instrument panel BMW X5 2006 E53 Service and warranty information

Inspection I
Engine CompartmentX5 3.0i,
4.4i, 4.8is
Read out diagnostic system. •
Check engine cooling system/heater hose connections for leaks. Check coolant level
and antifreeze protection level. Add coolant if required. •
Check windshield washer fluid level and antifreeze protection. Fill up and/or correct if
required. •
Check air conditioner for operation. •
Replace microfilter. (Note: reduce replacement interval in dusty operating conditions.) •
Reset service interval indicator. •
Body/Electrical
Check battery state-of-charge indicator and charge if required. •
Check lighting system, i.e.: headlights, foglights, parking, back-up, license plate, interior
(including map reading lights), glove box, flashlight, illuminated makeup mirrors,
luggage compartment/area lights. •
Check instrument panel and dashboard illumination. •
Check all warning/indicator lights, check control. •
Check turn signals, hazard warning flashers, brake lights, horns, headlight dimmer and
flasher switch. •
Check wipers and washer system(s); wiper blades, washer jet positions. •
Check condition and function of safety belts. •
Visually examine all SRS airbag units for torn covers, obvious damage or attachment of
decals, decorations or accessories. •
Check central locking/double lock. •
Check operation of all latches. •
Check heater/air conditioner blower, rear window defogger. •
Check rear view mirrors. •
Final Inspection
Road test with check of brakes, suspension, steering, clutch/manual transmission or
automatic transmission. •
7

Federal Emissions System Defect
Warranty
(Valid only in the U.S.A. and
Puerto Rico)
This warranty applies only to U.S. specification
SAVs distributed by BMW of North America
(BMW NA) or sold through the BMW NA Euro-
pean Delivery Program.
In accordance with the defect warranty provi-
sions of section 207(b) of the Clean Air Act,
BMW NA warrants to the first retail purchaser,
and each subsequent purchaser, that the SAV (a)
was designed, built and equipped so as to con-
form, at the time of sale, with all regulations of
the U.S. Environmental Protection Agency appli-
cable at the time of manufacture and (b) is free
from defects in materials and workmanship
which would cause it to fail to conform with appli-
cable regulations for a period of 2 years or
24,000 miles, whichever occurs first, except for
specific emission control components (as listed
on page 34), for which the warranty period is 8
years or 80,000 miles, whichever occurs first.
This warranty begins on the date of first retail
sale, or the date the SAV is first placed in service
as a demonstrator or company vehicle, whichever
is earlier.
Warranty claims must be made as soon as rea-
sonably possible after a defect is discovered. To
make a claim, the SAV must be brought to any
authorized BMW SAV center during normal busi-
ness hours.
The authorized BMW SAV center will, without
charge for parts or labor (including diagnosis),
either repair or replace the defective part, if any.
The decision whether to repair or replace said
parts is solely the prerogative of BMW NA and
must be expected to correct the failure of the
warranted part. Parts for which replacements are
made become the property of BMW NA. In all
cases, a reasonable time must be allowed for
warranty repairs to be completed after the SAV is
received by the authorized BMW SAV center.
For assistance in determining which specific
parts or components of your vehicle are covered
under this warranty, please contact your autho-
rized BMW SAV center. It is the owner’s responsibility to have all sched-
uled inspection and maintenance services per-
formed (at the owner’s expense), as prescribed in
the maintenance schedule for the BMW Emis-
sion Control System. Service intervals are com-
puted by the onboard BMW service interval
indicator and displayed on the instrument panel.
The instructions for proper maintenance and use
can be found in the X5 Owner’s Manual. It is
strongly recommended that any replacement
parts used for maintenance, repair or replace-
ment of emission control systems be certified
BMW Service Parts or BMW Authorized
Remanufactured Parts. Without invalidating this
warranty, the owner may elect to have mainte-
nance, repair or replacement of the emission
control systems performed by any automotive
repair establishment, or elect to use parts other
than certified BMW Service Parts. However, the
cost of such service or parts will not be covered
under this warranty, except in emergency situa-
tions. In an emergency situation, where an
authorized BMW SAV center or a warranty
replacement part is not reasonably available
(within 30 days), repairs may be performed at any
available service establishment using any equiva-
lent part. BMW NA will reimburse the owner for
such emergency repairs (including labor, parts
and diagnosis not to exceed BMW NA rates for
labor, parts, and diagnosis in said area) that are
covered under this warranty. Replaced parts and
paid invoices must be presented at an authorized
BMW SAV center as a condition of reimburse-
ment for emergency repairs not performed by an
authorized BMW SAV center.
The use of replacement parts, which are not of
equivalent quality, may impair the effectiveness
of the emission control system. If other than cer-
tified BMW Service Parts or Authorized Remanu-
factured Parts are used for maintenance, repair
or replacement of components affecting emis-
sion control, the owner should obtain assurances
that such parts are warranted by their manufac-
turer to be equivalent to genuine BMW parts in
performance and durability. BMW NA assumes
no liability under this warranty with respect to
parts other than genuine BMW parts.
32

California Emission Control
System Limited Warranty*
This warranty applies to California certified SAVs
distributed by BMW of North America (BMW NA)
or sold through the BMW NA European Delivery
Program, registered and operated primarily in
California.
BMW NA warrants to the original purchaser and
each subsequent owner that the SAV is:
a. designed, built and equipped so as to con- form with the applicable California Air
Resources Board emission standards.
b. free from defects in materials and workman- ship which cause any part that can affect
emissions to fail to conform with applicable
requirements or to fail a California Smog
Check test or EPA approved short test for a
period of 3 years or 50,000 miles, whichever
occurs first.
c. free from defects in materials and workman- ship in emission related parts, which are con-
tained in the California Emission Warranty
Parts List on page 38, for a period of 7 years
or 70,000 miles, whichever occurs first.
This warranty begins on the date of first retail
sale, or the date the SAV is first placed in service
as a demonstrator or company vehicle, whichever
is earlier.
To obtain service under this warranty, the SAV
must be brought, upon failure of a Smog Check
test or upon discovery of the defect, to the work-
shop of any authorized BMW SAV center, during
normal business hours. The authorized BMW
SAV center will honor or deny your claim within
30 days. If the claim is denied, the authorized
BMW SAV center will notify you in writing of the
reason(s). The authorized BMW SAV center is
required by law to honor the claim if notice is not
given to the owner within 30 days. The authorized BMW SAV center will, without
charge for parts or labor (including diagnosis),
either adjust, repair or replace the defective part
and other parts affected by the failure of the war-
ranted part, if any. If your SAV failed the California
Smog Check test or an EPA approved short test,
then BMW NA will repair your SAV so that it will
pass this test. Items that require scheduled
replacement are warranted up to the replace-
ment interval specified in the Service section of
this Statement. BMW NA may repair a part in lieu
of replacing it when performing warranty repairs.
Parts for which replacements are made become
the property of BMW NA. After 3 years or 50,000
miles, and in accordance with paragraph (c)
above, such repairs are limited to the repair or
replacement of those parts identified in the Cali-
fornia Emissions Warranty List.
If your California registered SAV is between 7 and
8 years old and has been driven less than 80,000
miles, then your SAV is eligible for additional war-
ranty coverage under the Federal Emissions War-
ranty.
A repair performed as the result of a smog check
test failure due to a defect in a part, which is war-
ranted for 7 years/70,000 miles, is covered.
In all cases, a reasonable time, not to exceed 30
days, must be allowed for a warranty repair to be
completed, after the SAV is received by the
authorized BMW SAV center.
It is the owner’s responsibility to have all required
maintenance services performed (at the owner’s
expense), as prescribed in the maintenance
schedule for the BMW Emission Control System.
Service intervals are computed by the service
interval indicator and displayed on the instrument
panel.
*The California Emissions Control System Lim-
ited Warranty applies to all 2006 U.S. specifica-
tion BMW SAVs sold, leased, and/or registered in
California, Maine, Massachusetts or Vermont.
37