brake AUDI R8 SPYDER 2011 Workshop Manual

.. Install the adapter @as far as it wi ll go on­
to the anti-theft wheel bolt
(D .
.. Push the wheel wrench over the adapter @
as far as it will go .
.. Loosen or t ighten the wheel bolt
c:> page 219.
We recommend a lways keeping the wheel
bolt adapter with you in the vehicle . It should
be stored in the vehicle tool k it.
There is a
co de number for the wheel bolt
l ocking device, stamped on the face of the
adapter . You can use th is number to obtain a
replacement adapter at an authorized Aud i
dealership, if necessa ry .
{!) Tips
Write down the wheel bolt locking dev ice
code number and store it in a safe place ,
away from the vehicle .
Raising the vehicle
Applies to vehicles: with origina l Audi jack
The vehicle must be li~ed with the jack* first
before the wheel can be removed .
•
Fig. 159 Ch ang ing a w hee l: mou nting po int fo r th e
j ack
F ig. 160 Close -up: proper pos it ioning of lift ing jack
What do I d o now ? 217
The descr iption for using the vehicle jack only
applies to the origina l jack * (not a vehicle
component; contact your author ized Audi
dealer if needed) .
.. Engage the
parking brake to prevent your
vehicle from rolling unintentionally .
.. Shift into 1st gear.
.. Find the
lifting po int in the sill on the side
w ith the affected wheel
c:> fig. 159.
.,. Extend the jack under the lifting point on
the doo r sil l unt il its arm is posit ioned d i­
rectly under the lifting point ~,&. .
.. Alig n the ja ck so that its arm@
c::> fig. 160
engages in the designated lifting poin t in
t he door s ill and the movable base ® lies
flat on the ground. The base @ must be
ver­
tical
under the lifting point @.
.. Wind the jack up further until the flat t ire
comes off the ground
c::> ,&. .
The jack must be installed
only at the places
indicated
c:> fig. 159 . There is only one desig­
nated jack mou nting point for each side of the
vehicle
c:> ,& .
An
unstable surface under the jack ca n cause
the vehicle to slip off the jack . Always provide
a f irm base for the jack on the ground . If nec­
essary place a sturdy board or sim ilar support
under the jack . On
hard, slippery surfaces
(such as tiles) use a rubbe r mat or similar to
pr event the jack from slippi ng
c:;, ,& .
A WARNING
-You or your passengers co ul d be inju red
while changing a whee l if you do no t fo l­
low safety precau tions :
- Positioning the jack under the vehicle
at any other place than those indicated
above may damage the vehicle or may
r esult in persona l injur ies.
- A soft or unstable surface under the
jac k may cause the ve hicle to slip off
the jack . A lways prov ide a firm base for
the jack on the ground. If necessa ry,
u se a st urdy boa rd under the jack. .,_

222 What do I do now ?
-Please note that the procedure for con ­
necting a jumper cable as described
above applies spec ifically to the case of
your vehicle be ing jump started. When
you are giving a jump start to another ve­
hicle, do
not connect the negative( -) ca­
ble to the negat ive( -) terminal on the
discharged battery ©-Instead, securely
connect the negative (- ) cable to either a
solid metal component that is firmly
bo lted to the engine b lock or to the en­
gine block itself . If the battery that is be ­
ing charged does not vent to the outside,
escaping battery gas cou ld ign ite and ex­
plode!
Emergency towing
with commercial tow
truck
General hints
Your Audi requires special handling for tow­
ing.
The following information is to be used by
commercia l tow truck operators who know
how to operate their equipment safely.
- Never tow your Audi, towing will cause dam­
age to the engine and transmission .
- Never wrap the safety chains or winch cables
around the brake lines.
- To prevent unnecessary damage, your Audi
must be transported with a car carrier (flat
bed truck).
- To load the vehicle on to the flat bed, use
the towing loop found in the vehicle tools
and attach to the front anchorage
~ page 222.
A WARNING
A vehicle being towed is not safe for pas­
sengers. Never allow anyone to ride in a
vehicle being towed, for any reason.
(D Note
The vehicle has very low ground clearance.
Make sure that no damage is caused to the
-
underside of the vehicle when it is being
loaded onto a f lat bed truck .
Front towing loop
Do not install the front towing loop until it is
needed.
Fig. 164 Right front bumper without grille : Tow ing
loop
fully screwed in
On the right front in the bumper, there is a
threaded hole behind the air intake grill into
which the towing loop is screwed.
"' Remove the towing loop from the vehicle
tool kit~
page 213.
"'Pull the lower part of the grill forwa rd and
out .
"' Screw the towing loop tightly into the
threaded ho le as far as it wi ll go ¢
fig. 164.
When it is no longer needed, unscrew the
towing loop and put it back into the on-board
toolkit. Make sure to have the towing loop stored in the vehicle at all times.
When installing the grill for the air duct, be
sure that the tabs on the grill are first insert­ ed into their guides on the vehicle. Then push
the grill into position.
A WARNING
= If the towing loop is not screwed in as far
as it will go, the thread can pull out when
the veh icle is towed -potential r isk of an
accident.
@ Tips
Check carefully to make sure the hook-up i s secure.

224 Fuses and bulbs
Fuse panel@
Consumer
Automatically dimming in-
side mirror, ga rage door
8 opener (Homel ink), washer
pump relay, power outlets
relay
10
~ button
11 Pressure sensor, climate
controls
12 Airbag
Fuse panel @
No . II Consumer
1 Radiator fan (1)
2 Radia tor fan (2)
3 Exterior lighting
4 Exterior lighting
6 Blower regulator
Fuse panel @
No . II Consumer
1 Rear view camera
2
Tire pressure monitoring
system
4
Cell phone package, te le-
phone antenna amplifier
5 Instrument cluster
6 Networking gateway
7 Steering column lever
8
Diagnostic interface, brake
pedal switch, selector lever
9 Rain/light sensor
10 Light switch
11 Special functions control
module
15 Sound amplifier
Radio
Fuse panel E
No. Consumer
3 Auxiliary water pump
5 Supply terminal 15, starter
Amps
10
10 5
5
II Amps
40 40
40
40
40
II Amps
5
10
7.5 5
5
5
10 5
5
5
30
20
Amps
10
30
Fuse panel @
No. Consumer
6 Pump for brake booster
7 Horn
8 Wiper motor
9 Wiper motor
10 Headlight washer system
12 Power outlets and cigarette
lighter
Fuse panel
®
No. !!Consumer
1
2
4
6
7
8
~~·
E lectronic Stabilization Pro­
gram
Electronic Stabilization Pro­
gram
Rear window defogger
Power locking system
Interior lights, washer noz­
zles
Anti-theft alarm sys tem
Climate controls
Heated seats
Lumbar support
11 Control module for doors
12 Control module for doors
Bulbs
Note
Amps
15
20
30
30
30
20
ll Amps ,
10
25
30
20
20
5
10
25 10
30 10
Your vehicle is equipped with maintenance­
free headlights and rear lights. However, if a
bulb has to be changed, please consult your
authorized Aud i dealer or other qualified
workshop .

230 Index
A
A/C operation ................. .... .. 75
ABS
refer to Anti-Lock Brake System . .. .. . 150
A cces sories . . . . . . . . . . . . . . . . . . . . . . . . 211
Active rollover protection system . .. ... 107
Retracting rollover protection ... .. ... 107
Adding
Eng ine coolant ... ..... ... .. .. .. .. .
183
Eng ine oil .. .. . ... ... .. .. .. .. .. .. . 180
Addit ional accessories .. .... .... .. .. . 211
Additives .................. ... .... . 180
Adjustable steering column ...... .. .... 77
Adju sting front sea ts ....... .. .. .. .. . .
66
Advanced Airbag System
Children ... ............... .. .... .
139
Compon ents ................ ..... . 124
Front ai rbags . . . . . . . . . . . . . . . . . . . . . 122
How the component s work togethe r .. 125
Mon ito ring . .... .. ... .. .. .. .. .. .. . 128
Weight-sen sing mat .. .... .. .. .. .. . 139
Airbag system . . . . . . . . . . . . . . . . . 117, 136
Car e ... .. .. ................ ..... . 130
Child restraints .. .. ... ...... .. .. .. .
140
Components (fron t air bags) .. .. .... . 124
Danger of fitting a child safety seat on
the front passenger seat . . . . . . . . . . . .
119
Disposal ............. ........ .... 130
Front airbags ... .. ... .... .. .. .. .. . 121
H ow do the front airbags work? . .... . 126
How many airbags does my vehicle
have? .................... .. .... .
124
Important safety instructions on the
knee airbag system ....... .. .. .. .. .
134
Important things to know . . . . . . . . . . . 117
Indica tor ligh t .... .... ..... .. .. .. . 128
Knee airbags ... ... .... ..... .. .. .. . 132
Monitoring ................. ... ... 128
PASSENGER AIR BAG OFF light . . . . . . . 128
Service .. ...... .. ... .... .. .. .. .. . 130
Side airbags ..... .. .. .... .. .. .. .. . 135
Warning/indicator light ..... ... .... .. 17
When must the system be inspected? . 128
Air cond itioning
A/C operation . .... .... ..... .. .. .. .. 75
A ir distribution .... ....... .. .. .. .. ..
74
Air recirculation mode ......... .... .. 75 Automatic mode
.............. .... . 75
Controls . . . . . . . . . . . . . . . . . . . . . . . . . .
72
Defrost ..... .. .. .. .............. .. 75
E conomi cal use .. ....... ..... ..... .
76
Fan .. .... .. .. .. ...... ... .... .... . 74
Rear window defogger . . . . . . . . . . . . . . . 76
Switching on and off .... ......... .. . 74
Temperature ... ............ ........ 73
Air d istribution . . . . . . . . . . . . . . . . . . . . . . 7 4
Air recirculation mode Air condit ioning . ................. .. 75
All-wheel drive .. ............ .......
155
Winter tires . .. .. ... .. ..... ... .... 203
Anti-free ze
refer to Engine cool ant system ... .. .. 181
Anti-Lock Brake System .......... .... 150
Warning/indicator light ............ .. 18
Anti-Slip Regulation System .. .... .... 150
Anti- theft alarm system ... .... ... .... . 43
Anti-theft whee l bolts .............. . 216
Ashtray ........... .... ........... .. 69
ASR
refer to An ti-Slip Regulation System .. 150
Asterisk .... .. .. .. .. ................ . 6
Audi magnetic ride ................. ..
82
Description . . . . . . . . . . . . . . . . . . . . . . . . 82
Wa rning/ind icator light ... .. .. .. .. .. . 15
Aud i Servi ce Repa ir Manuals and Li te ra-
ture ........ ... .. .. ... ....... .... .
209
Automated manua l transmission
ref er to R tronic . ................. .. 85
Automat ic be lt retractor ...... .. ... .. 112
Autom atic car w ash
refer to Washing ........... ....... 16 1
Automatic headlight ................. 55
Automat ic headl ight control ...... .. .. .
62
Automatic headlight s
Defective . . . . . . . . . . . . . . . . . . . . . . . . . 3 5
Auto Safety Hotline ............. ....
105
Average fuel mileage . . . . . . . . . . . . . . . . . 23
Aver age speed . .. .. .. ..... .. .. .. .... . 23
B
Battery ..... ..... .. ............... 184
Cha rging .. .. .. .. ...... .. .. ... .... 186
Checking . . . . . . . . . . . . . . . . . . . . . . . . . 184

Disconnecting ........... .. .. .. ... 184
Low ..... .. .. .. ........... .. .. ... 155
replac ing ... ............. .. .. .. .. . 187
State of charge . . . . . . . . . . . . . . . . . . . . 155
Vehicles not driven for long periods .. . 184
W inter operation . . . . . . . . . . . . . 184, 185
Working on the battery .... .. .. .. .. . 185
Battery voltage . . . . . . . . . . . . . . . . . . . . . . 34
B efore driving . . . . . . . . . . . . . . . . . . . . . . . 99
Blended gasoline . . . . . . . . . . . . . . . . . . . 170
Booster seats ............. .. .. .. ... 145
Brake system
Brake fluid . ............. .. .. .. .. . 184
Brake light defective ........ .. .. .. .. 35
Brake power assist unit ............. 153
Brakes ..... .. ............. .. .. ... 153
Ceramic brakes . . . . . . . . . . . . . . . . . . . . 153
Malfunction .. ........... .. .. .. .... 32
Warning/indicator light .... .. .. .. .. .. 17
Worn brake pads ........... .. .. .. .. 33
Break-in period ............ .. .. .. ... 158
Bulbs ...... ... ................ .... 224
C
California Proposit ion 65 Warning ..... 176
Battery specific . . . . . . . . . . . . . . . . . . . 186
Capac it ies ... .. ........... .. .. .... . 228
Carbon-fiber parts Ext erio r .. .. ............. .... .. .. . 164
I n terior .... .. ........... .. .. .. ... 166
Car care . .. .. ... .. .. ...... .. .. .. .. . 16 1
Cargo area
refer to Luggage compartment . . . . . . . 104
Car key . ... .. .. ... .......... .. .. .... 37
Catalytic converter ............ .... .. 158
Certification ... ........... .. .. .. ... 212
Changing a flat tire ........... .. .. .. . 216
Chass is
refer to Audi magnetic ride .... .... ... 82
Checking Eng ine coolant level ....... .. .. .. .. . 182
Tire pressure ............. .... .. .. . 195
Index 231
Child rest raints
Danger of using child restraints in the
fro nt seat . . . . . . . . . . . . . . . . . . . . . . . . 119
Where can I get additional informat ion
about child restraints and the ir use? .. 149
Child safety ... .. .... . ............ .. 138
Convertible locking retractor . . . . . . . . . 146
Important sa fety instructions for using
ch ild safety seats ..... ......... .. .. 141
Important t hings to know when driving
with ch ildren .. .. .. ..... .......... 138
Child safety seats . . . . . . . . . . . . . . . . . . . 143
Booster seats . . . . . . . . . . . . . . . . . . . . . 145
Convertib le child seats ......... .. .. 144
Co nvertib le locking retractor ..... .. .. 146
How do I properly install a child safety
sea t in my veh icle? .. ... ....... .... . 141
Infant seats . . . . . . . . . . . . . . . . . . . . . . 143
Installing . . . . . . . . . . . . . . . . . . . . . . . . 146
Safety instructions .... ......... .... 141
Cigarette lighter ... .... ... .... .... .. . 69
Cleaning Alcantara (synthetic suede) .......... 168
Engine compartment ............... 169
Exhaust tail pipes .................. 16S
Fabr ics and fabric coverings ..... .. .. 166
Leat her ...... ... .. ............... 167
Radio and navigation display ........ . 165
Safety belts ... .. ................. 168
Cleaning and protection .............. 161
Cleaning the navigation display ........ 165
Cleaning the radio display . .......... . 165
Climate controls ... .. .. ......... .. .. . 72
D ust filter . . . . . . . . . . . . . . . . . . . . . . . . . 72
Heating ... .. .. .. .. ............... . 72
Pollen filter ... .. .. . .. .. ...... .. .. . 72
Ventilation . . . . . . . . . . . . . . . . . . . . . . . . 72
Clock ............ .. .. ... ........ .. . 11
Closing Eng ine compartment lid ........ .. .. 176
Clutch overheat ing .. ...... ........... 36
Cold tire inflation pressure .......... .. 193
coming home . . . . . . . . . . . . . . . . . . . . . . . 55
Compass mirror . . . . . . . . . . . . . . . . . . . . . 64
Compliance ... .... .. . .. .......... .. 212
Consumer Information . . . . . . . . . . 105, 209
Contacting NHTSA ..... ............. 105
•
•

Resuming timing ...... ... .. .. .. .. .. 28
Selecting . . . . . . . . . . . . . . . . . . . . . . . . . 26
Start ing tim ing ....... ... .. .. .. .. .. 26
Sw itching to the trip computer .. .. .. .. 27
L aunch Contro l Program
M anual transmission ... ... .. .. .. .. .. 84
R tronic .... .. .... .... ... .. .. .. .... 87
L eather . .. .. .... ............. .. .. . 166
C lean ing
leaving home ............. .... .. ... .
Lifting jack . ... ... ..... ... .. .. .. .. .
Light 167
55
2 17
com ing/leavi ng home ............... 55
E xterior l igh ting . . . . . . . . . . . . . . . . . . . . 55
Light/ra in sensor
Automatic headlight cont ro l .. .. .. .. .. 62
D efective ..................... .... 35
Light sensor package . . . . . . . . . . . . . . . . 55
W iper and washer sy stem ( intermittent
wiping) . ... .... ...... ... .. .. .. .. .. 59
Lights Instrument panel illum ination ........ 56
sw itch ing on and off ................ 55
Light sen sor
Defective .. ..... ....... .... ... .... 35
Light sensor package . . . . . . . . . . . . . . . . . 55
L oading the luggage compartment .. .. . 104
Locking ... .. ................. .. .... 40
Power locking system . . . . . . . . . . . . . . . 40
L uggage compartment ... ... .. .. .. .. .. 59
Emergency exit ... ..... ... .. .. .. ... 213
light .... .. .. .. ........... .. .. .... 59
Loading .. .. ............. .... .. .. . 104
M
Maintenance .... .. ..... ... .. .. .. ... 209
M alf unct ion Indicato r Lamp (MIL) .. .. .. 22
Manual transmission
Launch Cont ro l Program . . . . . . . . . . . . . 84
Menu button . . . . . . . . . . . . . . . . . . . . . . . . 25
M enu d isplay . . . . . . . . . . . . . . . . . . . . . . . . 24
M irror
Vanity mirror . . . . . . . . . . . . . . . . . . . . . . 59
M ir rors
Activating the digital compass . ... .. .. 64
Automatically dimming inside mirror . .. 62
Inde x 235
Automat ic dimming for the ou ts ide mir -
ro rs . ... .. .. .. .... .. .. ...... ... .. . 64
Outs ide mirro rs . . . . . . . . . . . . . . . . . . . . 63
Moni to ring the Advanced Airbag System 128
N
Natura l leather .. .. .. ............... 166
New tires and wheels
N HT SA 199
C ontacting . ... .... . ... ...... ... .. lOS
No reverse gear .. ... ........... ...... 35
Number of seats . .. ................. 109
0
Octane rating
170
Odometer
..... ... .. ................ 12
Oil
refer to Engine oil ............. .... 178
On-Boa rd Di agnost ic System (0 80)
Data Link Connector (D LC) .... ... .. .. . 21
Malfunction Ind icator Lamp (MIL) . ... . 22
Open door or fron t lid wa rning ......... 20
Optional equipment Marked w ith an asterisk . . . . . . . . . . . . . . . 6
Outside mirro rs . ... ... .. .. ..... ... .. . 63
Ou tside temperature disp lay . . . . . . . . . . . 20
Owner's manual How the Owne r's Manual is organ ized ... 6
p
Pa int
Touc h-up .. .. .. .. .. ............... 164
Paint No.
Pa rking 226
o n a decline . . . . . . . . . . . . . . . . . . . . . . . 80
o n an incline . .. .. .................. 80
R tronic ... .. .. .. .. .. ........... .. . 86
Parking brake ....................... 79
Warning .. .. .. .. .. . .. .... ......... 32
Parking system advanced .............. 89
Adjusting the display ........... .. .. . 93
Adjusting the war ning tones ... ....... 93
Paralle l Parking . . . . . . . . . . . . . . . . . . . . 92
Reve rse parking ... ........... ...... 92
Safety p recautions .... ............. . 89
•
•

238 Index
Tire pressure monitoring system ...... . 206
Loss of air pressure . . . . . . . . . . . . . . . . . 34
Malfunctions . . . . . . . . . . . . . . . . . . . . . . 34
Sensors .. ............... .. .. .... . 201
Tires and wheels ......... .... .... . 201
Valves ... .. ................ ... ... 201
Warning/ indicator light .... .. .. .. .. . . 15
Tire repair kit .............. ... .... . 213
T ires .. .. ...... ........... .. .. .... . 189
Pressure ... ............. .... .. .. . 206
Replacing . . . . . . . . . . . . . . . . . . . 199, 201
Service life ............... ... .... . 198
Speed rating letter code ........... . 200
Tire manufacturing date ... .. .. .. .. . 200
Tire pressure monitoring system ..... 206
Tire specifications ......... ... .. .. . 200
Tread depth .. .. ...... .... ... .. .. . 198
Uniform tire quality grading .. .. .. ... 203
W inter t ires ............. .. .. .. .. . 203
Tires/Wheels Low aspect ratio t ires .... .. .. .. .... . 205
Tires and vehicle load limits ... ..... .. . 196
Tires and wheels Check ing tire pressure ......... .. ... 195
Cold t ire inflation pressure . .. .. .. .. . 193
Dimensions ............... ... .... . 199
General notes .............. .. .... . 189
Glossary of tire and loading termino lo-
gy .. .. .. ................. .. .... . 190
New tires and wheels ...... .. .. .... . 199
Replacing ............... ........ . 200
Snow chains .............. ... .. ... 204
T ire pressure monitor ing system .. .. . 201
Tires and vehicle load limits .. .. .. .. . 196
Wheel bolts ............. .... .... . 205
W inter t ires .. ........... .. .. .. .. . 203
Tire service life ................ .. .. . 198
Tool kit ..... ................ ..... . 213
Touch-up paint ............ .. .. .. .. . 164
Towing Tow truck procedures ...... .. .. .. .. . 222
T . l owing oop ................. .. .... .
222
Transport Canada ... ..... .. .. .. .. .. . 106
Tread Wear Indicator (TWI) .. .. .. .. .. .
198
Trip computer . . . . . . . . . . . . . . . . . . . . . . . 22
Trip odometer .............. ... .. ... . 12
Turn signals . ................. ..... .. 58 Turn
Signals
Warning/indicator lights ............. 16
u
Unfastening safety belts
Unidirectional tires ........ ...... .. . .
Uniform tire quality grading ....... .. . 114
189
203
Universal Radio-Frequency Remote Control
(HomeLink®) .... .. ............. .... . 95
Unlocking .. ... ... .. .............. .. 40
Power locking system ........... ... . 40
V
Vanity mirror . . . . . . . . . . . . . . . . . . . . . . . . 59
Vehicle-care products ................ 161
Vehicle electrical system . . . . . . . . . . . . . . 17
Vehicle Identification Number (VIN) .. .. 226
Vehicle jack . ...... ............. .... 217
Vehicle literature .. ................ ...
5
Vehicle tool kit .... ................ . 213
Ventilation . . . . . . . . . . . . . . . . . . . . . . . . . 72
Voltmeter display . . . . . . . . . . . . . . . . . . . . 13
w
Warning/indicator lights ......... .... . 10
Airbag system . . . . . . . . . . . . . . . . . . . . . 17
Anti-Lock Brake System . . . . . . . . . . . . . . 18
Audi magnetic ride .............. ... . 15
Brake system . . . . . . . . . . . . . . . . . . . . . . 17
Cruise control . . . . . . . . . . . . . . . . . . . . . . 17
Electronic differential lock (ED L) .. .. .. . 18
Electronic power control (EPC) . . . . . . . . 15
Electronic stabilization program (ESP) .. 16
Generator . . . . . . . . . . . . . . . . . . . . . . . . . 17
High beam . ..... ................ .. 16
Rear spoi ler ..... ............. ..... 16
Safety belts . . . . . . . . . . . . . . . . . . . . . . . 17
Tire pressure monitoring system . .. .. . lS
Turn signals . .. .. ..... ......... ... . 16
Warning lights . . . . . . . . . . . . . . . . . . . . . . 14
Red symbols in the center display . .... . 30
Yellow symbols in the center display .. . 30
Warranty coverages ................ . 209
Washing ...... ... ................ . 161
Folding top cleaning ... .. .. .. .. .. .. 163