engine BMW 6 SERIES CONVERTIBLE 2004 E64 Service and warranty information

14
Engine Oil
yes no
Vehicle check
Front BrakeBrake fluid
Rear Brake
Microfilter
State inspection(s)
Air cleaner element
Spark plugs
yes no
Distance reading
Date, stamp and signature
Engine Oil
yes no
Vehicle check
Front BrakeBrake fluid
Rear Brake
Microfilter
State inspection(s)
Air cleaner element
Spark plugs
yes no
Distance reading
Date, stamp and signature
Engine Oil
yes no
Vehicle check
Front BrakeBrake fluid
Rear Brake
Microfilter
State inspection(s)
Air cleaner element
Spark plugs
yes no
Distance reading
Date, stamp and signature

15
Engine Oil
yes no
Vehicle check
Front BrakeBrake fluid
Rear Brake
Microfilter
State inspection(s)
Air cleaner element
Spark plugs
yes no
Distance reading
Date, stamp and signature
Engine Oil
yes no
Vehicle check
Front BrakeBrake fluid
Rear Brake
Microfilter
State inspection(s)
Air cleaner element
Spark plugs
yes no
Distance reading
Date, stamp and signature
Engine Oil
yes no
Vehicle check
Front BrakeBrake fluid
Rear Brake
Microfilter
State inspection(s)
Air cleaner element
Spark plugs
yes no
Distance reading
Date, stamp and signature

Emission Control
Maintenance Schedule
The maintenance schedule as shown is
required for the proper functioning of the
emission control systems for optimum vehicle
performance and fuel economy.
Basic Engine
Engine oilAs specified by CBS
Engine oil filter As specified by CBS
Fuel System
Air filterAs specified by CBS
Ignition System
Spark plugs As specified by CBS
Emission Control Components
Oxygen sensorReplace at intervals
of 100,000 miles
Oxygen Sensor Service: The oxygen sensor
deteriorates strictly on a mileage basis and
must therefore be replaced to maximize
vehicle fuel economy and minimize exhaust
pollution.
16

Customer Assistance–
Notification
During a specific period (usually the earlier of
12 months or 12,000 miles, though this period
varies by state), some states require us or
our authorized BMW center, to repair in a
reasonable number of attempts, any defect or
condition which substantially impairs the use,
value, or safety of a new vehicle sold, leased
or registered in that state.
A “reasonable number of attempts”is gener-
ally defined as (i) two or more attempts to
repair the same defect (the number of
attempts may vary by state) or (ii) that the
same defect has caused the vehicle to be out
of service by reason of repair for more than
30 days (this period may vary by state),
except for delays created by conditions
beyond our control.
If we are unable to correct a defect or condi-
tion covered by these statutes in a reason-
able number of attempts, we may be
obligated either to replace the vehicle or
reimburse the owner/lessee in an amount
equal to the purchase price or lease
payments paid by the owner/lessee, less the
amount directly attributable to use of the
vehicle by the owner/lessee.
YOU SHOULD SEND WRITTEN NOTIFICA-
TION DIRECTLY TO BMW OF NORTH
AMERICA OF THE EXISTENCE OF AN
ALLEGED DEFECT. SEND WRITTEN
COMMUNICATION TO THE NATIONAL
CUSTOMER RELATIONS DEPARTMENT
ADDRESS LISTED BELOW.
BMW OF NORTH AMERICA
CUSTOMER RELATIONS DEPARTMENT
P.O. BOX 1227
WESTWOOD, NEW JERSEY 07675-1227
Telephone: 1-800-831-1117
BMW Import Processing Centers
As a BMW owner, you will experience BMW
quality first hand. Our dedication to excel-
lence in design, engineering, and service is
among the best in the world. And we invest
heavily every year in our people and facilities
to ensure that our quality standards are
consistently applied from the factory to the
BMW center.
Each BMW is inspected after its manufacture.
Imperfections in the mechanical and electrical
systems or damage to the sheet metal, paint,
trim or other components of the vehicle that
may occur during transportation from the
factory are normally detected and corrected.
Any defect in material or workmanship that
may occur during the warranty period is
covered under the New Vehicle Limited
Warranty.
Special Programs
SOMETIMES BMW OF NORTH AMERICA
OFFERS A SPECIAL ADJUSTMENT
PROGRAM TO PAY ALL OR PART OF THE
COST OF CERTAIN REPAIRS BEYOND THE
TERMS OF THE WARRANTY. CHECK WITH
YOUR BMW CENTER TO DETERMINE
WHETHER ANY ADJUSTMENT PROGRAM
IS APPLICABLE TO YOUR MOTOR
VEHICLE.
25

New Vehicle Limited Warranty –
2004 Models (Valid Only in the
U.S.A. and Puerto Rico)
Warrantor
BMW NA warrants 2004 U.S. specification
vehicles distributed by BMW NA or sold
through the BMW NA European Delivery
Program against defects in materials or
workmanship to the first retail purchaser, and
each subsequent purchaser.
Warranty Period
The warranty period is 48 months or 50,000
miles, whichever occurs first.
Warranty Begins
This warranty begins on the date of first
retail sale, or the date the vehicle is first
placed in service as a demonstrator or
company vehicle, whichever is earlier.
Warranty Coverage
To obtain service under this warranty, the
vehicle must be brought, upon discovery of a
defect in material or workmanship, to the
workshop of any authorized BMW center,
during normal business hours. The BMW
center will, without charge for parts or labor,
either repair or replace the defective part(s)
using new or authorized remanufactured
parts. The decision to repair or replace said
part(s) is solely the prerogative of BMW NA.
Parts for which replacements are made
become the property of BMW NA.
In all cases, a reasonable time must be allowed
for warranty repairs to be completed after the
vehicle is received by the BMW center.
Safety Belt Warranty - Kansas
Safety belts are covered under the BMW New
Vehicle Limited Warranty for defects in
material or workmanship for a period of 10
years, unlimited mileage from the date of
purchase. In order to be eligible for this
coverage, the vehicle must be a new car
retailed in the State of Kansas and the repair
performed by an authorized BMW center in
Kansas.
Towing/Other Owner Benefits
A 24-hour Roadside Assistance Program is
available to every BMW owner during the new
vehicle warranty period.
Roadside assistance and other owner
benefits are available by calling:
1-800-332-4269
For additional details on towing and other
owner benefits please refer to the BMW
Roadside Assistance section of this
Statement (page 26).
Other Items
Wheel alignment, balancing and wiper blade
inserts are covered up to 2,000 miles.
Items which are subject to wear and tear
or deterioration due to driving habits or
conditions, such as brake pads/linings,
brake discs, clutch disc, pressure plate,
filters, upholstery, trim and chrome items,
paint finish, drive belts, glass, and similar
items, are specifically limited to defects in
material or workmanship.
This warranty does not apply to the follow-
ing:
Damage which results from negligence,
improper operation of the vehicle, improper
repair, lack of or improper maintenance,
environmental influences, flood, accident or
fire damage, road salt corrosion, or use of
improper or contaminated fuel.
Damage to the engine, transmission or any
related component caused by improper shift-
ing of the transmission.
Maintenance services and parts when
replaced during maintenance such as spark
plugs, lubricants, fluids, engine tuneup parts,
replacement of filters, coolant, and refriger-
ant.
Failure to maintain the vehicle properly in
accordance with the instructions in the
Owner’s Manual or the Service section of this
Statement, that results in the failure of any
part of the vehicle.
30

Modification of the vehicle or installation of
any performance accessories or components
attached to the vehicle which alters the origi-
nal engineering and/or operating specifica-
tions or which result in damage to the other
original components, electrical interference,
electrical short, radio static, water leaks and
wind noise.
Tires are warranted by their respective
manufacturer as detailed in the applicable tire
manufacturer’s warranty statements.
Instructions for proper tire care and mainte-
nance are contained in the Owner’s Manual.
Should you experience difficulty in obtaining
warranty service from a tire manufacturer,
your authorized BMW center will assist you in
resolving the difficulty.
Non-BMW Parts – While you may elect to use
non-genuine BMW parts for maintenance or
repair services, BMW NA is not obligated to
pay for repairs that include non-genuine BMW
parts or for any damage resulting from the
use of non-genuine parts.
BMW will not accept any liability for any
parts and accessories not approved by
BMW.
This warranty shall be null and void if the
vehicle identification number has been
altered or cannot be read, if the odometer
has been replaced or altered and the true
mileage cannot be determined, if the
vehicle has been declared a total loss or
sold for salvage purposes, or if the vehicle
has been used in any competitive event.
General
These warranties give you specific legal
rights, and you may also have other rights
which vary from state to state.
THE DURATION OF ANY IMPLIED
WARRANTIES, INCLUDING THE IMPLIED
WARRANTY OF MERCHANTABILITY, IS
LIMITED TO THE DURATION OF THE
EXPRESS WARRANTIES HEREIN. BMW
NA HEREBY EXCLUDES INCIDENTAL AND
CONSEQUENTIAL DAMAGES, INCLUDING
LOSS OF TIME, INCONVENIENCE, OR
LOSS OF USE OF THE VEHICLE, FOR ANY
BREACH OF ANY EXPRESS OR IMPLIED
WARRANTY, INCLUDING THE IMPLIED
WARRANTY OF MERCHANTABILITY,
APPLICABLE TO THIS PRODUCT.
Some states do not allow limitations on how
long an implied warranty lasts, or the exclu-
sion or limitation of incidental or consequen-
tial damages, so the above limitations and
exclusions may not apply to you.
The BMW Certified Pre-Owned limited
warranty is applicable to the retail purchaser
and each subsequent retail purchaser (not for
resale purposes) of the CPO vehicle sold
through an authorized BMW center for 2
years or 50,000 miles from the effective date,
whichever occurs first.
31

The following systems are covered by the
Federal Emission Performance Warranty for a
period of two years or 24,000 miles,
whichever occurs first. The specific systems
may vary according to model, therefore, all of
the systems listed may not be used on your
vehicle. For assistance in determining which
systems and specific components within
these systems apply to your vehicle, please
contact your BMW center.
AIR INDUCTION SYSTEM
FUEL METERING SYSTEM
IGNITION SYSTEM
POSITIVE CRANKCASE VENTILATION
SYSTEM (PCV)
FUEL EVAPORATIVE CONTROL SYSTEM
EXHAUST SYSTEM
ENGINE EMISSION CONTROL SYSTEM
SENSORS/DEVICES
ON BOARD DIAGNOSTIC SYSTEM (OBD)
RELATED PARTS ASSOCIATED WITH THE
ABOVE SYSTEMS
The following components and/or system
are/is covered under the Federal Emission
Warranty for a period of 8 years or 80,000
miles, whichever occurs first.
CATALYTIC CONVERTER
ENGINE CONTROL MODULE (INCLUDING
ON-BOARD DIAGNOSTIC SYSTEM)
For assistance in determining coverage of the
specific components of the on-board diagnos-
tic system, please contact your BMW center.
36

California Emission Control
Warranty Statement*
Your Warranty Rights and
Obligations
The California Air Resources Board and
BMW of North America (BMW NA) are
pleased to explain the emission control
system warranty on your 2004 vehicle. In
California, new motor vehicles must be
designed, built and equipped to meet the
State’s stringent anti-smog standards. BMW
NA must warrant the emission control system
on your vehicle for the periods of time listed
below provided there has been no abuse,
neglect or improper maintenance of your
vehicle.
Your emission control system may include
parts such as the fuel injection system, the
ignition system, catalytic converter, and
engine computer. Also included may be
hoses, belts, connectors and other emission-
related assemblies.
Where a warrantable condition exists, BMW
NA will repair your vehicle at no cost to you
including diagnosis, parts and labor.
Manufacturer’s Warranty Coverage:
–For 3 years or 50,000 miles whichever
occurs first:
1. If your vehicle fails a Smog Check inspec-
tion, all necessary repairs and adjustments
will be made by BMW NA to ensure that
your vehicle passes the inspection. This is
your emission control system PERFOR-
MANCE WARRANTY.
2. If any emission-related part on your
vehicle is defective, the part will be
repaired or replaced by BMW NA. This is
your short-term emission control system
DEFECTS WARRANTY.
–For 7 years or 70,000 miles whichever
occurs first:
If an emission-related part specially noted on
page 40 as having coverage for 7 years or
70,000 miles is defective, the part will be
repaired or replaced by BMW NA. This is
your long-term emission control system
DEFECTS WARRANTY.
Owner’s Warranty Responsibilities:
–As the vehicle owner, you are responsible
for the performance of the required
maintenance listed in your Owner’s
Manual. BMW NA recommends that you
retain all receipts covering maintenance on
your vehicle, but BMW NA cannot deny
warranty solely for the lack of receipts or
for your failure to ensure the performance
of all scheduled maintenance.
–You are responsible for presenting your
vehicle to an authorized BMW center as
soon as a problem exists. The warranty
repairs should be completed in a reason-
able amount of time, not to exceed 30
days.
–As the vehicle owner, you should also be
aware that BMW NA may deny your
warranty coverage if your vehicle or part
has failed due to abuse, neglect, improper
maintenance or unapproved modifications.
If you have any questions regarding your
warranty rights and responsibilities, you
should contact:
BMW of North America
Customer Relations Department
PO. Box 1227
Westwood, N.J. 07675-1227
Telephone: 1-800-831-1117
Website:
www.bmwusa.com
or the
California Air Resources Board
9528 Telstar Avenue
P.O. Box 8001
El Monte, CA 91731
*The California Emissions Control System
Limited Warranty applies to all 2004 U.S.
specification BMW vehicles sold, leased,
and/or registered in California, Maine,
Massachusetts or Vermont.
37

For assistance in determining which parts are
covered by this warranty, please contact your
authorized BMW center or the BMW NA
Customer Relations Department at 1-800-
831-1117. You may obtain further information
concerning the emissions warranty or report
violations of warranty terms, by contacting Air
Resources Board (ARB), Mobile Source
Division, 9528 Telstar Avenue, P.O. Box 8001,
El Monte, CA 91731. Please include the title
of the BMW service department head and
telephone number.California Emission Warranty
Parts List
The following components are covered for
defects by the California Emission Control
System Limited Warranty for a period of 7
years or 70,000 miles, whichever comes first:
Component6 Series
Intake Manifold•
Vanos Camshaft Position Controller•
Engine Control Module•
Knock Sensor•
Fuel Tank•
Exhaust Manifold•
Exhaust Manifold with Catalyst•
Three Way Catalytic Converter•
Transmission Control Module•
40