40% m
in. -13 ° F
max. 45% (-25 °C)
Cold regions min . 50% max . -40 °F
max . 55% (-40 °C)
(D Note
-
Befo re the start of winter, have your author­
i zed Audi dealer or author ized Audi Se rvice
Facility check if the coolant additive in yo ur
vehicle ma tches the percen tage approp riate
fo r th e climate. This is especially import ant
whe n driving in co lder climates .
-If the approp ria te coolant addi tive is no t
available in an emergency, do no t ad d any
other additive. You co uld damage the en­
gine. If this happens, only use wate r and re­
store the correct mixture ratio with the
spec ified coolant additive as soon as possi­
ble.
- Only refill with new coo lant .
- Radiator sealant must not be mixed with
the coo lant .
Checking and Filling
Adding coolant
Fig. 184 En g in e compa rtment : coo lant expa nsion ta nk
cove r
Observe the safety prec autions c::> A in Working
in the engine comportmen t on page 198.
Checking the engine coolant level
Park the vehicle on a level surface.
.,. Switch t he ignit ion off.
.,. Read the coolant level on the coolant expansion
tank
c::> page 201, fig . 182. The coolant level
must be between the MIN and MAX mark ings
when the engine in cold. When the eng ine is
warm it can be slightly above the MAX marki ng.
Adding coolant
Requirement: there must be a residua l amount of
coolant in the expansion tank
c::> (D .
.,. Let the eng ine cool down .
.,. Place a cloth over the coolant expansion tank
cap and unscrew the cap counterclockw ise
c::> .&_ .
.,. Add coo lant m ixed in the cor rect rat io
c::> page 204 u p to the MAX mark ing.
.,. Ma ke sure that the f luid level remains stab le.
Add mo re coolant if necessary.
.,. Close the cap sec urely.
Coo la nt loss usually i ndicates there is a lea k. Im­
med iate ly drive you r ve hicle to a n author ized
Audi dealer or authorized A udi Se rvice Faci lity
and have the cooling system inspected. If the
cooling system is not leak ing, a loss can come
from the coolant boiling through overheat ing
and being pushed out of the cooling system.
205

Check ing and F illing
"' Clamp the charger terminal clamps to the jump
start pins according to the instruct ions. (pin un ­
der the red cover = "positive", pin with hexago ­
nal head = "negative").
"' Insert the power cable for the charging device
into the socket and switch the device on .
"' At the end of the charging process, switch the
charge r off and pull the power cab le out of the
socket.
"' Remove the c ha rge r termi nal clamps.
"' Close the red cover on the posi tive te rm inal.
"' Close the hood
¢ page 200.
A WARNING
- A highly explosive mixture of gases can form
when charging batter ies. On ly charge the
vehicle battery in well-vent ilated areas.
- A drained battery can freeze at tempera­
tures a round 32 °F (0 °C). A frozen or
thawed veh icle battery must not be charged
and must not be used anymore . The batte ry
hous ing can crac k an d battery acid can leak
o ut if ice fo rms, wh ic h increases the r is k of
an exp losion and ch emical burns. Contact an
authoriz e d Au di dea ler o r aut ho riz e d Aud i
Service Facility for mo re inform ation .
- Do no t conne ct o r dis co nne ct the c hargi ng
cable while charg ing because th is increases
the risk of an exp losion .
(D Tips
-Only ch arge the vehicle battery through the
c on nection s in t he e ng ine comp artmen t.
- Read a ll of the manufacture r's instruc tions
f or the charger befo re charg ing the ve hicle
b attery .
208
Windshield washer
system
Fi g. 187 En gin e compar tm en t: was her flui d rese rvoir cap
.., N
-N ~ a, m
The w indshield washer reservoir O con tains the
cleaning so lution for the windshield and the
headlight washer system *
q page 201, fig. 182.
The reservoir capacity can be found in
¢ page 257.
To reduce the risk of lime scale deposits on the
spray no zzles, use clean water with low amo unts
of calcium. Always add window cleaner to the wa­
ter. When the ou tside temperatures are cold , an
anti -freezing agent shou ld be added to the water
so tha t it does not freeze .
(D Note
-The concentration of ant i-freez ing agent
must be adjusted to the ve hicle operat ing
condi tions i n the respective cl imate . A con­
c entration that is too h igh can lead to vehi­
cl e damage.
- N ever add radia to r anti-free ze or other addi­
t ives to the washer fluid.
- Do not use a glass cleaner t hat contains
pai nt so lvents, because th is could damage
t h e pain t.
Service interval display
The service in terval display detects when your ve­
hicle is due for service.
The serv ice interval d isplay wo rks in two stages:
-Inspection or oil change rem inder: afte r a cer-
tain dis tance drive n, a message appears in the ..,.

co
co
.... N
" N .... 0 0 <..:l ' inst rument cl uste r display eac h time t he ig ni­
t io n is switc hed on or
off . The rema ining dis­
tance or time is displayed br ie fly .
- Inspection or oil change due: if your vehicle
has reac hed an inspection o r oi l change interval
o r both intervals at the same time, the mes­
sage
Inspection due! or Oil change due! or Oil
change and inspection due!
appears briefly af ­
te r swi tching t he igni tion on/off .
Checking service intervals
You can check t he rema ining distance o r time un­
til the ne xt oil change o r next inspection i n the
Ca r menu. To do this, select: t he
IC A RI fu nction
b utton
> (Car) * Systems cont rol b utton > Service
& checks > Service intervals.
Resetting the indicator
Your author ized Audi dealer or author ized A udi
Service Faci lity will reset the service interval dis­
p lay after pe rforming service.
I f yo u h ave cha nged t he oi l you rsel f, you must re­
set t he oil change in terva l.
To reset the indic ator, se le ct : th e
ICAR I fu nct ion
bu tton
> (Car) * Systems con trol button > Service
& checks > Service intervals. Tur n t he control
k nob downward to
Reset oil change interval and
p ress the cont rol knob.
- Only reset the oil ch ange in dicato r if the oil
was c hanged .
- Fo llow in g th e service i nte rv a ls is critical to
mai ntai ning th e service life a nd value o f
you r vehicle, especia lly t he engine. Even i f
t h e m ileage on the vehicle is low, do not ex ­
c e ed th e tim e for the n ext serv ic e .
- Calcu latin g the t ime to the next o il chan ge
i s interrupted w hen the ve hicle battery is
discon nect ed
c:> page 235.
Checking and Filling
209

Wheels
Wheels
Wheels and Ti res
General information
.,. Check your tires regularly for
damage (punctures, cuts, cracks
and bulges). Remove foreign ob ­
jects from the tire tread.
.,. If driving over curbs or similar
obstacles, drive slowly and ap­ proach the curb at an angle.
.,.Have faulty tires or rims re­
placed immediately.
.,.Protect your tires from oil,
grease and fuel.
.,.Mark tires before removing
them so that the same running
direction can be maintained if
they are reinstalled .
.,. Lay tires flat when storing and
store them in a cool, dry location
with as little exposure to light as
possible.
(D N ote
-Please note that summer and
winter tires are designed for
the conditions that are typical in those seasons . Audi recom­
mends using winter tires dur­
ing the winter months . Low
temperatures significantly de­ crease the elasticity of summ­
er tires, which affects traction
2 10
and b raking ability. If summer
tires are used in very cold
temperatures, cracks can form
on the tread bars, resulting in permanent tire damage that
can cause loud driving noise
and unbalanced tires.
-Burnished, polished or chromed rims must not be used in winter driving condi­
tions. The surface of the rims
does not have sufficient corro­
sion protection for this and
could be permanently dam­
aged by road salt or similar
substances.
Tire designations
F ig. 188 Tire des ignat ions on the side-
wall II>