service indicator BMW 3 SERIES 2007 E90 Service and warranty information

Exclusions from coverage
– Items reimbursable under your New Vehicle
Limited Warranty.
– Gasoline.
– Windshield washer additive (except when in
conjunction with scheduled maintenance).
– Tires, wheel alignment, tire balance and
rotation.
– Wear and tear of soft trim items, such as: seats,
carpets, moldings, headliner, door panels and
all chrome trim.
– Damage detected when performing the rust
perforation inspection.
– Damage which results from negligence,
improper operation of the vehicle, wear and tear
or deterioration due to driving habits or condi-
tions, improper repair, environmental influ-
ences, flood, accident or fire damage, road salt
corrosion, alteration, installation of non-BMW
accessories, or use of improper, poor quality or
contaminated fuel.
– Altered or unreadable Vehicle Identification
Number (VIN) or odometer irregularities or vehi-
cles where the true mileage cannot be
determined.
– Maintenance or repair after the vehicle is
deemed a total loss.
– Maintenance or repairs performed by other
than an Authorized BMW center within the
United States or Puerto Rico.
– Vehicles used in competitive events.
– Oil changes performed outside the recom-
mended maintenance intervals as indicated by
the Service Interval Display.
Maintenance Upgrade Option
Please contact your authorized BMW center for
information and availability on the optional Main-
tenance Program Upgrade for coverage up to 6
years and 100,000 miles.
Maintenance Program
The BMW Maintenance Program has been
devised with the following objectives: to maxi-
mize vehicle safety, reliability, and resale value byminimizing breakdowns resulting from wear, and
minimizing cost and inconvenience by comput-
ing maintenance intervals based upon the spe-
cific manner in which each individual vehicle is
driven.
Maintenance intervals on motor vehicles have
conventionally been specified based upon accu-
mulated mileage. However, driving conditions
have a major influence on routine maintenance
requirements; distance traveled is only one of the
significant factors. A vehicle driven for 50,000
miles of short trips in the city with numerous cold
starts, prolonged periods of idling, stop-and-go
driving, and high engine speeds during accelera-
tion requires more frequent maintenance inter-
vals than a vehicle driven for 50,000 miles for
long distances at low engine speeds primarily at
operating temperature.
The advanced technologies at BMW have led to
the development of the unique BMW Condition
Based Service (CBS) system which computes
the actual optimum maintenance requirements
based not only upon the accumulated mileage,
but taking into account important factors such as
high or low engine speeds, short or long trip driv-
ing, and condition of the engine oil and brake
pads.
The BMW Maintenance Program
Condition Based Service (CBS)
CBS is a further development of the Service
Interval Indicator System. Sensors and sophisti-
cated algorithms take even more detailed
account of the various conditions of vehicle use.
The remaining times for selected maintenance
tasks as well as any legally prescribed dates are
displayed to you individually:
Engine oil
2

Brakes - front and rear separately
Microfilter
Brake fluid
Spark plugs
Vehicle check
Required State Inspection(s)
CBS thus determines the current and future
maintenance requirements. This data can also be
read from the vehicle key by your BMW Service
Advisor and used to propose the optimum scope
of maintenance.
Have maintenance and repair work performed by
your BMW center. Make sure that the mainte-
nance work is stamped in this Service and War-
ranty Information Statement. These entries are
the evidence of regular maintenance of your vehi-
cle and a requirement for warranty claims.
Disconnecting the battery during periods
of long-term storage will interrupt the
calculation of time-based services. Have all items
requiring time-based maintenance, such as
brake fluid and possibly also the engine oil and
microfilter, brought up to date by your BMW cen-
ter. Also see the section on battery care on page
15 of this statement.
Service Interval Display
Info Display screen contents
The distance remaining until your next service
briefly appears when you switch on the ignition.
The Info Display immediately switches to
its compute mode when you press one of
the two buttons in the turn signal indicator
lever.
Control Display screen contents
The current Status of Service items determined
by the CBS are shown in the Control Display.
You can view additional information on service
and maintenance procedures by selecting the
OB data menu.
1.Select and confirm
2. Select “Service” and confirm your entry
3. The display shows a list of selected service
and maintenance procedures, as well as any
required state inspections.
Red Sectors
The service deadline has already passed.
Yellow Sectors
The deadline for service or a state inspection is
approaching. Please contact your BMW center
for an appointment.
3

Green lamps
No service is currently required.
You can request more detailed information on
every entry.
Turn the controller to scroll through the list, then
confirm the selected entry.
Confirm to exit the list.
The vehicles current service status is automati-
cally saved in the vehicles ignition key. The Ser-
vice Advisor at your BMW center has a device
called a key reader. When your Service Advisor
inserts your key into the key reader, all pertinent
vehicle and servicing data will be available, and a
customized maintenance checklist is printed out
based on the specific operations called for by the
Condition Based Service.
The performance of certain subsequent mainte-
nance elements, as required by the BMW New
Vehicle Limited Warranty, will be specified at
intervals computed by the BMW Service Interval
Indicator as follows:
– Oil Service: Engine oil should be changed with
the engine at operating temperature.Note:
Change oil at least once a year.
All 2007 model year 3 Series vehicles are facto-
ry-filled with BMW High Performance Synthetic
oils. At the time of the printing of this booklet, the
following oils are strongly recommended and
approved by BMW:
•BMW High Performance 5W-30 Synthetic Oil
(BMW part number 07 51 0 017 866)
•Mobil 1 0W-40
BMW is evaluating various synthetic oils for
inclusion in our list of recommended engine oils.
For the most current list of synthetic oils, please
contact your BMW center, or call BMW of NorthAmerica, LLC. at 1 800 831-1117. You can also
obtain this information from our website,
www.bmwusa.com/.
BMW recommends that you check your engine
oil level whenever you add fuel to your vehicle. If
you need to add oil between oil changes and are
unable to obtain BMW High Performance Syn-
thetic Oil, Mobil 1 or another special oil on the
list, use a synthetic oil with an API rating of SH or
higher.
The following maintenance elements must be
performed at the mileage/time stated (time inter-
vals begin from the vehicles production date):
– Brake Fluid Service: Change brake fluid every
two years, or when specified by CBS.
– Oxygen Sensor Service: The oxygen sensor
deteriorates strictly on a mileage basis and
must therefore be replaced every 120,000
miles to maximize vehicle fuel economy and
minimize exhaust pollution. For the 328i
SULEV (PZEV) models, the oxygen sensor
must be replaced every 150,000 miles. The
replacement of the oxygen sensor is required
under the terms of the applicable BMW emis-
sion system warranties.
– Spark Plug Service:
328i — Replace at 100,000 miles, or when
specified by CBS.
335i — Replace at 45,000 miles, or when spec-
ified by CBS.
– The engine coolant has a lifetime rating and
does not need to be changed.
For your convenience, you may also wish to have
your BMW center perform any necessary opera-
tions to fulfill any state inspection requirements
in your area concurrent with the maintenance
elements specified above during other repairs.
Make sure that confirmation of maintenance
work is always entered in this Service and War-
ranty Information Booklet. You may need this for
any warranty claims that become necessary, and
later on as evidence that your car has been given
the correct and regular maintenance that justifies
its resale or trade-in value.
BMW has applied the most modern technologi-
cal advances not only to the design and produc-
tion of your vehicle, but also to computing of the
4

optimum maintenance interval for your type of
operations and driving style. Your BMW center
has made a substantial investment in unique
BMW special service tools to enable his BMW
factory trained service technicians to perform
quality repairs on your BMW in minimal time.
Your service technician looks forward to serving
your every service need and to help maximize
your satisfaction with your BMW, its longevity,
and resale value.
Quality Certification I
For a detailed list of items inspected, refer to the
Quality Certification I form provided to the Owner
at time of delivery. A copy of the form is on file at
the selling BMW center.
Special Note
The maintenance requirements for your vehicle
are determined dynamically by the Condition
Based Service (CBS) system. The maintenance
items stated herein reflect the latest information
available at the time of the printing of this state-
ment, and are subject to change. The most cur-
rent maintenance recommendations are available
from your authorized BMW center.
Maintenance summary
The Condition Based Service (CBS) system will
determine the requirement for performance of
the maintenance services described on this and
the following page. These services may be
required either individually or in conjunction with
other maintenance services.
Standard operations
Maintenance work
•Brief diagnostic test
•Verify Check Control messages
•Check indicator and warning lights
•Reset CBS display
Engine oil
Maintenance work
•Change the engine oil and oil filter. We recom-
mend BMW High Performance 5W-30 Syn-
thetic Oil P/N 07 51 0 017 866.
•After every 3rd engine oil change: Intake air
cleaner: replace air filter element (reduce
replacement interval in dusty operating
conditions).
•Parking brake: check function and pre-burnish
Microfilter
Maintenance work
•Replace ventilation microfilter
Front brake
Maintenance work
•Replace brake pads, clean brake pad contact
points in calipers.
•Brake discs: Check surface and thickness, if
necessary replace at extra charge*
Rear brake
Maintenance work
•Replace brake pads, clean brake pad contact
points in calipers.
•Brake discs: Check surface and thickness, if
necessary replace at extra charge*
•Parking brake: Check condition, brake lining
thickness and function, if necessary replace at
extra charge*.
*Unless covered by Maintenance Program
5

For assistance in determining which specific
parts or components of your vehicle are covered
under this warranty, please contact your BMW
center.
It is the owners responsibility to have all sched-
uled inspection and maintenance services per-
formed (at the owners expense), as prescribed in
the maintenance schedule for the BMW Emis-
sion Control System. Service intervals are com-
puted by the onboard BMW service interval
indicator and displayed on the instrument panel.
The instructions for proper maintenance and use
can be found in the Owners Manual. It is strongly
recommended that any replacement parts used
for maintenance, repair or replacement of emis-
sion control systems be certified BMW Service
Parts or BMW Authorized Remanufactured Parts.
Without invalidating this warranty, the owner may
elect to have maintenance, repair or replacement
of the emission control systems performed by
any automotive repair establishment, or elect to
use parts other than certified BMW Service
Parts. However, the cost of such service or parts
will not be covered under this warranty, except in
emergency situations. In an emergency situation,
where an authorized BMW center or a warranty
replacement part is not reasonably available
(within 30 days), repairs may be performed at any
available service establishment using any equiva-
lent part. BMW NA will reimburse the owner for
such emergency repairs (including labor, parts
and diagnosis not to exceed BMW NA rates for
labor, parts, and diagnosis in said area) that are
covered under this warranty. Replaced parts and
paid invoices must be presented at a BMW cen-
ter as a condition of reimbursement for emer-
gency repairs not performed by a BMW center.
The use of replacement parts, which are not of
equivalent quality, may impair the effectiveness
of the emission control system. If other than cer-
tified BMW Service Parts or Authorized Remanu-
factured Parts are used for maintenance, repair
or replacement of components affecting emis-
sion control, the owner should obtain assurances
that such parts are warranted by their manufac-
turer to be equivalent to genuine BMW parts in
performance and durability. BMW NA assumes
no liability under this warranty with respect to
parts other than genuine BMW parts.However, the use of non-BMW replacement
parts or non-EPA certified parts does not invali-
date the warranty on other components, unless
non-BMW parts or non-EPA certified parts cause
damage to warranted parts.
What is not covered
This warranty does not cover malfunctions
caused by any of the following: accident, flood,
misuse, improper adjustment, modification, alter-
ation, tampering, disconnection, improper or
inadequate maintenance, use of leaded fuel or
fuels containing more than 10% ethanol, or other
oxygenates with more than 2.8% oxygen by
weight (i.e., more than 15% MTBE or more than
3% methanol plus an equivalent amount of
co-solvent).
The replacement of maintenance parts, such as
spark plugs, filters and similar items used in
required maintenance services, the repair or
replacement of maintenance parts beyond the
first required inspection/maintenance, or if the
part has been replaced earlier for reasons other
than it being defective.
The car or any part of the car unless a failure
causes the car to fail to conform to applicable
emission regulations.
Any car on which the odometer has been
replaced or altered and the true mileage cannot
be determined.
The car, if the vehicle identification number is
altered or cannot be read, or if the car has been
declared a total loss or sold for salvage purposes.
General
These warranties give you specific legal rights,
and you may also have other rights which vary
from state to state.
THE DURATION OF ANY IMPLIED WARRAN-
TIES, INCLUDING THE IMPLIED WARRANTY
OF MERCHANTABILITY, IS LIMITED TO THE
DURATION OF THE EXPRESS WARRANTIES
HEREIN.
BMW NA HEREBY EXCLUDES INCIDENTAL
AND CONSEQUENTIAL DAMAGES, INCLUD-
ING LOSS OF TIME, INCONVENIENCE, OR
LOSS OF USE OF THE VEHICLE, FOR ANY
34

California Emission Control
System Limited Warranty*
This warranty applies to California certified vehi-
cles distributed by BMW of North America (BMW
NA) or sold through the BMW NA European
Delivery Program, registered and operated pri-
marily in California.
BMW NA warrants to the original purchaser and
each subsequent owner that the vehicle is:
a. designed, built and equipped so as to con-
form with the applicable California Air
Resources Board emission standards.
b. free from defects in materials and workman-
ship which cause any part that can affect
emissions to fail to conform with applicable
requirements or to fail a California Smog
Check test or EPA approved short test for a
period of 3 years or 50,000 miles, whichever
occurs first.
c. free from defects in materials and workman-
ship in emission related parts, which are con-
tained in the California Emission Warranty
Parts List on page 40, for a period of 7 years
or 70,000 miles, whichever occurs first.
This warranty begins on the date of first retail
sale, or the date the vehicle is first placed in ser-
vice as a demonstrator or company vehicle,
whichever is earlier.
To obtain service under this warranty, the vehicle
must be brought, upon failure of a Smog Check
test or upon discovery of the defect, to the work-
shop of any authorized BMW center, during nor-
mal business hours. The BMW center will honor
or deny your claim within 30 days. If the claim is
denied, the BMW center will notify you in writing
of the reason(s). The BMW center is required by
law to honor the claim if notice is not given to the
owner within 30 days.
The BMW center will, without charge for parts or
labor (including diagnosis), either adjust, repair or
replace the defective part and other parts
affected by the failure of the warranted part, if
any. If your vehicle failed the California Smog
Check test or an EPA approved short test, then
BMW NA will repair your vehicle so that it will
pass this test. Items that require scheduled
replacement are warranted up to the replace-ment interval specified in the Service section of
this Statement. BMW NA may repair a part in lieu
of replacing it when performing warranty repairs.
Parts for which replacements are made become
the property of BMW NA. After 3 years or 50,000
miles, and in accordance with paragraph (c)
above, such repairs are limited to the repair or
replacement of those parts identified in the Cali-
fornia Emissions Warranty List.
If your California registered vehicle is between 7
and 8 years old and has been driven less than
80,000 miles, then your vehicle is eligible for
additional warranty coverage under the Federal
Emissions Warranty.
A repair performed as the result of a smog check
test failure due to a defect in a part, which is war-
ranted for 7 years/70,000 miles, is covered.
In all cases, a reasonable time, not to exceed 30
days, must be allowed for a warranty repair to be
completed, after the car is received by the BMW
center.
It is the owners responsibility to have all required
maintenance services performed (at the owners
expense), as prescribed in the maintenance
schedule for the BMW Emission Control System.
Service intervals are computed by the service
interval indicator and displayed on the instrument
panel.
However, BMW NA will not deny your warranty
repair claims solely because you do not have
maintenance records or you did not perform the
required maintenance unless BMW NA demon-
strates that such lack of required maintenance is
a direct cause of the emission control system
failure. The instructions for required maintenance
and use can be found in the Owners Manual and
in the Service section of this Statement.
*
The California Emissions Control System Limited
Warranty applies to all 2007 U.S. specification BMW
vehicles sold, leased, and/or registered in California,
Maine, Massachusetts or Vermont. This warranty
also applies to SULEV(PZEV) models sold, leased
and/or registered in Oregon or Washington.
SULEV(PZEV) models registered in California,
Maine, Massachusetts, New York, Connecticut,
Rhode Island and Vermont have different emissions
warranty coverage; please refer to the SULEV(PZEV)
section beginning on page 40.
38

California Emission Control
System Limited Warranty SULEV
(PZEV)*
This warranty applies to California certified vehi-
cles distributed by BMW of North America (BMW
NA) or sold through the BMW NA European
Delivery Program, registered and operated pri-
marily in California.
BMW NA warrants to the original purchaser and
each subsequent owner that the vehicle is:
a. designed, built and equipped so as to con-
form with the applicable California Air
Resources Board emission standards.
b. free from defects in materials and workman-
ship which cause any part that can affect
emissions to fail to conform with applicable
requirements or to fail a California Smog
Check test or EPA approved short test for a
period of 15 years or 150,000, whichever
occurs first.
c. free from defects in materials and workman-
ship in emission related parts for a period of
15 years or 150,000, whichever occurs first.
This warranty begins on the date of first retail
sale, or the date the vehicle is first placed in ser-
vice as a demonstrator or company vehicle,
whichever is earlier.
To obtain service under this warranty, the vehicle
must be brought, upon failure of a Smog Check
test or upon discovery of the defect, to the work-
shop of any authorized BMW center, during nor-
mal business hours. The BMW center will honor
or deny your claim within 30 days. If the claim is
denied, the BMW center will notify you in writing
of the reason(s). The BMW center is required by
law to honor the claim if notice is not given to the
owner within 30 days.
The BMW center will, without charge for parts or
labor (including diagnosis), either adjust, repair or
replace the defective part and other parts
affected by the failure of the warranted part, if
any. If your vehicle failed the California Smog
Check test or an EPA approved short test, then
BMW NA will repair your vehicle so that it will
pass this test. Items that require scheduledreplacement are warranted up to the replace-
ment interval specified in the Service section of
this Statement. BMW NA may repair a part in lieu
of replacing it when performing warranty repairs.
Parts for which replacements are made become
the property of BMW NA.
A repair performed as the result of a smog check
test failure due to a defect in a part, which is war-
ranted for 15 years/150,000, is covered.
In all cases, a reasonable time, not to exceed 30
days, must be allowed for a warranty repair to be
completed, after the car is received by the BMW
center.
It is the owners responsibility to have all required
maintenance services performed (at the owners
expense), as prescribed in the maintenance
schedule for the BMW Emission Control System.
Service intervals are computed by the service
interval indicator and displayed on the instrument
panel.
However, BMW NA will not deny your warranty
repair claims solely because you do not have
maintenance records or you did not perform the
required maintenance unless BMW NA demon-
strates that such lack of required maintenance is
a direct cause of the emission control system
failure. The instructions for required maintenance
and use can be found in the Owners Manual and
in the Service section of this Statement.
*The California Emissions Control System Lim-
ited Warranty SULEV(PZEV) applies to all 2007
U.S. specification BMW SULEV(PZEV) vehicles
sold, leased, and/or registered in California,
Maine, Massachusetts, Connecticut, Rhode
Island or Vermont.
It is strongly recommended that any replacement
parts used for maintenance, repair or replace-
ment of emission control systems be genuine
BMW Service Parts or BMW Authorized
Remanufactured Parts. Without invalidating this
warranty, the owner may elect to have mainte-
nance, repair or replacement of the emission
control systems performed by any automotive
repair establishment, or elect to use parts other
than BMW Authorized Remanufactured or genu-
ine BMW Service Parts. However, the cost of
such service or parts will not be covered under
this warranty, except in emergency situations. In
an emergency situation, where an authorized
43