air filter BMW 3 SERIES 2004 E46 Service and warranty information

63 Con-
Series vertible
Change oil and oil filter while engine is at normal operating temperature.  
We recommend BMW 5W-30 High Performance Synthetic Oil,
p/n 07 51 0 017 866.
Check transmission for leaks.  
Check rear axle for leaks.  
Half-shafts: Check for leaks at flexible boots.  
Visually check fuel tank, lines and connections for leaks.  
Check condition, position, and mounting of exhaust system.  
Examine for leaks.
Check power steering system for leaks. Check power steering fluid level;  
add fluid if necessary.
Check steering for absence of play, condition of suspension track rods,  
front axle joints, steering linkage and joint disc.
Check overall thickness of front and rear disc brake pads using special tool.  
If replacement is necessary: Examine brake disc surfaces. Clean brake pad
contact points in calipers. Grease wheel centering hubs. Check thickness
of parking brake linings only when replacing rear brake pads.
Check brake system connections and lines for leaks, damage  
and incorrect positioning.
Check parking brake actuation. Adjust if necessary.  
Check all tire pressures (including spare). Correct if necessary.  
Check condition of tires (outer surface [left/right]), tread wear and pattern;
in case of uneven tread wear, readjust wheel alignment if requested
(invoice separately).
Inspect entire body according to terms of rust performation limited warranty.  
(Must be performed at least every two years).
Engine Compartment
Read out diagnostic system.  
Check engine cooling system/heater hose connections for leaks.  
Check coolant level and antifreeze protection level. Add coolant if required.
Check windshield washer fluid level and antifreeze protection.  
Fill up and/or correct if required.
Check air conditioner for operation.  
Replace microfilter. (Note: reduce replacement interval in dusty  
operating conditions.)
Reset service interval indicator.
Inspection I
Only those items of inspection work which apply to your vehicle will be performed. This list is
subject to amendment.
Undercarriage

The maintenance schedule as shown
is required for the proper functioning
of the emission control systems for
optimum vehicle performance and fuel
economy.
Abbreviations:
I - Inspect
R - Replace part(s) and/or fluid listed
Basic Engine
Engine oil....................................................
Engine oil filter..........................................
Fuel System
Air filter.......................................................
Ignition System
Spark plugs...............................................
Emission Control Components
Oxygen sensor..........................................
Emission Control Maintenance Schedule 3 Series
Oxygen Sensor Service: The oxygen sensor deteriorates strictly on a mileage basis and must
therefore be replaced to maximize vehicle fuel economy and minimize exhaust pollution.
The mileage interval varies according to individual driving conditions and is determined by the
service interval indicator.
13
Oil Service
Inspection I
Oil Service
Inspection II
RRR R
RRR R
R
Replace at intervals of
100,000 miles
Replace at intervals of
120,000 miles3 Series

27
Warrantor
BMW NA warrants 2004 U.S. specification
vehicles distributed by BMW NA or sold through
the BMW NA European Delivery Program
against defects in materials or workmanship to
the first retail purchaser, and each subsequent
purchaser.
Warranty Period
The warranty period is 48 months or 50,000
miles, whichever occurs first.
Warranty Begins
This warranty begins on the date of first
retail sale, or the date the vehicle is first
placed in service as a demonstrator or
company vehicle, whichever is earlier.
Warranty Coverage
To obtain service under this warranty, the
vehicle must be brought, upon discovery of a
defect in material or workmanship, to the
workshop of any authorized BMW center,
during normal business hours. The BMW
center will, without charge for parts or labor,
either repair or replace the defective part(s)
using new or authorized remanufactured parts.
The decision to repair or replace said part(s) is
solely the prerogative of BMW NA. Parts for
which replacements are made become the
property of BMW NA.
In all cases, a reasonable time must be
allowed for warranty repairs to be completed
after the vehicle is received by the BMW
center.
Safety Belt Warranty - Kansas
Safety belts are covered under the BMW New
Vehicle Limited Warranty for defects in material
or workmanship for a period of 10 years,unlimited mileage from the date of purchase. In
order to be eligible for this coverage, the vehicle
must be a new car retailed in the State of
Kansas and the repair performed by an
authorized BMW center in Kansas.
Towing/Other Owner Benefits
A 24-hour Roadside Assistance Program is
available to every BMW owner during the new
vehicle warranty period.
Roadside assistance and other owner benefits
are available by calling:
1-800-332-4269
For additional details on towing and other
owner benefits please refer to the BMW
Roadside Assistance section of this Statement
(page 23).
Other Items
Wheel alignment, balancing and wiper blade
inserts are covered up to 2,000 miles.
Items which are subject to wear and tear or
deterioration due to driving habits or condi-
tions, such as brake pads/linings, brake discs,
clutch disc, pressure plate, filters, upholstery,
trim and chrome items, paint finish, drive belts,
glass, and similar items, are specifically
limited to defects in material or workmanship.
This warranty does not apply to the
following:
Damage which results from negligence,
improper operation of the vehicle, improper
repair, lack of or improper maintenance,
environmental influences, flood, accident or
fire damage, road salt corrosion, or use of
improper or contaminated fuel.
Maintenance services and parts when
replaced during maintenance such as spark
plugs, lubricants, fluids, engine tuneup parts,
replacement of filters, coolant, and refrigerant.
Failure to maintain the vehicle properly in
accordance with the instructions in the
Owner’s Manual or the Service section of this
Statement, that results in the failure of any
part of the vehicle.
New Vehicle Limited Warranty -
2004 Models
(Valid only in the U.S.A. and
Puerto Rico)

31 parts are warranted by their manufacturer to
be equivalent to genuine BMW parts in
performance and durability. BMW NA
assumes no liability under this warranty with
respect to parts other than genuine BMW
parts.
However, the use of non-BMW replacement
parts or non-EPA certified parts does not
invalidate the warranty on other components,
unless non-BMW par ts or non-EPA certified
parts cause damage to warranted parts.
What is not covered
This warranty does not cover malfunctions
caused by any of the following: accident, flood,
misuse, improper adjustment, modification,
alteration, tampering, disconnection, improper
or inadequate maintenance, use of leaded fuel
or fuels containing more than 10% ethanol, or
other oxygenates with more than 2.8% oxygen
by weight (i.e., more than 15% MTBE or more
than 3% methanol plus an equivalent amount
of co-solvent).
The replacement of maintenance parts, such
as spark plugs, filters and similar items used in
required maintenance services, the repair or
replacement of maintenance parts beyond the
first required inspection/maintenance, or if the
part has been replaced earlier for reasons
other than it being defective.
The car or any part of the car unless a failure
causes the car to fail to conform to applicable
emission regulations.
Any car on which the odometer has been
replaced or altered and the true mileage
cannot be determined.
The car, if the vehicle identification number is
altered or cannot be read, or if the car has
been declared a total loss or sold for salvage
purposes.
General
These warranties give you specific legal rights,
and you may also have other rights which vary
from state to state.THE DURATION OF ANY IMPLIED WARRAN-
TIES, INCLUDING THE IMPLIED WARRANTY
OF MERCHANTABILITY, IS LIMITED TO THE
DURATION OF THE EXPRESS WARRANTIES
HEREIN.
BMW NA HEREBY EXCLUDES INCIDENTAL
AND CONSEQUENTIAL DAMAGES, INCLUD-
ING LOSS OF TIME, INCONVENIENCE, OR
LOSS OF USE OF THE VEHICLE, FOR ANY
BREACH OF ANY EXPRESS OR IMPLIED
WARRANTY, INCLUDING THE IMPLIED
WARRANTY OF MERCHANTABILITY,
APPLICABLE TO THIS PRODUCT.
Some states do not allow limitations on how
long an implied warranty lasts, or the exclu-
sion or limitation of incidental or consequential
damages, so the above limitations and
exclusions may not apply to you. Additionally,
if you are a California, Maine, Massachusetts
or Vermont resident and your vehicle is
registered in that state, your vehicle is eligible
for California Emissions Warranty coverage.
These federal warranty provisions also apply
to all vehicles sold in all U.S. states and
territories regardless of whether a state has
enacted state warranty provisions that differ
from the federal provisions.

36 specification BMW vehicles sold, leased, and/
or registered in California, Maine,
Massachusetts or Vermont.
It is strongly recommended that any replace-
ment parts used for maintenance, repair or
replacement of emission control systems be
genuine BMW Service Parts or BMW
Authorized Remanufactured Parts. Without
invalidating this warranty, the owner may
elect to have maintenance, repair or
replacement of the emission control systems
performed by any automotive repair estab-
lishment, or elect to use parts other than
BMW Authorized Remanufactured or
genuine BMW Service Parts. However, the
cost of such service or parts will not be
covered under this warranty, except in
emergency situations. In an emergency
situation, where an authorized BMW center
is not reasonably available or a warranty
replacement part is not available within 30
days, repairs may be performed at any
available service establishment or by any
individual using any replacement part.
A repair not completed within 30 days
constitutes an emergency. BMW NA will
reimburse the owner for such emergency
repairs (including labor, par ts and diagnosis
not to exceed BMW suggested retail price for
all warranted parts replaced and labor
charges based on the manufacturer’s recom-
mended time allowance for the warranty repair
and the geographically appropriate hourly
labor rate) that are covered under this
warranty. Replaced parts and paid invoices
must be presented to a BMW center as a
condition of reimbursement for emergency
repairs not performed by a BMW center.
The use of replacement parts, which are not of
equivalent quality, may impair the effective-
ness of emission control systems. If other than
genuine BMW Service Parts or Authorized
Remanu-factured Parts are used for mainte-
nance, repair or replacement of components
affecting emission control, the owner should
obtain assurances that such parts are war-
ranted by their manufacturer to be equivalent
to genuine BMW parts in performance and
durability. BMW NA assumes no liability underthis warranty with respect to parts other than
genuine BMW parts.
However, the use of non-BMW replacement
parts does not invalidate the warranty on other
components, unless non-BMW parts cause
damage to warranted parts.
What is not covered
This warranty does not cover malfunctions
caused by any of the following: accident, flood,
misuse, modification, alteration, tampering,
disconnection, improper or inadequate
maintenance, except if performed by an
authorized BMW center doing warranty repair
work, use of leaded fuel or fuel other than as
specified in the Owner’s Manual.
The replacement of maintenance parts, such
as spark plugs, filters and similar items used in
required maintenance services or the repair or
replacement of maintenance parts beyond the
first replacement interval.
Any car on which the odometer has been
replaced or altered and the true mileage
cannot be determined.
The car, if the vehicle identification number is
altered or cannot be determined, or if the car
has been declared a total loss or sold for
salvage purposes.
General
The warranty gives you specific legal rights,
and you may also have other rights which vary
from state to state.
THE DURATION OF ANY IMPLIED WARRAN-
TIES, INCLUDING THE IMPLIED WARRANTY
OF MERCHANTABILITY, IS LIMITED TO THE
DURATION OF THE EXPRESS WARRANTIES
HEREIN. BMW OF NORTH AMERICA HERE-
BY EXCLUDES INCIDENTAL AND CONSE-
QUENTIAL DAMAGES, INCLUDING LOSS OF
TIME, INCONVENIENCE, OR LOSS OF USE
OF THE VEHICLE, FOR ANY BREACH OF ANY
EXPRESS OR IMPLIED WARRANTY, INCLUD-
ING THE IMPLIED WARRANTY OF MER-
CHANTABILITY, APPLICABLE TO THIS
PRODUCT.